NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
175 reports13,000 miles · Feb 28, 2006
Electrical System
DT*: THE CONTACT STATED THE ELECTRICAL SYSTEM WAS CONTINUALLY BLOWING FUSES THAT OPERATE THE HEADLIGHTS. WHILE DRIVING AT NIGHT IT WAS DANGEROUS BECAUSE THERE WERE NO INDICATIONS THAT THE FUSE WOULD BLOW. THE BULBS IN THE HEADLIGHT WERE REPLACED NUMEROUS TIMES TO SEE IF THE BULBS WERE THE PROBLEM. THE BULBS WOULD PASS INSPEC…
Read full complaint
DT*: THE CONTACT STATED THE ELECTRICAL SYSTEM WAS CONTINUALLY BLOWING FUSES THAT OPERATE THE HEADLIGHTS. WHILE DRIVING AT NIGHT IT WAS DANGEROUS BECAUSE THERE WERE NO INDICATIONS THAT THE FUSE WOULD BLOW. THE BULBS IN THE HEADLIGHT WERE REPLACED NUMEROUS TIMES TO SEE IF THE BULBS WERE THE PROBLEM. THE BULBS WOULD PASS INSPECTION WHEN TAKING OUT OF THE CONTACT'S VEHICLE. THE DEALER CAN NOT DUPLICATE THE PROBLEM AND NO REPAIRS WERE MADE.
NHTSA ODI #10151420
Mileage unknown · Feb 23, 2006
Exterior Lighting
I HAVE HAD THIS VEHICLE SINCE FEBRUARY 2004. SINCE I PURCHASED IT, I HAVE HAD TO REPLACE THE HEADLIGHTS ABOUT EVERY THREE MONTHS. THEY DO NOT GO OUT AT THE SAME TIME. ONE GOES, THEN SEVERAL WEEKS LATER THE OTHER GOES. I HAVE TAKEN TO REPLACING THEM BOTH AT THE SAME TIME, SINCE I KNOW THEY WILL BOTH GO OUT WITHIN A FEW WEEKS …
Read full complaint
I HAVE HAD THIS VEHICLE SINCE FEBRUARY 2004. SINCE I PURCHASED IT, I HAVE HAD TO REPLACE THE HEADLIGHTS ABOUT EVERY THREE MONTHS. THEY DO NOT GO OUT AT THE SAME TIME. ONE GOES, THEN SEVERAL WEEKS LATER THE OTHER GOES. I HAVE TAKEN TO REPLACING THEM BOTH AT THE SAME TIME, SINCE I KNOW THEY WILL BOTH GO OUT WITHIN A FEW WEEKS OF EACH OTHER. *JB
NHTSA ODI #10150980
21,000 miles · Feb 6, 2006
Exterior Lighting
AT LESS THAN 21K MILES A LOW BEAM HEADLIGHT BURNED OUT. WE DON'T USE THEM FOR DRL. THIS SEEMS ODD AND A FORUM ON KIA SORENTO'S SHOWS THE SAME CONCERN. AFTER BUYING NEW BULBS I FIND IT TAKES A PROFESSIONAL MECHANIC TO INSTALL THEM...THE DEALER CHARGES $18/BULB FOR LABOR ONLY. THIS SOUNDS LIKE A SCAM BY THE MANUFACTURER. THIS…
Read full complaint
AT LESS THAN 21K MILES A LOW BEAM HEADLIGHT BURNED OUT. WE DON'T USE THEM FOR DRL. THIS SEEMS ODD AND A FORUM ON KIA SORENTO'S SHOWS THE SAME CONCERN. AFTER BUYING NEW BULBS I FIND IT TAKES A PROFESSIONAL MECHANIC TO INSTALL THEM...THE DEALER CHARGES $18/BULB FOR LABOR ONLY. THIS SOUNDS LIKE A SCAM BY THE MANUFACTURER. THIS IS FOR A SORENTO WHICH YOUR DATABASE DOES NOT ALLOW FOR AN OPTION TO CHOOSE FROM. FOR MISFIRE PROBLEM I FILED BEFORE THIS I SELECTED SEDONA INSTEAD TO GET MY CLAIM THROUGH. 8JB
NHTSA ODI #10149565
10,000 miles · Feb 6, 2006
Engine And Engine Cooling
CHECK ENGINE LIGHT ON. ENGINE WAS KNOCKING. CALLED THE DEALER 3 TIMES AND EACH TIME THEY TRIED TO TELL ME IT WAS MY GAS CAP NOT LOCKED ON PROPERLY. WHEN I FINALLY BROUGHT IT IN THEY HAD TO DO AN ENTIRE TUNE UP BECAUSE A PLUG WAS MISFIRING. *JB
NHTSA ODI #10149564
Mileage unknown · Jan 31, 2006
Air BagsInjury
I WAS JUST NOTIFIED BY STATE FARM INSURANCE THAT THE AIR BAGS ON THE KIA SORENTO ARE NOT WORKING PROPERLY. THIS HAS CAUSED THEM TO REMOVE THE SAFETY DISCOUNT FROM THE VEHICLE. IF THE AIR BAGS ARE NOT WORKING IN ACCIDENTS THEN I FEEL THAT THEY NEED TO BE FIXED OR REPLACED SO PEOPLE WILL NOT DIE DUE TO THE FAILURE OF AIR BAGS. *…
