IllustrationTL* THE CONTACT OWNS A 2003 KIA SORENTO. WHEN REFUELING THE VEHICLE, FUEL EJECTED OUT OF THE REFUELING HOLE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 101,300.
2003 Kia Sorento
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Kia Sorento do not stand out strongly from the model-year median of 242.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sorento years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
350–25K
3725–50K
5050–75K
4275–100K
57100–150K
22150K+
243 reports with mileage · 62 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports3 fire reports8 injury reports
What owners actually said
305 reportsAIR BAGS COIL SPRING HAS BEEN REPLACED 4 TIMES. THE AIR BAG WARNING LIGHT IS ALWAYS ON AND KIA REFUSES TO FIX THE PROBLEM. I DON'T KNOW IF THE AIR BAGS WILL DEPLOY IN CASE OF A ACCIDENT. THIS IS BEEN A PROBLEM FROM THE DAY I PURCHASE THE CAR. I DON'T KNOW THE MAKER OF THE AIR BAG SISTEM.
EVERY TIME I HAVE TO FILL THE GAS TANK ON MY KIA SORENTO 2003 IT SHOOTS BACK THE GASOLINE LIKE A PROYECTILE. IT TAKES AN ETERNITY TO FILL THE GAS TANK IF YOU DON'T WANT TO HAVE GAS ALL OVER YOU. I HAVE EVEN BEING KICKED OUT OF SOME SERVICE STATIONS BECAUSE SPILING SO MUCH GAS IS A HAZARD. IS THERE ANY SAFETY RECALL FOR THIS PR…
Read full complaint
EVERY TIME I HAVE TO FILL THE GAS TANK ON MY KIA SORENTO 2003 IT SHOOTS BACK THE GASOLINE LIKE A PROYECTILE. IT TAKES AN ETERNITY TO FILL THE GAS TANK IF YOU DON'T WANT TO HAVE GAS ALL OVER YOU. I HAVE EVEN BEING KICKED OUT OF SOME SERVICE STATIONS BECAUSE SPILING SO MUCH GAS IS A HAZARD. IS THERE ANY SAFETY RECALL FOR THIS PROBLEM? I HAVE NOT HEARD A WORD FROM KIA.
THE DRIVER DOOR CANNOT BE OPENED FROM INSIDE OR OUTSIDE. I UNDERSTAND THIS IS A COMMON PROBLEM WITH KIA SORENTOS.
WHILE DRIVING I HEARD A CLUNK AND A THE CAR BEGAN ROLLING SIDE TO SIDE. I LIMPED TO A MECHANIC AND WAS TOLD THAT THE FRAME WHERE THE SUSPENSION AND ALL PARTS CONNECT WAS RUSTED OUT. FRAME REPAIR SAID THIS CAN NOT BE FIXED AS THE FRAME IS RUSTED OUT. WHERE THE STABILIZER AND SUSPENSION CONNECTS. TEH CAR ONLY HAS 149,OOO MILES AND…
Read full complaint
WHILE DRIVING I HEARD A CLUNK AND A THE CAR BEGAN ROLLING SIDE TO SIDE. I LIMPED TO A MECHANIC AND WAS TOLD THAT THE FRAME WHERE THE SUSPENSION AND ALL PARTS CONNECT WAS RUSTED OUT. FRAME REPAIR SAID THIS CAN NOT BE FIXED AS THE FRAME IS RUSTED OUT. WHERE THE STABILIZER AND SUSPENSION CONNECTS. TEH CAR ONLY HAS 149,OOO MILES AND IS IN NORTH CAROLINA. I HAVE READ OTHER REPORTS OF A RUSTED OUT SUPPORT FRAME ON THIS SITE. WILL THE MANUFACTURER REPLACE THIS FRAME.
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE STATIONARY, THE VEHICLE SPEWED FUEL ONTO THE GROUND WHEN FUEL WAS BEING ADDED. THIS ISSUE RECURRED REGARDLESS OF THE AMOUNT OF FUEL BEING ADDED TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 185,000.
THE CRANKSHAFT BOLT SUPPORTING THE TIMING SPROCKET AND BALANCE PULLEY SNAPPED AGAIN FOR THE THIRD TIME. RIGHT NOW THE VEHICLE IS IN THE THE KIA DEALER SERVICE CENTER TO REPLACE IT. ONCE AGAIN THEY ARE ASKING FOR A RIDICULOUS AMOUNT OF MONEY TO FIX. LAST BOLT LASTED 4,000 MILES BEFORE IT SNAPPED WHILE DRIVING 25 MPH.
TAKATA RECALL REAR FRAME CROSS MEMBER RUSTED OUT.
