IllustrationFULE IS SHOOTING BACK OF GAS TANK WHILE PUTTING IN GAS.THIS IS VERY DANGEROUS. PLEAS TELL ME A FIX FOR THIS. CAR IS STATIONARY.
2003 Kia Sorento
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Kia Sorento do not stand out strongly from the model-year median of 242.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sorento years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
350–25K
3725–50K
5050–75K
4275–100K
57100–150K
22150K+
243 reports with mileage · 62 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports3 fire reports8 injury reports
What owners actually said
305 reportsI ATTEMPTED TO FILL MY 2003 KIA SOENTO EX AND AFTER PUMPMING ABOUT $2.75 WORTH OF GAS, THE FUEL BEGAN TO SPIT BACK UP THROUGH THE FILLER HOSE AND SPURTED/ GUSH BACK OUT ON TO ME. IT GIVES YOU A FALSE SENSE THAT THE TANK IS FULL BUT IT'S NOT. I ATTEMPTED TO RE-FUEL AND AGAIN, THE GAS SPURT/ GUSH BACK OUT. I COULD GET NO MORE THAN…
Read full complaint
I ATTEMPTED TO FILL MY 2003 KIA SOENTO EX AND AFTER PUMPMING ABOUT $2.75 WORTH OF GAS, THE FUEL BEGAN TO SPIT BACK UP THROUGH THE FILLER HOSE AND SPURTED/ GUSH BACK OUT ON TO ME. IT GIVES YOU A FALSE SENSE THAT THE TANK IS FULL BUT IT'S NOT. I ATTEMPTED TO RE-FUEL AND AGAIN, THE GAS SPURT/ GUSH BACK OUT. I COULD GET NO MORE THAN $5.00 DOLLARS IN THE CAR. I SPOKE WITH THE KIA DEALERSHIP IN LITHONIA, GEORGIA AND THEY TOLD ME THAT THEY HAVE NEVER HEARD OF SUCH A MATTER. I WAS INSTRUCTED TO BRING THE VEHICLE BACK. HOWEVER, I BEGAN TO RESEARCH THIS MATTER AND IT WAS INVESTIGATED BY YOU ALL. KIA DID STATE THAT THEY WOULD LOOK INTO THE MATTER. I'M NOT CONFIDENT THAT WILL HAPPEN. THERE ARE THOUSANDS OF COMPLAINTS OUT THERE AMONG CONSUMERS ABOUT THIS SAME VEHICLE BETWEEN THE 2003 THROUGH 2006. PLEASE INVESTIGATE! I DO BELIEVE THAT THIS IS A RECALL ITEM. THE 2003 KIA SORENTO WAS THE FIRST VEHICLE MADE BY KIA CORPORATION.
WHILE DRIVING ON HIGHWAY APPROX 55MPH THE CAR JUST POWER. DEAD GAS PEDAL. HAD TO GET OVER TO SHOULDER BUT COULD NOT DUE TO THE STEERING LOCKING UP AND THE CAR SHUTTING DOWN. I GOT ASSISTANCE FROM PASSERBY WHO GO ME OVER TO SHOULDER. I STARTED UP THE CAR AND IT STARTED UP AND RAN WITH NO ISSUE. SUDDEN SHUT DOWM OF ENGINE IS VERY …
Read full complaint
WHILE DRIVING ON HIGHWAY APPROX 55MPH THE CAR JUST POWER. DEAD GAS PEDAL. HAD TO GET OVER TO SHOULDER BUT COULD NOT DUE TO THE STEERING LOCKING UP AND THE CAR SHUTTING DOWN. I GOT ASSISTANCE FROM PASSERBY WHO GO ME OVER TO SHOULDER. I STARTED UP THE CAR AND IT STARTED UP AND RAN WITH NO ISSUE. SUDDEN SHUT DOWM OF ENGINE IS VERY DANGEROUS. ONCE I GOT HOME AND HAD THE CAR CHECKED THE MECHANIC COULD NOT DUPLICATE THE INCIDENT IN ORDER TO MAKE REPAIRS. THIS HAPPENED 2 MORE TIMES AND ONLY HAPPENS TO ME ON HIGHWAY DRIVING. NEVER IN CITY DRIVING.
