NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
58 reportsClear category filter119,000 miles · May 5, 2014
Air Bags
TL* THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT INTERMITTENTLY ILLUMINATED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 11V473000 (AIR BAGS). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 119,000…
Read full complaint
TL* THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT INTERMITTENTLY ILLUMINATED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 11V473000 (AIR BAGS). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 119,000.
NHTSA ODI #10586631
40,000 miles · Dec 23, 2013
Air Bags
TL - THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED THAT THE PASSENGER AIR BAG OCCUPANCY CLASSIFICATION SYSTEM COULD NOT DETERMINE WHEN THE PASSENGER SEAT WAS OCCUPIED AND WOULD ERRONEOUSLY DEACTIVATE THE AIR BAG. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED BUT THE FAILURE WAS UNABLE TO BE REPLICATED. THE M…
Read full complaint
TL - THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED THAT THE PASSENGER AIR BAG OCCUPANCY CLASSIFICATION SYSTEM COULD NOT DETERMINE WHEN THE PASSENGER SEAT WAS OCCUPIED AND WOULD ERRONEOUSLY DEACTIVATE THE AIR BAG. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED BUT THE FAILURE WAS UNABLE TO BE REPLICATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V473000 (AIR BAGS). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 65,000. DR
NHTSA ODI #10557041
90,000 miles · Jul 31, 2013
Air BagsSeat BeltsCrashInjury
TLA* THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, IT BEGAN TO RAIN HEAVILY AND THE VEHICLE SUDDENLY HYDRO-PLANED. THE CONSUMER REGAINED CONTROL OF THE VEHICLE, BUT IT HYDRO -PLANED AGAIN AND THE VEHICLE HIT AN EMBANKMENT WITH THE FRONT BUMPER SPINNING THE VEHICLE AROUND. THE VE…
Read full complaint
TLA* THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, IT BEGAN TO RAIN HEAVILY AND THE VEHICLE SUDDENLY HYDRO-PLANED. THE CONSUMER REGAINED CONTROL OF THE VEHICLE, BUT IT HYDRO -PLANED AGAIN AND THE VEHICLE HIT AN EMBANKMENT WITH THE FRONT BUMPER SPINNING THE VEHICLE AROUND. THE VEHICLE THEN ROLLED OVER FOUR-SIX TIMES, BEFORE LANDING IN A DITCH. BOTH REAR SEAT BELTS BECAME UNLATCHED INDEPENDENTLY AND THE AIR BAGS FAILED TO DEPLOY UPON IMPACT. THE CONTACT SUSTAINED BRUISES, SCRAPES AND LACERATIONS TO THE SHOULDER AREA. TWO REAR PASSENGERS ALSO SUSTAINED LACERATIONS. ANOTHER PASSENGER SUFFERED FROM A CONCUSSION AND A BRUISED KIDNEY. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS DESTROYED AND TOWED TO A SALVAGE CENTER. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 08/27/13*LJ THE CONSUMER STATED THE AIR BAG DID NOT DEPLOY AND THE SEAT BELTS RELEASE
NHTSA ODI #10532905
90,000 miles · Jul 27, 2013
Air BagsSeat BeltsCrash
