NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
12 reportsClear category filter96,000 miles · Sep 24, 2014
Vehicle Speed Control
TL* THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING APPROXIMATELY 40 MPH, THE SPEEDOMETER FLUCTUATED AND SEIZED INTERMITTENTLY. IN ADDITION, THE VEHICLE WOULD ACCELERATE INDEPENDENTLY. IN ORDER TO PREVENT THE FAILURE, THE CONTACT HAD TO DRIVE AT A SLOWER SPEED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INC…
Read full complaint
TL* THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING APPROXIMATELY 40 MPH, THE SPEEDOMETER FLUCTUATED AND SEIZED INTERMITTENTLY. IN ADDITION, THE VEHICLE WOULD ACCELERATE INDEPENDENTLY. IN ORDER TO PREVENT THE FAILURE, THE CONTACT HAD TO DRIVE AT A SLOWER SPEED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V329000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.
NHTSA ODI #10638653
78,000 miles · Jan 22, 2013
Vehicle Speed ControlCrashInjury
TL* THE CONTACT OWNS A 2004 KIA SEDONA. THE CONTACT STATED THAT WHILE EXITING A CAR WASH, SHE SHIFTED FROM NEUTRAL TO DRIVE WITH THE BRAKE PEDAL DEPRESSED WHEN THE VEHICLE SUDDENLY ACCELERATED ON INDEPENDENTLY. THE VEHICLE THEN TRAVELED OVER A CURB BEFORE CRASHING INTO A TREE. THE VEHICLE CONTINUED TO ACCELERATE AND CAME TO A ST…
Read full complaint
TL* THE CONTACT OWNS A 2004 KIA SEDONA. THE CONTACT STATED THAT WHILE EXITING A CAR WASH, SHE SHIFTED FROM NEUTRAL TO DRIVE WITH THE BRAKE PEDAL DEPRESSED WHEN THE VEHICLE SUDDENLY ACCELERATED ON INDEPENDENTLY. THE VEHICLE THEN TRAVELED OVER A CURB BEFORE CRASHING INTO A TREE. THE VEHICLE CONTINUED TO ACCELERATE AND CAME TO A STOP WHEN THE FRONT AND REAR TIRES BECAME FLAT AND THE CONTACT SHIFTED INTO NEUTRAL. BOTH THE CONTACT AND A FRONT PASSENGER SUSTAINED BRUISING FROM THE CRASH AND WERE TRANSPORTED VIA AMBULANCE TO A HOSPITAL FOR TREATMENT OF THEIR INJURIES. THE VEHICLE WAS TOWED TO A SALVAGE YARD. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 78,000.
NHTSA ODI #10493816
100,000 miles · Dec 1, 2012
Service BrakesVehicle Speed Control
THIS HAS HAPPENED 3 TIMES, THE LATEST IN NOVEMBER WHILE ON THE INTERSTATE, DURING RUSH HOUR, GOING 60 MILES PER HOUR. MY VAN KEEPS DYING WHILE I'M DRIVING WHETHER IT WAS A SENSOR OR OUT OF GAS, WHATEVER THE REASON, WHEN POWER GOES OUT, THE BRAKE LOCKS UP AND I HAVE NO CONTROL TO SLOW DOWN OR STOP THE VAN. IT HAS TO COAST UNTIL I…
Read full complaint
THIS HAS HAPPENED 3 TIMES, THE LATEST IN NOVEMBER WHILE ON THE INTERSTATE, DURING RUSH HOUR, GOING 60 MILES PER HOUR. MY VAN KEEPS DYING WHILE I'M DRIVING WHETHER IT WAS A SENSOR OR OUT OF GAS, WHATEVER THE REASON, WHEN POWER GOES OUT, THE BRAKE LOCKS UP AND I HAVE NO CONTROL TO SLOW DOWN OR STOP THE VAN. IT HAS TO COAST UNTIL IT STOPS ON ITS OWN. THE LAST TIME TOOK ME A MILE AND HALF TO FINALLY STOP. THIS IS VERY DANGEROUS AND COULD CAUSE INJURY/AND OR DEATH IF THERE ARE OTHER VEHICLES IN FRONT OF ME. *TR
