NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
198 reports1,000 miles · Jun 8, 2004
Electrical SystemEngine And Engine Cooling
VEHICLE STALLED DUE TO AN ELECTRICAL COMPONENT SHORTING OUT THE BATTERY. THE BATTERY WAS REPLACED 4 TIMES AND ALTERNATOR WAS REPLACED ONCE. ALSO, THE ENGINE LIGHT CAME ON WHILE DRIVING. DEALERSHIP REPLACED THE ENTIRE MOTOR. VEHICLE BURNED EXCESSIVE FUEL UNDER NORMAL DRIVING CONDITION. THE ABOVE REPAIRS ONLY PROVIDED A TEM…
Read full complaint
VEHICLE STALLED DUE TO AN ELECTRICAL COMPONENT SHORTING OUT THE BATTERY. THE BATTERY WAS REPLACED 4 TIMES AND ALTERNATOR WAS REPLACED ONCE. ALSO, THE ENGINE LIGHT CAME ON WHILE DRIVING. DEALERSHIP REPLACED THE ENTIRE MOTOR. VEHICLE BURNED EXCESSIVE FUEL UNDER NORMAL DRIVING CONDITION. THE ABOVE REPAIRS ONLY PROVIDED A TEMPORARY SOLUTION FOR THE PROBLEMS.*AK
NHTSA ODI #10075890
10,000 miles · Apr 18, 2004
Seat BeltsService Brakes, HydraulicSteeringCrashInjury
ONE MORE TIME KIA SEDONA 2002 FAILED TO BRAKE CAR LOST CONTROL FRONT PASSENGER SEAT BELT SNAPPED OUT, LOOKS LIKE POWER STEERING FAILED AND BRAKES ALSO, NOT THE FIRST TIME BRAKES FAILED IN KIA SEDONA. PRIOR TO THIS ACCIDENT THE CONSUMER COMPLAINED TO THE DEALER ABOUT VIBRATIONS WHILE BRAKING. CAR ACCELERATE BY ITSELF (THROTTLE …
Read full complaint
ONE MORE TIME KIA SEDONA 2002 FAILED TO BRAKE CAR LOST CONTROL FRONT PASSENGER SEAT BELT SNAPPED OUT, LOOKS LIKE POWER STEERING FAILED AND BRAKES ALSO, NOT THE FIRST TIME BRAKES FAILED IN KIA SEDONA. PRIOR TO THIS ACCIDENT THE CONSUMER COMPLAINED TO THE DEALER ABOUT VIBRATIONS WHILE BRAKING. CAR ACCELERATE BY ITSELF (THROTTLE STUCK). *BF
NHTSA ODI #10065882
Mileage unknown · Mar 12, 2004
Power TrainService Brakes, HydraulicVisibility
OUR KIA SADONA IS A 2002 MODEL AND HAS ABOUT 52,000 MILES ON IT. IT HAS HAD PROBLEMS WITH THE TRANSMISSION, BRAKES AND THE WINDSHIELD HAS BEEN REPLACED THREE TIMES ETC. TODAY HOWEVER, MY HUSBAND WAS DRIVING THE VEHICLE WHEN THE FRONT DRIVERS SIDE SEAT IN THE VEHICLE BROKE. THE SEAT BROKE COMPLETELY OUT OF IT'S CHAMBER. THANK GO…
Read full complaint
OUR KIA SADONA IS A 2002 MODEL AND HAS ABOUT 52,000 MILES ON IT. IT HAS HAD PROBLEMS WITH THE TRANSMISSION, BRAKES AND THE WINDSHIELD HAS BEEN REPLACED THREE TIMES ETC. TODAY HOWEVER, MY HUSBAND WAS DRIVING THE VEHICLE WHEN THE FRONT DRIVERS SIDE SEAT IN THE VEHICLE BROKE. THE SEAT BROKE COMPLETELY OUT OF IT'S CHAMBER. THANK GOD THIS DID NOT HAPPEN DURING AN ACCIDENT. THE DEALERSHIP SAID THEY WOULD BE REPLACING THE PART THAT BROKE UNDER THE WARRANTY HOWEVER IT WILL BE AWHILE BEFORE THEY GET THE PART IN. THEY REFUSED TO PROVIDE US WITH A SAFE VEHICLE TO DRIVE DURING THE TIME IT TAKES TO GET IT FIXED AND KIA CORPORATE ALSO REFUSED SAYING THEY DO NOT PROVIDE RENTALS EVEN IF THE PART IS A DEFECT FROM THE MANUFACTURER. THEY PRIDE THEMSELVES ON THE WARRANTY OF THE CAR PARTS BUT WHO CARES HOW MUCH YOU HAVE TO SPEND ON RENTAL CARS WHILE YOURS IS IN THE SHOP SO MANY TIMES.*AK
NHTSA ODI #10062048
19,000 miles · Mar 11, 2004
Air BagsSeat BeltsSeatsCrash
WHILE DRIVING 50 MPH VEHICLE WAS INVOLVED IN A COLLISION. UPON IMPACT, DUAL AIR BAGS DID NOT DEPLOY, AND SEAT BELT BROKE. ACCORDING TO THE CONSUMER THE SEAT BELT RETRACTOR DID NOT LOCK DURING THE EVENT. DRIVER SUSTAINED NECK INJURIES DURING THE ROLLOVER CRASH. *AK THE BACK SEAT HAD BECOME DISLODGED DURING THE ACCIDENT. RE…
Read full complaint
