MULTIPLE INSTANCES WHERE VEHICLE HAS BEEN UNABLE TO START. WILL SUBSEQUENTLY TURN OVER FOR A PERIOD OF ABOUT 5 SECONDS AND FINALLY "CATCHES" AND WILL RUN ROUGH. UPON DRIVING THE VEHICLE WILL RUN ROUGH, HESITATE AND STALL, MOSTLY AT TIMES DURING A FULL STOP ATTEMPTING TO ACCELERATE TO NORMAL DRIVING SPEED IN TRAFFIC AND THROUGH…
Read full complaint
MULTIPLE INSTANCES WHERE VEHICLE HAS BEEN UNABLE TO START. WILL SUBSEQUENTLY TURN OVER FOR A PERIOD OF ABOUT 5 SECONDS AND FINALLY "CATCHES" AND WILL RUN ROUGH. UPON DRIVING THE VEHICLE WILL RUN ROUGH, HESITATE AND STALL, MOSTLY AT TIMES DURING A FULL STOP ATTEMPTING TO ACCELERATE TO NORMAL DRIVING SPEED IN TRAFFIC AND THROUGH TURNING. UPON INSPECTION AT DEALERSHIP, NO FAULTY PARTS FOUND AND CONDITION "DISAPPEARS". UPON RECEIPT OF VEHICLE FROM DEALERSHIP, PROBLEM HAS CONTINUED TO PLAGUE VEHICLE. REPLACED MANY PARTS UNDER THE ADVISEMENT OF THE DEALERSHIP AND HAVE NEVER FOUND A SOLUTION TO THE PROBLEM. NO CHECK ENGINE CODE PRESENT DURING PROBLEM. HAS LEFT FAMILY STRANDED ON MORE THAN A FEW OCCASIONS MAKING VEHICLE UNRELIABLE AND UNSAFE TO OPERATE. *TR
NHTSA ODI #10467191
80,800 miles · Oct 4, 2011
Engine And Engine CoolingPower Train
VAN WAS MAKING A HIGH-PITCHED WHINING SOUND. TOOK IT IN AND FOUND THAT THE WATER PUMP NEEDED REPLACEMENT. THEY TESTED IT AND IT WAS STILL NOT RUNNING PROPERLY SO THEY DUG A LITTLE DEEPER AND FOUND THAT THE COILS AND WIRING NEEDED TO BE REPLACED. GOT THE VAN BACK IN WORKING CONDITION AND LESS THAN TWO DAYS LATER, THE CHECK ENGINE…
Read full complaint
VAN WAS MAKING A HIGH-PITCHED WHINING SOUND. TOOK IT IN AND FOUND THAT THE WATER PUMP NEEDED REPLACEMENT. THEY TESTED IT AND IT WAS STILL NOT RUNNING PROPERLY SO THEY DUG A LITTLE DEEPER AND FOUND THAT THE COILS AND WIRING NEEDED TO BE REPLACED. GOT THE VAN BACK IN WORKING CONDITION AND LESS THAN TWO DAYS LATER, THE CHECK ENGINE LIGHT COMES ON. TOOK IT BACK AND THEY SAID IT NEEDED A NEW CATALYTIC CONVERTER. THANKS TO LAWS IN THE STATE OF CALIFORNIA, WE CANNOT REPLACE WITH AN AFTERMARKET ($200); INSTEAD WE WERE QUOTED $1K, AND THAT APPARENTLY IS ON THE CHEAP SIDE. THE GOV.'T HAS A WARRANTY PROGRAM TO REPLACE CATALYTIC CONVERTERS ON VEHICLES 80,000 MILES OR LESS. WE WERE JUST OUT OF THAT LIMIT. TOO BAD FOR US. WE'RE TRADING IT IN. *TR
NHTSA ODI #10428693
61,000 miles · Jun 21, 2011
Power TrainSteering
TL* THE CONTACT OWNS A 2004 KIA SEDONA. THE CONTACT STATED THAT WHILE ATTEMPTING A LEFT TURN, THE STEERING WHEEL LOCKED MAKING IT DIFFICULT FOR THE CONTACT TO TURN THE WHEEL. THE CONTACT TAPPED ON THE BRAKES AND THEN THE ACCELERATOR IN ORDER FOR THE STEERING WHEEL TO UNLOCK. THE DEALER WAS NOTIFIED OF THE FAILURE BUT THE VEHI…
Read full complaint
TL* THE CONTACT OWNS A 2004 KIA SEDONA. THE CONTACT STATED THAT WHILE ATTEMPTING A LEFT TURN, THE STEERING WHEEL LOCKED MAKING IT DIFFICULT FOR THE CONTACT TO TURN THE WHEEL. THE CONTACT TAPPED ON THE BRAKES AND THEN THE ACCELERATOR IN ORDER FOR THE STEERING WHEEL TO UNLOCK. THE DEALER WAS NOTIFIED OF THE FAILURE BUT THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 61,000. THE CONSUMER ALSO STATED THE VEHICLE JERKS AND THE POWER STEERING PROBLEM HAS WORSENED SIGNIFICANTLY. UPDATED 07/19/11
