NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
9 reportsClear category filterMileage unknown · Oct 8, 2021
Unknown Or OtherFire
Everything appears normal driving down road bout 45 to 50 mph. Slowed down for car n front was turning when I noticed smoke coming from under hood around headlights both sides. Then we pulled into a storage unit place. When even more smoke . I got out popped hood it was all on fire. I turned off van and a friend and I got a coup…
Read full complaint
Everything appears normal driving down road bout 45 to 50 mph. Slowed down for car n front was turning when I noticed smoke coming from under hood around headlights both sides. Then we pulled into a storage unit place. When even more smoke . I got out popped hood it was all on fire. I turned off van and a friend and I got a couple cups and dipped in water puddle and put fire out , while we were watching to make sure it restarted 2 more times. After half hour goes by and no more smoke . Closed van up found a ride home after contacting insurance company.
NHTSA ODI #11436117
214,000 miles · Mar 21, 2018
Unknown Or OtherFire
ON SATURDAY, DECEMBER 16, AT APPROXIMATELY 11:30 AM, MY WIFE'S 2004 KIA SEDONA SPONTANEOUSLY CAUGHT FIRE IN THE DRIVEWAY OF OUR HOME. I HAD DRIVEN IT THAT MORNING TO RUN A QUICK ERRAND, ACTUAL DRIVE TIME LESS THAN HALF AN HOUR WITHOUT ANYTHING OUT OF THE ORDINARY. I RETURNED HOME, PARKED IN OUR DRIVEWAY BEHIND MY FORD WINDSTAR…
Read full complaint
ON SATURDAY, DECEMBER 16, AT APPROXIMATELY 11:30 AM, MY WIFE'S 2004 KIA SEDONA SPONTANEOUSLY CAUGHT FIRE IN THE DRIVEWAY OF OUR HOME. I HAD DRIVEN IT THAT MORNING TO RUN A QUICK ERRAND, ACTUAL DRIVE TIME LESS THAN HALF AN HOUR WITHOUT ANYTHING OUT OF THE ORDINARY. I RETURNED HOME, PARKED IN OUR DRIVEWAY BEHIND MY FORD WINDSTAR. BOTH MY WIFE AND MYSELF WERE IN OUR HOUSE WHEN WE HEARD A LOUD BOOM FOLLOWED SHORTLY BY A SECOND BOOM. THAT IS WHEN WE SAW THAT FIRE WAS COMING FROM THE ENGINE COMPARTMENT OF HER VAN AND THE REAR OF MY WINDSTAR WAS ON FIRE. WE IMMEDIATELY CALLED 911 AND SHORTLY THEREAFTER OUR LOCAL FIRE COMPANY ARRIVED AND BEGAN FIGHTING THE BLAZE. BY THAT TIME BOTH VEHICLES WERE ENGULFED IN FLAMES. THE FIRE APPEARS TO HAVE STARTED IN THE ENGINE COMPARTMENT OF THE KIA. BOTH VEHICLES ARE A TOTAL LOSS. UNTIL THIS INCIDENT, NOTWITHSTANDING BASIC MAINTENANCE AND REPAIRS, THE KIA SEDONA WAS A VERY RELIABLE VEHICLE. AS WITH THE WINDSTAR, MAINTENANCE AND REPAIRS WERE DONE ON A REGULAR AND AS NEEDED BASIS BY THE SAME SHOP THAT HAS WORKED ON ALL OUR VEHICLES FOR OVER 10 YEARS. I AM SURE I CAN PRODUCE MAINTENANCE AND REPAIR RECORDS IF NEEDED. THE LAST TIME THE KIA WAS SERVICED WAS LATE OCTOBER OF THIS YEAR TO REPLACE AN ALTERNATOR.