NHTSA ODI #10486690
100,900 miles · Oct 5, 2012
Vehicle Speed Control
DRIVING IN MOUNTAINS IN SOUTHWEST IN OCTOBER USING CRUISE CONTROL AT 60 MPH. THE CRUISE WAS DISENGAGED BY THE DRIVER AS A TURN APPROACHED. VEHICLE SUDDENLY ACCELERATED FULLY. BRAKES DID NOT SLOW IT AND THEY BECAME UNRESPONSIVE. DRIVER PUT VEHICLE IN NEUTRAL AND ENGINE CONTINUED TO REV PAST 6000 RPM'S. IN NEUTRAL, VEHICLE WAS ABL…
Read full complaint
DRIVING IN MOUNTAINS IN SOUTHWEST IN OCTOBER USING CRUISE CONTROL AT 60 MPH. THE CRUISE WAS DISENGAGED BY THE DRIVER AS A TURN APPROACHED. VEHICLE SUDDENLY ACCELERATED FULLY. BRAKES DID NOT SLOW IT AND THEY BECAME UNRESPONSIVE. DRIVER PUT VEHICLE IN NEUTRAL AND ENGINE CONTINUED TO REV PAST 6000 RPM'S. IN NEUTRAL, VEHICLE WAS ABLE TO COAST TO A STOP. AFTER A TOW TO A REPAIR SHOP, THE MECHANIC FOUND THE CRUISE CONTROL ASSEMBLY BROKE AND THE CABLE CONNECTED TO THE THROTTLE RECOILED PULLING THE THROTTLE WIDE OPEN. THE MECHANIC DISENGAGED THE CRUISE CONTROL CABLE FROM THE THROTTLE AND THE VEHICLE COULD BE DRIVEN NORMALLY WITHOUT CRUISE. *TR
NHTSA ODI #10478695
88,000 miles · Aug 24, 2009
Vehicle Speed Control
COMPLAINT 10281505 PREVIOUSLY FILED. SEDONA HAD THROTTLE CABLE REPLACED IN OCTOBER 05 AS PART OF KIA SERVICE RECALL. PROBLEM SAME AS IN COMPLAINT 10139518 FROM SEPT 2005 REPORTED INCIDENT. THE 2005 AND THIS 2009 INCIDENT DID NOT OCCUR IN THE WINTER IN FREEZING CONDITIONS. *TR
NHTSA ODI #10281559
88,000 miles · Aug 24, 2009
Vehicle Speed Control
KIA SEDONA 2004 TRAVELING ABOUT 30 MPH WITH GENTLE ACCELERATION. CAR WITHOUT USING ACCELERATOR SPED UP TO 40+ MPH AND BRAKES COULD NOT STOP CAR. CAR STOPPED BY PULLING OVER AND TURNING OFF ENGINE. *TR
NHTSA ODI #10281505
41,799 miles · Jan 15, 2008
SuspensionVehicle Speed Control
BAD MISFIRE IN MOTOR CAUSING THE CRUISE CONTROL TO TURN OFF AND TRANS TO SLAM OUT AND THEN BACK INTO OVER DRIVE,CAME CLOSE TO GETTING HIT IN THE REAR ON I-95. I HAVE HAD THIS VAN BACK TO KIA MINEY TIMES AND ITS STILL NOT FIX. ALL SO THE LAST TIME I HAD THE VAN FOR SERVICE I COMPLAINED ABUT A BEARING NOISE THEY DID NOT FIX IT T…
Read full complaint
BAD MISFIRE IN MOTOR CAUSING THE CRUISE CONTROL TO TURN OFF AND TRANS TO SLAM OUT AND THEN BACK INTO OVER DRIVE,CAME CLOSE TO GETTING HIT IN THE REAR ON I-95. I HAVE HAD THIS VAN BACK TO KIA MINEY TIMES AND ITS STILL NOT FIX. ALL SO THE LAST TIME I HAD THE VAN FOR SERVICE I COMPLAINED ABUT A BEARING NOISE THEY DID NOT FIX IT THE NOISE IS GETTING WORSE. *TR
NHTSA ODI #10214941
24,717 miles · Oct 12, 2005
Vehicle Speed ControlCrashInjury
DRIVING VEHICLE AS NORMAL ON RTE 1 NORTH. ATTEMPTED TO SLOW VEHICLE TO STOP AT AMBER COLORED LIGHT BEFORE INTERSECTION WITH E. GRAND AVE,VEHICLE TRAVELING OVER 5 MPH BUT UNDER 10 MPH AT THIS TIME, APPLIED BRAKES, VEHICLE DID NOT SLOW DOWN. PUMPED BRAKES AND PUSHED BRAKE PEDAL TO FLOOR OF VEHICLE TO NO AVAIL, VEHICLE STILL MOVI…