AIRBAG INDICATOR TURNED ON AND HAS BEEN ON SINCE THE BEGINNING OF THE YEAR. I HAVE NOT BEEN DRIVING THE VEHICLE SINCE THE INDICATOR LIGHT TURNED ON IN FEAR OF THE AIRBAGS DEPLOYING ON THEIR OWN WHILE I'M DRIVING OR NOT DEPLOYING IF AN ACCIDENT OCCURS.
THE CAR STARTED MAKING A SCRUBBING SOUND AND THE BRAKES WOULD NOT WORK. THE NEXT DAY THE BRAKES WORKED SCRUBBING SOUND CONTINUED AND WE WERE TOLD BY THE MECHANIC THAT THE ENGINE NEEDS REPLACING.
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING AT 55 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL IN ORDER TO TURN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE HARMONICA BALANCE IN THE STEERING COLUMN NEEDED TO BE REPLACED. …
Read full complaint
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING AT 55 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL IN ORDER TO TURN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE HARMONICA BALANCE IN THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. IN ADDITION, THE CONTACT NOTICED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE HARMONICA BALANCE NEEDED TO BE REPLACED AND THE REAR AXLE CORRODED AND NEEDED TO BE WELDED. THE VEHICLE WAS REPAIRED; HOWEVER, WHILE AT AN INDEPENDENT MECHANIC FOR ROUTINE SERVICE, THE MECHANIC STATED THAT THE SUBFRAME WAS CORRODED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 79,000.
THE BOLT HOLDING THE HARMONIC BALANCER PULLEY TO THE CRANKSHAFT FELL OUT AND ALL THE ENGINE BELTS AND PULLEYS STOPPED TURNING RESULTING IN A LOSS OF POWER STEERING, AND MAKING THE VEHICLE VERY DIFFICULT TO STEER. THIS HAPPENED AT A LOW SPEED AND THE DRIVER WAS BARELY ABLE TO TURN OFF THE ROAD WITHOUT AN ACCIDENT. AT A HIGHER S…
Read full complaint
THE BOLT HOLDING THE HARMONIC BALANCER PULLEY TO THE CRANKSHAFT FELL OUT AND ALL THE ENGINE BELTS AND PULLEYS STOPPED TURNING RESULTING IN A LOSS OF POWER STEERING, AND MAKING THE VEHICLE VERY DIFFICULT TO STEER. THIS HAPPENED AT A LOW SPEED AND THE DRIVER WAS BARELY ABLE TO TURN OFF THE ROAD WITHOUT AN ACCIDENT. AT A HIGHER SPEED, IN HEAVY TRAFFIC, OR ON MOUNTAIN ROADS, THE RESULT WOULD LIKELY HAVE BEEN MUCH WORSE. THE CAR WAS TOWED TO A KIA DEALER AND REPAIRED FOR APPROXIMATELY $1,500.00, REPLACING THE FAILED PARTS WITH NEW PARTS AND WITH A WARRANTY OF 12 MONTHS/10 THOUSAND MILES. PREVIOUSLY, AT 70 THOUSAND MILES AS PREVENTIVE MAINTENANCE, THE TIMING BELT WAS REPLACED BY A KIA DEALER. KIA MOTORS, HAVING KNOWN OF MANY FAILURES OF THE BOLT, SPROCKET, AND PULLEY, SHOULD HAVE UPGRADED THESE PARTS YEARS AGO AND ISSUED A RECALL OR AT LEAST A SERVICE BULLETIN TO AVOID SUCH DANGEROUS FAILURES. AFTER OUR EXPERIENCE, WE DID NOT TRUST THIS CAR AND TRADED IT IN FOR A NEW CAR FROM HOPEFULLY A MORE RESPONSIBLE MANUFACTURER.
