PASSENGER AIR BAG LIGHT IS ON. THE DEALER SAID THAT THE PASSENGER SEAT AIR BAG SENSOR NEEDS REPLACEMENT. I HAVE BEEN READING MANY OTHERS ARE EXPERIENCING THIS PROBLEM WHICH COULD CAUSE THE AIR BAG MAY DEPLOY UNEXPECTEDLY OR NOT EVEN AT ALL. THE DEALER SAID MY CAR DOES NOT FALL UNDER SOME RECALL WITH THE SAME PROBLEM FOR DIFFER…
Read full complaint
PASSENGER AIR BAG LIGHT IS ON. THE DEALER SAID THAT THE PASSENGER SEAT AIR BAG SENSOR NEEDS REPLACEMENT. I HAVE BEEN READING MANY OTHERS ARE EXPERIENCING THIS PROBLEM WHICH COULD CAUSE THE AIR BAG MAY DEPLOY UNEXPECTEDLY OR NOT EVEN AT ALL. THE DEALER SAID MY CAR DOES NOT FALL UNDER SOME RECALL WITH THE SAME PROBLEM FOR DIFFERENT PRODUCTION DATES. THE DEALER WAS QUICK TO SAY T WOULD COST AROUND $2000.00 TO FIX THIS. CALLED KIA AND THEY SAID IT IS NOT A SAFETY ISSUE THEY WORRY ABOUT. SCARY IT IS AN AIR BAG FAULT. I HAVE BEEN GOING BACK IN FORTH WITH DEALER AND CORPORATE FOR ASSISTANCE BUT THERE IS NO HELP AND I FOUND THIS SITE SEARCHING AND HOPE YOU CAN HELP NOT JUST ME BUT ALL THE OTHERS OUT THERE HAVING THE SAME PROBLEM
NHTSA ODI #11010978
90,000 miles · Oct 21, 2016
Air BagsStructure
TL* THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE DOOR WAS JAMMED AND THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.
NHTSA ODI #10917735
129,000 miles · Sep 9, 2016
Air Bags
I RECEIVED A RECALL NOTICE ON MY 2007 KIA SORENTO TO HAVE THE CLOCK SPRING REPLACED. PRIOR TO TAKING THE CARTO THE DEALER THE AIRBAG WARNING LIGHT CAME ON. I TOOK THE CAR TO THE FRANKLIN TN DEALERSHIP ASSUMING THE LIGHT WAS CAUSED BY THE CLOCK SPRING RECALL. THE TECH INFORMED ME THAT IT WAS CAUSED BY THE OCS MAT IN THE PASSENGE…
Read full complaint
I RECEIVED A RECALL NOTICE ON MY 2007 KIA SORENTO TO HAVE THE CLOCK SPRING REPLACED. PRIOR TO TAKING THE CARTO THE DEALER THE AIRBAG WARNING LIGHT CAME ON. I TOOK THE CAR TO THE FRANKLIN TN DEALERSHIP ASSUMING THE LIGHT WAS CAUSED BY THE CLOCK SPRING RECALL. THE TECH INFORMED ME THAT IT WAS CAUSED BY THE OCS MAT IN THE PASSENGER SEAT AND IT COULD BE FIXED FOR $2,200+. HE ALSO SAID THAT I DID NOT NEED A CLOCK SPRING. WHEN I CHECKED ON THE CLOCK SPRING RECALL I SEE MY CAR NOW HAS NO RECALLS ACTIVE. WITH THE SAME OCS MAT PROBLEM BEING COVERED ON THE SPECTRA MODEL I FEEL THE SORENTO SHOULD ALSO BE INCLUDED IN THE EXTENDED COVERAGE.