Read full complaint
I WAS JUST NOTIFIED BY STATE FARM INSURANCE THAT THE AIR BAGS ON THE KIA SORENTO ARE NOT WORKING PROPERLY. THIS HAS CAUSED THEM TO REMOVE THE SAFETY DISCOUNT FROM THE VEHICLE. IF THE AIR BAGS ARE NOT WORKING IN ACCIDENTS THEN I FEEL THAT THEY NEED TO BE FIXED OR REPLACED SO PEOPLE WILL NOT DIE DUE TO THE FAILURE OF AIR BAGS. *JB
NHTSA ODI #10149166
Mileage unknown · Jan 24, 2006
Service Brakes, HydraulicTires
THE REAR OF THE VEHICLE BEGAN TO PRODUCE A HUMMING NOISE AND IT GRADUALLY GOT LOUDER UNTIL THE PASSENGER SIDE REAR BRAKE ASSEMBLY AND TIRE CAME OUT OF THE 2004 KIA SEDONA. *AK
NHTSA ODI #10148495
35,000 miles · Jan 12, 2006
Seat BeltsCrashFireInjury
DT: THE CONTACT STATED WHILE DRIVING AT 3 TO 5 MPH THE CONTACT'S VEHICLE WAS HIT ON N THE SIDE BY ANOTHER VEHICLE PULLING FROM A DRIVEWAY. THE DRIVER AND PASSENGER SEAT BELTS FAILED TO LOCK WHEN THE IMPACT OCCURRED. THE CONTACT SUSTAINED INJURIES TO THE NOSE, REQUIRING SURGERY. THE VEHICLE WAS TOWED TO THE LOCAL DEALER. T…
Read full complaint
DT: THE CONTACT STATED WHILE DRIVING AT 3 TO 5 MPH THE CONTACT'S VEHICLE WAS HIT ON N THE SIDE BY ANOTHER VEHICLE PULLING FROM A DRIVEWAY. THE DRIVER AND PASSENGER SEAT BELTS FAILED TO LOCK WHEN THE IMPACT OCCURRED. THE CONTACT SUSTAINED INJURIES TO THE NOSE, REQUIRING SURGERY. THE VEHICLE WAS TOWED TO THE LOCAL DEALER. TODAY, THE DEALER PLACED THE VEHICLE IN AN ACCIDENT SIMULATOR IN ORDER TO TEST THE SEAT BELTS. THE RESULTS SHOWED THE SEAT BELTS WERE WORKING PROPERLY AND DID NOT LOCK BECAUSE OF THE SPEED AT THE TIME OF THE ACCIDENT. THE DEALER DETERMINED THE SEAT BELTS SHOULD HAVE LOCKED AT A SPEED OF 25 MPH. *AK
NHTSA ODI #10147663
Mileage unknown · Jan 3, 2006
Service Brakes, Hydraulic
BEFORE 10,000 MILES, THE FRONT WOULD VIBRATE WHEN BRAKING FROM HIGHWAY SPEEDS OR GOING DOWN STEEP HILLS. I HAD THE ROTORS TURNED BECAUSE THEY WERE WARPED. WITHIN 3 MONTHS, THE SAME THING HAPPENED AGAIN. THE ROTORS WERE WARPED AGAIN. I TOOK IT TO THE DEALERSHIP AND THEY REPLACED THE ROTORS. WITHIN 3 MONTHS IT DID IT AGAIN. …
Read full complaint
BEFORE 10,000 MILES, THE FRONT WOULD VIBRATE WHEN BRAKING FROM HIGHWAY SPEEDS OR GOING DOWN STEEP HILLS. I HAD THE ROTORS TURNED BECAUSE THEY WERE WARPED. WITHIN 3 MONTHS, THE SAME THING HAPPENED AGAIN. THE ROTORS WERE WARPED AGAIN. I TOOK IT TO THE DEALERSHIP AND THEY REPLACED THE ROTORS. WITHIN 3 MONTHS IT DID IT AGAIN. I TOOK IT BACK TO THE DEALERSHIP AND THEY REPLACED THE ROTORS AGAIN. I ALSO REPLACED THE BRAKES OUT OF MY POCKET. IT HAS BEEN ANOTHER 3 MONTHS AND IT IS STARTING AGAIN. AT A ROUTINE OIL CHANGE AND BRAKE INSPECTION, FIRESTONE SAYS THE ROTORS ARE WARPED AND MY BRAKE PADS ARE DOWN TO 25%. THE VEHICLE IS ONLY 2 YEARS OLD AND HAS LESS THAN 30,000 MILES ON IT. I HAVE HAD 3 DIFFERENT SETS OF ROTORS PUT ON THIS VEHICLE. *JB
NHTSA ODI #10146799
200,250 miles · Dec 28, 2005
Engine And Engine CoolingParking BrakeService Brakes, Hydraulic
NONE. *NM
NHTSA ODI #10146201
3,000 miles · Dec 7, 2005
Exterior Lighting
ON MULTI OCCASIONS REAR BRAKE OR DIRECTIONAL LIGHTS FAIL. THIS STARTED WITH 3000 MILES AND STILL IS ORRURRING WITH LESS THAN 10, 000 MILES ON THE CAR. *NM
NHTSA ODI #10144653
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Illustration