IllustrationGOT INTO VAN TODAY TO DRIVE IT AND THE BACK OF THE SEAT BROKE FROM THE BOTTOM OF THE SEAT. *TR
2002 Kia Sedona
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Kia Sedona do not stand out strongly from the model-year median of 120.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sedona years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
310–25K
2225–50K
2750–75K
1475–100K
8100–150K
7150K+
109 reports with mileage · 89 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports13 fire reports11 injury reports
What owners actually said
198 reportsDOOR HANDLES, PASSENGERS AND DRIVER, FRONT AND BACK. HANDLES IN THE FRONT HAVE BOTH BEEN REPLACED ONCE, AND THE NEW ONES ARE NOW DEFECTIVE AND WILL NOT OPEN FROM THE INSIDE. REAR PASSENGER DOOR HANDLES ARE BROKEN ON THE OUTSIDE. IF THE VEHICLE WAS IN AN ACCIDENT AND NEEDED TO BE EXITED QUICKLY, OR ENTERED QUICKLY, THIS POSES …
Read full complaint
DOOR HANDLES, PASSENGERS AND DRIVER, FRONT AND BACK. HANDLES IN THE FRONT HAVE BOTH BEEN REPLACED ONCE, AND THE NEW ONES ARE NOW DEFECTIVE AND WILL NOT OPEN FROM THE INSIDE. REAR PASSENGER DOOR HANDLES ARE BROKEN ON THE OUTSIDE. IF THE VEHICLE WAS IN AN ACCIDENT AND NEEDED TO BE EXITED QUICKLY, OR ENTERED QUICKLY, THIS POSES A SAFETY PROBLEM. *TR
TL*THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT HEARD AN UNFAMILIAR NOISE AND THE INSTRUMENT PANEL CAUGHT FIRE WHILE THE VEHICLE WAS PARKED. THE CAUSE OF THE FAILURE WAS ELECTRICAL. THE INSURANCE COMPANY WAS NOTIFIED. THE VEHICLE IS CURRENTLY PARKED IN HIS DRIVEWAY. THE CURRENT AND FAILURE MILEAGES WERE 61,000.
THERE WAS NO EVENTS LEADING UP TO THE FAILURE, I WAS PULL ON TO THE ROAD AND LOST COMPLETE CONTROL OF MY STEERING, MY STEERING WHEEL JUST KEPT GOING AROUND AND AROUND, COMPLETE STEERING FAILURE. I HAVE NOT DONE ANYTHING YET TO FIX... *TR
2002 KIA SEDONA WITH STEERING FAILURE. CONSUMER STATES THAT MECHANIC TOLD HER THAT A BOLT FELL OUT AND COULD NOT BE REPLACED UNLESS THE ENTIRE STEERING SHAFT WAS REPLACED. CONSUMER STATES THAT WASN'T THE FIRST TIME THE STEERING HAS HAD PROBLEMS. *KB THE CONSUMER STATED DURING THE FIRST YEAR OF OWNING THE VEHICLE, THE TRANSMISS…
Read full complaint
2002 KIA SEDONA WITH STEERING FAILURE. CONSUMER STATES THAT MECHANIC TOLD HER THAT A BOLT FELL OUT AND COULD NOT BE REPLACED UNLESS THE ENTIRE STEERING SHAFT WAS REPLACED. CONSUMER STATES THAT WASN'T THE FIRST TIME THE STEERING HAS HAD PROBLEMS. *KB THE CONSUMER STATED DURING THE FIRST YEAR OF OWNING THE VEHICLE, THE TRANSMISSION FAILED ,THE DRIVERS SEAT MOTOR HAD TO BE REPLACED SEVERAL TIMES AND THE FUSE THAT CONTROLLED THE DASHBOARD LIGHTS MALFUNCTIONED ON A CONTINUOUS BASIS. *JB
TL*THE CONTACT OWNS A 2002 KIA SEDONA. THE VEHICLE HAD BEEN PARKED FOR APPROXIMATELY 8-10 HOURS WHEN IT SUDDENLY CAUGHT FIRE. THE WIRING FUSE BOX CAUSED THE ENGINE, RADIO, AND WIPER/WASHER TO ACTIVATE. THE FIRE ORIGINATED IN THE INSTRUMENT PANEL. THE CONTACT WAS ABLE TO DOUSE THE FIRE WITH A FIRE EXTINGUISHER. THE VEHICLE W…