WE WERE TRAVELING DOWN I-64 AT 6:45 PM AT 70 MPH WHEN A DOWNPOUR BEGAN SUDDENLY MY HUSBAND EASED OFF OF THE ACCELERATOR AND AS WE ENTERED THE RAIN. WE BEGAN TO HYDROPLANE WE SPUN 180 DEGREES. HE REGAINED CONTROL ONLY TO HYDROPLANE AGAIN. THIS TIME HE DID A 360 AND WENT INTO A DITCH HITTING A EARTHEN EMBANKMENT WITH THE FRONT…
Read full complaint
WE WERE TRAVELING DOWN I-64 AT 6:45 PM AT 70 MPH WHEN A DOWNPOUR BEGAN SUDDENLY MY HUSBAND EASED OFF OF THE ACCELERATOR AND AS WE ENTERED THE RAIN. WE BEGAN TO HYDROPLANE WE SPUN 180 DEGREES. HE REGAINED CONTROL ONLY TO HYDROPLANE AGAIN. THIS TIME HE DID A 360 AND WENT INTO A DITCH HITTING A EARTHEN EMBANKMENT WITH THE FRONT FENDER SPINNING US AROUND AND PUSHING THE REAR OF THE CAR UP THE EMBANKMENT THIS THEN CAUSED THE CAR TO BEGIN ROLLING WE ROLLED AT LEAST 4 TIMES BEFORE SLIDING AT LEAST 100 YARDS DOWN THE INTERSTATE. NO AIRBAGS DEPLOYED. MY HUSBANDS SEAT BELT HELD. HOWEVER, I WAS IN THE BACK SEAT WITH OUR SON AND MY SEAT BELT AS WELL AS HIS RELEASED THROWING US INTO THE CARGO AREA. WE ALL WERE INJURED AND TRANSPORTED TO THE HOSPITAL BY AMBULANCE. WHEN WE NOTIFIED KIA THEY ACTED AS IF THIS WAS NO BIG DEAL. *TR
NHTSA ODI #10532115
120,000 miles · Apr 18, 2012
Air BagsCrashInjury
TL* THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, HER VISION BECAME BLURRED AND SHE LOST CONTROL OF THE VEHICLE. THE VEHICLE WAS THEN DRIVEN OFF INTO A DITCH AND THE CONTACT CRASHED INTO A CONCRETE BLOCK. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED BACK TO THE CONTACT'S RESIDENCE. THE …
Read full complaint
TL* THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, HER VISION BECAME BLURRED AND SHE LOST CONTROL OF THE VEHICLE. THE VEHICLE WAS THEN DRIVEN OFF INTO A DITCH AND THE CONTACT CRASHED INTO A CONCRETE BLOCK. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED BACK TO THE CONTACT'S RESIDENCE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT SUFFERED MAJOR INJURIES TO HER BACK AND SUSTAINED A FRACTURED RIB. THE VEHICLE HAD MAJOR DAMAGES TO THE FRONT END. THE FAILURE AND THE CURRENT MILEAGES WERE 120,000. ..UPDATED 05/23/12 *BF
NHTSA ODI #10455640
8,000 miles · Feb 19, 2012
Air Bags
THE PASSENGER SIDE AIRBAG SENSOR IN MY 2007 KIA SORENTO HAS FAILED INTERMITTENTLY EVER SINCE I PURCHASED THE VEHICLE IN 2009. IT FAILS AT LEAST 50% OF THE TIME WHEN A PASSENGER IS IN THE SEAT (SOMETIMES >200 LBS.) UPON COMPLAINING TO THE DEALER, THEY CONTINUED TO INSIST THAT THE PASSENGER WAS NOT SITTING PROPERLY IN THE SEAT. …
Read full complaint
THE PASSENGER SIDE AIRBAG SENSOR IN MY 2007 KIA SORENTO HAS FAILED INTERMITTENTLY EVER SINCE I PURCHASED THE VEHICLE IN 2009. IT FAILS AT LEAST 50% OF THE TIME WHEN A PASSENGER IS IN THE SEAT (SOMETIMES >200 LBS.) UPON COMPLAINING TO THE DEALER, THEY CONTINUED TO INSIST THAT THE PASSENGER WAS NOT SITTING PROPERLY IN THE SEAT. THIS IS RIDICULOUS. I KNOW OF NO OTHER CARS WHERE THAT IS AN ISSUE. THE DEALER SAYS TO GET OUT AND BACK IN AGAIN, BUT THAT IS NOT GOING TO HAPPEN WHEN YOU ARE ON A BUSY HIGHWAY GOING 65 MPH AND REALIZE THE AIRBAG