NHTSA ODI #10905099
59,000 miles · Apr 12, 2016
Air Bags
TL* THE CONTACT OWNS A 2007 KIA SORENTO. WHILE DRIVING 15 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE PASSENGER SENSOR MAT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE…
Read full complaint
TL* THE CONTACT OWNS A 2007 KIA SORENTO. WHILE DRIVING 15 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE PASSENGER SENSOR MAT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 59,000.
NHTSA ODI #10855108
Mileage unknown · Jan 16, 2015
Air Bags
TL* THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED THAT THE DRIVER AND THE PASSENGER SIDE AIR BAG WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10673015
Mileage unknown · Aug 29, 2014
Air Bags
2007 KIA SORENTO PASSENGER SEAT AIR BAG ALARM - DUE TO SEAT SENSOR PROBLEMS OR OTHER PROBLEMS. PROBLEM HAS RECURRED HUNDREDS OF TIMES SINCE PURCHASED NEW. ADVISED BY SERVICE MANAGER OF GREER, SC KIA THAT FAULT WAS DUE TO PASSENGER NOT SITTING PROPERLY IN SEAT WITH FEET POSITIONED PROPERLY BUT ADVISED BY A KIA TECHNICIAN, CON…
Read full complaint
2007 KIA SORENTO PASSENGER SEAT AIR BAG ALARM - DUE TO SEAT SENSOR PROBLEMS OR OTHER PROBLEMS. PROBLEM HAS RECURRED HUNDREDS OF TIMES SINCE PURCHASED NEW. ADVISED BY SERVICE MANAGER OF GREER, SC KIA THAT FAULT WAS DUE TO PASSENGER NOT SITTING PROPERLY IN SEAT WITH FEET POSITIONED PROPERLY BUT ADVISED BY A KIA TECHNICIAN, CONFIDENTIALLY, THAT THIS IS NOT TRUE. PASSENGER SEAT SENSOR WAS ADJUSTED AFTER SEVERAL VISITS BUT FAULT RECURS TIME AFTER TIME WHICH MEANS THE PASSENGER AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH. KIA DOES NOT APPEAR TO TAKE MATTER SERIOUSLY. THIS COULD RESULT IN DEATHS. OTHER DEALER REPRESENTATIVES REFERS THE PROBLEM BACK TO SERVICE MANAGER ONLY. NUMBER OF COMPLAINTS: AT LEAST SIX OR MORE - TO LITTLE AVAIL. PROBLEM STILL EXISTS FROM TIME TO TIME. USUALLY THE PASSENGER CAN BOUNCE UP AND DOWN SEVERAL TIMES AND FINALLY GET THE ALARM TO EXTINGUISH SHOWING NORMAL AIR BAG OPERATION FOR THE PASSENGER SIDE. WROTE LETTER TO REGIONAL KIA DEALERSHIP TO NO AVAIL. CALLED KIA HELP LINE TO NO AVAIL. ONLY TOLD TO REFER PROBLEM TO KIA DEALERSHIP SERVICE MANAGER. INCIDENT DATE SINCE TIME OF PURCHASE IN JUNE OR JULY, 2007. GUESSING PURCHASE DATE SINCE IT HAS BEEN A FEW YEARS. STILL OWN VEHICLE. *TR
NHTSA ODI #10629272
125,000 miles · Aug 25, 2014
Air Bags
TL* THE CONTACT OWNS A 2007 KIA SORENTO. WHILE DRIVING 10 MPH, THE DRIVER SIDE AIR BAG WARNING INDICATOR ILLUMINATED. THE FAILURE OCCURRED NUMEROUS TIMES AND WAS SIMILAR TO THE FAILURE LISTED IN NHTSA CAMPAIGN NUMBER: 11V473000 (AIR BAGS). THE DEALER STATED THAT THE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND …
Read full complaint
TL* THE CONTACT OWNS A 2007 KIA SORENTO. WHILE DRIVING 10 MPH, THE DRIVER SIDE AIR BAG WARNING INDICATOR ILLUMINATED. THE FAILURE OCCURRED NUMEROUS TIMES AND WAS SIMILAR TO THE FAILURE LISTED IN NHTSA CAMPAIGN NUMBER: 11V473000 (AIR BAGS). THE DEALER STATED THAT THE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.
