IllustrationMY WIFE WAS DRIVING OUR 1998 KIA SEPHIA AND THE ENGINE BEGAN TO STALL. SHE PULLED INTO A PARKING LOT AND THE ENGINE CAUGHT ON FIRE. MY WIFE RAN AWAY FORM THE VEHICLE. THE WHOLE FRONT OF THE CAR WAS BURNED UP. *NM
1998 Kia Sephia
Owner reports · Recalls · Investigations
More warning signs than most Sephia years
Owner complaints for the 1998 Kia Sephia are substantially higher than the model-year median of 107.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sephia years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 35 of 491 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 250 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports15 fire reports12 injury reports
Engine And Engine Cooling complaints
108 reportsOVER A PERIOD OF TIME, APPROXIMATELY 70,00 MILES ON MY CAR, THE AC/HEATER FAN MOTOR WILL BLOW AIR INTERMITTENTLY, REGARDLESS OF THE FAN'S SPEED SETTING. EVENTUALLY, THE FAN STOPS BLOWING ALL TOGETHER. THIS SAME THING HAS HAPPENED WITH MY 1999 KIA SEPHIA. *JB
SINCE MAY OF 2002, THIS CAR HAS BEEN IN THE SHOP 9 TIMES AND OF THIS DATE IT IS STILL THERE. FIRST THEY SAID IT WAS FUSES. ACTUALLY IT HAS NEVER RUN OR STARTED RIGHT. IT HAD TO BE TOWED AT LEAST 4 TIMES. THE LAST TIME THAT IT WENT IN WAS 8/5/03, THEY FIXED THE WATER PUMP, BELTS, CRANK PULLEY. THIS WAS ALL UNDER WARRANTY. WHEN I …
Read full complaint
SINCE MAY OF 2002, THIS CAR HAS BEEN IN THE SHOP 9 TIMES AND OF THIS DATE IT IS STILL THERE. FIRST THEY SAID IT WAS FUSES. ACTUALLY IT HAS NEVER RUN OR STARTED RIGHT. IT HAD TO BE TOWED AT LEAST 4 TIMES. THE LAST TIME THAT IT WENT IN WAS 8/5/03, THEY FIXED THE WATER PUMP, BELTS, CRANK PULLEY. THIS WAS ALL UNDER WARRANTY. WHEN I PICKED UP MY CAR IT MADE A TERRIBLE SOUND. THEY SAID IT WAS THE NEW BELTS. SO I DROVE IT HOME AND 2 DAYS LATER IT?S BACK IN THERE. THE NEXT DAY SABRINA CALLED AND SAID THAT IT WAS THE AIR CONDITIONER COMPRESSOR. IT WAS GOING TO COST ME OVER 600.00 TO FIX IT. I HAVE A LIMITED INCOME OF 535.00 A MONTH, AM DISABLED AND IF THE CAR BROKE DOWN I DON'T KNOW WHAT I WOULD DO.. THE CAR IS STILL AT KIA DEALER SHIP, THAT'S AS OF TODAY.
