NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
18 reportsClear category filter100,000 miles · Mar 30, 2017
Electrical SystemUnknown Or Other
TAKATA RECALL..MY VAN STALLS OUT NO MATTER WHERE..STOPPED AT IDLE IT RANDOMLY SHUTS OFF..DRIVING AVERAGE SPEED IN TOWN 45MPH IT RANDOMLY SHUTS OFF..ON THE HWY. SPEEDS AVERAGE FROM 55 TO 70 MPH IT RANDOMLY SHUTS OFF ..IN HEAVY TRAFFIC THIS IS VERY DANGEROUS..I HAVE REPLACED THE FOLLOWING.. FUEL PUMP FUEL FILTER FUEL PUMP RELAY…
Read full complaint
TAKATA RECALL..MY VAN STALLS OUT NO MATTER WHERE..STOPPED AT IDLE IT RANDOMLY SHUTS OFF..DRIVING AVERAGE SPEED IN TOWN 45MPH IT RANDOMLY SHUTS OFF..ON THE HWY. SPEEDS AVERAGE FROM 55 TO 70 MPH IT RANDOMLY SHUTS OFF ..IN HEAVY TRAFFIC THIS IS VERY DANGEROUS..I HAVE REPLACED THE FOLLOWING.. FUEL PUMP FUEL FILTER FUEL PUMP RELAYS THROTTLE POSITION SENSOR MASS AIR FLOW SENSOR CRANK SHAFT POSITION SENSOR OXYGEN SENSOR FUEL COIL PACKS SPARK PLUGS INTAKE GASKETS INJECTORS AIR FILTER JUST LIKE THE HUNDREDS OF PEOPLE ON THE FORUMEBAY ABOUT KIA SEDONA..I'VE PUT $1000'S IN THE VAN WITH NO SOLUTION TO THE DANGEROUS ISSUES..THE ONLY THING LEFT TO CHANGE IS THE INTERNAL WIRING..THIS PROBLEM IS WAY TO COMMON FOR KIA NOT TO HAVE A RECALL ON IT..ITS A HUGE SAFETY HAZARD AND NEEDS TO HAVE SOMETHING DONE ABOUT IT..NOT JUST FOR ME BUT FOR EVERYONE THAT HAS A KIA SEDONA..ITS OBVIOUSLY A SHORT IN THE WIRING AND IS A MANUFACTURER FLAW FOR SO MANY PEOPLE TO HAVE THE SAME ISSUE..BTW MY VAN ONLY HAS 100.000 MILES ON IT I'VE SEEN SOME AS LOW AS 30.000 WITH THIS SAME ISSUE..NO EXCUSES FOR THIS..ANY KIND OF ELECTRONIC SHORT OUT HAS POTENTIAL FOR FIRE NOT TO MENTION THE HAZARDS OF THE VAN RANDOMLY STOPPING IN TOWN AT INTERSECTION ON THE INTERSTATE .
NHTSA ODI #10969516
130,000 miles · May 14, 2015
Electrical SystemFire
UPON RETURNING HOME AND PARKING MY VAN AFTER RUNNING AN ERRAND OF ABOUT 5 MILES, I SAW SMOKE COMING FROM THE ENGINE COMPARTMENT, RAN TO GET A FIRE EXTINGUISHER, THE FIRE WAS PUT OUT WITHIN 60 (SIXTY) SECONDS AFTER SEEING THE SMOKE. REMOVING THE AIR CLEANER AND OTHER COMPONENTS, -- THE WIRE HARNESS ON THE PASSENGER SIDE OF T…
Read full complaint
UPON RETURNING HOME AND PARKING MY VAN AFTER RUNNING AN ERRAND OF ABOUT 5 MILES, I SAW SMOKE COMING FROM THE ENGINE COMPARTMENT, RAN TO GET A FIRE EXTINGUISHER, THE FIRE WAS PUT OUT WITHIN 60 (SIXTY) SECONDS AFTER SEEING THE SMOKE. REMOVING THE AIR CLEANER AND OTHER COMPONENTS, -- THE WIRE HARNESS ON THE PASSENGER SIDE OF THE ENGINE COMPARTMENT WAS FOUND CHARRED BY THE FIRE. NO IMMEDIATE REASON WAS FOUND FOR THIS INCIDENT TO OCCUR.