IS NOT ON. SO, THEN THEY SAY TO LIFT YOUR BUTT UP FOR 10 SECONDS AND THEN SIT BACK DOWN. IT SOMETIMES WORKS, BUT TAKES A FEW TRIES. AND, DO YOU KNOW HOW EMBARRASSING THAT IS TO ASK A GUEST (PARTICULARLY IF A BUSINESS GUEST) TO DO THAT? AGAIN, IT IS JUST SO RIDICULOUS THAT I FEAR OWNERS WILL IGNORE IT THUS PUTTING THEIR PASSENGERS AT RISK. SO, I WAS THRILLED TO SEE THAT THERE WAS FINALLY A RECALL OF THE 2007 SORENTO PASSENGER AIRBAG SENSOR IN THE FALL OF 2011. FINALLY, THEY ADMIT THERE IS A PROBLEM. HOWEVER, THEN THE DEALER SAYS THAT MY VIN IS NOT COVERED BY THE RECALL. REALLY??? THIS RECALL NEEDS TO BE EXPANDED. I AM TAKING MY CAR BACK AGAIN NEXT WEEK AND IF IT IS NOT REPLACED BY KIA, I WILL BE CALLING THE KIA HEADQUARTERS LEGAL DEPARTMENT TO COMPLAIN. IF YOU CAN HELP GET THIS RECALL EXPANDED SO THAT I AND OTHERS DO NOT HAVE TO GO THROUGH THIS, I WOULD GREATLY APPRECIATE IT. *TR
NHTSA ODI #10448472
14,000 miles · Jan 26, 2012
Air Bags
TL* THE CONTACT OWNS A 2007 KIA SORENTO. WHILE THE CONTACT STARTED THE IGNITION, THE FRONT PASSENGER SIDE AIR BAG WARNING INDICATOR BEGAN TO ILLUMINATE. THE FAILURE OCCURRED WHENEVER AN OCCUPANT WAS POSITIONED IN THE FRONT PASSENGER SEAT AND WEIGHED 115 POUNDS OR LESS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON FIVE DIFFER…
Read full complaint
TL* THE CONTACT OWNS A 2007 KIA SORENTO. WHILE THE CONTACT STARTED THE IGNITION, THE FRONT PASSENGER SIDE AIR BAG WARNING INDICATOR BEGAN TO ILLUMINATE. THE FAILURE OCCURRED WHENEVER AN OCCUPANT WAS POSITIONED IN THE FRONT PASSENGER SEAT AND WEIGHED 115 POUNDS OR LESS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON FIVE DIFFERENT OCCASIONS FOR THE SAME FAILURE. THE COMPUTER SOFTWARE WAS UPDATED AND ON A SEPARATE OCCASION, THE SIDE AIR BAG DETENTION SENSOR WAS REPLACED. THE FAILURE CONTINUED TO OCCUR AFTER EACH REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 14,000.
NHTSA ODI #10445471
39,325 miles · Jan 13, 2012
Air Bags
TL* THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED THAT THE PASSENGER AIR BAG OCCUPANCY CLASSIFICATION SYSTEM COULD NOT DETERMINE WHEN THE PASSENGER SEAT WAS OCCUPIED AND WOULD ERRONEOUSLY DEACTIVATE THE AIR BAG. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V473000 (AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE) BUT WA…
Read full complaint
TL* THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED THAT THE PASSENGER AIR BAG OCCUPANCY CLASSIFICATION SYSTEM COULD NOT DETERMINE WHEN THE PASSENGER SEAT WAS OCCUPIED AND WOULD ERRONEOUSLY DEACTIVATE THE AIR BAG. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V473000 (AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE) BUT WAS ADVISED BY AN AUTHORIZED DEALER THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS ALSO CONTACTED AND CONFIRMED TO THE CONTACT THAT THE VEHICLE WAS NOT RECALLED. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 55,736 AND THE FAILURE MILEAGE WAS 39,325.
