IllustrationDRIVING ON INTERSTATE AND VEHICLE SUDDENLY FELT LIKE SOMEONE SLAMMED ON THE BRAKES AND SLOWED THE VEHICLE FROM 65 MPH TO 35MPH RIGHT AWAY. THIS PROBLEM HAS HAPPENED 5 TIMES, 5/21/03, 5/23/03, 5/24/03, 5/27/03, 5/28/03. VEHICLE HAS BEEN TO DEALER SERVICE DEPT. 5/21/03, 5/23/03, 5/27/03, 5/28/03.
2002 Kia Sedona
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Kia Sedona do not stand out strongly from the model-year median of 120.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sedona years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
310–25K
2225–50K
2750–75K
1475–100K
8100–150K
7150K+
109 reports with mileage · 89 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports13 fire reports11 injury reports
What owners actually said
198 reportsFALLAS SISTEMA AIRE ACONDICIONADO DESDE 8-28-2002, TODAVIA SIGUE DANDIO PROBLEMAS EN ESTOS MOMENTOS SE ENCUENTRA EN TALLER DE KIA PARA REPARACION. FRENOS REPARADOS EN 2 OCASIONES LOS ROTORES Y PADS. CRISTAL DELANTERO SE QUEBRO SIN RAZON. RADIO DEJO DE FUNCIONAR. *NLM
1 MAY 03 UPDATE FROM LETTER BELOW (SENT KIA ADDRESSES-SIDE NOTE: WITHOUT "OUTLOOK" YOU CANNOT CONTACT KIA SUPPORT VIA E-MAIL, LETTER CUT TO NOTHING TO MEET WORD REQUIREMENT) KIA CUSTOMER AFFAIRS (STEVE LAREZ 800 225-3193) CONTACTED ME SAID THEY WOULD LOOK INTO IT (21 APR 03). STEVE CALLS ME BACK (22 APR 03) TO INFORM ME T…
Read full complaint
1 MAY 03 UPDATE FROM LETTER BELOW (SENT KIA ADDRESSES-SIDE NOTE: WITHOUT "OUTLOOK" YOU CANNOT CONTACT KIA SUPPORT VIA E-MAIL, LETTER CUT TO NOTHING TO MEET WORD REQUIREMENT) KIA CUSTOMER AFFAIRS (STEVE LAREZ 800 225-3193) CONTACTED ME SAID THEY WOULD LOOK INTO IT (21 APR 03). STEVE CALLS ME BACK (22 APR 03) TO INFORM ME THAT HE HAS TALKED TO THE DISTINCT REP AND THAT THE BEST THEY WOULD DO WAS OFFER A WINDSHIELD AT WHOLESALE COST. TODAY, I WRITE TO YOU FOLKS AFTER SEEING A SIMILAR COMPLIANT IN YOUR DATABASE (FILED 30 AUG 2001), NOTE OTHER SIMILAR 2002 SEDONA WINDSHIELD COMPLAINTS MAY BE FOUND AT WWW.CARSURVEY.ORG I AM VERY CONCERNED ABOUT REPLACING THE WINDSHIELD (AGAIN!) AND HAVING THE SAME THING HAPPEN (AGAIN!). THREE WINDSHIELDS CRACKED IN 18 MONTHS IS NOT REASONABLE. OR AT LEAST NOT TO THE PRUDENT MAN. KIA FOLKS: 16 APR 03 I REALLY NEED SOME HELP. BOTTOMLINE: I HAVE HAD 2002 KIA SEDONA FOR LESS THAN 18 MONTHS THE WINDSHIELD HAS CRACKED FOR THE THIRD TIME * SEPT 01 (LATE) - BOUGHT THE SEDONA. * OCT 01 (~ MID) - WINDSHIELD #1 CRACKED. NO PARTS IN THE SYSTEM FOR A 2002; KIA DID NOT COVER THE REPLACEMENT * DEC 01 - WINDSHIELD, #2 INSTALLED * FEB 02 - I-65 OUTSIDE OF LOUISVILLE, WINDSHIELD #2 CRACKS. * APR 02 '' KIA BILL PENNY GOODWILLS WINDSHIELD #3 * MAR 03 - I-565 TOWARDS DECATUR WINDSHIELD #3 CRACKS ON ALL THE WINDSHIELDS THE CRACKS STARTED IN THE BLACK AREA NEAR RUBBER SEAM. SOME POINTS: * OUR SEDONA IS A GREAT CAR, EXCEPT THE WINDSHIELD * THE INTERNET HAS OTHER 02 SEDONAS WITH THE SAME WINDSHIELD PROBLEMS * THREE WINDSHIELDS CRACKING INSIDE OF 18 MONTHS IS EXCESSIVE - OUR SEDONA IS OUR FOURTH VAN OVER 15 YEARS. THE OTHER VANS HAD ONE CRACKED WINDSHIELD IN 14 YEARS. A COUPLE OF POTENTIAL PROBLEMS: - MOUNTING PROCEDURES/TECHNIQUES AND OR THE DESIGN - WINDSHIELD ROBUSTNESS (NOT DESIGNED TO ACCEPTED INDUSTRY STANDARD) - MY OTHER KIA''S (2) HAVE NO WINDSHIELD PROBLEMS
DEFECTIVE AUTO EQUIPMENT.