NHTSA ODI #10628169
2,000 miles · Aug 7, 2014
Air Bags
TL* THE CONTACT OWNS A 2007 KIA SORENTO. WHILE DRIVING APPROXIMATELY 45 MPH, THE PASSENGER SIDE AIR BAG WARNING INDICATOR ILLUMINATED. THE FAILURE OCCURRED INTERMITTENTLY AT VARIOUS SPEEDS. THE DEALER COULD NOT DIAGNOSE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 2,000.
NHTSA ODI #10619512
74,688 miles · Jul 10, 2014
Air Bags
THE AIR BAG LIGHT ON MY 2007 KIA SORENTO REMAINS ILLUMINATED WHILE DRIVING THE CAR. UPON FURTHER INVESTIGATION I FOUND THERE WAS A RECALL FROM KIA MOTORS SC076A AND ALSO FROM NHTSA #11V473000 TO REPLACE THE SENSOR. I TOOK THE VEHICLE TO HART KIA IN SALEM VIRGINIA TO HAVE THIS RECALL AND ANOTHER RECALL FOR BRAKE LIGHTS REPAIRED.…
Read full complaint
THE AIR BAG LIGHT ON MY 2007 KIA SORENTO REMAINS ILLUMINATED WHILE DRIVING THE CAR. UPON FURTHER INVESTIGATION I FOUND THERE WAS A RECALL FROM KIA MOTORS SC076A AND ALSO FROM NHTSA #11V473000 TO REPLACE THE SENSOR. I TOOK THE VEHICLE TO HART KIA IN SALEM VIRGINIA TO HAVE THIS RECALL AND ANOTHER RECALL FOR BRAKE LIGHTS REPAIRED. THE DEALERSHIP REPAIRED THE BRAKE ISSUE BUT TOLD ME THAT MY CAR WAS NOT RECALLED FOR THE PASSENGER AIR BAG SENSOR AND A NEW SEAT WOULD COST $1,300.00. I CALLED KIA MOTORS AND FILED A CLAIM BECAUSE MY VEHICLE WAS MANUFACTURED BETWEEN JUNE 15, 2006 AND NOVEMBER 27, 2007. KIA MOTORS AND THE DEALERSHIP SAID THEY WOULD PAY FOR THE SEAT ITSELF BUT I WOULD HAVE TO PAY FOR THE LABOR. WHEN I ASKED WHY I SHOULD HAVE TO PAY FOR A RECALL ITEM I WAS TOLD BY BOTH PARTIES THAT IT WAS NOT THEIR FAULT.I DID NOT MANUFACTURE THE CAR, I PURCHASED THEIR PRODUCT. KIA MOTORS SHOULD BE RESPONSIBLE FOR THE PART AND THE LABOR, SINCE THEY INSTALLED FAULTY PARTS WHEN THE CAR WAS MANUFACTURED. THEY PAID FOR THE PART AND LABOR ON THE BRAKE RECALL, THEY CAN NOT BE SELECTIVE WHEN REPAIRING RECALLS. THEY MANUFACTURED THE CAR SO THEY SHOULD PAY 100% OF THE REPAIR BILL IT MAKES ME WONDER HOW MANY PEOPLE ACTUALLY HAD TO PAY $1,300.00 FOR A RECALL.. *TR
NHTSA ODI #10609600
93,000 miles · Jun 12, 2014
Air Bags
TL* THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED WHILE STARTING THE VEHICLE, THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE OCCUPANT POSITION DETECTION SYSTEM SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEE…
Read full complaint
TL* THE CONTACT OWNS A 2007 KIA SORENTO. THE CONTACT STATED WHILE STARTING THE VEHICLE, THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE OCCUPANT POSITION DETECTION SYSTEM SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 93,000.