DEAR SIR: KIA SEPHIA 1998 HAS SEVERAL OTHER PROBLEMS WHICH NEVER BEEN REPORTED. MY CAR (VIN# [XXX]; 52,000 MILES) HAS (1) AN OIL LEAK FROM THE ENGINE HEAD (VALVE COVER) GASKET, WHICH CAN POTENTIALLY CREATE A FIRE, AND IT HAS (2) VERY PURE AIR FLOW ON THE WINDSHIELD WHICH REDUCE MY DRIVING VISABILITY DUE TO FOG ACCUMULATION IN…
Read full complaint
DEAR SIR: KIA SEPHIA 1998 HAS SEVERAL OTHER PROBLEMS WHICH NEVER BEEN REPORTED. MY CAR (VIN# [XXX]; 52,000 MILES) HAS (1) AN OIL LEAK FROM THE ENGINE HEAD (VALVE COVER) GASKET, WHICH CAN POTENTIALLY CREATE A FIRE, AND IT HAS (2) VERY PURE AIR FLOW ON THE WINDSHIELD WHICH REDUCE MY DRIVING VISABILITY DUE TO FOG ACCUMULATION INSIDE OF THE WIENDSHIELD. BOTH CONDITIONS ARE VERY DANGEROUS AND MAY LEAD TO A CAR CRASH. PLEASE INFORM KIA MANUFACTURING CORPORATION THAT THESE DEFICIENCIES SHOULD BE FIXED FOR FREE. THANKS! SINCERELY, [XXX] [XXX] [XXX] *AK UPDATED 07/26/2012 *JS
PURCHASED THE CAR IN 1999. HAVE HAD NUMEROUS PROBLEMS STARTING IT. REPLACED THE STARTER 3 TIMES. STILL HAVE PRBLEMS STARTING IT. 2002 DIDN'T PASS INSPECTION BECAUSE OF EXAUST, KIA DEALERSHIP WAS SUPPOSE TO FIX PROBLEM STILL HAVING PROBLEMS STARTING AND EXAUST INSPECTION FAILED AGAIN. *AK
VEHICLE ENGINE CAUGHT ON FIRE. *MR WHEN THE CONSUMER ATTEMPTED TO COME TO STOP THE VEHICLE, THE BRAKE PEDAL WENT TO THE FLOOR AND THE BRAKES FAILED. CONSUMER HAD TO DRIVE ON THE LAWN IN ORDER TO GET THE VEHICLE TO STOP. AND THEN THE ENGINE CAUGHT ON FIRE. *TT *JB
THE ENGINE/THROTTLE FAILS CAUSING THE CONSUMER TO PRESS DOWN ON THE ACCELERATOR WITH EXTREME FORCE TO GET THE VEHICLE RUNNING. *JB
CONSUMER STATES HAVING A PROBLEM W/ITH "CABLE" THAT GOES FROM GAS TANK TO ENGINE. CONSUMER ADVISES THAT CABLE IS ATTACHED TO A WIRING HARNESS THAT GETS VERY HOT AND IS SHOWING SIGNS OF MELTING. AS A RESULT, VEHICLE STALLS W/O WARNING AND WIRINGS HAVE TO BE ADJUSTED BEFORE VEHICLE IS ABLE TO RESTART. MR
CONSUMER RECEIVED A RECALL NOTICE, 00V175000, AFTER FOUR ATTEMPTS THE RECALL WAS FIXED, THE PROBLEM IS BETTER BUT AT CERTAIN TIMES THE VEHICLE STILL BLOWS OUT GAS *YD REFERENCED IN RQ03-006
RECALL 00V175000 REPAIRS ON ORVR VALVE WAS DONE THE SECOND TIME IN NOV. 2001. WHEN FUELING VEHICLE FUEL IS STILL SPILLING ON GROUND, DEALER NOW DETERMINED THE CANISTER AND CANISTER VALVE NEED TO BE REPLACED. REFERENCED IN RQ03-006
Official recalls
602V216000 · Seat Belts:front:buckle Assembly
Aug 16, 2002
ON CERTAIN PASSENGER VEHICLES, THE SAFETY BELT BUCKLE MAY "FALSE LATCH" AND EXPOSE THE DRIVER TO UNRESTRAINED MOVEMENT DURING A CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: OWNER NOTIFICATION BEGAN DECEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
02V207000 · Exterior Lighting:hazard Flashing Warning Lights:switch
Jul 29, 2002
ON CERTAIN PASSENGER VEHICLES WITH 36,000 MILES OR LESS AS OF JULY 15, 2002, AN ELECTRICAL CONTACT PROBLEM MAY HAVE DEVELOPED IN THE HAZARD SWITCH WHICH COULD RESULT IN INOPERATIVE HAZARD LIGHTS AND/OR INOPERATIVE TURN SIGNALS.