NHTSA ODI #10443703
Mileage unknown · Aug 23, 2010
Air BagsEquipment
KIA SORENTO-2007-FRONT PASSENGER-AIR BAG "IDIOT LIGHT". FOR 2 YRS. TRIPS BACK AND FORTH REGARDING THIS LIGHT TO DEALER. UNABLE TO ASSURE THAT AIR BAG SYSTEM IS REALLY WORKING. LIGHT IS ON WHEN SOMEONE IS SITTING IN SEAT AND INDICATES THE AIR BAG IS OFF. SEATS AND SENSORS HAVE BEEN REPLACED TO NO AVAIL. THEY JUST TOLD ME TODAY 8-…
Read full complaint
KIA SORENTO-2007-FRONT PASSENGER-AIR BAG "IDIOT LIGHT". FOR 2 YRS. TRIPS BACK AND FORTH REGARDING THIS LIGHT TO DEALER. UNABLE TO ASSURE THAT AIR BAG SYSTEM IS REALLY WORKING. LIGHT IS ON WHEN SOMEONE IS SITTING IN SEAT AND INDICATES THE AIR BAG IS OFF. SEATS AND SENSORS HAVE BEEN REPLACED TO NO AVAIL. THEY JUST TOLD ME TODAY 8-23-2010 THAT THERE IS NO MORE THEY CAN DO. LIGHT IS STILL ON AND THEIR COMPUTER STILL SAYS THAT IT IS WORKING. YOU HAVE MANY COMPLAINTS OF THE SAME THING-IS ANYTHING BEING DONE? EITHER THE LIGHT,SENSOR,AIR BAG OR COMPUTER IS NOT RIGHT. THIS HAS BEEN A PROBLEM SINCE I BOUGHT THE CAR NEW. THIS IS AN INTERMITTENT OCCURRENCE-DOESN'T MATTER WHEN OR WHO IS SITTING IN THE SEAT, IF THE CAR IS WARM OR COLD. THE SEAT(SENSOR) HAS BEEN CHANGED,COMPUTER HAS DIAGNOSED AND KIA HAS TALKED TO THE TECH'S. THEIR MACHINES ARE NOT TELLING THEM THAT SOMETHING IS WRONG BUT THE SERVICE MANAGERS AND SALES PEOPLE HAVE WITNESSED IT. ARE YOU INVESTIGATING THIS? *TR
NHTSA ODI #10351371
Mileage unknown · Mar 1, 2010
Air BagsEngine And Engine Cooling
OUR 2007 KIA SORENTO, PURCHASED NEW, AND NOW WITH 20,000 MILES, HAS, SINCE PURCHASE, HAD THE PASSENGER AIRBAG NOT ON SIGNAL GO ON, ALMOST EVERY TIME WE USE IT. THE DEALERSHIP SAID THEY MUST SEE IT HAPPEN, AND CANNOT REPLICATE IT. WHEN WE MADE OUR WAY TO THE DEALERSHIP, WHILE THE SIGNAL WAS LIT, THEY SAW IT, VISUALLY IT, AND MADE…
Read full complaint
OUR 2007 KIA SORENTO, PURCHASED NEW, AND NOW WITH 20,000 MILES, HAS, SINCE PURCHASE, HAD THE PASSENGER AIRBAG NOT ON SIGNAL GO ON, ALMOST EVERY TIME WE USE IT. THE DEALERSHIP SAID THEY MUST SEE IT HAPPEN, AND CANNOT REPLICATE IT. WHEN WE MADE OUR WAY TO THE DEALERSHIP, WHILE THE SIGNAL WAS LIT, THEY SAW IT, VISUALLY IT, AND MADE A NOTE, HOWEVER, THE "COMPUTER" DID NOT RECOGNIZE IT AS A PROBLEM, SO THEY WILL NOT CORRECT THE "PROBLEM". WE HAVE BEEN TOLD THAT IF THAT IS LIT UP AND SOMEONE IS IN THE SEAT DURING AN ACCIDENT, THE AIRBAG WILL NOT DEPLOY. I AM TOLD THAT KIA AND THEIR DEALERSHIPS ARE AWARE OF THIS PROBLEM, AND COULD REPLACE THE SEAT BOTTOM TO FIX THIS PROBLEM, YET NONE OF THE DEALERSHIPS WE HAVE TAKEN IT TOO, WILL REPLACE IT, UNLESS THE MAIN OFFICE MAKES IT A RECALL. OUR SECOND COMPLAINT THAT THEY ARE NOT WILLING TO DO ANYTHING ABOUT IS THE STRONG ODOR OF ANTIFREEZE, WHICH LITERALLY MAKES ME SICK ON MY STOMACH WHEN IT HAPPENS, WHICH IS NOT ALL OF THE TIME. I AM AFRAID THESE FUMES COULD BE HARMFUL. *TR
NHTSA ODI #10315271
Official recalls
4Feb 14, 2020
Kia Motors America (Kia) is recalling certain 2006-2010 Sedona and 2007-2009 Sorento vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence & remedy
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the vehicle is turned off, increasing the risk of an injury.
