IllustrationAT 18000 MI. VAN SHOOK WHILE BRAKING. DEALER CUT ROTORS AND REPLACED BRAKE PADS. AT 20000 MI. VAN SHOOK AGAIN BROUGHT VEHICLE BACK TO DEALER, DEALER REPLACED ROTORS AND BRAKE PADS. AT 33000 MI PROBLEM STARTED ALL OVER AGAIN. *NM
2004 Kia Sedona
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Kia Sedona do not stand out strongly from the model-year median of 120.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sedona years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
1625–50K
1850–75K
2175–100K
16100–150K
7150K+
129 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Wheels. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports13 fire reports8 injury reports
Service Brakes, Hydraulic complaints
28 reportsDT*: THE CONTACT STATED AT VARIOUS SPEEDS, THE VEHICLE'S FRONT BRAKES MADE A SCREECHING NOISE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO DETERMINED THAT THE FRONT BRAKE PADS WERE WORN AND INSTALLED NEW PADS. THE VEHICLE RETURNED TO THE DEALER 4 MONTHS LATER, BECAUSE THE PADS WORE OUT PREMATURELY AND HAD TO BE REPLACED. THIS…
Read full complaint
DT*: THE CONTACT STATED AT VARIOUS SPEEDS, THE VEHICLE'S FRONT BRAKES MADE A SCREECHING NOISE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO DETERMINED THAT THE FRONT BRAKE PADS WERE WORN AND INSTALLED NEW PADS. THE VEHICLE RETURNED TO THE DEALER 4 MONTHS LATER, BECAUSE THE PADS WORE OUT PREMATURELY AND HAD TO BE REPLACED. THIS DID NOT REMEDY THE PROBLEM. ON THE 3RD VISIT, THE DEALER REPLACED THE FRONT CALIPERS BUT THE PROBLEM PERSISTED. THE VEHICLE WAS TAKEN TO THE DEALER ON 2 OTHER OCCASIONS FOR FRONT PAD REPLACEMENT, BUT THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOT CONTACTED.
THEY WERE MINOR AT FIRST, SPEAKER COVER, WEATHER STRIPPING, AND NOISE WHEN BACKING UP. THEN THE OTHER PROBLEMS CAME: FAULTY PILOT BEARING, CLUTCH, AND PRESSURE PLATE, 4WD LIGHT, E BRAKE, POWER WINDOWS, PAINT COMING OF VEHICLE IN VARIOUS PLACES, DOME LAMP,DOOR LOCK SENSOR, GEAR SHIFTER, WINDSHIELD MOLDING, AIR BAG LIGHT,GAS PEDAL…
Read full complaint
THEY WERE MINOR AT FIRST, SPEAKER COVER, WEATHER STRIPPING, AND NOISE WHEN BACKING UP. THEN THE OTHER PROBLEMS CAME: FAULTY PILOT BEARING, CLUTCH, AND PRESSURE PLATE, 4WD LIGHT, E BRAKE, POWER WINDOWS, PAINT COMING OF VEHICLE IN VARIOUS PLACES, DOME LAMP,DOOR LOCK SENSOR, GEAR SHIFTER, WINDSHIELD MOLDING, AIR BAG LIGHT,GAS PEDAL STICKING, CUP HOLDER. THE ONES THAT CONCERN ME THE MOST IS THE VIBRATION THAT I HAVE AT SPEEDS OF 65-75 MPH. THE WHOLE STEERING WHEEL SHAKES AND THE VIBRATION CAN BE FELT BELOW. I HAVE SEEN WHERE THERE ARE OTHER COMPLAINTS ON THIS MODEL FOR THIS. I AM CONCERNED BECAUSE I HAVE TAKEN IT TO THE DEALER AND THEY CANNOT LOCATE