IllustrationPOWER STEERING SEEMS TO FADE IN AND OUT INTERMITTENTLY. I LOOKED ONLINE AND SEE THAT THERE AREA A LOT OF KIA SADONA OWNER THAT ARE HAVING THE SAME ISSUE HOWEVER THERE IS NO RECALL. THIS IS A SAFETY CONCERN AND THIS SHOULD BE TAKEN CARE OF NOW BEFORE SOME ONE GETS KILLED. *TR
2004 Kia Sedona
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Kia Sedona do not stand out strongly from the model-year median of 120.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sedona years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
1625–50K
1850–75K
2175–100K
16100–150K
7150K+
129 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Wheels. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports13 fire reports8 injury reports
Steering complaints
22 reportsTL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE TRYING TO MAKE A TURN THE RACK A PINION STEERING MADE A CLANGING NOISE IN STAGES, JERKS BACK AND FORTH AND BECAME VERY HARD TO TURN. THE DEALER WAS CALLED AND INFORMED HIM THAT THE WARRANTY EXPIRED AND HE HAD TO PAY FOR THE REPAIRS. THE MANUFACTURER WAS CALLED AND CONFIRMED THAT THE W…
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE TRYING TO MAKE A TURN THE RACK A PINION STEERING MADE A CLANGING NOISE IN STAGES, JERKS BACK AND FORTH AND BECAME VERY HARD TO TURN. THE DEALER WAS CALLED AND INFORMED HIM THAT THE WARRANTY EXPIRED AND HE HAD TO PAY FOR THE REPAIRS. THE MANUFACTURER WAS CALLED AND CONFIRMED THAT THE WARRANTY EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 55,000.
MY 2004 KIA SEDONA STEERING COLUMN DISINTEGRATED CAUSING STEERING FAILURE. IT HAD TO BE COMPLETELY REPLACED AT MY COST. *TR
2004 KIA SEDONA. STEERING THIS VEHICLE BECAME EXTREMELY DANGEROUS WHEN EXECUTING TURNS, ESPECIALLY EXITING FROM HIGHWAYS. STEERING FEELS AS IF IT IS BINDING AND ABOUT TO SEIZE. STEERING WHEEL WILL NOT RETURN TO CENTER WITHOUT SIGNIFICANT DRIVER EFFORT. THE PROBLEM IS MORE NOTICEABLE WHEN APPLYING THE BRAKES. KIA SIMPLY ADVI…
Read full complaint
2004 KIA SEDONA. STEERING THIS VEHICLE BECAME EXTREMELY DANGEROUS WHEN EXECUTING TURNS, ESPECIALLY EXITING FROM HIGHWAYS. STEERING FEELS AS IF IT IS BINDING AND ABOUT TO SEIZE. STEERING WHEEL WILL NOT RETURN TO CENTER WITHOUT SIGNIFICANT DRIVER EFFORT. THE PROBLEM IS MORE NOTICEABLE WHEN APPLYING THE BRAKES. KIA SIMPLY ADVISED ME THE VEHICLE IS OUT OF WARRANTY AND THE STEERING MECHANISM IS NOT PART OF THE DRIVE TRAIN. THE REPAIR SHOP INDICATES THE STEERING SYSTEM NEEDS REPLACEMENT OF THE RACK AND PINION MECHANISM. THIS VEHICLE WAS PURCHASED NEW IN NJ AND IT HAS BEEN USED PRIMARILY IN NJ AND THE NORTHEAST; THE VEHICLE IS USED AS THE FAMILY CAR WITH MOST DRIVING DONE LOCALLY WITHIN TOWN. MILEAGE IS APPROX 63,000. THE PROBLEM IS NOT RELATED TO THE POWER STEERING FLUID OR PUMP. THE STEERING MECHANISM IS ABOUT THE MOST BASIC AND CRITICAL SAFETY SYSTEM ON A CAR NEXT TO THE BRAKES. PRIOR INVESTIGATIONS LISTED ON THE NHTSA SITE MENTION A PROBLEM RATE 11 TIMES HIGHER IN SALT BELT STATES (MY VEHICLE HAD TO HAVE THE REAR WHEEL BEARINGS REPLACED FOR THIS ISSUE VIA A SAFETY RECALL). IT SEEMS THIS IS SOMETHING THE CAR MANUFACTURER NEEDS TO RECONSIDER. *TR
POWER STEERING SEEMS TO FADE IN AND OUT INTERMITTENTLY. *TR
TL* THE CONTACT OWNS A 2004 KIA SEDONA. WHEN MAKING TURNS SHE CAN HEAR A CLINGING NOISE IN THE STEERING COLUMN. ALSO SHE EXPERIENCED DIFFICULTLY STEERING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. SHE WAS ADVISED THAT THE INTERMEDIATE SHAFT BINDING NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 50000.…
Read full complaint
TL* THE CONTACT OWNS A 2004 KIA SEDONA. WHEN MAKING TURNS SHE CAN HEAR A CLINGING NOISE IN THE STEERING COLUMN. ALSO SHE EXPERIENCED DIFFICULTLY STEERING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. SHE WAS ADVISED THAT THE INTERMEDIATE SHAFT BINDING NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 50000.