Remedy: Kia will notify owners, and dealers will install a relay in the main junction box to prevent power from being directed to the HECU when the vehicle's ignition switch is turned off, free of charge. The recall began June 5, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC186.
Additional source detail variants (2)
Electrical System
Kia Motors America (Kia) is recalling certain 2006-2010 Sedona and 2007-2009 Sorento vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the vehicle is turned off, increasing the risk of an injury.
Remedy: Kia will notify owners, and dealers will install a relay in the main junction box to prevent power from being directed to the HECU when the vehicle's ignition switch is turned off, free of charge. The recall began June 5, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC186.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Kia Motors America (Kia) is recalling certain 2006-2010 Sedona and 2007-2009 Sorento vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the vehicle is turned off, increasing the risk of an injury.
Remedy: Kia will notify owners, and dealers will install a relay in the main junction box to prevent power from being directed to the HECU when the vehicle's ignition switch is turned off, free of charge. The recall began June 5, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC186.
Apr 1, 2013
Kia Motors Corporation (Kia) is recalling certain model year 2007-2010 Rondo, model year 2007-2011 Sedona, Sorento and Sportage, model year 2010-2011 Soul, model year 2008-2011 Optima, model year 2010 Forte, model year 2007-2009 Amanti, and model year 2009 Borrego vehicles. Originally, in April 2013, Kia recalled 623,658 model year 2007-2010 Rondo and Sportage, model year 2007-2011 Sorento, model year 2007 Sedona, model year 2010-2011 Soul, and model year 2011 Optima vehicles. In September 2013, Kia informed the agency that it was adding an additional 356,719 vehicles to this campaign. The total number of vehicles being recalled is now 980,377. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake-transmission shift interlock feature preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of PARK without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Kia will send an interim notification to owners in May 2013. When parts are available, owners will receive a second notification and dealers will replace the stop lamp switch, free of charge. Owners may contact Kia at 1-800-333-4542. Kia's recall campaign number is SC098.
Sep 7, 2011
KIA IS RECALLING CERTAIN MODEL YEAR 2007-2008 SORENTO PASSENGER CARS MANUFACTURED FROM JUNE 15, 2006 THROUGH NOVEMBER 27, 2007. THE FRONT PASSENGER AIR BAG MAY BE TURNED OFF WHEN AN ADULT IS IN THE PASSENGER SEAT. THE FRONT PASSENGER AIR BAG IS DESIGNED TO BE TURNED OFF IN LIMITED CIRCUMSTANCES INCLUDING WHEN CHILDREN AND SMALL ADULTS ARE SEATED IN THE FRONT PASSENGER SEAT, THERE IS A CHILD RESTRAINT IN THAT SEAT OR THE SEAT IS NOT OCCUPIED. THE VEHICLE'S OCCUPANT CLASSIFICATION SYSTEM (OCS), WHICH CLASSIFIES THE OCCUPANT IN THE FRONT PASSENGER SEAT, MAY MISCLASSIFY AN ADULT PASSENGER AS A CHILD OR CHILD SEAT AND IMPROPERLY TURN OFF THE PASSENGER SIDE AIR BAG. WHEN THE AIR BAG IS DEACTIVATED THE "PASSENGER AIR BAG OFF" LIGHT WILL ILLUMINATE ON THE CENTER INSTRUMENT PANEL.