Consequence & remedy
Consequence: THE LOSS OF TURN SIGNALS OR REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS TURNING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH. OWNER NOTIFICATION BEGAN SEPTEMBER 6, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
00V175000 · Engine And Engine Cooling:exhaust System:emission Control
Jul 17, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. MANUFACTURING CHANGES WERE MADE TO THE ORVR SPRING FORCE AND FLOAT WIRE LENGTH REDUCING THE VALVE ANGLE. CERTAIN VALVES CAUSED FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY.
Consequence & remedy
Consequence: THIS WOULD CAUSE CUSTOMERS TO ADD MORE FUEL TO THE TANK CAUSING FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK.
Remedy: DEALERS WILL REPLACE THE ORVR VALVE. OWNER NOTIFICATION BEGAN NOVEMBER 13, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
99V317000 · Fuel System, Gasoline:delivery:fuel Pump
Nov 9, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. ELECTRICAL CURRENT TO THE FUEL PUMP PASSES THROUGH THE C304 AND C305 CONNECTORS. IF EXPOSED TO MOISTURE, THESE CONNECTORS COULD CORRODE. OVER TIME, THE FUEL PUMP WILL NOT RECEIVE ENOUGH CURRENT TO OPERATE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE ENGINE TO STALL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE EXISTING CONNECTORS AND REPOSITION THOSE CONNECTORS TO AN AREA WHERE THE PLACEMENT IS DESIGNED TO PREVENT CONTACT WITH MOISTURE.
99V318000 · Fuel System, Gasoline:delivery:fuel Pump
Nov 9, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ELECTRICAL CIRCUIT FOR THE FUEL PUMP IS GROUNDED AT JUNCTION CONNECTOR G300. IF THE PIN TENSION IS POOR, OR THE BOLT SECURING THE CONNECTOR TO THE VEHICLE FLOOR IS NOT TIGHTENED SUFFICIENTLY, A POOR CONNECTION IS MADE. AS THE FUEL PUMP OPERATES, THE POOR CONNECTION CAN CREATE HEAT WHICH IN TURN INCREASES RESISTANCE. EVENTUALLY THE FUEL PUMP WILL NOT RECEIVE ENOUGH CURRENT TO OPERATE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE ENGINE TO STALL, INCREASING THE RISK OF A CRASH.
Remedy: THIS CORRECTIVE ACTION IS BEING PERFORMED IN CONJUNCTION WITH RECALL NO. 99V317.
99V271000 · Visibility:windshield Wiper/washer:linkages
Oct 6, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BALL SOCKET ON THE WINDSHIELD WIPER LINK MAY BE OUT OF TOLERANCE RESULTING IN THE LINK DISENGAGING FROM THE WIPER MOTOR DRIVE UNDER LOAD, SUCH AS PUSHING AGAINST ICE, SNOW OR OTHER RESISTANCE. ALSO THE WIPER ARM RETAINING NUT COULD BE INADEQUATELY TIGHTENED ALLOWING THE WIPER ARM TO SLIP AND/OR STOP FUNCTIONING.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE IMPAIRMENT OF VISIBILITY IN INCLEMENT WEATHER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE WINDSHIELD WIPER LINK AND ALSO PROPERLY TIGHTEN THE WIPER ARM RETAINING NUTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
12EA04004 · Refueling Spit Back
Opened Feb 3, 2004 · Closed Jul 29, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (7)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage:tank Assembly
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Other:storage:tank Assembly:filling/charging
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Other:storage:tank Assembly
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
RQ03006 · Refueling Spit Back