THE PROBLEM. I ALSO HAVE PROBLEMS SHIFTING INTO LOWER GEARS ESPECIALLY IN THE MORNINGS. I ALSO HAVE PROBLEMS SHIFTING INTO 1ST GEAR FROM NEUTRAL. I WAS SITTING AT A STOP LIGHT AND WHEN THE LIGHT TURNED GREEN WENT TO PUT MY CAR INTO FIRST, IT WOULD NOT GO, I SHIFTED INTO 2ND AND TRIED TO GO INTO 1ST BUT IT WOULD NOT GO. I FINALLY CUT THE VEHICLE OFF AND GOT IT INTO 1ST. THE OTHER MAIN CONCERN IS THERE IS A DELAY ON ACCELERATION. I EXPERIENCE IT AFTER MY VEHICLE HAS SAT FOR 5 OR MORE HOURS. WHEN THE GAS PEDAL IS PUSHED THE VEHICLE WILL NOT GO OR WILL MOVE SEVERAL FEET AND THEN STOP. I HAVE MADE THE DEALERSHIP AWARE OF THESE PROBLEMS AND SOME HAVE BEEN FIXED BUT THE MAJOR ONES, VIBRATION, HESITATION, AND SHIFTING INTO 1ST CANNOT BE FIXED BECAUSE THE CAUSE IS UNKNOWN. I HAVE ALREADY HAD TWO CLOSE CALLS IN THIS VEHICLE ONE BECAUSE I COULD NOT GET MY CAR INTO GEAR AND I WAS ABOUT HIT FROM BEHIND. THE OTHER WAS THE HESITATION WHERE THE CAR STALLED JUST AS I WAS PULLING ONTO THE ROAD AND WOULD NOT GO. THE VIBRATION CONCERNS ME TOO BECAUSE THIS COULD BE THE TRANSMISSION OR STEERING, AND I KNOW THAT MUCH OF A VIBRATION HAS TO AFFECT OTHER THINGS AS WELL. I AM GOING TO CONTACT SOMEONE ABOUT TRYING TO DECLARE THIS VEHICLE AS A LEMON. I AM CONCERNED FOR MY DAUGHTER'S SAFETY AND THIS IS MY ONLY SOURCE OF TRANSPORTATION. PLEASE HELP ME. *JB
WE RECENTLY HAD TO HAVE BRAKES REDONE ON OUR KIA SEDONA WITH ONLY 25,000 MILES. WE WERE TOLD THERE WAS ONLY 5 PERCENT BRAKING LEFT. THIS IS CONSISTENT WITH THE VIBRATIONS WE OBSERVED UPON BRAKING. WE WERE TOLD BY THE KIA SERVICE MANAGER THAT THE VEHICLE WAS VERY HEAVY IN FRONT AND THAT WAS THE REASON FOR THE EXTREME BRAKE F…
Read full complaint
WE RECENTLY HAD TO HAVE BRAKES REDONE ON OUR KIA SEDONA WITH ONLY 25,000 MILES. WE WERE TOLD THERE WAS ONLY 5 PERCENT BRAKING LEFT. THIS IS CONSISTENT WITH THE VIBRATIONS WE OBSERVED UPON BRAKING. WE WERE TOLD BY THE KIA SERVICE MANAGER THAT THE VEHICLE WAS VERY HEAVY IN FRONT AND THAT WAS THE REASON FOR THE EXTREME BRAKE FAILURE. WE WERE ALSO TOLD THEY HAD TO REPLACE THE BRAKES ON A SEDONA WITH ONLY 13,000 MILES. THE SERVICE MANAGER ALSO SAID THE BRAKE WEAR WAS DUE TO DRIVING HABITS. AS A COMPARISON, WE HAVE A FORD WINDSTAR, 1995 MODEL, WITH ABOUT 140,000 MILES AND IT HAD TO HAVE ONLY ONE BRAKE JOB. ANOTHER VEHICLE IN OUR POSSESSION, A NISSAN FRONTIER WITH OVER 80,000 MILES HAS NOT HAD TO HAVE THE BRAKES REDONE. I FEEL THIS IS A DESIGN PROBLEM WITH KIA SEDONA AND CAN LEAD TO A SAFETY ISSUE. *JB
DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE THE BRAKES MADE A GRINDING NOISE. THE DEALERSHIP REPLACED THE FRONT AND REAR BRAKES AND ROTORS HOWEVER THE PROBLEM STILL EXISTS. THE MANUFACTURER WAS ALERTED.