Kia Motors America (Kia) is recalling certain 2006-2010 Sedona and 2007-2009 Sorento vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence & remedy
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the vehicle is turned off, increasing the risk of an injury.
Remedy: Kia will notify owners, and dealers will install a relay in the main junction box to prevent power from being directed to the HECU when the vehicle's ignition switch is turned off, free of charge. The recall began June 5, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC186.
Additional source detail variants (2)
Electrical System
Kia Motors America (Kia) is recalling certain 2006-2010 Sedona and 2007-2009 Sorento vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the vehicle is turned off, increasing the risk of an injury.
Remedy: Kia will notify owners, and dealers will install a relay in the main junction box to prevent power from being directed to the HECU when the vehicle's ignition switch is turned off, free of charge. The recall began June 5, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC186.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Kia Motors America (Kia) is recalling certain 2006-2010 Sedona and 2007-2009 Sorento vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the vehicle is turned off, increasing the risk of an injury.
Remedy: Kia will notify owners, and dealers will install a relay in the main junction box to prevent power from being directed to the HECU when the vehicle's ignition switch is turned off, free of charge. The recall began June 5, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC186.
Kia Motors Corporation (Kia) is recalling certain model year 2007-2010 Rondo, model year 2007-2011 Sedona, Sorento and Sportage, model year 2010-2011 Soul, model year 2008-2011 Optima, model year 2010 Forte, model year 2007-2009 Amanti, and model year 2009 Borrego vehicles. Originally, in April 2013, Kia recalled 623,658 model year 2007-2010 Rondo and Sportage, model year 2007-2011 Sorento, model year 2007 Sedona, model year 2010-2011 Soul, and model year 2011 Optima vehicles. In September 2013, Kia informed the agency that it was adding an additional 356,719 vehicles to this campaign. The total number of vehicles being recalled is now 980,377. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake-transmission shift interlock feature preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of PARK without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Kia will send an interim notification to owners in May 2013. When parts are available, owners will receive a second notification and dealers will replace the stop lamp switch, free of charge. Owners may contact Kia at 1-800-333-4542. Kia's recall campaign number is SC098.
KIA IS RECALLING CERTAIN MODEL YEAR 2007-2008 SORENTO PASSENGER CARS MANUFACTURED FROM JUNE 15, 2006 THROUGH NOVEMBER 27, 2007. THE FRONT PASSENGER AIR BAG MAY BE TURNED OFF WHEN AN ADULT IS IN THE PASSENGER SEAT. THE FRONT PASSENGER AIR BAG IS DESIGNED TO BE TURNED OFF IN LIMITED CIRCUMSTANCES INCLUDING WHEN CHILDREN AND SMALL ADULTS ARE SEATED IN THE FRONT PASSENGER SEAT, THERE IS A CHILD RESTRAINT IN THAT SEAT OR THE SEAT IS NOT OCCUPIED. THE VEHICLE'S OCCUPANT CLASSIFICATION SYSTEM (OCS), WHICH CLASSIFIES THE OCCUPANT IN THE FRONT PASSENGER SEAT, MAY MISCLASSIFY AN ADULT PASSENGER AS A CHILD OR CHILD SEAT AND IMPROPERLY TURN OFF THE PASSENGER SIDE AIR BAG. WHEN THE AIR BAG IS DEACTIVATED THE "PASSENGER AIR BAG OFF" LIGHT WILL ILLUMINATE ON THE CENTER INSTRUMENT PANEL.
Consequence & remedy
Consequence: THE PASSENGER SIDE AIR BAG IS TURNED OFF WHEN THE OCS MISCLASSIFIES AN ADULT PASSENGER. WITH THE FRONT PASSENGER AIRBAG OFF, THE FRONT PASSENGER WILL NOT HAVE THE PROTECTION OF THE PASSENGER AIR BAGS IN SOME FRONTAL COLLISIONS, THUS INCREASING THE RISK OF OCCUPANT INJURY.