Consequence & remedy
Consequence: THE PASSENGER SIDE AIR BAG IS TURNED OFF WHEN THE OCS MISCLASSIFIES AN ADULT PASSENGER. WITH THE FRONT PASSENGER AIRBAG OFF, THE FRONT PASSENGER WILL NOT HAVE THE PROTECTION OF THE PASSENGER AIR BAGS IN SOME FRONTAL COLLISIONS, THUS INCREASING THE RISK OF OCCUPANT INJURY.
Remedy: KIA WILL UPDATE THE PROGRAMMING IN THE SORENTO OCS CONTROL MODULE AT NO CHARGE. THE RECALL REMEDY IS CURRENTLY AVAILABLE UNDER SERVICE CAMPAIGN SC076. OWNERS MAY CONTACT KIA CUSTOMER SERVICE AT 1-800-333-4542.
Apr 17, 2009
HUYNDAI-KIA IS RECALLING 139,844 MY 2006-2007- SEDONA, SPORTAGE, SORENTO AND MY RONDO AND AMANTI VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 17, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
EA09017 · Air Bag Occupant Classification System
Opened Nov 19, 2009 · Closed Sep 26, 2011
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
The Sorento's front passenger air bag may be turned off when an adult is seated in the passenger seat. The front passenger air bag is designed to be turned off in limited circumstances including when children and small adults are seated in the front passenger seat, there is a child restraint in that seat, or the seat is not occupied.But the Sorento has misclassified adults sitting in the passenger seat.This causes the passenger side frontal air bag to deactivate and the PASSENGER AIR BAG OFF light to illuminate. On May 12, 2009, Kia launched a Technical Service Bulletin campaign (SC076) to address this problem, installing upgraded occupant classification system (OCS) software in vehicles built prior to the 11/27/2007 production date. ODI and Kia identified 908 owner reports and 927 warranty claims related to this OCS issue.Kia also reported one crash where the passenger frontal air bag did not deploy in a frontal crash due to misclassification.Testing of Sorento vehicles built prior to December 2007 shows that misclassification can occur.As of April 2011, Kia reports that approx. 46,000 of the 57,228 vehicles have been upgraded with the revised software.On September 6, 2011, Kia submitted a defect notice and will recall the affected vehicles that have not been upgraded.Owner notification is scheduled to start in late-September 2011.The recall will upgrade the OCS software.Accordingly the investigation is closed.
Additional source detail variants (3)
Air Bags:frontal
The Sorento's front passenger air bag may be turned off when an adult is seated in the passenger seat. The front passenger air bag is designed to be turned off in limited circumstances including when children and small adults are seated in the front passenger seat, there is a child restraint in that seat, or the seat is not occupied.But the Sorento has misclassified adults sitting in the passenger seat.This causes the passenger side frontal air bag to deactivate and the PASSENGER AIR BAG OFF light to illuminate. On May 12, 2009, Kia launched a Technical Service Bulletin campaign (SC076) to address this problem, installing upgraded occupant classification system (OCS) software in vehicles built prior to the 11/27/2007 production date. ODI and Kia identified 908 owner reports and 927 warranty claims related to this OCS issue.Kia also reported one crash where the passenger frontal air bag did not deploy in a frontal crash due to misclassification.Testing of Sorento vehicles built prior to December 2007 shows that misclassification can occur.As of April 2011, Kia reports that approx. 46,000 of the 57,228 vehicles have been upgraded with the revised software.On September 6, 2011, Kia submitted a defect notice and will recall the affected vehicles that have not been upgraded.Owner notification is scheduled to start in late-September 2011.The recall will upgrade the OCS software.Accordingly the investigation is closed.