NHTSA ODI #11080722
101,294 miles · Jun 5, 2017
Unknown Or Other
WHEN I WENT TO START MY CAR IT IMMEDIATELY SHUT OFF, AS IT OCCASIONALLY DOES. THE RPM'S DROPPED AND THE ENGINE CUT OUT. USUALLY THE PROBLEM IS RESOLVED BY ME REVVING THE ENGINE FOR A MINUTE OR TWO, BUT THE PROBLEM PERSISTED LONGER THAN USUAL. IT EVENTUALLY STAYED ON AND I TRIED TO DRIVE AWAY. AS I CHANGED INTO GEAR EVERYTHING SE…
Read full complaint
WHEN I WENT TO START MY CAR IT IMMEDIATELY SHUT OFF, AS IT OCCASIONALLY DOES. THE RPM'S DROPPED AND THE ENGINE CUT OUT. USUALLY THE PROBLEM IS RESOLVED BY ME REVVING THE ENGINE FOR A MINUTE OR TWO, BUT THE PROBLEM PERSISTED LONGER THAN USUAL. IT EVENTUALLY STAYED ON AND I TRIED TO DRIVE AWAY. AS I CHANGED INTO GEAR EVERYTHING SEEMED OKAY, I REVERSED FROM WHERE I WAS PARKED THEN I PUT IT INTO DRIVE AND WHILE IN THE MIDDLE OF THE ROAD THE ENGINE CUT OUT AND I WAS STUCK THERE FOR ONLY A FEW SECONDS LUCKILY. I DROVE BACK TO WHERE I WAS PARKED AND AS I STOPPED THE ENGINE CUT OUT ON ME. THIS TYPICALLY HAS HAPPENED TO ME WHEN THE GAS TANK WAS BELOW HALF. I MANAGED TO GET TO A GAS STATION AND FILL UP AND THAT STOPPED THE PROBLEM.
NHTSA ODI #10993222
100,000 miles · Mar 30, 2017
Electrical SystemUnknown Or Other
TAKATA RECALL..MY VAN STALLS OUT NO MATTER WHERE..STOPPED AT IDLE IT RANDOMLY SHUTS OFF..DRIVING AVERAGE SPEED IN TOWN 45MPH IT RANDOMLY SHUTS OFF..ON THE HWY. SPEEDS AVERAGE FROM 55 TO 70 MPH IT RANDOMLY SHUTS OFF ..IN HEAVY TRAFFIC THIS IS VERY DANGEROUS..I HAVE REPLACED THE FOLLOWING.. FUEL PUMP FUEL FILTER FUEL PUMP RELAY…
Read full complaint
TAKATA RECALL..MY VAN STALLS OUT NO MATTER WHERE..STOPPED AT IDLE IT RANDOMLY SHUTS OFF..DRIVING AVERAGE SPEED IN TOWN 45MPH IT RANDOMLY SHUTS OFF..ON THE HWY. SPEEDS AVERAGE FROM 55 TO 70 MPH IT RANDOMLY SHUTS OFF ..IN HEAVY TRAFFIC THIS IS VERY DANGEROUS..I HAVE REPLACED THE FOLLOWING.. FUEL PUMP FUEL FILTER FUEL PUMP RELAYS THROTTLE POSITION SENSOR MASS AIR FLOW SENSOR CRANK SHAFT POSITION SENSOR OXYGEN SENSOR FUEL COIL PACKS SPARK PLUGS INTAKE GASKETS INJECTORS AIR FILTER JUST LIKE THE HUNDREDS OF PEOPLE ON THE FORUMEBAY ABOUT KIA SEDONA..I'VE PUT $1000'S IN THE VAN WITH NO SOLUTION TO THE DANGEROUS ISSUES..THE ONLY THING LEFT TO CHANGE IS THE INTERNAL WIRING..THIS PROBLEM IS WAY TO COMMON FOR KIA NOT TO HAVE A RECALL ON IT..ITS A HUGE SAFETY HAZARD AND NEEDS TO HAVE SOMETHING DONE ABOUT IT..NOT JUST FOR ME BUT FOR EVERYONE THAT HAS A KIA SEDONA..ITS OBVIOUSLY A SHORT IN THE WIRING AND IS A MANUFACTURER FLAW FOR SO MANY PEOPLE TO HAVE THE SAME ISSUE..BTW MY VAN ONLY HAS 100.000 MILES ON IT I'VE SEEN SOME AS LOW AS 30.000 WITH THIS SAME ISSUE..NO EXCUSES FOR THIS..ANY KIND OF ELECTRONIC SHORT OUT HAS POTENTIAL FOR FIRE NOT TO MENTION THE HAZARDS OF THE VAN RANDOMLY STOPPING IN TOWN AT INTERSECTION ON THE INTERSTATE .
