Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 64 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports1 fire reports8 injury reports
What owners actually said
64 reports
Mileage unknown · Sep 21, 2000
Visibility
THERE ARE BROWN SPOTS, IN AN OTHERWISE NAVY BLUE COLORED DASH, THAT APPEAR TO BE BURNED AREAS. ALSO, THE PART OF THE DASH CONNECTED CLOSEST TO THE WIND SHIELD HAS BECOME COMPLETELY UNGLUED. UPON CONTACTING THE MANUFACTURER, WE WERE TOLD THAT THEY WOULD PAY FOR THE DASH ITSELF BUT WE WOULD HAVE TO PAY FOR THE LABOR. SINCE OUR …
Read full complaint
THERE ARE BROWN SPOTS, IN AN OTHERWISE NAVY BLUE COLORED DASH, THAT APPEAR TO BE BURNED AREAS. ALSO, THE PART OF THE DASH CONNECTED CLOSEST TO THE WIND SHIELD HAS BECOME COMPLETELY UNGLUED. UPON CONTACTING THE MANUFACTURER, WE WERE TOLD THAT THEY WOULD PAY FOR THE DASH ITSELF BUT WE WOULD HAVE TO PAY FOR THE LABOR. SINCE OUR WARRANTEE HAD EXPIRED, WE THOUGHT THAT WAS PRETTY FAIR UNTIL WE WERE INFORMED WE COULD ONLY HAVE IT REPAIRED AT THE DEALERSHIP (WHO CHARGES $80/HOUR). OUR REGULAR AUTO BODY SPECIALIST WOULD CHARGE US HALF OF THAT AMOUNT, AND THAT WOULD INCLUDE ACTUALLY PAYING FOR THE DASH. THE MANUFACTURER AGREED TO LET US TAKE THE FREE DASH OUTSIDE THE DEALERSHIP FOR REPAIR. THEN WHEN WE ASKED FOR THAT AGREEMENT IN WRITING, THEY CLAIMED THEY HAD NEVER AGREED TO ALLOW THAT. WE ASKED THEM TO REVIEW THEIR "QUALITY ASSURANCE" TAPES. WE WERE THEN TOLD THAT EVEN IF THE TAPES PROVED THE CONVERSATION OCCURED AS WE SAID, WE STILL COULD NOT TAKE THE DASH ANYWHERE OTHER THAN THE DEALERSHIP. WE DID NOT EVEN BUY THE CAR FROM THE DEALERSHIP. BY OFFERING TO GIVE US A REPLACEMENT DASH FREE OF CHARGE, THEY WERE ADMITTING THAT IT WAS A DEFECT. OF ALL THE PEOPLE THAT WE SHOWED THE DASH TO, NOT ONE PERSON HAD EVER SEEN ANYTHING LIKE IT IN THEIR LIVES. WE FEEL THAT WE WERE DECEIVED BY THE MANUFACTURER.
NHTSA ODI #732180
Mileage unknown · Sep 12, 2000
Engine And Engine Cooling
RADIATOR HAS OVERHEATED AND CRACKED, CAUSING FLUID TO LEAK INTO THE ENGINE COMPARTMENT, DAMAGING THE ENGINE. CONSUMER HAS CONTACTED DEALER. PLEASE PROVIDE ANY FURTHER DETAILS.*AK
NHTSA ODI #870269
Mileage unknown · Aug 2, 2000
Electrical System
CONSUMER DIDN'T KNOW THAT HORN NEVER WORKED WHEN VEHICLE WAS PURCHASED. CONSUMER WAS ABLE TO AVOID AN ACCIDENT AFTER REALIZING IT DIDN'T WORK. DEALER REPLACED IT ONCE BEFORE. HORN STILL HAS A PROBLEM. *AK
NHTSA ODI #866628
Mileage unknown · Jul 25, 2000
Air BagsSteeringCrashInjury
VEHICLE LOST CONTROL, AND THEN ROLLED OVER A COUPLE TIMES, AND AIR BAGS DID NOT DEPLOY. VEHICLE WAS TOTALED. *AK
NHTSA ODI #865977
Mileage unknown · Dec 8, 1999
Interior LightingLatches/locks/linkagesSeats
SEVERAL PROBLEMS WITH DOOR LATCH, DASH, INTERIOR LIGHTING AND DRIVER SEAT. *AK
NHTSA ODI #715780
Mileage unknown · Dec 2, 1999
Service Brakes, HydraulicCrash
WHEN BRAKES WERE APPLIED PEDAL WENT TO THE FLOOR, RESULTING IN EXTENDED STOPPING DISTANCE, CAUSING A COLLISION. DEALER HAS REPLACED THE BRAKES SEVERAL TIMES PRIOR TO THE COLLISION. *AK
NHTSA ODI #853596
Mileage unknown · Sep 8, 1999
Air BagsSeat BeltsCrashInjury
DRIVER WAS INVOLVED IN 4 CAR COLLISION WHERE THERE WAS FRONTAL AND REAR IMPACT, DUAL AIRBAGS DID NOT DEPLOY, AND SEATBELTS UNLATCHED BY THEMSELVES, CAUSING SERIOUS INJURIES. VEHICLE IS A TOTAL LOSS. *AK
NHTSA ODI #847226
Mileage unknown · Sep 2, 1999
Power Train
THE ORIGINAL CLUTCH WAS REPLACED AT 20000 MILES, THEN THE ORIGINAL TRANSMISSION WAS REPLACED AT 60000 MILES. NOW AT 72500 MILES BOTH THE CLUTCH AND TRANSMISSION ARE BEING REPLACED AGAIN, AFTER A TOTAL FAILURE.
NHTSA ODI #710841
Mileage unknown · Jul 23, 1999
Power TrainService Brakes, HydraulicStructure
BRAKES WOULD SQUEAL. HAD TROUBLE STOPPING/EAR WINDSHIELD KEEPS POPPING OUT BENT FRAME, AND TRANSMISSION HAS BEEN REPLACED TWICE BECAUSE SHAFT IS CROOKED.CONSUMER CONTACTED DEALER. *AK
NHTSA ODI #843140
Mileage unknown · Jun 3, 1999
Power Train
WHEN DRIVING AT ANY SPEED, THE SHIFT PATTERN INDICATOR WHICH IS SITTING ON THE TAIL PIPE KEEPS LOOSENING. *AK
ON CERTAIN PASSENGER VEHICLES, THE SAFETY BELT BUCKLE MAY "FALSE LATCH" AND EXPOSE THE DRIVER TO UNRESTRAINED MOVEMENT DURING A CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: OWNER NOTIFICATION BEGAN DECEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE02051 · Safety Belt Buckle Malfunction
Opened Jun 17, 2002 · Closed Sep 20, 2002
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
BY LETTER DATED AUGUST 25, 2002, KIA ADVISED NHTSA THAT THE SUBJECT VEHICLES WILL BE RECALLED.SPECIFIC CORRECTIVE ACTION TO BE TAKEN BY KIA HAS NOT BEEN REPORTED TO NHTSA AT THIS TIME.THE SAFETY RECALL PROGRAM HAS BEEN ASSIGNED CAMPAIGN NO. 02V-216.
1995 Kia Sephia Problems, Complaints & Recalls | Skip That Year
Illustration