NHTSA ODI #10407682
Mileage unknown · Jul 30, 2006
Air BagsInterior LightingPower Train
THEY WERE MINOR AT FIRST, SPEAKER COVER, WEATHER STRIPPING, AND NOISE WHEN BACKING UP. THEN THE OTHER PROBLEMS CAME: FAULTY PILOT BEARING, CLUTCH, AND PRESSURE PLATE, 4WD LIGHT, E BRAKE, POWER WINDOWS, PAINT COMING OF VEHICLE IN VARIOUS PLACES, DOME LAMP,DOOR LOCK SENSOR, GEAR SHIFTER, WINDSHIELD MOLDING, AIR BAG LIGHT,GAS PEDAL…
Read full complaint
THEY WERE MINOR AT FIRST, SPEAKER COVER, WEATHER STRIPPING, AND NOISE WHEN BACKING UP. THEN THE OTHER PROBLEMS CAME: FAULTY PILOT BEARING, CLUTCH, AND PRESSURE PLATE, 4WD LIGHT, E BRAKE, POWER WINDOWS, PAINT COMING OF VEHICLE IN VARIOUS PLACES, DOME LAMP,DOOR LOCK SENSOR, GEAR SHIFTER, WINDSHIELD MOLDING, AIR BAG LIGHT,GAS PEDAL STICKING, CUP HOLDER. THE ONES THAT CONCERN ME THE MOST IS THE VIBRATION THAT I HAVE AT SPEEDS OF 65-75 MPH. THE WHOLE STEERING WHEEL SHAKES AND THE VIBRATION CAN BE FELT BELOW. I HAVE SEEN WHERE THERE ARE OTHER COMPLAINTS ON THIS MODEL FOR THIS. I AM CONCERNED BECAUSE I HAVE TAKEN IT TO THE DEALER AND THEY CANNOT LOCATE THE PROBLEM. I ALSO HAVE PROBLEMS SHIFTING INTO LOWER GEARS ESPECIALLY IN THE MORNINGS. I ALSO HAVE PROBLEMS SHIFTING INTO 1ST GEAR FROM NEUTRAL. I WAS SITTING AT A STOP LIGHT AND WHEN THE LIGHT TURNED GREEN WENT TO PUT MY CAR INTO FIRST, IT WOULD NOT GO, I SHIFTED INTO 2ND AND TRIED TO GO INTO 1ST BUT IT WOULD NOT GO. I FINALLY CUT THE VEHICLE OFF AND GOT IT INTO 1ST. THE OTHER MAIN CONCERN IS THERE IS A DELAY ON ACCELERATION. I EXPERIENCE IT AFTER MY VEHICLE HAS SAT FOR 5 OR MORE HOURS. WHEN THE GAS PEDAL IS PUSHED THE VEHICLE WILL NOT GO OR WILL MOVE SEVERAL FEET AND THEN STOP. I HAVE MADE THE DEALERSHIP AWARE OF THESE PROBLEMS AND SOME HAVE BEEN FIXED BUT THE MAJOR ONES, VIBRATION, HESITATION, AND SHIFTING INTO 1ST CANNOT BE FIXED BECAUSE THE CAUSE IS UNKNOWN. I HAVE ALREADY HAD TWO CLOSE CALLS IN THIS VEHICLE ONE BECAUSE I COULD NOT GET MY CAR INTO GEAR AND I WAS ABOUT HIT FROM BEHIND. THE OTHER WAS THE HESITATION WHERE THE CAR STALLED JUST AS I WAS PULLING ONTO THE ROAD AND WOULD NOT GO. THE VIBRATION CONCERNS ME TOO BECAUSE THIS COULD BE THE TRANSMISSION OR STEERING, AND I KNOW THAT MUCH OF A VIBRATION HAS TO AFFECT OTHER THINGS AS WELL. I AM GOING TO CONTACT SOMEONE ABOUT TRYING TO DECLARE THIS VEHICLE AS A LEMON. I AM CONCERNED FOR MY DAUGHTER'S SAFETY AND THIS IS MY ONLY SOURCE OF TRANSPORTATION. PLEASE HELP ME. *JB
NHTSA ODI #10163893
10,000 miles · Jun 28, 2005
Power TrainService Brakes, Hydraulic
DT: TOOK KIA, SEDONA 2004 4 TIMES TO DEALER FOR BRAKE FAILURE. THE BRAKES SQUEAKED A LOT, AND THE PROBLEM HAS NOT BEEN FIXED PROPERLY. CONSUMER TOOK VEHICLE TO THE DEALER AND THE PROBLEM WAS FIXED. BUT, THEN AGAIN ONE COULD HEAR A SOUND ON THE BRAKES. CONSUMER WAS TAKEN BACK VEHICLE TO DEALER FOR THE 5TH TIME. TO …
Read full complaint