NHTSA ODI #10716372
172,000 miles · Mar 19, 2015
Electrical SystemFire
CAUGHT ON FIRE WHILE PARKED AFTER DRIVING ENGINE WAS OFF . HISTORY OF OIL LEAKS. #15003607 VAN TOTALED AND SENT TO SALVAGE YARD. *TR
NHTSA ODI #10695433
150,000 miles · Dec 30, 2014
Electrical System
TL* THE CONTACT OWNS A 2004 KIA SEDONA. WHILE OPENING THE FRONT DRIVER SIDE EXTERIOR DOOR HANDLE, ALL FOUR DOORS ON THE VEHICLE LOCKED INDEPENDENTLY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000. UPDAT…
Read full complaint
TL* THE CONTACT OWNS A 2004 KIA SEDONA. WHILE OPENING THE FRONT DRIVER SIDE EXTERIOR DOOR HANDLE, ALL FOUR DOORS ON THE VEHICLE LOCKED INDEPENDENTLY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000. UPDATED 6/11/15*CN UPDATED 06/16/15*JB
NHTSA ODI #10669086
60,000 miles · Dec 26, 2014
Electrical SystemSteering
WHILE DRIVING IN WET CONDITIONS THE BRAKE AND BATTERY LIGHT WILL COME ON INSTRUMENT PANEL AND THERE IS A LOSS OF POWER OF STEERING. WHEN TAKEN TO KIA DEALERSHIP TO FIX PROBLEM THEY TOLD US IT IS A COMMON COMPLAINT AMONG KIA CARS. THEY CHECKED ALL BELTS, BATTERY AND ALTERNATOR ALL TESTS CAME BACK NORMAL. WHILE DRIVING IT IS DANGE…
Read full complaint
WHILE DRIVING IN WET CONDITIONS THE BRAKE AND BATTERY LIGHT WILL COME ON INSTRUMENT PANEL AND THERE IS A LOSS OF POWER OF STEERING. WHEN TAKEN TO KIA DEALERSHIP TO FIX PROBLEM THEY TOLD US IT IS A COMMON COMPLAINT AMONG KIA CARS. THEY CHECKED ALL BELTS, BATTERY AND ALTERNATOR ALL TESTS CAME BACK NORMAL. WHILE DRIVING IT IS DANGEROUS TO LOSE POWER OF STEERING ESPECIALLY IN WET CONDITIONS. *TR
NHTSA ODI #10668374
139,685 miles · Aug 14, 2014
Electrical SystemFire
WIRING UNDER SEAT SHORTED CAUSING SMALL FIRE INSIDE..EXTINGUISHED WIRING UNDER CAR IN SAME AREA MELTED SHORTING EVERY THING OUT. *TR
NHTSA ODI #10622317
Mileage unknown · Mar 4, 2013
Electrical SystemFuel/propulsion SystemSeats
VAN DOES NOT STAY STARTED. SENSOR CONTROL AND SHORT ON SEATS. *TR
NHTSA ODI #10501254
Mileage unknown · Mar 13, 2012
Electrical SystemEngine And Engine Cooling
CPSC#I1230221A. 2004 KIA SEDONA. CONSUMER STATED HE WAS HAVING DIFFICULTY IN STARTING THE VEHICLE DUE TO STALLING. THE VEHICLE WILL SHUT OFF WHILE IDLING AND WHILE DRIVING. LOSS OF POWER RESULTS IN DIFFICULTY IN STEERING THE VEHICLE. *LN THE CONSUMER STATED NONE OF THE REPAIRS, HAVE FIXED THE STALLING ISSUE.
NHTSA ODI #10452019
45,000 miles · Oct 28, 2009
Electrical System
KIA SEDONA 2004-VEHICLE WILL NOT SHUT OFF EVEN WHEN THE KEYS ARE REMOVED FROM THE IGNITION. THE CAR WILL DRIVE HOWEVER NO FUNCTIONS ON THE DASHBOARD WILL WORK, LIGHTS, WIPERS, RADIO, HEADLIGHTS ETC. THIS HAPPENED FOR ABOUT 1 WEEK IN JUNE 2009 AND HERE AND THERE THROUGHOUT THE SUMMER. I DID HAVE IT TOWED BACK TO THE DEALERSHI…
Read full complaint
KIA SEDONA 2004-VEHICLE WILL NOT SHUT OFF EVEN WHEN THE KEYS ARE REMOVED FROM THE IGNITION. THE CAR WILL DRIVE HOWEVER NO FUNCTIONS ON THE DASHBOARD WILL WORK, LIGHTS, WIPERS, RADIO, HEADLIGHTS ETC. THIS HAPPENED FOR ABOUT 1 WEEK IN JUNE 2009 AND HERE AND THERE THROUGHOUT THE SUMMER. I DID HAVE IT TOWED BACK TO THE DEALERSHIP BUT AT THE TIME THEY WERE UNABLE TO IDENTIFY THE PROBLEM AS IT HAD CORRECTED ITSELF. IT HAPPENED AGAIN THE WEEK OF OCTOBER 21ST. THE BATTERY HAD TO BE DISCONNECTED TO TURN THE VEHICLE OFF. THEY ARE STILL UNSURE OF WHAT IS CAUSING THE CAR TO REMAIN ON WITHOUT THE KEY IN THE IGNITION. *TR
NHTSA ODI #10290164
61,000 miles · Aug 12, 2008
Electrical SystemStructure
VEHICLE FLOORBOARD GOT HOT AND MELTED THE WIRING HARNESS UNDER CARPET. KIA DEALER FOUND NO CAUSE FOR THE EXCESSIVE HEAT BUT REPLACED THE WIRING AT MY EXPENSE. *TR
NHTSA ODI #10237828
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Illustration