Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
350–25K
3725–50K
5050–75K
4275–100K
57100–150K
22150K+
243 reports with mileage · 62 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports3 fire reports8 injury reports
What owners actually said
305 reports
36,000 miles · Sep 22, 2014
Service BrakesSteering
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE MADE AN ABNORMAL NOISE WHEN THE BATTERY AND ANOTHER UNKNOWN WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT HAD TO PUMP THE BRAKE PEDAL SEVERAL TIMES BEFORE THE VEHICLE WOULD STOP AND THE POWER STEERING STOP WORKI…
Read full complaint
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE MADE AN ABNORMAL NOISE WHEN THE BATTERY AND ANOTHER UNKNOWN WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT HAD TO PUMP THE BRAKE PEDAL SEVERAL TIMES BEFORE THE VEHICLE WOULD STOP AND THE POWER STEERING STOP WORKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE CRANK SHAFT PULLEY BOLT WAS HOLDING TOO MUCH WEIGHT CAUSING IT TO FRACTURE. THE VEHICLE HAD BEEN REPAIRED BUT THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 36,000.
NHTSA ODI #10638149
Mileage unknown · Aug 31, 2014
Engine
THE OVERFLOW BOTTLE FOR THE RADIATOR HAS BEEN LEAKING AGAIN. THE FIRST ONE THAT CAME WITH THE CAR WAS REPLACED IN 2011 AND NOW WE ARE HAVING TO REPLACE THE RADIATOR RESERVOIR AGAIN. *TR
NHTSA ODI #10629793
Mileage unknown · Aug 31, 2014
Visibility/wiper
THE WIPER MOTOR STRIPS OUT EASILY. TOOK IT IN TO HAVE IT FIXED AND IT STILL SLAMS DOWN INTO THE CAR. I WENT BACK IN AND IT STILL DOESN'T WORK. NOW IT COMPLETELY QUIT. *TR
NHTSA ODI #10629792
88,676 miles · Aug 30, 2014
Fuel/propulsion System
WE WERE ATTEMPTING TO FILL THE SORENTO UP WITH GAS WHEN IT SUDDENLY SPIT GAS OUT OF THE TANK WHEN WE HAD ONLY PUT $11 INTO TO. IT WAS CLOSE TO EMPTY WHEN WE GOT TO THE GAS STATION. WE TRIED A COUPLE TIMES WITH THE SAME RESULT. THE CAR WOULD NOT TAKE ANYMORE GAS. *TR
NHTSA ODI #10629630
122,049 miles · Aug 27, 2014
Engine
I WAS TOLD BY THE MECHANIC THAT "SOMETHING HAPPENED INSIDE THE ENGINE THAT CANNOT BE REPAIRED". PRIOR TO THE ENGINE FAILURE (MAY, 2014) THE REAR THROTTLE PLATE CAME APART AND LODGED IN THE LOWER INTAKE MANIFOLD. THE MECHANIC WAS UNABLE TO RETRIEVE THE SCREWS AND ONE WAS EVEN LODGED IN A CYLINDER HEAD. A THROTTLE PLATE ASSEMBL…
Read full complaint
I WAS TOLD BY THE MECHANIC THAT "SOMETHING HAPPENED INSIDE THE ENGINE THAT CANNOT BE REPAIRED". PRIOR TO THE ENGINE FAILURE (MAY, 2014) THE REAR THROTTLE PLATE CAME APART AND LODGED IN THE LOWER INTAKE MANIFOLD. THE MECHANIC WAS UNABLE TO RETRIEVE THE SCREWS AND ONE WAS EVEN LODGED IN A CYLINDER HEAD. A THROTTLE PLATE ASSEMBLY WAS INSTALLED AND THE CAR WAS DRIVABLE BUT WITH AN AUDIBLE NOISE. AT THIS TIME I WAS TOLD THE SAME PROBLEM EXISTS WITH MANY KIA'S AND YET A RECALL HAS NOT BEEN ISSUED. MY CAR IS NOT DRIVABLE, IT'S A V6 AND THE LEFT SIDE OF THE ENGINE IS COMPLETELY SHUT DOWN AND I FEEL KIA COULD HAVE AVOIDED THIS WITH A RECALL WHEN THEY HAVE KNOWN FOR YEARS THAT THE PROBLEM EXISTS. *TR
NHTSA ODI #10628837
96,000 miles · Aug 26, 2014
