IllustrationI WAS DRIVING ON ROUTE 55 WITH MY 2YR OLD DAUGHTER AND I WAS GOING 70MPH WHEN THE TREAD SEPARATED FROM THE TIRE CAUSING MY CAR TO FISHTAIL IN BETWEEN BOTH LANES ON THE HIGHWAY UNTIL I WAS ABLE TO GAIN CONTROL AGAIN AND GOT MY CAR TO THE SHOULDER OF THE HIGHWAY. THE DEFECTIVE TIRE IS A FIRESTONE WILDERNESS HT 225/70R15
2005 Kia Sedona
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Kia Sedona do not stand out strongly from the model-year median of 120.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sedona years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
710–25K
1425–50K
1150–75K
1775–100K
15100–150K
15150K+
143 reports with mileage · 42 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports9 fire reports11 injury reports
What owners actually said
185 reportsSTALLS WITH NO WARNING ALL SPEEDS ALL WEATHER CONDITIONS..ENGINE HOT OR COLD..STARTS RIGHT BACK UP..VERY DANGEROUS
BRAKES CONSTANTLY SQUEAK AFTER NEW BRAKES AND PADS ON. ELECTRIC WINDOWS PASSAGENER AND DRIVER SIDE NOT WORKIN
TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE DRIVING LOW SPEEDS, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER (KIA OF GRAND BLANC AT 6167 SAGINAW RD, GRAND BLANC, MI 48439, (810) 694-5600) WHERE IT WAS DIAGNOSED THAT THE VEHICLE DID NOT HAVE THE ORIGINAL CRANKSHAFT POSITION SENSOR PART. THE VEHICLE WA…
Read full complaint
TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE DRIVING LOW SPEEDS, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER (KIA OF GRAND BLANC AT 6167 SAGINAW RD, GRAND BLANC, MI 48439, (810) 694-5600) WHERE IT WAS DIAGNOSED THAT THE VEHICLE DID NOT HAVE THE ORIGINAL CRANKSHAFT POSITION SENSOR PART. THE VEHICLE WAS NOT REPAIRED DUE TO THE DEALER NOT DIAGNOSING THE AFTERMARKET DORMAN CRANKSHAFT POSITION SENSOR THAT WAS DEFECTIVE AND CAUSED THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE CRANKSHAFT POSITION SENSOR WAS NOT A KIA PART AND DID NOT OFFER ANY FURTHER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 165,000.
IN MOTION. THE BRAKES BECAME MORE AND MORE SPONGY. UPON INSPECTION I FOUND THE STUDS THAT HOLD THE MASTER BRAKE CYLINDER TO THE BOOSTER, ONE WAS BROKEN OFF AND THE OTHER HAD A LOOSE NUT.
TL* THE CONTACT OWNS A 2005 KIA SEDONA. THE CONTACT STATED THAT THERE WAS A PROGRESSING NOISE HEARD NEAR THE BRAKE SYSTEM. THE DEALER DIAGNOSED THAT THE WHEEL BEARINGS AND HUBS PREMATURELY FRACTURED AND WERE HELD TOGETHER ONLY BY TWO BOLTS. THE PARTS HAD TO BE REPLACED ON THE FRONT DRIVER'S SIDE TIRE. THE DEALER WAS TO FURTHER I…
Read full complaint
TL* THE CONTACT OWNS A 2005 KIA SEDONA. THE CONTACT STATED THAT THERE WAS A PROGRESSING NOISE HEARD NEAR THE BRAKE SYSTEM. THE DEALER DIAGNOSED THAT THE WHEEL BEARINGS AND HUBS PREMATURELY FRACTURED AND WERE HELD TOGETHER ONLY BY TWO BOLTS. THE PARTS HAD TO BE REPLACED ON THE FRONT DRIVER'S SIDE TIRE. THE DEALER WAS TO FURTHER INSPECT THE OTHER THREE TIRES. IN ADDITION, THE VEHICLE WAS TO BE TAKEN TO AN INDEPENDENT REPAIR SHOP. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT PROVIDED NO SOLUTION. THE MANUFACTURER STATED THAT THE VEHICLE WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 05V232000 (WHEELS). THE CONTACT WAS UNCERTAIN AS TO WHO WOULD REPAIR THE VEHICLE AND IF THE FAILURE WOULD RECUR. THE FAILURE MILEAGE WAS NOT AVAILABLE.
TIRES ARE STILL OVER 1/2 TREAD BUT BIG BULGES IN TREAD AREA
TL* THE CONTACT OWNED A 2005 KIA SEDONA. WHILE DRIVING 35 MPH, THE VEHICLE SUDDENLY SHUT OFF AND THE BRAKES AND POWER STEERING NO LONGER FUNCTIONED. THE CONTACT RAN OFF THE ROAD INTO A DITCH. THE VEHICLE CAUGHT FIRE AND EXPLODED. A FIRE REPORT WAS FILED AND THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES AND A …
Read full complaint
TL* THE CONTACT OWNED A 2005 KIA SEDONA. WHILE DRIVING 35 MPH, THE VEHICLE SUDDENLY SHUT OFF AND THE BRAKES AND POWER STEERING NO LONGER FUNCTIONED. THE CONTACT RAN OFF THE ROAD INTO A DITCH. THE VEHICLE CAUGHT FIRE AND EXPLODED. A FIRE REPORT WAS FILED AND THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED AND TOWED. THE ORIGIN OF THE FIRE WAS UNDETERMINED. THE APPROXIMATE FAILURE MILEAGE WAS 240,000.
TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE THE VEHICLE WAS PARKED, IT ROLLED BACK AND CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES SUSTAINED. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE AWAY FROM THE SCENE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. TH…
Read full complaint
TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE THE VEHICLE WAS PARKED, IT ROLLED BACK AND CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES SUSTAINED. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE AWAY FROM THE SCENE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000. UPDATED 02/03/17*LJ *CN
TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE DRIVING 20 MPH, THE BRAKES FAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER. THE CONTACT STATED THAT THE VEHICLE WAS NO LONGER SAFE. THE MECHANIC STATED THAT THE BRAKE SYSTEM NEEDED REPAIRING, BUT NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 168,000.
Official recalls
205V329000 · Vehicle Speed Control:cables
Jul 20, 2005
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence & remedy
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
05V232000 · Wheels
May 19, 2005
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence & remedy
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.