AIR BAG LIGHT CAME ON AND STAYED ON. TOOK TO KIA DEALERSHIP WHERE I PURCHASED 2003 KIA SORENTO (NEW) WAS TOLD THAT THE "CLOCK SPRING" NEEDED TO BE REPLACED AND THAT IT WAS VERY COMMON THAT THEY HAD TO BE REPLACED. I WAS TOLD THAT I HAD TO PAY FOR REPAIR. I ASKED IF IT WAS A COMMON PROBLEM THAT THEY HAD TO REPLACE A LOT WHY HAD I…
Read full complaint
AIR BAG LIGHT CAME ON AND STAYED ON. TOOK TO KIA DEALERSHIP WHERE I PURCHASED 2003 KIA SORENTO (NEW) WAS TOLD THAT THE "CLOCK SPRING" NEEDED TO BE REPLACED AND THAT IT WAS VERY COMMON THAT THEY HAD TO BE REPLACED. I WAS TOLD THAT I HAD TO PAY FOR REPAIR. I ASKED IF IT WAS A COMMON PROBLEM THAT THEY HAD TO REPLACE A LOT WHY HAD IT NOT BEEN A "SAFETY ISSUE" AND A RECALL BEEN ENACTED. THEY DID NOT KNOW. *NM
NHTSA ODI #10152718
65 miles · Jan 25, 2005
Air Bags
THE AIR BAG SENSOR LOCATED IN THE FRONT PASSENGER SEAT DID NOT ENGAGED WHEN A PASSENGER SAT IN THE, SEAT. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY WERE UNABLE TO RESOLVE THE PROBLEM. *JB
NHTSA ODI #10108788
1,000 miles · Dec 17, 2004
Air Bags
THE AIR BAG LIGHT WAS ON AFTER BEING SERVICED NINE TIMES. *JB
NHTSA ODI #10105036
Mileage unknown · Oct 18, 2004
Air BagsCrashInjury
THE AIR BAG DID NOT DEPLOY WHEN THE VEHICLE WAS INVOLVED IN A FRONT-END ACCIDENT. *BF AS A RESULT OF THE ACCIDENT AND THE AIR BAG NOT DEPLOYING, THE CONSUMER SUFFERED NECK AND BACK INJURIES. *JB
NHTSA ODI #10097348
31,500 miles · May 28, 2004
Air BagsEngine And Engine Cooling
I WAS DRIVING MY VEHICLE TO WORK. FOR THE PAST 2 TO 3 DAYS, I NOTICED SOME NOISE FROM MY ENGINE THAT SOUNDED LIKE A LOOSE BELT. NO PROBLEM, I COULD REPLACE IT ON THE WEEKEND. ON THE WAY TO WORK, MY POWER STEERING WENT AND THE ENGINE LIGHT FLICKERED ON AND OFF. I DIDN'T WANT TO BE STUCK ON A BACKROAD IN MAINE WITH NO CELL SERVICE…
Read full complaint
I WAS DRIVING MY VEHICLE TO WORK. FOR THE PAST 2 TO 3 DAYS, I NOTICED SOME NOISE FROM MY ENGINE THAT SOUNDED LIKE A LOOSE BELT. NO PROBLEM, I COULD REPLACE IT ON THE WEEKEND. ON THE WAY TO WORK, MY POWER STEERING WENT AND THE ENGINE LIGHT FLICKERED ON AND OFF. I DIDN'T WANT TO BE STUCK ON A BACKROAD IN MAINE WITH NO CELL SERVICE SO I CONTINUED, SLOWLY, TO WORK. AFTER REACHING WORK, I HAD THE 24 HOUR SERVICE TOW MY KIA SORENTO TO THE NEAREST DEALER. THIS VEHICLE IS 18 MONTHS OLD AND THEY TELL ME THE BOLT HOLDING THE CRANKSHAFT TO THE PULLEY HAS SHEARED OFF. THEY CANNOT REMOVE THE BOLT PIECES FROM THE CRANKSHAFT AND HAVE TO REPLACE IT. TO TOP IT OFF, THE AIRBAG LIGHT WAS ON, FOR THE SECOND TIME, AND THE RADIO HAS BEEN REPLACE TWICE. *LA
NHTSA ODI #10073282
Mileage unknown · Apr 13, 2004
Air Bags
WHILE DRIVING AND TURNING SRS LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC WAS NOT ABLE TO DETERMINE THE CAUSE OF THE PROBLEM. *AK
NHTSA ODI #10067114
17,800 miles · Apr 12, 2004
Air BagsVehicle Speed ControlCrash
ON SATURDAY, APRIL 3, 2004, MY 2003 KIA SORRENTO WAS PARKED IN THE MIDDLE OF MY DRIVEWAY WHILE I MOVED THE LAWN. AFTER RETURNING MY LAWN MOWER TO THE GARAGE, I GOT INTO THE SORRENTO TO MOVE IT BACK INTO THE GARAGE. AFTER I STARTED THE VEHICLE AND PUT IT INTO DRIVE, IT ACCELERATED RAPIDLY, PULLED ME THROUGH THE GARAGE AND THROUGH…
Read full complaint