Air Bags:frontal:sensor/control MODULE-INACTIVE
The Sorento's front passenger air bag may be turned off when an adult is seated in the passenger seat. The front passenger air bag is designed to be turned off in limited circumstances including when children and small adults are seated in the front passenger seat, there is a child restraint in that seat, or the seat is not occupied.But the Sorento has misclassified adults sitting in the passenger seat.This causes the passenger side frontal air bag to deactivate and the PASSENGER AIR BAG OFF light to illuminate. On May 12, 2009, Kia launched a Technical Service Bulletin campaign (SC076) to address this problem, installing upgraded occupant classification system (OCS) software in vehicles built prior to the 11/27/2007 production date. ODI and Kia identified 908 owner reports and 927 warranty claims related to this OCS issue.Kia also reported one crash where the passenger frontal air bag did not deploy in a frontal crash due to misclassification.Testing of Sorento vehicles built prior to December 2007 shows that misclassification can occur.As of April 2011, Kia reports that approx. 46,000 of the 57,228 vehicles have been upgraded with the revised software.On September 6, 2011, Kia submitted a defect notice and will recall the affected vehicles that have not been upgraded.Owner notification is scheduled to start in late-September 2011.The recall will upgrade the OCS software.Accordingly the investigation is closed.
Air Bags
The Sorento's front passenger air bag may be turned off when an adult is seated in the passenger seat. The front passenger air bag is designed to be turned off in limited circumstances including when children and small adults are seated in the front passenger seat, there is a child restraint in that seat, or the seat is not occupied.But the Sorento has misclassified adults sitting in the passenger seat.This causes the passenger side frontal air bag to deactivate and the PASSENGER AIR BAG OFF light to illuminate. On May 12, 2009, Kia launched a Technical Service Bulletin campaign (SC076) to address this problem, installing upgraded occupant classification system (OCS) software in vehicles built prior to the 11/27/2007 production date. ODI and Kia identified 908 owner reports and 927 warranty claims related to this OCS issue.Kia also reported one crash where the passenger frontal air bag did not deploy in a frontal crash due to misclassification.Testing of Sorento vehicles built prior to December 2007 shows that misclassification can occur.As of April 2011, Kia reports that approx. 46,000 of the 57,228 vehicles have been upgraded with the revised software.On September 6, 2011, Kia submitted a defect notice and will recall the affected vehicles that have not been upgraded.Owner notification is scheduled to start in late-September 2011.The recall will upgrade the OCS software.Accordingly the investigation is closed.
PE09034 · Air Bag Ocs
Opened Jul 17, 2009 · Closed Nov 30, 2009
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
KIA REPORTS THAT FOR VEHICLES BUILT PRIOR TO THE SOFTWARE UPDATE OF 11/27/2007, THE VEHICLES CAN IMPROPERLY CLASSIFY AN ADULT AS A CHILD RESTRAINT SEAT AND THUS ILLUMINATE THE AIRBAG OFF WARNING LIGHT AND SUPPRESS THE FRONTAL PASSENGER AIRBAG.ON MAY 12, 2009, KIA LAUNCHED A TECHNICAL SERVICE BULLETIN (SB076) CAMPAIGN TO RE-FLASH ALL VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.KIA ALSO BELIEVES THAT INTERMITTENT OCCUPANT MOVEMENT AND OUT OF POSITION SEATING CONTRIBUTED TO THE HIGH NUMBER OF COMPLAINTS.905 OF THE 947 COMPLAINTS AND 1,014 OF THE 1,107 WARRANTY CLAIMS WERE ASSOCIATED WITH THE 57,228 VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.THERE WAS ONE FRONTAL PASSENGER AIRBAG NON-DEPLOYMENT CRASH THAT RESULTED IN ONE MINOR INJURY OF A BELTED ADULT PASSENGER OCCUPANT.THIS PRELIMINARY EVOLUTION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-017) TO FURTHER ASSESS THIS ISSUE FOR ALL MY2007-2008 SORENTO VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.