Remedy: KIA WILL UPDATE THE PROGRAMMING IN THE SORENTO OCS CONTROL MODULE AT NO CHARGE. THE RECALL REMEDY IS CURRENTLY AVAILABLE UNDER SERVICE CAMPAIGN SC076. OWNERS MAY CONTACT KIA CUSTOMER SERVICE AT 1-800-333-4542.
HUYNDAI-KIA IS RECALLING 139,844 MY 2006-2007- SEDONA, SPORTAGE, SORENTO AND MY RONDO AND AMANTI VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 17, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
EA09017 · Air Bag Occupant Classification System
Opened Nov 19, 2009 · Closed Sep 26, 2011
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
The Sorento's front passenger air bag may be turned off when an adult is seated in the passenger seat. The front passenger air bag is designed to be turned off in limited circumstances including when children and small adults are seated in the front passenger seat, there is a child restraint in that seat, or the seat is not occupied.But the Sorento has misclassified adults sitting in the passenger seat.This causes the passenger side frontal air bag to deactivate and the PASSENGER AIR BAG OFF light to illuminate. On May 12, 2009, Kia launched a Technical Service Bulletin campaign (SC076) to address this problem, installing upgraded occupant classification system (OCS) software in vehicles built prior to the 11/27/2007 production date. ODI and Kia identified 908 owner reports and 927 warranty claims related to this OCS issue.Kia also reported one crash where the passenger frontal air bag did not deploy in a frontal crash due to misclassification.Testing of Sorento vehicles built prior to December 2007 shows that misclassification can occur.As of April 2011, Kia reports that approx. 46,000 of the 57,228 vehicles have been upgraded with the revised software.On September 6, 2011, Kia submitted a defect notice and will recall the affected vehicles that have not been upgraded.Owner notification is scheduled to start in late-September 2011.The recall will upgrade the OCS software.Accordingly the investigation is closed.
Additional source detail variants (3)
Air Bags:frontal
The Sorento's front passenger air bag may be turned off when an adult is seated in the passenger seat. The front passenger air bag is designed to be turned off in limited circumstances including when children and small adults are seated in the front passenger seat, there is a child restraint in that seat, or the seat is not occupied.But the Sorento has misclassified adults sitting in the passenger seat.This causes the passenger side frontal air bag to deactivate and the PASSENGER AIR BAG OFF light to illuminate. On May 12, 2009, Kia launched a Technical Service Bulletin campaign (SC076) to address this problem, installing upgraded occupant classification system (OCS) software in vehicles built prior to the 11/27/2007 production date. ODI and Kia identified 908 owner reports and 927 warranty claims related to this OCS issue.Kia also reported one crash where the passenger frontal air bag did not deploy in a frontal crash due to misclassification.Testing of Sorento vehicles built prior to December 2007 shows that misclassification can occur.As of April 2011, Kia reports that approx. 46,000 of the 57,228 vehicles have been upgraded with the revised software.On September 6, 2011, Kia submitted a defect notice and will recall the affected vehicles that have not been upgraded.Owner notification is scheduled to start in late-September 2011.The recall will upgrade the OCS software.Accordingly the investigation is closed.