NHTSA ODI #10969516
Mileage unknown · Mar 31, 2007
Engine And Engine CoolingFuel System, GasolineUnknown Or Other
CAR BUCKING AND SHIFTING PROBLEMS. KIA HAS HAD MANY PROBLEMS WITH THE SEDONA AND FUEL PROBLEMS THAT THEY ARE WELL AWARE OF BUT REFUSE TO DO ANYTHING ABOUT THEM. THE CAR STALLS ON THE FREE WAY IT BUCK VIOLENTLY AND THERE ARE NUMEROUS OWNERS THAT ARE HAVING THE SAME PROBLEMS THAT WE ARE FACING. *JB
NHTSA ODI #10186644
22,344 miles · Jun 8, 2006
Child SeatUnknown Or Other
DT*: THE CONTACT STATED WHILE THE CHILD WAS RESTRAINED, THE BOOSTER SEATBELT CLIPS FRACTURED WHICH ALLOWED THE SEATBELT TO RUB THE CHILD'S NECK. THIS INCIDENT OCCURRED WITHOUT WARNING. NO INJURIES WERE SUSTAINED. THE MANUFACTURER WAS ALERTED. THE CHILD SAFETY SEAT IS AN EVENFLO COMET, MODEL # 3221213P1, DATE OF MANUFACTURE O…
Read full complaint
DT*: THE CONTACT STATED WHILE THE CHILD WAS RESTRAINED, THE BOOSTER SEATBELT CLIPS FRACTURED WHICH ALLOWED THE SEATBELT TO RUB THE CHILD'S NECK. THIS INCIDENT OCCURRED WITHOUT WARNING. NO INJURIES WERE SUSTAINED. THE MANUFACTURER WAS ALERTED. THE CHILD SAFETY SEAT IS AN EVENFLO COMET, MODEL # 3221213P1, DATE OF MANUFACTURE OCT. 23, 2002.
NHTSA ODI #10159328
22,344 miles · Jun 8, 2006
Child SeatUnknown Or Other
DT*: THE CONTACT STATED WHILE THE CHILD WAS RESTRAINED, THE BOOSTER SEATBELT CLIPS FRACTURED WITHOUT WARNING WHICH ALLOWED THE SEATBELT TO RUB THE CHILD'S NECK. NO INJURIES WERE SUSTAINED. THE MANUFACTURER WAS ALERTED. THE CHILD SAFETY SEAT IS AN EVENFLO COMET, MODEL # 3221213P1, DATE OF MANUFCATURE JAN. 16, 2003.
NHTSA ODI #10159326
Mileage unknown · Aug 19, 2005
Unknown Or Other
DT: THE CONSUMER RECEIVED A RECALL LETTER IN THE MAIL ON JUNE 15, 2005. THERE WAS NO RECALL NUMBER ON THE LETTER. THE CONSUMER HAS CONTACTED THE DEALER AND THEY DO NOT HAVE THE PARTS. IT HAS BEEN A MONTH SINCE THE CONSUMER RECEIVED THE LETTER. THE CONSUMER CONTACTED THE MANUFACTURER AND THE PARTS WERE BACK ORDERED. *JB *SC
NHTSA ODI #10129868
Mileage unknown · Jun 1, 2005
TiresUnknown Or Other
DT: THE SPARE TIRE UNDERNEATH THE VAN SITS ON A METAL RACK. THE METAL RUBED ON THE TIRE AND MADE RIDGES ON THE TIRE. CONSUMER CONTACTED MANUFACTURER. *AK *SB *NM
NHTSA ODI #10120093
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Illustration