ENGINE LIGHT IS ON, AIRBAG LIGHT IS ON, CLOCK CAN'T KEEP RIGHT TIME, NOW WON'T START AT ALL, I WISHED I NEVER BOUGHT THIS 2003 KIA SORENTO, THEY ARE NOTHING BUT JUNK. PLEASE ANYBODY WHO READS THIS DO NOT BUY A KIA VEHICLE. I HATE KIA VEHICLES, I WILL NEVER OWN ONE AGAIN, I WOULD NOT TAKE A KIA VEHICLE, EVEN IF THEY GIVE ME ONE. …
Read full complaint
ENGINE LIGHT IS ON, AIRBAG LIGHT IS ON, CLOCK CAN'T KEEP RIGHT TIME, NOW WON'T START AT ALL, I WISHED I NEVER BOUGHT THIS 2003 KIA SORENTO, THEY ARE NOTHING BUT JUNK. PLEASE ANYBODY WHO READS THIS DO NOT BUY A KIA VEHICLE. I HATE KIA VEHICLES, I WILL NEVER OWN ONE AGAIN, I WOULD NOT TAKE A KIA VEHICLE, EVEN IF THEY GIVE ME ONE. TO MANY PROBLEMS, SINCE I BOUGHT IT, HAVEN'T BEEN ANYWHERE IN TWO WEEKS, BECAUSE KIA VEHICLE IS JUNK.
ALL LIGHTS COME ON, HORN BLOWS, BUT WILL NOT START AT ALL, THIS KIA SORENTO IS JUNK, ITS FALLING APART, I GOT A DISABLE MOTHER, NOW CAN'T TAKE HER TO HER DOCTOR APPOINTMENTS, EVERY SINCE I HAD IT, ITS BEEN NOTHING BUT JUNK, WE LIVE ON FIXED INCOME, CAN'T AFFORD TO GET ANOTHER VEHICLE, AND THIS 2003 KIA SORENTO SHOULD NOT BE ON T…
Read full complaint
ALL LIGHTS COME ON, HORN BLOWS, BUT WILL NOT START AT ALL, THIS KIA SORENTO IS JUNK, ITS FALLING APART, I GOT A DISABLE MOTHER, NOW CAN'T TAKE HER TO HER DOCTOR APPOINTMENTS, EVERY SINCE I HAD IT, ITS BEEN NOTHING BUT JUNK, WE LIVE ON FIXED INCOME, CAN'T AFFORD TO GET ANOTHER VEHICLE, AND THIS 2003 KIA SORENTO SHOULD NOT BE ON THE ROAD, ALL KIA SORENTO VEHICLES ARE JUNK, CLOCK IS MESSED UP, COMES OFF AND ON, AIRBAG LIGHT IS ON, NOW WON'T EVEN START AT ALL, SOMETHING NEEDS TO BE DONE ABOUT KIA DEALERSHIPS SELLING JUNK VEHICLES, WILL COMPLAIN AGAIN AND AGAIN, THEY ARE JUNK!
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT THE FUEL WAS NOT GOING INTO THE FUEL TANK PROPERLY UPON REFUELING THE VEHICLE AND THERE WAS A CLICKING NOISE AS IF IT WERE FULL. THE CONTACT HAD TO TAKE AN EXTENDED PERIOD OF TIME TO ENSURE THE FUEL TANK WAS ACTUALLY FULL. THE VEHICLE WAS TAKEN TO THE DEALER AND TH…
Read full complaint
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT THE FUEL WAS NOT GOING INTO THE FUEL TANK PROPERLY UPON REFUELING THE VEHICLE AND THERE WAS A CLICKING NOISE AS IF IT WERE FULL. THE CONTACT HAD TO TAKE AN EXTENDED PERIOD OF TIME TO ENSURE THE FUEL TANK WAS ACTUALLY FULL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY DID NOT DIAGNOSE THE FAILURE. THE VEHICLE WAS TO BE TAKEN TO AN INDEPENDENT MECHANIC TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V353000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.
Official recalls
105V353000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Aug 4, 2005
CERTAIN SPORT UTILITY VEHICLES MAY EXPERIENCE A FUEL LEAK FROM FUEL TUBES NEAR THE FUEL TANK DUE TO AN INTERFERENCE FIT WITH THE VEHICLE FLOOR PANEL.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE A SECTION OF THE FUEL LINE. THE RECALL BEGAN ON OCTOBER 10, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10023 · Fuel Spill During Refueling
Opened Jul 12, 2010 · Closed Dec 21, 2011
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Additional source detail variants (4)
Fuel System, Gasoline
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Fuel System, Gasoline:storage
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Fuel System, Gasoline:storage:tank Assembly
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.