Read full complaint
TL*THE CONTACT OWNS A 2002 KIA SEDONA. THE VEHICLE HAD BEEN PARKED FOR APPROXIMATELY 8-10 HOURS WHEN IT SUDDENLY CAUGHT FIRE. THE WIRING FUSE BOX CAUSED THE ENGINE, RADIO, AND WIPER/WASHER TO ACTIVATE. THE FIRE ORIGINATED IN THE INSTRUMENT PANEL. THE CONTACT WAS ABLE TO DOUSE THE FIRE WITH A FIRE EXTINGUISHER. THE VEHICLE WAS LATER TOWED TO A DEALER AND THEY DID NOT PROVIDE A REASON AS TO WHY IT CAUGHT FIRE. THE CONTACT FOUND NUMEROUS COMPLAINTS ON THE SAME TYPE OF VEHICLE WITH IDENTICAL FAILURES. THE CURRENT AND FAILURE MILEAGES WERE 72,000. UPDATED 03/06/08. *LJ THE CONSUMER STATED THE RECALL WAS DONE, HOWEVER EVER SINCE THE REPAIR, THE SEATS NEVER WORKED CORRECTLY. THE CONSUMER HAD WORKED DONE ON THE AIR CONDITIONER. UPDATED
SINCE PURCHASING A SEDONA VAN IN '02 WE HAVE HAD NONE STOP ELECTRICAL ISSUES. THE BATTERY HAS BEEN REPLACED AT LEAST TWICE, SAME FOR THE ALTERNATOR, AND MOST RECENTLY THE CAR CAUGHT FIRE BEHIND THE PANEL NEST TO THE PARKING BRAKE PEDAL. MY WIFE DROVE THE CAR AT 1:00PM TO THE STORE AND THEN CAME HOME, PARKED IN THE DRIVEWAY…
Read full complaint
SINCE PURCHASING A SEDONA VAN IN '02 WE HAVE HAD NONE STOP ELECTRICAL ISSUES. THE BATTERY HAS BEEN REPLACED AT LEAST TWICE, SAME FOR THE ALTERNATOR, AND MOST RECENTLY THE CAR CAUGHT FIRE BEHIND THE PANEL NEST TO THE PARKING BRAKE PEDAL. MY WIFE DROVE THE CAR AT 1:00PM TO THE STORE AND THEN CAME HOME, PARKED IN THE DRIVEWAY, AND LOCKED THE DOORS. AT 10:00PM WE WERE AWAKEN BY A NEIGHBOR WHO TOLD US THAT THE CAR WAS RUNNING, THE WIPERS RUNNING, AND THE INTERIOR FILLING WITH SMOKE. I UNLOCKED THE DOORS AND USED THE EXTINGUISHER TO STOP THE FIRE. THANKFULLY SHE DID NOT PARK IN THE GARAGE OR OUR HOUSE WOULD PROBABLY HAVE CAUGHT FIRE. *TR MM
2002 KIA SEDONA ABS LIGHT ILLUMINATED. MECHANIC DETERMINED THAT THE ABS CONTROL MODULE NEEDED TO BE REPROGRAMMED. CONSUMER VEHICLE WAS NOT INVOLVED IN THE RECALL. MECHANIC WAS UNABLE TO REPAIR THE CONSUMER'S VEHICLE. *KB THE MECHANIC WAS NOT ABLE TO REPAIR THE VEHICLE, BECAUSE KIA WOULD NOT RELEASE COMPUTER INFORMATION FOR THE…
Read full complaint
2002 KIA SEDONA ABS LIGHT ILLUMINATED. MECHANIC DETERMINED THAT THE ABS CONTROL MODULE NEEDED TO BE REPROGRAMMED. CONSUMER VEHICLE WAS NOT INVOLVED IN THE RECALL. MECHANIC WAS UNABLE TO REPAIR THE CONSUMER'S VEHICLE. *KB THE MECHANIC WAS NOT ABLE TO REPAIR THE VEHICLE, BECAUSE KIA WOULD NOT RELEASE COMPUTER INFORMATION FOR THE NECESSARY DIAGNOSTICS. THE CONSUMER CALLED SEVERAL OTHER DEALERSHIP AND THEY WERE NOT VERY ACCOMDATING. THE HEADLIGHTS FAILED TWICE. THE BATTERY AND BELTS HAD TO BE REPLACED AND THE AC WAS RUNNING LOW. THE CONSUMER BELIEVED THERE MAY BE SOME TYPE OF PROBLEM WITH THE ALTERNATOR. *JB
TL*THE CONTACT OWNS A 2002 KIA SEDONA. WHEN THE CONTACT STARTED THE VEHICLE, THE DRIVER SIDE SEAT BELT BEGAN SMOKING. THE SEAT BELT THEN CAUGHT FIRE WHEN IT CAME IN CONTACT WITH THE WIRES ATTACHED TO THE SEAT BELT CONNECTOR AND A PIECE OF HARD PLASTIC AROUND THE BOTTOM OF THE SEAT (SEAT GUARD). THE CONTACT EXTINGUISHED THE FI…