ON SATURDAY, APRIL 3, 2004, MY 2003 KIA SORRENTO WAS PARKED IN THE MIDDLE OF MY DRIVEWAY WHILE I MOVED THE LAWN. AFTER RETURNING MY LAWN MOWER TO THE GARAGE, I GOT INTO THE SORRENTO TO MOVE IT BACK INTO THE GARAGE. AFTER I STARTED THE VEHICLE AND PUT IT INTO DRIVE, IT ACCELERATED RAPIDLY, PULLED ME THROUGH THE GARAGE AND THROUGH THE BACK WALL, WHICH IS SOLID BRICK. I WENT THROUGH MY FRONT YARD, AND THE ONLY REASON I STOPPED WAS BECAUSE THE VEHICLE WENT OVER SOME BOULDERS AND DOWN AN INCLINE, CAUSING THE BACK WHEELS TO COME OFF THE GROUND. I ALSO HIT A TREE IN MY FRONT YARD. THE AIR BAGS DID NOT DEPLOY.*AK
NHTSA ODI #10065957
Mileage unknown · Jan 25, 2004
Air Bags
I PURCHASED A 2003 EX KIA SORENTO IN JUNE 2003. ON JULY 13,2003 THE AIR BAG LIGHT SYSTEM CAME ON. THE VEHICLE WAS TAKEN TO BARRON KIA. THEY STATED THEY REPLACED THE AIR BAG MODULE. IT TOOK FIVE DAYS TO REPAIR. ON NOVEMBER 11, 2003 THE AIR BAG LIGHT WENT BACK ON. THE VEHICLE WAS TAKEN TO BARRON KIA ON THE 14TH. IT WAS AT THE D…
Read full complaint
I PURCHASED A 2003 EX KIA SORENTO IN JUNE 2003. ON JULY 13,2003 THE AIR BAG LIGHT SYSTEM CAME ON. THE VEHICLE WAS TAKEN TO BARRON KIA. THEY STATED THEY REPLACED THE AIR BAG MODULE. IT TOOK FIVE DAYS TO REPAIR. ON NOVEMBER 11, 2003 THE AIR BAG LIGHT WENT BACK ON. THE VEHICLE WAS TAKEN TO BARRON KIA ON THE 14TH. IT WAS AT THE DEALERSHIP FOR ANOTHER SIX DAYS. THEY STATED IT WAS THE LOJACK ALARM SYSTEM THAT WAS CAUSING THE PROBLEM. IT WAS FIXED. ON NOVEMBER 29,2003 THE AIRBAG LIGHT BEGAN TO FLICKER ON AND OFF. THE VEHICLE WAS TAKEN BACK TO BARRON KIA ON DECEMBER 3, 2003, IN ORDER FOR A LOJACK TECHNICIAN TO REMOVE THE ALARM AND FOR BARRON KIA TO FIX AND RUN TEST ON THE AIRBAG. THE CAR WAS THERE 11 DAYS AND SUPPOSEDLY CHECKED FOR ALL AIRBAG POSSIBLE PROBLEMS. ALL TEST CAME BACK NORMAL. ON JANUARY 19, 2004 THE AIRBAG LIGHT WENT BACK ON. THE CAR WAS ONCE AGAIN TAKEN TO BARRON KIA ON THAT DAY. AT THIS POINT, THE ALARM IS DISCONNECT AND THE AIR BAG CONTINUES TO ILLUMINATE AND INDICATING THAT THERE MAY BE A MALFUNCTION WITH THE SAFETY SYSTEM WITH THE CAR. THE VEHICLE IS STILL AT BARRON KIA (HAS BEEN THEIR 7 DAYS NOW) AND IS AWAITING THE INSTALLATION OF ANOTHER AIRBAG MODULE. I HAVE BEEN IN CONTACTED WITH THE KIA HOTLINE SEVERAL TIMES AS WELL AS LOJACK CUSTOMER SERVICE. NEITHER COMPANY WANTS TO TAKE RESPONSIBILITY OR ACCOUNTABILITY. IT IS DISTRESSING TO ME THAT SUCH COMPANIES WOULD JEOPARDIZES THE LIVES OF THEIR CUSTOMERS. I AM ALSO DISTURBED THAT A NEW CAR WOULD BE SOLD AND RETURNED TO ME SEVERAL TIMES WITH A DEFECTIVE SAFETY SYSTEM. *LA
NHTSA ODI #10054864
14,723 miles · Dec 26, 2003
Air Bags
1. (11/03/03 1ST INCIDENT) "AIR BAG" SYSTEM LIGHT CAME ON. VEHICLE WAS TAKEN TO JEFFERY KIA FOR REPAIR. I WAS CALLED TO PICKUP VEHICLE TWO DAYS LATER. (UNAWARE AT THE TIME THAT THE AIR BAG SYSTEM HAD BEEN DISABLED) WEEK LATER RECEIVED CALL THAT AIR BAG WAS IN AND TO RETURN VEHICLE FOR AIR BAG REPLACEMENT. REPAIR COMPLETED AND VE…
Read full complaint
