ON FEB. 25, 2018, WE PURCHASED A 2003 KIA SEDONA VAN FROM CITY START AUTO SALES IN PARADISE, CA. ALL FOUR TIRES AND THE SPARE WERE GOODYEAR INTEGRITY 215/70R15. THE TIRES READ MAX. PSI 44, BUT THE VAN SAID TO RUN AT 35 PSI. SO, ONCE A WEEK ON A COOL MORNING (BETWEEN 68-75 DEGREES OUTSIDE WITHOUT IT HAVE BEEN DRIVEN), MY WIFE OR …
Read full complaint
ON FEB. 25, 2018, WE PURCHASED A 2003 KIA SEDONA VAN FROM CITY START AUTO SALES IN PARADISE, CA. ALL FOUR TIRES AND THE SPARE WERE GOODYEAR INTEGRITY 215/70R15. THE TIRES READ MAX. PSI 44, BUT THE VAN SAID TO RUN AT 35 PSI. SO, ONCE A WEEK ON A COOL MORNING (BETWEEN 68-75 DEGREES OUTSIDE WITHOUT IT HAVE BEEN DRIVEN), MY WIFE OR I WOULD MAKE SURE THE TIRES WERE 34-35 PSI. DURING THIS 3 MONTH PERIOD, WE NOTICED NOTHING WRONG WITH THE TIRES. ON MAY 31, 2018, I WAS DRIVING FROM MY HOUSE IN MAGALIA, CA TO CHICO, CA. JUST AS I STARTED TO MERGE ONTO HWY 99 IN CHICO, I HEARD A THUMPING SOUND, THEN A BANG--TWICE. I IMMEDIATELY PULLED OVER AND SAW 2 TIRES HAD COMPLETELY BLOWN OUT AND ONE WAS SERIOUSLY SHOWING THE METAL BELT. I HAD TO PAY TO GET A TOW TRUCK OUT AND IMMEDIATELY PURCHASE 4 NEW TIRES. WE'VE HAD A LITTLE WORK DONE ON THE REAR-LEFT FENDER CONTINUED TO HAVE WEIRD SOUNDS COMING FROM THE LEFT REAR WHERE THE WORST BLOW OUT HAPPENED. I JUST HAVEN'T HAD TIME TO TAKE IT IN YET. I KNOW IT WAS HOTTER IN CHICO THAN AT MY HOME, BUT IT WAS PROBABLY IN THE UPPER 80'S AT THAT TIME. I HAD NO WARNING AND IF IT HAPPENED WHEN I WAS ON THE FREEWAY, IT WOULD'VE BEEN A DISASTER. THE TIRE COMPANY SHOWED US THE SPARE, SAID WE COULD USE IT AS ONE FOR A SHORT TIME, BUT EVEN IT IS SHOWING SOMETHING WRONG TO THE TIRE GUY.
NHTSA ODI #11112219
43,000 miles · Dec 1, 2010
Tires
TL*THE CONTACT OWNS A 2003 KIA SEDONA EQUIPPED WITH BRIDGESTONE FIRESTONE FR380 TIRES, TIRE SIZE P215/70/R15. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH, AND THE FRONT END OF THE VEHICLE AND STEERING WHEEL BEGAN TO SHAKE. THE VEHICLE WAS TAKEN TO A TIRE CENTER WHERE THE FRONT DRIVER SIDE TIRE AND BOTH REAR TIRES WERE REPLACED.…
Read full complaint
TL*THE CONTACT OWNS A 2003 KIA SEDONA EQUIPPED WITH BRIDGESTONE FIRESTONE FR380 TIRES, TIRE SIZE P215/70/R15. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH, AND THE FRONT END OF THE VEHICLE AND STEERING WHEEL BEGAN TO SHAKE. THE VEHICLE WAS TAKEN TO A TIRE CENTER WHERE THE FRONT DRIVER SIDE TIRE AND BOTH REAR TIRES WERE REPLACED. THE TECHNICIAN STATED THAT THE TIRE TREAD EXHIBITED PREMATURE WEAR. THE SIMILAR FAILURE RECURRED ONE YEAR AND NINE MONTHS AFTER THE REPLACEMENT OF THE THREE TIRES. THE CONTACT PLANNED TO NOTIFY THE TIRE CENTER FOR THE VEHICLE TO BE INSPECTED AND TO DETERMINE WHICH TIRE WAS DEFECTIVE. THE FAILURE MILEAGE WAS APPROXIMATELY 43,000. THE DOT NUMBER WAS UNKNOWN.