DT: TOOK KIA, SEDONA 2004 4 TIMES TO DEALER FOR BRAKE FAILURE. THE BRAKES SQUEAKED A LOT, AND THE PROBLEM HAS NOT BEEN FIXED PROPERLY. CONSUMER TOOK VEHICLE TO THE DEALER AND THE PROBLEM WAS FIXED. BUT, THEN AGAIN ONE COULD HEAR A SOUND ON THE BRAKES. CONSUMER WAS TAKEN BACK VEHICLE TO DEALER FOR THE 5TH TIME. TO SEE WHAT COULD BE DONE. ALSO TRANSMISSION WHEN IN DRIVE AROUND 5 MPH, WANTED TO STOP, THEN JUMPED TO NORMAL. ALSO WHEN THE CAR WAS IDLING IN PARK OR STOPPING IT SHOOK. *AK
NHTSA ODI #10126821
Mileage unknown · Jun 15, 2005
Power Train
DT: TOOK VEHICLE TO DEALER AT LEAST 15 TIMES, THEY SAID NOT KICKING UP ANY ERA CODES. THE THROTTLE BODY WAS CHANGED ALSO TRANSMISSION CONTROL MODULE (TCM ) WAS THEN CHANGED. THIS DID NOT FIX THE PROBLEM. THEY DID SOMETHING WITH THE GROUNDS. IN FEBRUARY 2005 THEY PUT IN A NEW TRANSMISSION. LIKE THE CAR IT WAS LOSING POWE…
Read full complaint
DT: TOOK VEHICLE TO DEALER AT LEAST 15 TIMES, THEY SAID NOT KICKING UP ANY ERA CODES. THE THROTTLE BODY WAS CHANGED ALSO TRANSMISSION CONTROL MODULE (TCM ) WAS THEN CHANGED. THIS DID NOT FIX THE PROBLEM. THEY DID SOMETHING WITH THE GROUNDS. IN FEBRUARY 2005 THEY PUT IN A NEW TRANSMISSION. LIKE THE CAR IT WAS LOSING POWER, AND CAR WAS GEARING DOWN ON ITS OWN. AT FIRST THIS ONLY HAPPENED ONCE OR TWICE A WEEK, BUT CURRENTLY IT HAPPENED EVERY TIME CONSUMER GOT INTO THE CAR. THE LAST THIS HAPPENED CONSUMER PULLED OUT ONTO A ROAD AND CAR HAD NO POWER, AND DID NOT WANT TO ACCELERATE. IT WAS ALMOST HIT BY A TRACTOR TRAILER. DROVE TO DEALERSHIP DID NOT TURN OFF THE CAR. TECHNICIAN DROVE THE CAR, AND HE SAID THAT THE TRANSMISSION KICKED ITSELF INTO SAFE MODE, WHICH MEANT THE CAR STAYED IN SECOND GEAR WHILE DRIVING. *AK
NHTSA ODI #10125427
1,825 miles · Feb 18, 2005
Electrical SystemEngine And Engine CoolingPower Train
WHILE DRIVING 50 MPH VEHICLE STALLED. VEHICLE WAS STILL DRIVEABLE. DEALERSHIP INFORMED THE CONSUMER THAT THERE TRANSMISSION FAILED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK DEALER STATED PROBLEM WAS CAUSED BY ELECTRICL HARNESS. ALSO HAVING MULTIPLE FAILURES WITH OUTPUT SPEED SENSOR; TRANSMISSION 3 TIMES; …
Read full complaint
WHILE DRIVING 50 MPH VEHICLE STALLED. VEHICLE WAS STILL DRIVEABLE. DEALERSHIP INFORMED THE CONSUMER THAT THERE TRANSMISSION FAILED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK DEALER STATED PROBLEM WAS CAUSED BY ELECTRICL HARNESS. ALSO HAVING MULTIPLE FAILURES WITH OUTPUT SPEED SENSOR; TRANSMISSION 3 TIMES; THERMOSTAT ASSEMBLY; POWER STEERING LEAKED; INPUT SPEED SENSOR; LOW GROUND VOLTAGE FAILED; FUSE BLOCK PROBLEMS; CRUISE CONTROL. CONSUMER WAS ADVISED THAT DUE TO THE DESIGN OF THE CRUISE CONTROL, THE VEHICLE ACCELERATES OFTEN WHILE ON AN INCLINE AT 45 TO 55 MPH AS IF VEHICLE'S ENGINE/TRANSMISSION WAS RACING. *TT *TC
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence & remedy
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence & remedy
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
2004 Kia Sedona Problems, Complaints & Recalls | Skip That Year
Illustration