Read full complaint
DRIVING VEHICLE AS NORMAL ON RTE 1 NORTH. ATTEMPTED TO SLOW VEHICLE TO STOP AT AMBER COLORED LIGHT BEFORE INTERSECTION WITH E. GRAND AVE,VEHICLE TRAVELING OVER 5 MPH BUT UNDER 10 MPH AT THIS TIME, APPLIED BRAKES, VEHICLE DID NOT SLOW DOWN. PUMPED BRAKES AND PUSHED BRAKE PEDAL TO FLOOR OF VEHICLE TO NO AVAIL, VEHICLE STILL MOVING , MAINTAINING SPEED,AND ABOUT TO TRAVEL THROUGH RED LIGHT AT INTERSECTION, ALSO APPLIED EMERGENCY BRAKE, VEHICLE DID NOT STOP, VEHICLE PROCEEDED THROUGH RED LIGHT AND COLLIDED WITH ANOTHER VEHICLE TRAVELING EAST BOUND ON E.GRAND AVENUE, AFTER COLLISION TURNED OFF VEHICLE, VEHICLE RESTARTED, TESTED BRAKES ON SIDE OF ROAD, BRAKES WERE APPLIED BUT DID NOT FUNCTION NORMALLY, WHEN BRAKES WERE APPLIED THEY HESITATED AND YOU COULD STILL PUSH PEDAL TO FLOOR WITHOUT STOPPING VEHICLE. TURNED OFF CAR AGAIN AND RESTARTED FOR LATER TESTING BY POLICE OFFICER. LATER TESTING SHOWED BRAKES "APPEARED" TO FUNCTION NORMALLY. CAR WAS DRIVEN TO DEALER FOR FURTHER TESTING, OBSERVING BRAKES JERKING AND HESITATING. CAR HAD NOT DEMONSTRATED THIS BEHAVIOR PRIOR TO INCIDENT. MECHANIC CALLED IN SPECIALIST, AS PER MANUFACTURER, TO MAKE ASSESSMENT OF BRAKES. RECALL NOTICE RECEIVED FOR DEFECTIVE THROTTLE, PRODUCING SAME EFFECT AS DEMONSTRATED AT INCIDENT. INFORMED MECHANIC OF RECALL NOTICE UPON RECEIPT,RECALL REPAIRED AS PER DEALER MECHANIC. CAR HAS NOT PRODUCED SAME EFFECT SINCE. *NM
NHTSA ODI #10139518
Mileage unknown · Sep 20, 2005
Vehicle Speed Control
I HAVE RECEIVED A SAFETY RECALL NOTICE FROM KIA MOTORS AMERICA, INC DATED AUGUST 29, 2005, NOTIFYING ME THAT MY 2004 KIA SEDONA REQUIRES IMMEDIATE SERVICE AT NO COST TO MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. I HAVE CONTACTED NATIONWIDE KIA, THE DEALERSHIP WHERE I PURCHASED THE VEHICLE (SEE CONTACT INFORMATION BEL…
Read full complaint
I HAVE RECEIVED A SAFETY RECALL NOTICE FROM KIA MOTORS AMERICA, INC DATED AUGUST 29, 2005, NOTIFYING ME THAT MY 2004 KIA SEDONA REQUIRES IMMEDIATE SERVICE AT NO COST TO MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. I HAVE CONTACTED NATIONWIDE KIA, THE DEALERSHIP WHERE I PURCHASED THE VEHICLE (SEE CONTACT INFORMATION BELOW), WITHOUT A RESPONSE TO DATE. NATIONWIDE KIA 1600 YORK RD TIMONIUM, MD 21093 PH: (410) 561-9000 FX: (410) 561-1967 . *NM
NHTSA ODI #10137124
5,200 miles · Aug 23, 2005
SuspensionVehicle Speed Control
DT: THE CALLER RECEIVED A RECALL LETTER BUT CAN'T GET REPAIR WORK DONE. DEALER SAID THEY DID HAVE THE PARTS TO FIX IT. THROTTLE CABLE AND WHEEL BARINGS FAIKED. DEALER SAID PARTS WERE ON BACK ORDER. MANUFACTURER HAS NOT BEEN CONTACTED YET.*AK
NHTSA ODI #10133873
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Illustration