Read full complaint
TL*THE CONTACT OWNS A 2002 KIA SEDONA. WHEN THE CONTACT STARTED THE VEHICLE, THE DRIVER SIDE SEAT BELT BEGAN SMOKING. THE SEAT BELT THEN CAUGHT FIRE WHEN IT CAME IN CONTACT WITH THE WIRES ATTACHED TO THE SEAT BELT CONNECTOR AND A PIECE OF HARD PLASTIC AROUND THE BOTTOM OF THE SEAT (SEAT GUARD). THE CONTACT EXTINGUISHED THE FIRE. KIA STATED THAT A RECALL REPAIR HAD BEEN PERFORMED ON THE VEHICLE IN APRIL OF 2006 AND THAT SHE WOULD BE RESPONSIBLE FOR ANY CURRENT REPAIRS. THE SEAT BELT AREA OF THE VEHICLE WAS DAMAGED. THE VEHICLE HAS NOT BEEN INSPECTED BY THE DEALER OR A MECHANIC. THE CONTACT ALSO STATED THAT THE PASSENGER SIDE DOOR HANDLE FAILED AND A NEW ONE HAD BEEN ORDERED BEFORE THE FIRE OCCURRED. THE CURRENT AND FAILURE MILEAGES WERE 77,600.
TL*THE CONTACT OWNS A 2002 KIA SEDONA. WHILE DRIVING LESS THAN 25 MPH, THE CONTACT NOTICED THAT THE AIR BAG LIGHT WAS ILLUMINATED. THE DEALER STATED THAT THE SEAT BELT SENSOR FAILED AND CAUSED THE AIR BAG LIGHT TO ILLUMINATE. NO REPAIRS HAVE BEEN MADE AS OF YET. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE …
Read full complaint
TL*THE CONTACT OWNS A 2002 KIA SEDONA. WHILE DRIVING LESS THAN 25 MPH, THE CONTACT NOTICED THAT THE AIR BAG LIGHT WAS ILLUMINATED. THE DEALER STATED THAT THE SEAT BELT SENSOR FAILED AND CAUSED THE AIR BAG LIGHT TO ILLUMINATE. NO REPAIRS HAVE BEEN MADE AS OF YET. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 84,000. UPDATED 09/19/TR *TR
Official recalls
305V013000 · Vehicle Speed Control:cables
Jan 19, 2005
ON CERTAIN MINI VANS, DURING ASSEMBLY, THE THROTTLE CABLE WOULD TWIST ITSELF OUT OF POSITION.
Consequence & remedy
Consequence: THIS CAN PERMIT THE CABLE TO BE HUNG UP, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE FREE OF CHARGE. VEHICLES PRODUCED FROM MARCH 20, 2001 THROUGH NOVEMBER 7, 2001 WILL HAVE A GUIDE CLIP INSTALLED ON THE THROTTLE BODY ASSEMBLY IN ORDER TO ENSURE THAT THE TENSION FORCE CABLE DOES NOT MOVE OUT OF POSITION. VEHICLES MANUFACTURED BEGINNING ON NOVEMBER 8, 2001, ALREADY HAVE THE EXTENDED GUIDE, WHICH ACCOMPLISHES THE SAME OBJECTIVE. THE RECALL BEGAN MARCH 21, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
03V135000 · Seats:mid/rear Assembly
Apr 3, 2003
ON CERTAIN PASSENGER VEHICLES, SOME OF THE SECOND AND THIRD ROW SEAT STRIKERS INSTALLED ON THE VEHICLE FLOOR PAN HAVE BEEN IMPROPERLY HEAT TREATED AND COULD BREAK IN A CRASH.
Consequence & remedy
Consequence: THIS COULD RESULT IN INJURIES TO OCCUPANTS OF THESE SEATS.
Remedy: DEALERS WILL REPLACE THE SEAT STRIKERS. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542
03V017000 · Seat Belts:rear/other
Jan 22, 2003
CERTAIN MINI VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE SECOND AND THIRD SEAT BELT BUCKLE ANCHOR BOLTS DO NOT COMPLY WITH THE STANDARDS.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE ANCHOR BOLTS. OWNER NOTIFICATION BEGAN FEBRUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.