2004 Kia Sorento

I WAS DRIVING THE CAR WHEN I SUDDENLY STARTED HEARING RATTLING NOISES FROM THE ENGINE. THE POWER STEERING STOPPED WORKING AND THE STEERING WHEEL WOULD NOT TURN. THANKFULLY, I WAS ON A SIDE STREET WITH NO OTHER TRAFFIC. IF I HAD BEEN IN TRAFFIC OR TRAVELING AT A HIGHER SPEED, THIS WOULD SURELY HAVE CAUSED A CRASH. MY MECHANIC SAYS THAT THE CRANKSHAFT BOLT IS SHEARED OFF AND MUST BE DRILLED OUT TO BE REPLACED. KIA WON'T COVER THIS EXPENSIVE REPAIR, SAYS IT IS NOT COVERED BY THEIR WARRANTY. AFTER RESEARCHING THIS ISSUE, I SEE THAT KIA IS AWARE OF A DEFECT IN THE BOLT AND HAS ISSUED SERVICE BULLETINS AND DISCONTINUED THE BOLT, ISSUING A NEW PART TO REPLACE IT. THERE ARE ALREADY NUMEROUS COMPLAINTS ON THIS AND OTHER SITES DUE TO THIS ISSUE, SPANNING SEVERAL MODEL YEARS. TO DATE, I HAVE NOT SEEN A RECALL FROM KIA. DANGEROUS DEFECT AND ALARMING LACK OF CONCERN (NOT TO MENTION CUSTOMER SERVICE) FROM KIA. I WOULD NEVER HAVE BOUGHT THIS CAR IF I HAD KNOWN THE GAMBLE I WAS TAKING WITH MY FAMILY'S SAFETY. I HOPE OTHERS WILL NOT MAKE THE SAME MISTAKE. *TR

TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS, STEERING BECAME VERY DIFFICULT AND THE BATTERY, CHECK ENGINE, AND BRAKE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE CATALYTIC CONVERTER AND THE CRANK SHAFT BOLT AND PIN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 94,186 AND THE CURRENT MILEAGE WAS APPROXIMATELY 120,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2004 KIA SORENTO EX. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THERE WAS AN UNEXPECTED LOSS OF POWER STEERING. THE CONTACT MANEUVERED THE VEHICLE TO A PARKING LOT WITH DIFFICULT IN TURNING THE STEERING WHEEL. THE VEHICLE WAS THEN TOWED TO AN INDEPENDENT MECHANIC WHO INFORMED THE CRANK SHAFT BOLT FRACTURED. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED.THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 71,000.

WE HAVE HAD 4 INSTANCES WITH THE SAME ISSUE IN THE FIXING THE PULLEY CRANK SHAFT. JUNE 30, 08, (RECALL) OCTOBER 6, 09, AUG 10, 10 AND ONCE AGAIN SEPT 18,12. THIS IS THE SAME ISSUE THAT CAUSES YOU TO LOOSE STEERING WHILE DRIVING WITH APPARENTLY NO WARNING. I FIND THIS EXTREMELY TROUBLING AS WE HAVE A NEW DRIVER LEARNING WITH THIS CAR. WE ARE LUCKY TO REPORT THAT THERE HAVE BEEN NO ACCIDENTS OR DEATHS BUT I THINK IT IS A VERY DANGEROUS SITUATION THAT WILL SOON HAPPEN. THE DEALER WAGNER KIA OF SHREWSBURY,MA FEELS THAT IT IS NOT AN ISSUE AND IS JUST FROM WEAR AND TEAR. 4 TIMES FOR THE SAME PROBLEM? OBVIOUSLY KIA HAS NOT FIXED THE PROBLEM CORRECTLY. IT ANGERS ME THAT KIA IS NOT TAKING THIS SERIOUSLY. WE DRIVE OUR CHILDREN AS WELL AS OTHER CHILDREN IN THIS CAR AND COULD OF HAD SERIOUS TO FATAL INJURIES. FROM THIS BOLT SHEARING OFF IT HAS ALSO CAUSED OTHER MAJOR DAMAGE TO THE CAR THAT WE HAVE ALREADY HAD FIXED. *TR

TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED WHILE DRIVING 60 MPH THE POWER STEERING FAILED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED HE USED THE WRONG STEERING FLUID IN THE VEHICLE, WHICH CAUSED THE FAILURE. THE CONTACT EMAILED THE MANUFACTURER AND WAS AWAITING A RESPONSE. THE FAILURE MILEAGE WAS 56,000 AND THE CURRENT MILEAGE WAS 60,000.