IllustrationCONSUMER COMPLAINS OF A LOUD WHISLTE WHEN DRIVING OVER 40 MPH. THE FACTORY REP TEST DROVE THE VEHICLE AND DETERMINED IT TO BE THE ROOF RACK. THEIR SOLUTION WAS POSSIBLY A REDESIGN OF THE CROSS MEMBERS. NOTHING HAS BEEN DONE. *JG
2002 Kia Sedona
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Kia Sedona do not stand out strongly from the model-year median of 120.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sedona years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
310–25K
2225–50K
2750–75K
1475–100K
8100–150K
7150K+
109 reports with mileage · 89 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports13 fire reports11 injury reports
What owners actually said
198 reportsCONSUMER STATES THAT DURING A VEHICLE ACCIDENT THE FRONT SEAT BELTS BUCKLES WILL NOT LATCH PROPERLY CAUSING INJURIES TO THE CONSUMER. DEALER NOTIFIED. MR
THE BRAKE PEDAL PLACEMENT MAKES IT EASY TO SIMULTANEOUSLY PRESS BOTH THE BRAKE AND ACCELERATOR PEDAL WHEN ATTEMPTING TO STOP THE VEHICLE. ON ONE OCCASION THE VEHICLE CRASHED INTO THE WALL OF THE CONSUMER'S GARAGE. THE DEALER HAS BEEN NOTIFIED. *TS *NLM
WHEN APPLYING THE BRAKE CONSUMER SIMULTANEOUS APPLIED ACCELERATOR PEDAL. DEALER HAS BEEN NOTIFIED PLEASE PROVIDE FURTHER INFORMATION. TS
THIS STARTED AS A SLIGHT KNOCK & WITHIN 5 MINUTES THE ENGINE WAS SCREAMING LOUD KNOCKING BANGING CLANKING ETC. TOTAL LOSS OF POWER, AND SLIPPING OF GEARS ON TOP OF WHAT SOUNDING LIKE THE ENGINE FALLING APART. THEY TOOK A MONTH TO REPLACE THE ENGINE NOW I HAVE HAD NUMEROUS SPEEDOMETER, CHECK ENGINE, ODOMETER & CHECK ENGINE FAILUR…
Read full complaint
THIS STARTED AS A SLIGHT KNOCK & WITHIN 5 MINUTES THE ENGINE WAS SCREAMING LOUD KNOCKING BANGING CLANKING ETC. TOTAL LOSS OF POWER, AND SLIPPING OF GEARS ON TOP OF WHAT SOUNDING LIKE THE ENGINE FALLING APART. THEY TOOK A MONTH TO REPLACE THE ENGINE NOW I HAVE HAD NUMEROUS SPEEDOMETER, CHECK ENGINE, ODOMETER & CHECK ENGINE FAILURES/MALFUNCTIONS. DT
THE CONSUMER STATES THAT THE VEHICLE STALLS. ON ONE OCCASION THE VEHICLE WAS MOVED IN THE STREET WITH TRAFFIC FLOW, AND THE VEHICLE SHUT DOWN. A VEHICLE HAD CONTINUED MOVING AND SLIGHTLY SCRAPED THE REAR OF THE CONSUMER'S VEHICLE. THE ENGINE LIGHT HAD COME ON. THE VEHICLE WAS TAKEN TO A SHOP FOR REPAIRS AND AFTER INSTALLING …
Read full complaint
THE CONSUMER STATES THAT THE VEHICLE STALLS. ON ONE OCCASION THE VEHICLE WAS MOVED IN THE STREET WITH TRAFFIC FLOW, AND THE VEHICLE SHUT DOWN. A VEHICLE HAD CONTINUED MOVING AND SLIGHTLY SCRAPED THE REAR OF THE CONSUMER'S VEHICLE. THE ENGINE LIGHT HAD COME ON. THE VEHICLE WAS TAKEN TO A SHOP FOR REPAIRS AND AFTER INSTALLING A NEW BATTERY, THE ALTERNATOR DOESN'T CRANK. *SCC
OUR SEDONA HAS BEEN PULLING SINCE WE FIRST BOUGHT IT. FIRST TO THE LEFT, THEN TO THE RIGHT, THEN NOTHING, NO PULL. BEEN ALIGNED TWICE. ALSO BEEN TOLD I TAKE MY HANDS OFF UNEVENLY WHICH CAUSES TO PULL, ALSO THAT I DON'T KNOW HOW TO KEEP CORRECT TIRE PRESSURE IN. THE CAR PULLS HEAVILY. ONE WAY OR THE OTHER. SCARED TO DRIVE. ALSO B…
Read full complaint
OUR SEDONA HAS BEEN PULLING SINCE WE FIRST BOUGHT IT. FIRST TO THE LEFT, THEN TO THE RIGHT, THEN NOTHING, NO PULL. BEEN ALIGNED TWICE. ALSO BEEN TOLD I TAKE MY HANDS OFF UNEVENLY WHICH CAUSES TO PULL, ALSO THAT I DON'T KNOW HOW TO KEEP CORRECT TIRE PRESSURE IN. THE CAR PULLS HEAVILY. ONE WAY OR THE OTHER. SCARED TO DRIVE. ALSO BRAKES VIBRATE CAR BADLY WHEN BRAKING FROM HIGH TO LOW SPEED ESPECIALLY ON A DOWNHILL. HAVE CONTACTED THE BBB AUTO LINE. I BELIEVE THE CAR IS EXTREMELY UNSAFE AND I CAN NOT STAND DRIVING THIS THING. IT IS A TWO HOUR DRIVE TO MY KIA DEALER AND I HAVE BEEN THERE A LOT. **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT OVER TO ARTEMIS**768313