EngineSteering
I BOUGHT A 2003 KIA SORENTO FROM MY NIECE BACK IN NOVEMBER 2013 FOR $2000 AND NOT EVEN TWO WEEKS INTO OWNING THIS VEHICLE, THE CRANK SHAFT BROKE IN HALF! THE BOLT BROKE OFF IN HALF INSIDE THE CRANK SHAFT PULLEY AND THE OTHER HALF OF THE BOLT WAS INSIDE THE CRANK SHAFT CASE. TO MY UNDERSTANDING, THIS IS THE SECOND TIME THAT THE C…
Read full complaint
I BOUGHT A 2003 KIA SORENTO FROM MY NIECE BACK IN NOVEMBER 2013 FOR $2000 AND NOT EVEN TWO WEEKS INTO OWNING THIS VEHICLE, THE CRANK SHAFT BROKE IN HALF! THE BOLT BROKE OFF IN HALF INSIDE THE CRANK SHAFT PULLEY AND THE OTHER HALF OF THE BOLT WAS INSIDE THE CRANK SHAFT CASE. TO MY UNDERSTANDING, THIS IS THE SECOND TIME THAT THE CRANK SHAFT NEEDED REPAIRING (MY NIECE, HUSBAND WHO WERE THE FIRST AND ORIGINAL OWNERS TO THIS KIA SORENTO HAD IT BREAK DOWN ON HIM ON THE FREEWAY AS WELL, HAD TO GET IT TOWED TO KIA THEN PAID THEM TO FIX IT WHEN THEY OWNED THE VEHICLE) BUT THIS TIME, WHEN THIS ISSUE HAPPENED AGAIN WHILE I OWNED THE VEHICLE, THE CRANK SHAFT FAILED IN A GREATER AND MORE COSTLY CONDITION THEN THE FIRST TIME THE CRANK SHAFT FAILED ON THEM. WHICH THEN CAUSED ENGINE FAILURE, LOSS OF POWER STEERING, LOSS OF THE CHARGING SYSTEM, LOSS OF THE COOLING SYSTEM AND LOSS OF CONTROL OF THE VEHICLE, EVERYTHING SHUT DOWN, VEHICLE WOULDN'T START UP AFTER THAT AND IT COULD HAVE BEEN A VERY DANGEROUS SITUATION AS IT HAPPENED WHILE ON THE FREEWAY AND WHILE MY HUSBAND, MY DAUGHTER AND MY GRANDDAUGHTER WAS IN THE VEHICLE TRAVELING. IT COULD HAVE JEOPARDIZE THEIR LIFE'S AS WELL AS OTHER! *TR
NHTSA ODI #10628320
80,000 miles · Aug 25, 2014
Fuel/propulsion System
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT EXPERIENCED DIFFICULTY PLACING FUEL IN THE VEHICLE. THE FUEL WOULD NOT ENTER THE TANK AND LEAKED OUT WHILE THE CONTACT ATTEMPTED TO INSERT FUEL. AN INDEPENDENT MECHANIC STATED THAT THE VEHICLE NEEDED A NEW CANISTER FILTER, FUEL CAP, AND FILLER PIPE. THE VEHICLE HAD NOT BEEN RE…
Read full complaint
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT EXPERIENCED DIFFICULTY PLACING FUEL IN THE VEHICLE. THE FUEL WOULD NOT ENTER THE TANK AND LEAKED OUT WHILE THE CONTACT ATTEMPTED TO INSERT FUEL. AN INDEPENDENT MECHANIC STATED THAT THE VEHICLE NEEDED A NEW CANISTER FILTER, FUEL CAP, AND FILLER PIPE. THE VEHICLE HAD NOT BEEN REPAIRED AND THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. UPDATED 10/8/14*CN THE CONSUMER STATED THE MANUFACTURER WAS CONTACTED. THE MANUFACTURER STATED THE VEHICLE WAS OUT OF WARRANTY. THE CONSUMER WAS NOT NOTIFIED OF ANY RECALLS DUE TO BEING THE SECOND OWNER. THE VEHICLE WAS REPAIRED AT THE OWNER'S EXPENSE. UPDATED 3/24/2015 *JS
NHTSA ODI #10628094
140,000 miles · Aug 16, 2014
Air BagsService BrakesSteering
I WAS COMING HOME FROM WORK ONE DAY ,WHEN THE CRANKSHAFT BOLT CAME OUT OF MY CAR .I BARELY MADE IT HOME .BUT THE FRONT END WAS JARRING MY AIRBAG LIGHT CAME ON MY BREAKS LIKE SAME ONE AND I DID NOT HAVE NO CONTROL OF MY STEERING .THEN IT COST ME 1700 .THEN ONE DAY I WAS IN TOWN AND THE CRANKSHAFT BOLT CAME OUT OF MY CAR AGAIN WHI…
Read full complaint