1. (11/03/03 1ST INCIDENT) "AIR BAG" SYSTEM LIGHT CAME ON. VEHICLE WAS TAKEN TO JEFFERY KIA FOR REPAIR. I WAS CALLED TO PICKUP VEHICLE TWO DAYS LATER. (UNAWARE AT THE TIME THAT THE AIR BAG SYSTEM HAD BEEN DISABLED) WEEK LATER RECEIVED CALL THAT AIR BAG WAS IN AND TO RETURN VEHICLE FOR AIR BAG REPLACEMENT. REPAIR COMPLETED AND VEHICLE RETURNED NEXT DAY. 2.) (2ND INCIDENT) ON VACATION IN STARKE, FA., DECEMBER 24, 2003 "AIR BAG" SYSTEM LIGHT CAME ON. TOLD TO RETURN TO DEALER (KIA HOTLINE) DROVE 16 HOURS 12/25/03 TO GET VEHICLE TO JEFFERY KIA AND DELIVERED TO DEALER 12/26/03. I AM DISTURBED THAT VEHICLE WAS INITIALLY RETURNED TO ME IN UNSAFE CONDITION AND UNSATISFACTORILY REPAIRED AND PLACED MY GRAND CHILDREN IN JEOPARDY.*AK
NHTSA ODI #10051135
Mileage unknown · Apr 22, 2003
Air BagsCrash
THE VEHICLE WAS INVOLVED IN AN ACCIDENT, AND NONE OF THE AIR BAGS DEPLOYED. *JB
CERTAIN SPORT UTILITY VEHICLES MAY EXPERIENCE A FUEL LEAK FROM FUEL TUBES NEAR THE FUEL TANK DUE TO AN INTERFERENCE FIT WITH THE VEHICLE FLOOR PANEL.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE A SECTION OF THE FUEL LINE. THE RECALL BEGAN ON OCTOBER 10, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE10023 · Fuel Spill During Refueling
Opened Jul 12, 2010 · Closed Dec 21, 2011
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Additional source detail variants (4)
Fuel System, Gasoline
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Fuel System, Gasoline:storage
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Fuel System, Gasoline:storage:tank Assembly
Complaints allege that while refueling the vehicle, fuel can spill out or spit back from the fuel filler port on model year (MY) 2003 Kia Sorento vehicles (subject vehicles).Consumers report that the spilled fuel can splash on the person fueling the vehicle, or on the side of the vehicle and the ground.The subject vehicles are equipped with an evaporative emissions control system that, among other things, manages air exchange between the fuel tank and the atmosphere in an environmentally safe manner.The system consists of a vapor canister, various control valves and tubing, and a canister filter (fuel tank air filter) through which the air that flows in and out of the fuel tank must pass.Kia's testing found that if the canister filter becomes significantly clogged, excess pressure can build up in the fuel tank and cause fuel to spit back from the filler port during refueling.Kia has stated that the canister filter requires regularly scheduled service maintenance; however, the component is not listed as a maintenance item in the owner's or service manual for the subject vehicles.ODI notes that Kia does list the filter on the maintenance schedule in the owner's manual for MY 2005 and newer Kia Sorento vehicles.To address the issue of fuel spit back during refueling, Kia will conduct a service campaign of approximately 86,000 MY 2003 and 2004 Kia Sorento vehicles.The campaign will provide a one-time replacement of the canister filter, at no cost to the owner.Kia will begin notifying the affected owners in late January 2012 and will inform the owners that the filter must be serviced at regular intervals.Kia will also provide an updated service maintenance schedule.Consumers should refer to the service campaign bulletin number SC092 available in the investigative file.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.
Illustration