EVER SINCE I'VE OWNED THE KIA SEDONA I HAVE NOT BEEN ABLE TO FILL THE GAS TANK WITHOUT FUEL SPITTING BACK OUT AT ME FROM THE FILLER TUBE. I'M NOT TOPPING OFF THE TANK, I'M EITHER FILLING IT BY HOLDING THE FUEL NOZZLE WITH MY HAND OR USING THE LITTLE CATCH TO HOLD THE FUEL NOZZLE OPEN. THE VAN HAD A VALVE REPLACED BY THE DEALE…
Read full complaint
EVER SINCE I'VE OWNED THE KIA SEDONA I HAVE NOT BEEN ABLE TO FILL THE GAS TANK WITHOUT FUEL SPITTING BACK OUT AT ME FROM THE FILLER TUBE. I'M NOT TOPPING OFF THE TANK, I'M EITHER FILLING IT BY HOLDING THE FUEL NOZZLE WITH MY HAND OR USING THE LITTLE CATCH TO HOLD THE FUEL NOZZLE OPEN. THE VAN HAD A VALVE REPLACED BY THE DEALER IN THE FILLER TUBE BUT THIS DID NOT FIX THE PROBLEM. AFTER A THIRD TRY TO GET THE PROBLEM FIXED AT A DIFFERANT KIA DEALER THE SERVICE ADVISOR HAD ME CALL THE KIA HOTLINE AT 1800-333-4542 AND I WAS TOLD THE SAME THING THAT THE SERVICE ADVISOR HIMSELF HAD BEEN TOLD BY KIA, THAT THIS PROBLEM WAS NORMAL FOR THE SEDONA AND HERE IS WHY ACCORDING TO KIA, THE FILLER TUBE FEEDS GAS INTO THE TANK AT THE BOTTOM OF THE TANK THEREFORE BUILDING UP PRESSURE INSIDE THE GAS TANK AS IT IS BEING FILLED. THE SOLUTION: FILL THE TANK UP VERY SLOWLY AS TO NOT BUILD UP PRESSURE INSIDE THE TANK WHILE FILLING. I'VE OWNED A FEW CARS AND NEVER HAD TO WORRY ABOUT FILLING UP THE TANKS FAST OR SLOW, PUT THE NOZZLE IN THE TANK PUMP THE GAS THE NOZZLE SHUTS OFF WHEN IT'S FULL YOU PAY AND HAVE A NICE DAY. ANY HELP OR ASSISTANCE IS GREATLY APPRECIATED, I FEEL THIS IS A SAFETY/DESIGN ISSUE AND WOULD VERY MUCH LIKE TO GET THE PROBLEM FIXED OR BUY A SAFER VAN. MY REFERANCE NUMBER THROUGH KIA IF IT WILL HELP IS 110625. MR
CONSUMER STATES THAT THE VEHICLE HAVE STALLED ON THREE OCCASIONS. VEHICLE TAKEN TO THE DEALER. DEALER INFORMED THAT THE ALTERNATOR WAS OVERHEATING AND CAUSING THE VEHICLE TO STALL. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. *MR
SEAT BELT BUCKLE IS NOT LOCKING SEAT BELTS IN PLACE. CONTACTED DEAL AND DEALER WAS AWARE OF THE PROBLEM.AK
Official recalls
305V013000 · Vehicle Speed Control:cables
Jan 19, 2005
ON CERTAIN MINI VANS, DURING ASSEMBLY, THE THROTTLE CABLE WOULD TWIST ITSELF OUT OF POSITION.
Consequence & remedy
Consequence: THIS CAN PERMIT THE CABLE TO BE HUNG UP, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE FREE OF CHARGE. VEHICLES PRODUCED FROM MARCH 20, 2001 THROUGH NOVEMBER 7, 2001 WILL HAVE A GUIDE CLIP INSTALLED ON THE THROTTLE BODY ASSEMBLY IN ORDER TO ENSURE THAT THE TENSION FORCE CABLE DOES NOT MOVE OUT OF POSITION. VEHICLES MANUFACTURED BEGINNING ON NOVEMBER 8, 2001, ALREADY HAVE THE EXTENDED GUIDE, WHICH ACCOMPLISHES THE SAME OBJECTIVE. THE RECALL BEGAN MARCH 21, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
03V135000 · Seats:mid/rear Assembly
Apr 3, 2003
ON CERTAIN PASSENGER VEHICLES, SOME OF THE SECOND AND THIRD ROW SEAT STRIKERS INSTALLED ON THE VEHICLE FLOOR PAN HAVE BEEN IMPROPERLY HEAT TREATED AND COULD BREAK IN A CRASH.
Consequence & remedy
Consequence: THIS COULD RESULT IN INJURIES TO OCCUPANTS OF THESE SEATS.
Remedy: DEALERS WILL REPLACE THE SEAT STRIKERS. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542
03V017000 · Seat Belts:rear/other
Jan 22, 2003
CERTAIN MINI VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE SECOND AND THIRD SEAT BELT BUCKLE ANCHOR BOLTS DO NOT COMPLY WITH THE STANDARDS.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE ANCHOR BOLTS. OWNER NOTIFICATION BEGAN FEBRUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.