Opened Aug 15, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (6)
Fuel System, Gasoline
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage:tank Assembly
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Other:storage:tank Assembly:filling/charging
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Other:storage:tank Assembly
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA02016 · NON-CRASH Engine Compartment Fires
Opened Aug 6, 2002 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery:cables
ODI GATHERED FIRE DATA FROM VARIOUS SOURCES AND INSPECTED SUBJECT VEHICLES TO ASSESS THE SCOPE AND FREQUENCY OF NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY STARTER CABLE CHAFING.ODI'S ANALYSIS FOUND THAT MOST OF THE SUSPECT FIRES OCCURRED AFTER THE VEHICLE HAD RECEIVED SERVICE REPAIRS IN THE AREA OF THE SUBJECT CABLE.CONSUMER COMPLAINT DATA INDICATE THAT THE PROBLEM EXPERIENCE HAS DECLINED SINCE A PEAK IN LATE 2001.THE MOST RECENT KNOWN EVENT OCCURRED IN NOVEMBER OF 2002. KIA WILL PERFORM A SERVICE CAMPAIGN BEGINNING IN LATE 2003 TO INSPECT SUBJECT VEHICLES BUILT PRIOR TO JANUARY 2000 FOR CABLE DAMAGE AND WILL REPLACE DAMAGED CABLES AS NECESSARY. GIVEN THE DECLINING FIRE RATE AND KIA?S SERVICE CAMPAIGN, FURTHER EXPENDITURE OF AGENCY RESOURCES IS UNJUSTIFIED IN THIS MATTER.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FURTHER DETAILS MAY BE FOUND IN THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery:cables
ODI GATHERED FIRE DATA FROM VARIOUS SOURCES AND INSPECTED SUBJECT VEHICLES TO ASSESS THE SCOPE AND FREQUENCY OF NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY STARTER CABLE CHAFING.ODI'S ANALYSIS FOUND THAT MOST OF THE SUSPECT FIRES OCCURRED AFTER THE VEHICLE HAD RECEIVED SERVICE REPAIRS IN THE AREA OF THE SUBJECT CABLE.CONSUMER COMPLAINT DATA INDICATE THAT THE PROBLEM EXPERIENCE HAS DECLINED SINCE A PEAK IN LATE 2001.THE MOST RECENT KNOWN EVENT OCCURRED IN NOVEMBER OF 2002. KIA WILL PERFORM A SERVICE CAMPAIGN BEGINNING IN LATE 2003 TO INSPECT SUBJECT VEHICLES BUILT PRIOR TO JANUARY 2000 FOR CABLE DAMAGE AND WILL REPLACE DAMAGED CABLES AS NECESSARY. GIVEN THE DECLINING FIRE RATE AND KIA?S SERVICE CAMPAIGN, FURTHER EXPENDITURE OF AGENCY RESOURCES IS UNJUSTIFIED IN THIS MATTER.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FURTHER DETAILS MAY BE FOUND IN THE ATTACHED CLOSING REPORT.
Electrical System
ODI GATHERED FIRE DATA FROM VARIOUS SOURCES AND INSPECTED SUBJECT VEHICLES TO ASSESS THE SCOPE AND FREQUENCY OF NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY STARTER CABLE CHAFING.ODI'S ANALYSIS FOUND THAT MOST OF THE SUSPECT FIRES OCCURRED AFTER THE VEHICLE HAD RECEIVED SERVICE REPAIRS IN THE AREA OF THE SUBJECT CABLE.CONSUMER COMPLAINT DATA INDICATE THAT THE PROBLEM EXPERIENCE HAS DECLINED SINCE A PEAK IN LATE 2001.THE MOST RECENT KNOWN EVENT OCCURRED IN NOVEMBER OF 2002. KIA WILL PERFORM A SERVICE CAMPAIGN BEGINNING IN LATE 2003 TO INSPECT SUBJECT VEHICLES BUILT PRIOR TO JANUARY 2000 FOR CABLE DAMAGE AND WILL REPLACE DAMAGED CABLES AS NECESSARY. GIVEN THE DECLINING FIRE RATE AND KIA?S SERVICE CAMPAIGN, FURTHER EXPENDITURE OF AGENCY RESOURCES IS UNJUSTIFIED IN THIS MATTER.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FURTHER DETAILS MAY BE FOUND IN THE ATTACHED CLOSING REPORT.