Air Bags:frontal:sensor/control MODULE-INACTIVE
The Sorento's front passenger air bag may be turned off when an adult is seated in the passenger seat. The front passenger air bag is designed to be turned off in limited circumstances including when children and small adults are seated in the front passenger seat, there is a child restraint in that seat, or the seat is not occupied.But the Sorento has misclassified adults sitting in the passenger seat.This causes the passenger side frontal air bag to deactivate and the PASSENGER AIR BAG OFF light to illuminate. On May 12, 2009, Kia launched a Technical Service Bulletin campaign (SC076) to address this problem, installing upgraded occupant classification system (OCS) software in vehicles built prior to the 11/27/2007 production date. ODI and Kia identified 908 owner reports and 927 warranty claims related to this OCS issue.Kia also reported one crash where the passenger frontal air bag did not deploy in a frontal crash due to misclassification.Testing of Sorento vehicles built prior to December 2007 shows that misclassification can occur.As of April 2011, Kia reports that approx. 46,000 of the 57,228 vehicles have been upgraded with the revised software.On September 6, 2011, Kia submitted a defect notice and will recall the affected vehicles that have not been upgraded.Owner notification is scheduled to start in late-September 2011.The recall will upgrade the OCS software.Accordingly the investigation is closed.
Air Bags
The Sorento's front passenger air bag may be turned off when an adult is seated in the passenger seat. The front passenger air bag is designed to be turned off in limited circumstances including when children and small adults are seated in the front passenger seat, there is a child restraint in that seat, or the seat is not occupied.But the Sorento has misclassified adults sitting in the passenger seat.This causes the passenger side frontal air bag to deactivate and the PASSENGER AIR BAG OFF light to illuminate. On May 12, 2009, Kia launched a Technical Service Bulletin campaign (SC076) to address this problem, installing upgraded occupant classification system (OCS) software in vehicles built prior to the 11/27/2007 production date. ODI and Kia identified 908 owner reports and 927 warranty claims related to this OCS issue.Kia also reported one crash where the passenger frontal air bag did not deploy in a frontal crash due to misclassification.Testing of Sorento vehicles built prior to December 2007 shows that misclassification can occur.As of April 2011, Kia reports that approx. 46,000 of the 57,228 vehicles have been upgraded with the revised software.On September 6, 2011, Kia submitted a defect notice and will recall the affected vehicles that have not been upgraded.Owner notification is scheduled to start in late-September 2011.The recall will upgrade the OCS software.Accordingly the investigation is closed.
PE09034 · Air Bag Ocs
Opened Jul 17, 2009 · Closed Nov 30, 2009
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
KIA REPORTS THAT FOR VEHICLES BUILT PRIOR TO THE SOFTWARE UPDATE OF 11/27/2007, THE VEHICLES CAN IMPROPERLY CLASSIFY AN ADULT AS A CHILD RESTRAINT SEAT AND THUS ILLUMINATE THE AIRBAG OFF WARNING LIGHT AND SUPPRESS THE FRONTAL PASSENGER AIRBAG.ON MAY 12, 2009, KIA LAUNCHED A TECHNICAL SERVICE BULLETIN (SB076) CAMPAIGN TO RE-FLASH ALL VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.KIA ALSO BELIEVES THAT INTERMITTENT OCCUPANT MOVEMENT AND OUT OF POSITION SEATING CONTRIBUTED TO THE HIGH NUMBER OF COMPLAINTS.905 OF THE 947 COMPLAINTS AND 1,014 OF THE 1,107 WARRANTY CLAIMS WERE ASSOCIATED WITH THE 57,228 VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.THERE WAS ONE FRONTAL PASSENGER AIRBAG NON-DEPLOYMENT CRASH THAT RESULTED IN ONE MINOR INJURY OF A BELTED ADULT PASSENGER OCCUPANT.THIS PRELIMINARY EVOLUTION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-017) TO FURTHER ASSESS THIS ISSUE FOR ALL MY2007-2008 SORENTO VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.