THE REAR SEAT BELT WAS REPLACED PER RECALL 03V-017000. AFTER THE SEAT BELT WAS REPAIRED THE CONSUMER WAS UNABLE TO SECURE A CHILD SAFETY SEAT IN THE REAR SEAT BECAUSE THE BELT WOULD NOT LOCK/RETRACT. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO INDICATED THAT THE BELT IS SUPPOSE TO RETRACT BACK AFTER BEING PULLED OUT. *NLM
AFTER SEVERAL ATTEMPTS TO START THE VEHICLE IT WAS TOWED TO A MECHANICS GARAGE. THE MECHANIC STATED THE FUEL PUMP WAS DEFECTIVE. *NLM *JB
THE VEHICLE DID NOT HOLD WHEN GOING DOWN A HILL OR NO LOW RANGE. THERE WAS A KNOCKING SOUND COMING FROM THE MOTOR(DEALER DIDN'T FIND PROBLEM), AND A WIND NOISE HAD COME FROM THE FRONT GLASS WHILE THE VEHICLE WAS IN MOTION. *NLM *SCC
THE WINDSHIELD HAD A BURN ODOR. *JB
THE MINI-VAN STARTED WITH A SIMPLE OIL LEAK THAT DEVELOPED INTO A CRACKED OIL FILTER HOUSING ON THE ENGINE TO THEN 3 BURNED OUT COILS AND TWO CHECK ENGINE LIGHTS ALL WITHIN 30 DAYS. CAR STILL IN SHOP. EB. *NLM
WHILE MY WIFE WAS GOING TO WORK FEBRUARY 27,2003 THE KIA SEDONA'S GAS PEDAL CONTINUED TO JAM WHICH RESULTED IN IT TO SPEED UNCONTROLLABLE. WHEN I FOUND HER ON THE SIDE OF THE ROAD SHE DIDN'T WANT TO DRIVE IT, SO I DROVE TO THE DEALER, ITS BEEN THERE EVER SINCE UNABLE TO REPAIR IT. *NLM
Official recalls
305V013000 · Vehicle Speed Control:cables
Jan 19, 2005
ON CERTAIN MINI VANS, DURING ASSEMBLY, THE THROTTLE CABLE WOULD TWIST ITSELF OUT OF POSITION.
Consequence & remedy
Consequence: THIS CAN PERMIT THE CABLE TO BE HUNG UP, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE FREE OF CHARGE. VEHICLES PRODUCED FROM MARCH 20, 2001 THROUGH NOVEMBER 7, 2001 WILL HAVE A GUIDE CLIP INSTALLED ON THE THROTTLE BODY ASSEMBLY IN ORDER TO ENSURE THAT THE TENSION FORCE CABLE DOES NOT MOVE OUT OF POSITION. VEHICLES MANUFACTURED BEGINNING ON NOVEMBER 8, 2001, ALREADY HAVE THE EXTENDED GUIDE, WHICH ACCOMPLISHES THE SAME OBJECTIVE. THE RECALL BEGAN MARCH 21, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
03V135000 · Seats:mid/rear Assembly
Apr 3, 2003
ON CERTAIN PASSENGER VEHICLES, SOME OF THE SECOND AND THIRD ROW SEAT STRIKERS INSTALLED ON THE VEHICLE FLOOR PAN HAVE BEEN IMPROPERLY HEAT TREATED AND COULD BREAK IN A CRASH.
Consequence & remedy
Consequence: THIS COULD RESULT IN INJURIES TO OCCUPANTS OF THESE SEATS.
Remedy: DEALERS WILL REPLACE THE SEAT STRIKERS. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542
03V017000 · Seat Belts:rear/other
Jan 22, 2003
CERTAIN MINI VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE SECOND AND THIRD SEAT BELT BUCKLE ANCHOR BOLTS DO NOT COMPLY WITH THE STANDARDS.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE ANCHOR BOLTS. OWNER NOTIFICATION BEGAN FEBRUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.