NHTSA ODI #10368494
48,765 miles · Jun 11, 2007
Tires
TL*THE CONTACT OWNS A 2003 KIA SEDONA. THE TIRES ARE BIGO EURO TOUR TIRES, SIZE P212/70R15. WHILE DRIVING 60MPH, THE VEHICLE JERKED. IT APPEARED TO BE A FLAT TIRE; HOWEVER, THE TIRE FELL OFF OF THE VEHICLE AND ROLLED DOWN THE INTERSTATE. THE CONTACT WAS ABLE TO CONTROL THE VEHICLE AND IT WAS TOWED TO THE DEALER. THEY WERE UN…
Read full complaint
TL*THE CONTACT OWNS A 2003 KIA SEDONA. THE TIRES ARE BIGO EURO TOUR TIRES, SIZE P212/70R15. WHILE DRIVING 60MPH, THE VEHICLE JERKED. IT APPEARED TO BE A FLAT TIRE; HOWEVER, THE TIRE FELL OFF OF THE VEHICLE AND ROLLED DOWN THE INTERSTATE. THE CONTACT WAS ABLE TO CONTROL THE VEHICLE AND IT WAS TOWED TO THE DEALER. THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE CURRENT MILEAGE WAS 48946 AND THE FAILURE MILEAGE WAS 48765.
NHTSA ODI #10192902
34,000 miles · Aug 29, 2006
Engine And Engine CoolingLatches/locks/linkagesService Brakes, Hydraulic
CAR HAS BEEN HUGE HEADACHE BOUGHT NEW IN 2003 HAS BEEN TOWED TWICE FOR LEAKING COOLANT LINES THAT RUSTED OUT. LAST TIME WAS ON VACATION KIA HAS NOT RETURNED ON PHONE CALL OR E-MAIL AS IT COST ME 300 DOLLARS AND CAR IS UNDER BUMPER TO BUMPER WARRANTY HAS 34K MILES . DRIVERS DOOR HANDLE BROKE AND AIRBAG LIGHT WAS ON FIXED BY DEAL…
Read full complaint
CAR HAS BEEN HUGE HEADACHE BOUGHT NEW IN 2003 HAS BEEN TOWED TWICE FOR LEAKING COOLANT LINES THAT RUSTED OUT. LAST TIME WAS ON VACATION KIA HAS NOT RETURNED ON PHONE CALL OR E-MAIL AS IT COST ME 300 DOLLARS AND CAR IS UNDER BUMPER TO BUMPER WARRANTY HAS 34K MILES . DRIVERS DOOR HANDLE BROKE AND AIRBAG LIGHT WAS ON FIXED BY DEALER. ONE BRAKE PAD LINING FELL OFF AT 25K MILES REPLACED MYSELF. MOST IMPORTANT WE HAD A REAR TIRE BLOW OUT AT 60 MPH IN THREE LANES OF TRAFFIC. TIRE SHREDDED APART WITH 28K MILES AND WAS NEW YORK INSPECTED 2 MONTHS EARLIER. OTHER BACK TIRE BUBBLED OUT ON ONE SIDE AND MADE THE CAR SHUDDER. REPLACED TIRES MYSELF BUT PLEASE INVESTIGATE THIS CAR NOW I AM REALLY WORRIED AFTER READING ABOUT THE AIRBAGS NOT DEPLOYING. *JB
NHTSA ODI #10167006
Mileage unknown · Jan 21, 2005
Tires
2003 KIA SEDONA DRIVER FRONT DRIVER'S SIDE TIRE BLEW OUT TWICE IN THE LAST TWO YEARS.***NO ANSWER REQUIRED***. *MR
NHTSA ODI #10128029
Mileage unknown · Jan 20, 2005
Engine And Engine CoolingStructureSuspension
I'VE HAD A NUMBER OF PROBLEMS WITH MY 2003 KIA SEDONA. INITIALLY ONE OF THE GASKETS LEAKED AND HAD TO N BE REPLACED. THE WINDSHIELD CRACKED OVERNIGHT IN THE GARAGE WHEN THERE WAS NO WEATHER EXTREMES. THE WHEEL BEARINGS WENT IN THE FRONT TIRE. RECENTLY THE ENGINE HAD TO BE REPLACED BECAUSE IT WAS LEAKING AND AFTER REPLACING ALL …