THE REAR OF THE VEHICLE BEGAN TO PRODUCE A HUMMING NOISE AND IT GRADUALLY GOT LOUDER UNTIL THE PASSENGER SIDE REAR BRAKE ASSEMBLY AND TIRE CAME OUT OF THE 2004 KIA SEDONA. *AK
BEFORE 10,000 MILES, THE FRONT WOULD VIBRATE WHEN BRAKING FROM HIGHWAY SPEEDS OR GOING DOWN STEEP HILLS. I HAD THE ROTORS TURNED BECAUSE THEY WERE WARPED. WITHIN 3 MONTHS, THE SAME THING HAPPENED AGAIN. THE ROTORS WERE WARPED AGAIN. I TOOK IT TO THE DEALERSHIP AND THEY REPLACED THE ROTORS. WITHIN 3 MONTHS IT DID IT AGAIN. …
Read full complaint
BEFORE 10,000 MILES, THE FRONT WOULD VIBRATE WHEN BRAKING FROM HIGHWAY SPEEDS OR GOING DOWN STEEP HILLS. I HAD THE ROTORS TURNED BECAUSE THEY WERE WARPED. WITHIN 3 MONTHS, THE SAME THING HAPPENED AGAIN. THE ROTORS WERE WARPED AGAIN. I TOOK IT TO THE DEALERSHIP AND THEY REPLACED THE ROTORS. WITHIN 3 MONTHS IT DID IT AGAIN. I TOOK IT BACK TO THE DEALERSHIP AND THEY REPLACED THE ROTORS AGAIN. I ALSO REPLACED THE BRAKES OUT OF MY POCKET. IT HAS BEEN ANOTHER 3 MONTHS AND IT IS STARTING AGAIN. AT A ROUTINE OIL CHANGE AND BRAKE INSPECTION, FIRESTONE SAYS THE ROTORS ARE WARPED AND MY BRAKE PADS ARE DOWN TO 25%. THE VEHICLE IS ONLY 2 YEARS OLD AND HAS LESS THAN 30,000 MILES ON IT. I HAVE HAD 3 DIFFERENT SETS OF ROTORS PUT ON THIS VEHICLE. *JB
NONE. *NM
KIA SEDONA REAR OUTER BEARINGS AND/OR HUB ASSEMBLY NEEDING REPLACED. *TS WHEN THE CONSUMER ARRIVED AT THE DEALERSHIP, SHE INFORMED THE REPRESENTATIVE THE LEFT REAR SEAT WOULD NOT COME OUT AND THE AIR BAG LIGHT WAS ON. WHEN THE CONSUMER WENT TO PICK UP THE VAN AND AFTER GOING OVER THE PAPERWORK, SHE NOTICED ONLY THE AIR BAG LIGH…
Read full complaint
KIA SEDONA REAR OUTER BEARINGS AND/OR HUB ASSEMBLY NEEDING REPLACED. *TS WHEN THE CONSUMER ARRIVED AT THE DEALERSHIP, SHE INFORMED THE REPRESENTATIVE THE LEFT REAR SEAT WOULD NOT COME OUT AND THE AIR BAG LIGHT WAS ON. WHEN THE CONSUMER WENT TO PICK UP THE VAN AND AFTER GOING OVER THE PAPERWORK, SHE NOTICED ONLY THE AIR BAG LIGHT WAS FIXED AND EVERYTHING ELSE THE PARTS WERE ON ORDER. AFTER GETTING ANOTHER APPOINTMENT, THE CONSUMER THEN TOLD THE DEALER SHE WAS EXPERIENCING A PULSATION WHEN IN THE BRAKES. THE DEALER TOLD THE CONSUMER THE BRAKES WERE NOT A PART OF THE WARRANTY, HOWEVER THEY WOULD TAKE THE RESPONSIBILITY FOR THE ROTORS, BUT THE CONSUMER WOULD HAVE TO PAY FOR THE BRAKE PADS. THE CONSUMER STATED THE PULSATION PROBLEM HAD NEVER BEEN FIXED. THE CONSUMER WAS TOLD NOW THE REAR BRAKES WERE PULSATING. *JB
DT: THE CONTACT OWNS A 2004 KIA SEDONA. WHEN APPLYING THE BRAKES THE WHOLE FRONT END VIBRATED. DID NOT HEAR NOISES WHEN APPLYING THE BRAKES. SHE NOTICED THIS AROUND TWO MONTHS AGO. THE CONSUMER MOTHER-IN -LAW ALSO HAD A 2005 KIA SEDONA AND SHE EXPERIENCED THE SAME PROBLEM. THE CONSUMER TOOK CAR TO A DEALER, AND THEY TOLD…
Read full complaint
DT: THE CONTACT OWNS A 2004 KIA SEDONA. WHEN APPLYING THE BRAKES THE WHOLE FRONT END VIBRATED. DID NOT HEAR NOISES WHEN APPLYING THE BRAKES. SHE NOTICED THIS AROUND TWO MONTHS AGO. THE CONSUMER MOTHER-IN -LAW ALSO HAD A 2005 KIA SEDONA AND SHE EXPERIENCED THE SAME PROBLEM. THE CONSUMER TOOK CAR TO A DEALER, AND THEY TOLD HER THAT IT WAS NOT THE BRAKES. THEY WERE NOT SURE WHAT IT WAS. THE CONSUMER SAID THIS HAPPENS AT ANY SPEED.*AK *JB
Official recalls
205V329000 · Vehicle Speed Control:cables
Jul 20, 2005
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence & remedy
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
05V232000 · Wheels
May 19, 2005
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence & remedy
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.