NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
198 reports92,000 miles · Mar 18, 2014
Air BagsCrashInjury
TL* THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH AND CRASHED INTO THE REAR ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUFFERED HEAD, NECK AND BACK INJURIES. THE VEHICLE WAS DESTROYED AND A POLICE REPORT WAS FILED AT THE SCENE. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE…
Read full complaint
TL* THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH AND CRASHED INTO THE REAR ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUFFERED HEAD, NECK AND BACK INJURIES. THE VEHICLE WAS DESTROYED AND A POLICE REPORT WAS FILED AT THE SCENE. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS 92,000.
NHTSA ODI #10573181
130,500 miles · Feb 21, 2014
Electrical SystemEngineFire
THE CAR WAS PARKED IN FRONT OF THE HOUSE. A NEIGHBOR KNOCKED ON THE DOOR AND TOLD US THAT THE KIA WAS ON FIRE. NO ONE WAS IN THE CAR AT THAT TIME. THE ENGINE COMPARTMENT WAS TOTALLY BURNED UP. THE CAR GAVE ME NO OTHER PROBLEMS. *TR
NHTSA ODI #10565372
187,376 miles · Nov 23, 2013
Air BagsCrash
DRIVING HOME AND A DEER JUMPED OUT IN FRONT OF MY VAN AND I HIT THE DEER AND TOTALED MY VAN BAD WHERE THE AIR BAGS SHOULD OF WENT OFF BUT IT DIDN'T NOW THERE'S A LIGHT ON THE DASH THAT LOOKS LIKE A GUY SITTING IN A SEAT WITH A BELT ON AND AN AIR BAG IN FRONT OF IT.
NHTSA ODI #10553509
69,500 miles · Aug 30, 2013
Electrical SystemSteeringFire
I DROVE 25 MINUTES FROM A TO B AND PARKED MY CAR. TURNED THE ENGINE OFF SAT THERE WITH THE RADIO ON FOR 1 MINUTE EXACTLY AND I HEAR A. PSHHHHH AND SMOKE RISING QUICKLY, THEN A FLAME FROM THE FUSE BOX BY MY LEFT FOOT. I GOT OUT OPENED THE DOOR LOOKED FOR THE SMOKE AND FLAME THAT WERE REFLECTING AND WAVING. I OPENED THE FUSE BOX S…
Read full complaint
I DROVE 25 MINUTES FROM A TO B AND PARKED MY CAR. TURNED THE ENGINE OFF SAT THERE WITH THE RADIO ON FOR 1 MINUTE EXACTLY AND I HEAR A. PSHHHHH AND SMOKE RISING QUICKLY, THEN A FLAME FROM THE FUSE BOX BY MY LEFT FOOT. I GOT OUT OPENED THE DOOR LOOKED FOR THE SMOKE AND FLAME THAT WERE REFLECTING AND WAVING. I OPENED THE FUSE BOX SLIDER COVER WITH A KNIFE AND STARTED TO SQUIRT WATER OUT FROM MY BOTTLED WATER QUICKLY. THANK GOODNESS I HAD WATER. FLAME WENT OUT AND I SAW THE INSIDE OF THE FUSE COVER BURNT, AND A FUSE LOOKED LIKE IT CAUGHT ON FIRE BECAUSE THE FUSE LOOKED COMPLETELY MELTED.I HAVE A VIDEO OF THE AFTERMATH RIGHT AFTER THE FIRE WENT OUT. TOMORROW ILL BE CALLING INSURANCE, KIA, AND WHOEVER ELSE THAT CAN HELP ME UNDERSTAND WHAT IS GOING ON AND WHAT I CAN DO TO ENSURE MY SAFETY. PLEASE HELP OR APPROVE A RECALL. THANK GOODNESS I DIDNT EXIT MY CAR SO QUICK OR ALOT OF THE CAR WOULD HAVE BEEN ON FIRE.