Additional source detail variants (3)
Air Bags:frontal
KIA REPORTS THAT FOR VEHICLES BUILT PRIOR TO THE SOFTWARE UPDATE OF 11/27/2007, THE VEHICLES CAN IMPROPERLY CLASSIFY AN ADULT AS A CHILD RESTRAINT SEAT AND THUS ILLUMINATE THE AIRBAG OFF WARNING LIGHT AND SUPPRESS THE FRONTAL PASSENGER AIRBAG.ON MAY 12, 2009, KIA LAUNCHED A TECHNICAL SERVICE BULLETIN (SB076) CAMPAIGN TO RE-FLASH ALL VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.KIA ALSO BELIEVES THAT INTERMITTENT OCCUPANT MOVEMENT AND OUT OF POSITION SEATING CONTRIBUTED TO THE HIGH NUMBER OF COMPLAINTS.905 OF THE 947 COMPLAINTS AND 1,014 OF THE 1,107 WARRANTY CLAIMS WERE ASSOCIATED WITH THE 57,228 VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.THERE WAS ONE FRONTAL PASSENGER AIRBAG NON-DEPLOYMENT CRASH THAT RESULTED IN ONE MINOR INJURY OF A BELTED ADULT PASSENGER OCCUPANT.THIS PRELIMINARY EVOLUTION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-017) TO FURTHER ASSESS THIS ISSUE FOR ALL MY2007-2008 SORENTO VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.
Air Bags:frontal:sensor/control MODULE-INACTIVE
KIA REPORTS THAT FOR VEHICLES BUILT PRIOR TO THE SOFTWARE UPDATE OF 11/27/2007, THE VEHICLES CAN IMPROPERLY CLASSIFY AN ADULT AS A CHILD RESTRAINT SEAT AND THUS ILLUMINATE THE AIRBAG OFF WARNING LIGHT AND SUPPRESS THE FRONTAL PASSENGER AIRBAG.ON MAY 12, 2009, KIA LAUNCHED A TECHNICAL SERVICE BULLETIN (SB076) CAMPAIGN TO RE-FLASH ALL VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.KIA ALSO BELIEVES THAT INTERMITTENT OCCUPANT MOVEMENT AND OUT OF POSITION SEATING CONTRIBUTED TO THE HIGH NUMBER OF COMPLAINTS.905 OF THE 947 COMPLAINTS AND 1,014 OF THE 1,107 WARRANTY CLAIMS WERE ASSOCIATED WITH THE 57,228 VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.THERE WAS ONE FRONTAL PASSENGER AIRBAG NON-DEPLOYMENT CRASH THAT RESULTED IN ONE MINOR INJURY OF A BELTED ADULT PASSENGER OCCUPANT.THIS PRELIMINARY EVOLUTION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-017) TO FURTHER ASSESS THIS ISSUE FOR ALL MY2007-2008 SORENTO VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.
Air Bags
KIA REPORTS THAT FOR VEHICLES BUILT PRIOR TO THE SOFTWARE UPDATE OF 11/27/2007, THE VEHICLES CAN IMPROPERLY CLASSIFY AN ADULT AS A CHILD RESTRAINT SEAT AND THUS ILLUMINATE THE AIRBAG OFF WARNING LIGHT AND SUPPRESS THE FRONTAL PASSENGER AIRBAG.ON MAY 12, 2009, KIA LAUNCHED A TECHNICAL SERVICE BULLETIN (SB076) CAMPAIGN TO RE-FLASH ALL VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.KIA ALSO BELIEVES THAT INTERMITTENT OCCUPANT MOVEMENT AND OUT OF POSITION SEATING CONTRIBUTED TO THE HIGH NUMBER OF COMPLAINTS.905 OF THE 947 COMPLAINTS AND 1,014 OF THE 1,107 WARRANTY CLAIMS WERE ASSOCIATED WITH THE 57,228 VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.THERE WAS ONE FRONTAL PASSENGER AIRBAG NON-DEPLOYMENT CRASH THAT RESULTED IN ONE MINOR INJURY OF A BELTED ADULT PASSENGER OCCUPANT.THIS PRELIMINARY EVOLUTION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-017) TO FURTHER ASSESS THIS ISSUE FOR ALL MY2007-2008 SORENTO VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.
Illustration