PE02051 · Safety Belt Buckle Malfunction
Opened Jun 17, 2002 · Closed Sep 20, 2002
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
BY LETTER DATED AUGUST 25, 2002, KIA ADVISED NHTSA THAT THE SUBJECT VEHICLES WILL BE RECALLED.SPECIFIC CORRECTIVE ACTION TO BE TAKEN BY KIA HAS NOT BEEN REPORTED TO NHTSA AT THIS TIME.THE SAFETY RECALL PROGRAM HAS BEEN ASSIGNED CAMPAIGN NO. 02V-216.
PE02028 · Battery Cable Chafing
Opened Mar 6, 2002 · Closed Aug 6, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE00028 · Transmission Oil Cooler Line
Opened Jul 12, 2000 · Closed Nov 7, 2000
Status: closed (inferred from source dates) · Power Train
THE OIL COOLER LINE ALLEGEDLY DEVELOPS LEAKS AT IT'S JUNCTION TO THE RADIATOR
EA00018 · Turn Sighal
Opened Jun 29, 2000 · Closed Jul 29, 2002
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00004 · Turn Signal, Traffic Safety Hazard
Opened Jan 13, 2000 · Closed Jun 29, 2000
Status: closed (inferred from source dates) · Exterior Lighting
ALLEGE THAT WHILE DRIVING, THE TRUN SIGNAL SWITCH FAILED.THIS FAILURE INCREASES THE RISK OF A VEHICLE CRASH DUE TO OPERATOR DISTRACTION AND DUE TO OTHER VEHICLES BEING UNINFORMED OF THE OPERATOR'S INTENTIONS.
EA99034 · Refueling Spit Back
Opened Dec 16, 1999 · Closed Jun 29, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
The number and dates of complaints and warrant claims reported by Kia indicates that fuel spit-back has been a serieous ongoing problem with the Sephia models.Kia has made changes in both the ORVR valve and in the installation process on the fuel tank check valve, in an attempt to correct the problem.The failure of the check valve, due to cracking during installation, could go undetected until problems develop with the ORVR valve.Should an ORVR valve malfunction, when the vehicle has a tank chech valve with a latent crack, significant fuel spitting out the fuel filler pipe during refueling is possible.Current owners of 1998 and 1999 models could still be driving vehicles with latent defects.
SQ99020 · Intermittent Stalling
Opened Jun 30, 1999 · Closed Jan 12, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
Kia issued a Kia Technical Times in October 1998 stating that, due to loose connections at the fuel pump ground at G300, the fuel pump may shut off intermittently.The corrective action is to solder the fuel pump ground terminals at the terminal connec
Additional source detail variants (2)
Vehicle Speed Control:linkages
Kia issued a Kia Technical Times in October 1998 stating that, due to loose connections at the fuel pump ground at G300, the fuel pump may shut off intermittently.The corrective action is to solder the fuel pump ground terminals at the terminal connec
Vehicle Speed Control:linkages
Kia issued a Kia Technical Times in October 1998 stating that, due to loose connections at the fuel pump ground at G300, the fuel pump may shut off intermittently.The corrective action is to solder the fuel pump ground terminals at the terminal connec
PE99042 · Refueling SPIT- Back
Opened Jun 24, 1999 · Closed Dec 16, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
The subject vehicles are equipped with Onboard Refueling Vapor Recover Systems.Owners report that, during the refueling process, fuel sprays out of the refueling opening and soaks the person refueling the vehicle with liquid gasoline
PE99033 · Windshield Wiper
Opened May 6, 1999 · Closed Oct 21, 1999
Status: closed (inferred from source dates) · Visibility
ALLEGED WINDSHIELD WIPER BECOMES INOPERATIVE WHEN THE WIPER ARM AND PIVOT SEPARATE