NHTSA ODI #10538031
163,000 miles · Aug 28, 2013
Exterior LightingInterior Lighting
THE HEADLIGHTS KEEPS BLOWING. HAVE REPLACED 3 TIMES. ALL THE LIGHT ON THE INSIDE KEEPS COMING ON (BATTERY, CHECK ENGINE LIGHT, SEAT BELT LIGHT; BELL RINGS). HAD ALTERNATOR CHECKED AND IT IS FINE. THE FUSES ARE FINE. THERE IS DEFECT WITH THIS VEHICLE, I SAW OTHERS WITH THE SAME COMPLAINT, EVEN ON NEWER MODELS. THE COMPANY NE…
Read full complaint
THE HEADLIGHTS KEEPS BLOWING. HAVE REPLACED 3 TIMES. ALL THE LIGHT ON THE INSIDE KEEPS COMING ON (BATTERY, CHECK ENGINE LIGHT, SEAT BELT LIGHT; BELL RINGS). HAD ALTERNATOR CHECKED AND IT IS FINE. THE FUSES ARE FINE. THERE IS DEFECT WITH THIS VEHICLE, I SAW OTHERS WITH THE SAME COMPLAINT, EVEN ON NEWER MODELS. THE COMPANY NEEDS TO FIX THIS. CAN'T DRIVE THE VEHICLE AT NIGHT. AND THE LIGHT REPLACEMENT IS EXPENSIVE. THERE IS A SHAKING AND RUMBLING SOUND COMING FROM VEHICLE. HAVE HAD ENGINE PROBLEMS, HAVE HAD PROBLEMS EVERY SINCE I THIS VEHICLE. ITS BEEN AT THE SHOP MORE THAN ON THE ROAD. HAD I KNOW THAT THE VEHICLE HAD SO MANY ISSUES, I WOULD HAVE NEVER PURCHASED IT. *TT
NHTSA ODI #10537811
139,582 miles · Mar 4, 2013
Steering
I TOOK THE VAN TO THE MECHANIC ABOUT A MONTH AGO. THEY TOLD ME IT NEEDED A STEERING COUPLER AND A FLANGE. THE STEERING WHEEL WAS VERY LOOSE WHEN DRIVING AND WOULD MAKE A CREAKING SOUND. *TR
NHTSA ODI #10501184
105,000 miles · Feb 13, 2013
Engine
TL* THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, SHE HEARD A KNOCKING NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS INSPECTED AND IT WAS DETERMINED THAT THE THREADS FOR THE CRANK SHAFT BOLT WERE MISSING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFOR…
Read full complaint
TL* THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, SHE HEARD A KNOCKING NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS INSPECTED AND IT WAS DETERMINED THAT THE THREADS FOR THE CRANK SHAFT BOLT WERE MISSING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE BALANCER AND BOLT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 105,500.
NHTSA ODI #10498010
90,000 miles · Nov 9, 2012
Air BagsSeat Belts
AIRBAG LIGHT WAS ILLUMINATING INTERMITTENTLY - TOOK TO DEALERSHIP FOR DIAGNOSTIC IN 2010. KIA DEALERSHIP IN TURNERSVILLE SAID THAT LIGHT ILLUMINATING WAS NORMAL AND NO ISSUE. I RECENTLY HAD TIMING CHAIN REPLACED BY SAME DEALERSHIP - DIFFERENT TECH. THIS TIME THEY SAID THAT THE LIGHT MEANT THE AIRBAGS WOULD NOT DEPLOY IN AN ACCID…
Read full complaint
AIRBAG LIGHT WAS ILLUMINATING INTERMITTENTLY - TOOK TO DEALERSHIP FOR DIAGNOSTIC IN 2010. KIA DEALERSHIP IN TURNERSVILLE SAID THAT LIGHT ILLUMINATING WAS NORMAL AND NO ISSUE. I RECENTLY HAD TIMING CHAIN REPLACED BY SAME DEALERSHIP - DIFFERENT TECH. THIS TIME THEY SAID THAT THE LIGHT MEANT THE AIRBAGS WOULD NOT DEPLOY IN AN ACCIDENT! THEY SAID REPAIRS WOULD NOT BE COVERED! I AM FURIOUS. *TR
NHTSA ODI #10483838
62,000 miles · Aug 16, 2012
Electrical SystemStructure
TL* THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT STATED THAT THE AIR CONDITIONING UNIT FAILED AND WAS BLOWING WARM AIR. THE VEHICLE WAS TAKEN TO THE DEALER AND AN INSPECTION WAS PERFORMED, WHICH DETERMINED THAT THE CONDENSER WAS LEAKING. THE DEALER ALSO FOUND THAT THE VEHICLE PASSENGER SIDE OF THE SUB FRAME WAS CORRODED WITH …
Read full complaint
TL* THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT STATED THAT THE AIR CONDITIONING UNIT FAILED AND WAS BLOWING WARM AIR. THE VEHICLE WAS TAKEN TO THE DEALER AND AN INSPECTION WAS PERFORMED, WHICH DETERMINED THAT THE CONDENSER WAS LEAKING. THE DEALER ALSO FOUND THAT THE VEHICLE PASSENGER SIDE OF THE SUB FRAME WAS CORRODED WITH ONLY TWO INCHES OF METAL LEFT SUPPORTING THE ENGINE. THE CORROSION ALSO SPREAD TO THE DRIVER'S SIDE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DENIED ASSISTANCE WITH THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 62,000.
NHTSA ODI #10471149
194,231 miles · Jun 17, 2012
Power Train
FAILURE OF AUTOMATIC TRANSMISSION TO ENGAGE IN REVERSE. *TR
NHTSA ODI #10461986
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Illustration