WHILE DRIVING ON ROUTE 495 NORTH IN MASSACHUSETTS BETWEEN EXITS 7 AND 8, MY KIA SORENTO LOST POWER TO THE ENGINE TO THE POINT I HAD TO STOP IN THE BREAKDOWN LANE. NO WARNING OF PRIOR SMELL OR POWER LOSS HAD OCCURRED PRIOR TO THE INCIDENT. TOWED TO TWO DIFFERENT SERVICE STATIONS AND BOTH INFORMED ME THAT THE ENGINE FAILED AND LOS…
Read full complaint
WHILE DRIVING ON ROUTE 495 NORTH IN MASSACHUSETTS BETWEEN EXITS 7 AND 8, MY KIA SORENTO LOST POWER TO THE ENGINE TO THE POINT I HAD TO STOP IN THE BREAKDOWN LANE. NO WARNING OF PRIOR SMELL OR POWER LOSS HAD OCCURRED PRIOR TO THE INCIDENT. TOWED TO TWO DIFFERENT SERVICE STATIONS AND BOTH INFORMED ME THAT THE ENGINE FAILED AND LOST COMPRESSION ON MORE THAN ONE CYLINDERS. VERY DANGEROUS SITUATION TO BE ON THE HIGHWAY AND LOSING POWER.
IT IS BEYOND ME HOW KIA MOTORS CAN GET AWAY WITH TELLING A BUNCH OF AUTOMOBILE ENGINEERS, THAT THE PROBLEM WITH THERE VEHICLES SPITTING BACK GASOLINE ONTO A PERSON AND KIA MOTORS TELLING THEM IT'S AN AIR FILTER. I TOOK MY2003 KIA SORENTO BACK TO THE DEALERS THINKING I WAS GOING TO GET A NEW CHARCOAL FILTER WHEN ALL WAS SAID AND …
Read full complaint
IT IS BEYOND ME HOW KIA MOTORS CAN GET AWAY WITH TELLING A BUNCH OF AUTOMOBILE ENGINEERS, THAT THE PROBLEM WITH THERE VEHICLES SPITTING BACK GASOLINE ONTO A PERSON AND KIA MOTORS TELLING THEM IT'S AN AIR FILTER. I TOOK MY2003 KIA SORENTO BACK TO THE DEALERS THINKING I WAS GOING TO GET A NEW CHARCOAL FILTER WHEN ALL WAS SAID AND DONE I RECEIVED A $20 AIR FILTER FOR THE CHARCOAL CHAMBER WHICH HAD NO PROBLEM TO BEGIN WITH. I STILL HAVE A 2003 KIA SORENTO THAT SPITS FUEL BACK ON TO ME AND I"M WAITING FOR THE DAY SOMEONE THROWS A CIGARETTE BUTT AT ME AND I CATCH FIRE< BECAUSE I WILL OWN KIA OF AMERICA AND A WEALTHY LAWSUIT AGAINST THE NATIONAL TRAFIC SAFETY PANEL. DO YOU KNOW I HAD A SHORT ACCESS TO A KIA SITE RECENTLY AND SEEN OVER 100 SERVICE BULLETINS, NOT JUST 8 THAT ARE ON THIS SITE I GUESS YOU PEOPLE FORGOT WHO YOU WORK FOR THE UNITED STSTES PEOPLE/NOT KIA MOTORS AND YOU CAN BET YOUR ASS I'M NOT DONE UNTIL EVERYONE OF MY SERVICE BULLETINS IS ADDRESSED SO YOU BEAN COUNTERS BETTER START FIGURING BLAME BECAUSE AS I SAID WHEN I'M DONE YOU'LL SEE THIS IS BULLSHIT IF THIS WERE FORD, CHEVY OR CHRYSLER YOU WOULD HAVE DRAGGED THEY'RE ASS ACROSS THE COALS WELL YOU BETTER START WITH THE SLANTY EYE KOREANS TOO. I KNEW THEIR WAS A REASON MY MOTHER DIDN'T WANT ME GOING INTO THEIR BOSTON STORES WHEN I WAS A KID. GOT HELP YOU IF THIS THING CATCHES FIRE WITH MY KIDS IN IT, BECAUSE MY 2 YEAR OLD IS STRAPPED RIGHT ABOVE YOUR NO PROBLEM WHATSOEVER I MADE BETTER GO KARTS WHEN I WAS 10 YEARS OLD I DONT KNOW WHAT THE GOVERNMENTS PROBLEM IS BUT IT BETTER BE TAKEN CARE OF OR YOU MAY FIND IT ON YOUR LAWN ON FIRE !!! *TR
Official recalls
105V353000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Aug 4, 2005
CERTAIN SPORT UTILITY VEHICLES MAY EXPERIENCE A FUEL LEAK FROM FUEL TUBES NEAR THE FUEL TANK DUE TO AN INTERFERENCE FIT WITH THE VEHICLE FLOOR PANEL.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE A SECTION OF THE FUEL LINE. THE RECALL BEGAN ON OCTOBER 10, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10023 · Fuel Spill During Refueling
Opened Jul 12, 2010 · Closed Dec 21, 2011
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Additional source detail variants (4)
Fuel System, Gasoline
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Fuel System, Gasoline:storage
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Fuel System, Gasoline:storage:tank Assembly
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.