Additional source detail variants (3)
Air Bags:frontal
KIA REPORTS THAT FOR VEHICLES BUILT PRIOR TO THE SOFTWARE UPDATE OF 11/27/2007, THE VEHICLES CAN IMPROPERLY CLASSIFY AN ADULT AS A CHILD RESTRAINT SEAT AND THUS ILLUMINATE THE AIRBAG OFF WARNING LIGHT AND SUPPRESS THE FRONTAL PASSENGER AIRBAG.ON MAY 12, 2009, KIA LAUNCHED A TECHNICAL SERVICE BULLETIN (SB076) CAMPAIGN TO RE-FLASH ALL VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.KIA ALSO BELIEVES THAT INTERMITTENT OCCUPANT MOVEMENT AND OUT OF POSITION SEATING CONTRIBUTED TO THE HIGH NUMBER OF COMPLAINTS.905 OF THE 947 COMPLAINTS AND 1,014 OF THE 1,107 WARRANTY CLAIMS WERE ASSOCIATED WITH THE 57,228 VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.THERE WAS ONE FRONTAL PASSENGER AIRBAG NON-DEPLOYMENT CRASH THAT RESULTED IN ONE MINOR INJURY OF A BELTED ADULT PASSENGER OCCUPANT.THIS PRELIMINARY EVOLUTION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-017) TO FURTHER ASSESS THIS ISSUE FOR ALL MY2007-2008 SORENTO VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.
Air Bags:frontal:sensor/control MODULE-INACTIVE
KIA REPORTS THAT FOR VEHICLES BUILT PRIOR TO THE SOFTWARE UPDATE OF 11/27/2007, THE VEHICLES CAN IMPROPERLY CLASSIFY AN ADULT AS A CHILD RESTRAINT SEAT AND THUS ILLUMINATE THE AIRBAG OFF WARNING LIGHT AND SUPPRESS THE FRONTAL PASSENGER AIRBAG.ON MAY 12, 2009, KIA LAUNCHED A TECHNICAL SERVICE BULLETIN (SB076) CAMPAIGN TO RE-FLASH ALL VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.KIA ALSO BELIEVES THAT INTERMITTENT OCCUPANT MOVEMENT AND OUT OF POSITION SEATING CONTRIBUTED TO THE HIGH NUMBER OF COMPLAINTS.905 OF THE 947 COMPLAINTS AND 1,014 OF THE 1,107 WARRANTY CLAIMS WERE ASSOCIATED WITH THE 57,228 VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.THERE WAS ONE FRONTAL PASSENGER AIRBAG NON-DEPLOYMENT CRASH THAT RESULTED IN ONE MINOR INJURY OF A BELTED ADULT PASSENGER OCCUPANT.THIS PRELIMINARY EVOLUTION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-017) TO FURTHER ASSESS THIS ISSUE FOR ALL MY2007-2008 SORENTO VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.
Air Bags
KIA REPORTS THAT FOR VEHICLES BUILT PRIOR TO THE SOFTWARE UPDATE OF 11/27/2007, THE VEHICLES CAN IMPROPERLY CLASSIFY AN ADULT AS A CHILD RESTRAINT SEAT AND THUS ILLUMINATE THE AIRBAG OFF WARNING LIGHT AND SUPPRESS THE FRONTAL PASSENGER AIRBAG.ON MAY 12, 2009, KIA LAUNCHED A TECHNICAL SERVICE BULLETIN (SB076) CAMPAIGN TO RE-FLASH ALL VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.KIA ALSO BELIEVES THAT INTERMITTENT OCCUPANT MOVEMENT AND OUT OF POSITION SEATING CONTRIBUTED TO THE HIGH NUMBER OF COMPLAINTS.905 OF THE 947 COMPLAINTS AND 1,014 OF THE 1,107 WARRANTY CLAIMS WERE ASSOCIATED WITH THE 57,228 VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.THERE WAS ONE FRONTAL PASSENGER AIRBAG NON-DEPLOYMENT CRASH THAT RESULTED IN ONE MINOR INJURY OF A BELTED ADULT PASSENGER OCCUPANT.THIS PRELIMINARY EVOLUTION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-017) TO FURTHER ASSESS THIS ISSUE FOR ALL MY2007-2008 SORENTO VEHICLES BUILT PRIOR TO THE 11/27/2007 PRODUCTION DATE.
Illustration