ABOUT A YEAR AGO MY STEERING ON MY 04 KIA SEDONA WAS GETTING TIGHT AND HARD TO TURN, NOW THERE IS A CLICKING NOISE WHEN TURNING THE STEERING WHEEL MY FRIEND HAS AN 03 SEDONA AND HERS DID THE SAME THING IS THIS A RECALL? *TR
I HAVE A 2004 KIA SEDONA. I AM THE ONLY OWNER. I STARTED HAVING STEERING PROBLEMS ABOUT 5 DAYS AGO. I ALMOST RAN INTO ANOTHER CAR TURNING THE CORNER. I TOOK IT INTO MY KIA DEALER TO BE TOLD MY STEERING BINDING HAS FAILED. SO NOW I HAVE TO PAY OVER $500 TO HAVE IT REPAIRED, SINCE THIS IS A SAFETY HAZARD. I BELIEVE THIS TO BE A D…
Read full complaint
I HAVE A 2004 KIA SEDONA. I AM THE ONLY OWNER. I STARTED HAVING STEERING PROBLEMS ABOUT 5 DAYS AGO. I ALMOST RAN INTO ANOTHER CAR TURNING THE CORNER. I TOOK IT INTO MY KIA DEALER TO BE TOLD MY STEERING BINDING HAS FAILED. SO NOW I HAVE TO PAY OVER $500 TO HAVE IT REPAIRED, SINCE THIS IS A SAFETY HAZARD. I BELIEVE THIS TO BE A DEFECT ON MY KIA. I WOULD LIKE FOR THEM TO TAKE CARE OF IT AND REIMBURSE ME FOR MY COSTS. *TR
WHILE DRIVING, I NOTICED THE STEERING STARTED TO GET MORE AND MORE HARD TO CORRECT WHILE TURNING. AS YOU ARE TURNING THE WHEEL STICKS, THEN GIVES AND STICKS AGAIN. WHILE IN THE STUCK POSITION, IF YOU DO NOT TURN THE WHEEL HARDER, THE VAN WILL CONTINUE TO LEAD IN THE DIRECTION. WE TOOK THE VAN IN FOR INSPECTION, AND WERE TOLD …
Read full complaint
WHILE DRIVING, I NOTICED THE STEERING STARTED TO GET MORE AND MORE HARD TO CORRECT WHILE TURNING. AS YOU ARE TURNING THE WHEEL STICKS, THEN GIVES AND STICKS AGAIN. WHILE IN THE STUCK POSITION, IF YOU DO NOT TURN THE WHEEL HARDER, THE VAN WILL CONTINUE TO LEAD IN THE DIRECTION. WE TOOK THE VAN IN FOR INSPECTION, AND WERE TOLD IT WAS THE POWER STEERING PUMP. THEY REPLACED IT, BUT WE OUT OF THE 60,000 MILE WARRANTY. THANKFULLY WE BOUGHT THE EXTENDED WARRANTY, SO IT ONLY COST US THE $100 DEDUCTIBLE. THEY THEN TOLD US THE POWER STEERING BELT NEEDED REPLACED, BUT WAS NOT COVERED UNDER THE EXTENDED WARRANTY. AFTER WE RECEIVED THE VAN BACK, IT CONTINUED TO DO THE SAME. WE ARE TAKING THE VAN BACK IN FOR SERVICE AND COMPLAINT TOMORROW. HOPEFULLY THEY GET IT RIGHT THIS TIME. THIS IS NOT SOMETHING TO THINK YOU GOT IT RIGHT THE FIRST TIME, HAS TO BE ABSOLUTELY RIGHT THE FIRST TIME. ESPECIALLY WHEN YOU HAVE 2 SMALL KIDS. *TR
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE HER DAUGHTER WAS DRIVING AT ABOUT 5 TO 10 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN IN ALL DRIVING CONDITIONS. THE CONTACT ALSO HEARD A SQUEAKING SOUND WHEN TURNING THE STEERING WHEEL. THE STEERING SHAFT U-JOINT FAILURE (BADLY CORRODED) CAUSED THE CONTACT TO CRASH THE FRONT …
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE HER DAUGHTER WAS DRIVING AT ABOUT 5 TO 10 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN IN ALL DRIVING CONDITIONS. THE CONTACT ALSO HEARD A SQUEAKING SOUND WHEN TURNING THE STEERING WHEEL. THE STEERING SHAFT U-JOINT FAILURE (BADLY CORRODED) CAUSED THE CONTACT TO CRASH THE FRONT END OF HER VEHICLE INTO THE BRIDGE ON HER DRIVEWAY. SHE HAS NOT TAKEN THE VEHICLE TO A DEALER. THE DEALER SAID THAT THERE IS A NATIONAL BACK ORDER FOR STEERING INTERMEDIATE SHAFT. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 90,000 AND FAILURE MILEAGE WAS 89,000.
Official recalls
205V329000 · Vehicle Speed Control:cables
Jul 20, 2005
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence & remedy
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
05V232000 · Wheels
May 19, 2005
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence & remedy
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.