I WAS COMING HOME FROM WORK ONE DAY ,WHEN THE CRANKSHAFT BOLT CAME OUT OF MY CAR .I BARELY MADE IT HOME .BUT THE FRONT END WAS JARRING MY AIRBAG LIGHT CAME ON MY BREAKS LIKE SAME ONE AND I DID NOT HAVE NO CONTROL OF MY STEERING .THEN IT COST ME 1700 .THEN ONE DAY I WAS IN TOWN AND THE CRANKSHAFT BOLT CAME OUT OF MY CAR AGAIN WHICH THIS TIME I DID NOT HAVE NO CONTROL OF THE STEERING IT TOOK EVERY MUSCLE THAT I HAD TO KEEP IT IN THE ROAD THE FRONT AND SHOOK SO BAD IT JARRED EVERYTHING I LOSE MY AIRBAG LIGHT CAME ON MY BRAKE LIGHTS CAME ON SEAT BELT LIGHT CAME ON IT WAS A HAZARDOUS ON THE HIGHWAY SERIOUSLY KILLED ME OR SOMEONE ELSE OR REALLY BADLY HURT THEM.THEN I TOOK IT BACK TO THE MECHANIC AGAIN AND HE SAID WELCOME IT'S GOING TO COST YOU 1700 MORE WHICH I DID NOT HAVE SO I LET THE BANK HAVE IT BACK WHICH NOW IT HAS RUN MY CREDIT BECAUSE I DIDN'T HAVE THE MONEY TO GET IT FIXED AND I LOST MY CREDIT BECAUSE OF THISSO YES THEY NEED TO DO A RECALL ON THE CRANKSHAFT BOLT BEFORE IT DOES KILL SOMEONE IS THAT WHAT THEY'RE WAITING FOR FOR SOMEONE TO DIE BEFORE THEY DO SOMETHING ABOUT.AND I KEEP ON REPLACING BUGS BRAKE LIGHTS HEADLIGHTS AND EVERYTHING THEY KEEP ON BLOWING IN THIS IN THE KIA AND I KEEP ON PUTTING MONEY IN IT FOR ME TO GET IT INSPECTED IT COST ME A HUNDRED SIXTY TWO DOLLARS AND 22 DISH TO REPLACE BULBS THAT I JUST REPLACE NOT EVEN A MONTH BEFORE THAT I HAVE RECEIPTS I AM SO TIRED OF PUTTING MONEY INTO THIS KIA I DIDN'T HAVE NO OTHER CHOICE BUT TO LET THEM TAKE IT BECAUSE IT C AND THE TIRES AT 8 MY TIRES UP AND I PUT NEW TIRES ON WHICH COST ME 800 800 AGAIN TO PUT IN800 AGAIN TO PUT INAND WHEN THIS BIT WHEN THIS HAPPENED I CALLED KIA IN CHARLOTTESVILLE VIRGINIA AND THEY SAID THEY PUT A NEW CRANK BOLT IN AT THE KIDS EMBRACE CHEVROLET BEFORE I BOARDED SO THIS WOULD MAKE THREE TIMES THE CRANKSHAFT BOLT HAD BEEN REPLACED I WANT THIS KIA..................
NHTSA ODI #10625724
118,892 miles · Jul 24, 2014
Fuel System, Gasoline
FUEL LINE LEAKING. FIXED AND NOW LEAKING AGAIN SOMEPLACE ELSE. *TR
NHTSA ODI #10616152
133,000 miles · Jul 22, 2014
Fuel/propulsion System
WHILE PUMPING, THE FUEL SPITS BACK OUT FROM THE TANK. IT IS RATHER ANNOYING AS I LOSE MONEY FUELING AND IT TAKES FOREVER TO FUEL. NORMALLY WHEN I REACH ABOUT $15.00 IN GAS IT BEGINS REGURGITATING. THIS HAPPENS EVERY TIME I ATTEMPT TO FUEL. *TR
CERTAIN SPORT UTILITY VEHICLES MAY EXPERIENCE A FUEL LEAK FROM FUEL TUBES NEAR THE FUEL TANK DUE TO AN INTERFERENCE FIT WITH THE VEHICLE FLOOR PANEL.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE A SECTION OF THE FUEL LINE. THE RECALL BEGAN ON OCTOBER 10, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE10023 · Fuel Spill During Refueling
Opened Jul 12, 2010 · Closed Dec 21, 2011
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Additional source detail variants (4)
Fuel System, Gasoline
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Fuel System, Gasoline:storage
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Fuel System, Gasoline:storage:tank Assembly
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Illustration