Read full complaint
I'VE HAD A NUMBER OF PROBLEMS WITH MY 2003 KIA SEDONA. INITIALLY ONE OF THE GASKETS LEAKED AND HAD TO N BE REPLACED. THE WINDSHIELD CRACKED OVERNIGHT IN THE GARAGE WHEN THERE WAS NO WEATHER EXTREMES. THE WHEEL BEARINGS WENT IN THE FRONT TIRE. RECENTLY THE ENGINE HAD TO BE REPLACED BECAUSE IT WAS LEAKING AND AFTER REPLACING ALL THE GASKETS IT COULDN'T GET PRESSURE. THE DRIVER'S DOOR HANDLE BROKE, THE LUMBAR SUPPORT STOPPED WORKING. THE HOOD WOULDN'T CLOSE PROPERLY. AND ON TOP OF ALL THOSE THINGS I'VE HAD 2 BLOWOUTS TO THE FRONT DRIVER'S TIRE IN A 2 YEAR PERIOD. THE DEALER SAYS THERE IS NOTHING WRONG WITH THE WHEEL BUT I'M NOT SURE HE EVEN CHECKED BECAUSE OF THE ENGINE PROBLEMS HE HAD TO DEAL WITH. *JB
NHTSA ODI #10107637
3,000 miles · Mar 28, 2004
Tires
TIRE ON PASSENGER SIDE REAR HAD A PIN HOLE ON THE INSIDE OF THE SIDEWALL. SPOKE TO SOMEONE ELSE WHO HAD THE SAME VAN WHO HAD THE SAME PROBLEM. *JB
NHTSA ODI #10064055
Mileage unknown · Oct 24, 2003
Tires
MY TIRE RIPPED OFF THE RIM WHEN WE DRIVING ABOUT 60 MPH LIKE THE ONES DID FOR FIRESTONE AND IT DID DAMAGE TO MY VAN THE COMPANY DID NOT WANT TO FIX ANYTHING WELL WE LUCKY NO ONE GOT HURT. SO I TOOK IT TO THE DEALER AND THEY SAID THEY NEVER SEEN THIS HAPPEN I THINK YOU SHOULD LOOK AT THESE TIRES. *LA
NHTSA ODI #10043503
Mileage unknown · Oct 3, 2003
Tires
WHILE DRIVING 60 TO 65 MPH THE REAR RIGHT PASSENGER TIRE BLEW OUT. THE CONSUMER KNOWS HE DID NOT RUN OVER ANY OBJECT IN THE ROAD. THE MANUFACTURER OF THE TIRE WAS CONTACTED AND ASK THE CONSUMER TO SEND THE TIRE BACK FOR FURTHER CHECK UP. THE MANUFACTURER CALLED HIM BACK TO LET HIM KNOW THAT THE TIRE HAD BEEN CHECK AND INDICAT…
Read full complaint
WHILE DRIVING 60 TO 65 MPH THE REAR RIGHT PASSENGER TIRE BLEW OUT. THE CONSUMER KNOWS HE DID NOT RUN OVER ANY OBJECT IN THE ROAD. THE MANUFACTURER OF THE TIRE WAS CONTACTED AND ASK THE CONSUMER TO SEND THE TIRE BACK FOR FURTHER CHECK UP. THE MANUFACTURER CALLED HIM BACK TO LET HIM KNOW THAT THE TIRE HAD BEEN CHECK AND INDICATED THAT IT WAS A SIDE IMPACT. CONSUMER DOES NOT AGREE WITH THE FINDINGS. *NLM
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence & remedy
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence & remedy
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN MINI VANS, DURING ASSEMBLY, THE THROTTLE CABLE WOULD TWIST ITSELF OUT OF POSITION.
Consequence & remedy
Consequence: THIS CAN PERMIT THE CABLE TO BE HUNG UP, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE FREE OF CHARGE. VEHICLES PRODUCED FROM MARCH 20, 2001 THROUGH NOVEMBER 7, 2001 WILL HAVE A GUIDE CLIP INSTALLED ON THE THROTTLE BODY ASSEMBLY IN ORDER TO ENSURE THAT THE TENSION FORCE CABLE DOES NOT MOVE OUT OF POSITION. VEHICLES MANUFACTURED BEGINNING ON NOVEMBER 8, 2001, ALREADY HAVE THE EXTENDED GUIDE, WHICH ACCOMPLISHES THE SAME OBJECTIVE. THE RECALL BEGAN MARCH 21, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN PASSENGER VEHICLES, THERE WAS A PROGRAMMING ERROR IN THE ANTI-LOCK BRAKING SYSTEM (ABS) ELECTRONIC CONTROL MODULE LOGIC. THE PROGRAMMING ERROR COULD CAUSE REDUCED BRAKING FORCE AT SPEEDS BELOW 25 MPH, WHICH COULD RESULT IN INCREASED STOPPING DISTANCES.
Consequence & remedy
Consequence: SUCH INCREASED STOPPING DISTANCES COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPROGRAM THE CONTROL MODULE. OWNER NOTIFICATION BEGAN MAY 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE05035 · Electrical Fire
Opened Jun 28, 2005 · Closed Oct 19, 2005
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash
BY LETTER DATED OCTOBER 4, 2005, KIA NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO. 05V463) INVOLVING ALL MODEL YEAR (MY) 2002, 2003 KIA SEDONA EX VEHICLES AND CERTAIN MY 2004 KIA SEDONA EX VEHICLES.KIA?S RECALL COVERS 74,276 VEHICLES.KIA REPORTS THAT FIRES WERE CAUSED BY WIRING UNDER FRONT SEATS BEING MISROUTED; THIS ALLOWED THE WIRE TO BE PINCHED BY METAL SEAT COMPONENTS.OVER TIME, THE SHORT IN THE WIRING UNDER THE SEAT CAUSES OVERHEATING OF COMPONENTS IN THE FUSE BOX (LOCATED UNDER THE DRIVER SIDE INSTRUMENT PANEL).SPECIFICALLY, THE CIRCUIT BREAKER DIODES CYCLE ON-OFF-ON ETC. AND OVERHEAT.KIA WILL INSPECT VEHICLES FOR PROPER WIRE ROUTING AND INSTALL PROTECTIVE COVERING OVER CERTAIN METAL PARTS UNDER FRONT SEATS.DEALERS WILL ALSO APPLY A LABEL WARNING TECHNICIANS NOT TO REMOVE THE CIRCUIT BREAKER DIODES WHICH CANNOT BE SERVICED BUT CAN BE DAMAGED BY REMOVAL ATTEMPTS.BASED ON KIA?S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
2003 Kia Sedona Problems, Complaints & Recalls | Skip That Year
Illustration