WHILE DRIVING 50 MPH VEHICLE WAS INVOLVED IN A COLLISION. UPON IMPACT, DUAL AIR BAGS DID NOT DEPLOY, AND SEAT BELT BROKE. ACCORDING TO THE CONSUMER THE SEAT BELT RETRACTOR DID NOT LOCK DURING THE EVENT. DRIVER SUSTAINED NECK INJURIES DURING THE ROLLOVER CRASH. *AK THE BACK SEAT HAD BECOME DISLODGED DURING THE ACCIDENT. RECALL#03V135000. *SC *JB
NHTSA ODI #10050280
3,300 miles · Feb 17, 2004
Electrical SystemLatches/locks/linkagesService Brakes, HydraulicFire
ON JULY 4, 2002 WE PURCHASED A 2002 KIA SEDONA MINIVAN. IMMEDIATELY AFTER DRIVING OUT OF THE DEALERSHIP WE PARKED AT A STORE, WHEN WE RETURNED TO THE VEHICLE IT WOULD NOT START. WE CALLED THE DEALERSHIP AND THEY SENT OUT A TOW TRUCK. THE VAN WAS TOWED TO THE DEALERSHIP AND THE SERVICE ADVISER INDICATED THAT THEY HAD NUMEROUS …
Read full complaint
ON JULY 4, 2002 WE PURCHASED A 2002 KIA SEDONA MINIVAN. IMMEDIATELY AFTER DRIVING OUT OF THE DEALERSHIP WE PARKED AT A STORE, WHEN WE RETURNED TO THE VEHICLE IT WOULD NOT START. WE CALLED THE DEALERSHIP AND THEY SENT OUT A TOW TRUCK. THE VAN WAS TOWED TO THE DEALERSHIP AND THE SERVICE ADVISER INDICATED THAT THEY HAD NUMEROUS COMPLAINTS REGARDING A DRIVER SEAT RELAY THAT WAS CAUSING THE BATTERIES TO GO OUT ON THIS YEAR, MAKE AND MODEL OF VEHICLE. HE INDICATED THAT THEY WERE CHANGING ALL RELAYS. THEY REPLACED WITH NEW BATTERY AND NEW RELAY ON THE VAN. THE VAN CONTINUED TO GIVE US PROBLEMS, THE WHOLE ELECTRICAL SYSTEM (STEREO, WINDOWS, DOOR LOCKS) WOULD GO OFF AND ON AS WE WERE DRIVING. IF WE WOULD STOP VEHICLE, THE VEHICLE WOULD NOT START. WE HAD NUMEROUS JUMP STARTS. WE TOOK THE VEHICLE IN APPROX. 4 OR 5 TIMES TO THE DEALERSHIP WITH COMPLAINTS REGARDING PROBLEMS, THERE WAS BLACK SMOKE COMING OUT OF THE EXHAUST WHEN WE WOULD START THE VEHICLE. BRAKES WOULD SQUEAL WHEN APPLIED. VAN WAS TERRIBLY HOT UNDER THE CAR AND IT WOULD BLOW OUT THE HEAT AND ALMOST BURN US. I ASKED THE SERVICE ADVISER IF THEY COULD EXCHANGE THE VAN FOR ANOTHER ONE AND HE INDICATED THAT THEY HAD TO HAVE A CONTINUOUS REPORT OF REPAIRS IN ORDER TO TURN IT IN AS A "LEMON". WE WERE TRAVELING IN MEXICO FOR BUSINESS AND PLEASURE WHEN OUR VAN STARTED ON FIRE ON THE HIGHWAY AND OTHER AUTOS NOTICED AND WAVED US DOWN TO STOP. WE NOTICED, PULLED OFF THE ROAD SAFELY AND ALL 6 ADULT PASSENGERS WERE ABLE TO GET OUT SAFELY AND RUN AWAY FROM THE VEHICLE AS IT STARTED EXPLODING. THE FIRE CAME FROM ALL UNDERNEATH OF THE VAN. THE MEXICAN FEDERAL HIGHWAY POLICE CAME TO WHERE THE VAN WAS AND TOOK A REPORT OF THE INCIDENT. THE VAN BURNT DOWN TO A SKELETON. I REPORTED THE INCIDENT TO THE KIA CUSTOMER SERVICE, THEY DENIED OUR CLAIM WITHOUT NO EXPLANATION. NO ONE EVER CALLED TO FIND OUT THE FACTS OR GATHER INFORMATION. OBVIOUSLY, THEY DID NOT EVEN LOOK AT THEIR OWN SERVICE REPAIR TICKETS. *JB
NHTSA ODI #10058351
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingEquipmentService Brakes, Hydraulic
I REALLY NEED HELP AND DON?T KNOW WHAT TO DO. ALSO WITH MY CAR MY ENGINE LIGHT WAS CONSTANTLY ON AND TO THIS DAY THE LIGHT IS PROBABLY STILL ON AND KIA HAVE NOT CONTACTED ME YET AND EVEN THOUGH I HAVE A RENTAL FROM ENTERPRISE THROUGH KIA PAYING THAT IS NOT THE ISSUE I WANT MY CAR SO THAT CAN SELL IT SO THAT I DON?T LOSE MY HOME…
Read full complaint
I REALLY NEED HELP AND DON?T KNOW WHAT TO DO. ALSO WITH MY CAR MY ENGINE LIGHT WAS CONSTANTLY ON AND TO THIS DAY THE LIGHT IS PROBABLY STILL ON AND KIA HAVE NOT CONTACTED ME YET AND EVEN THOUGH I HAVE A RENTAL FROM ENTERPRISE THROUGH KIA PAYING THAT IS NOT THE ISSUE I WANT MY CAR SO THAT CAN SELL IT SO THAT I DON?T LOSE MY HOME BECAUSE I AM UNEMPLOYED DUE TO THIS BUCKET OF BOLTS. AND ALSO THE KIA REPAIR MAN STEVE JOHNSON AT KIRKLAND KIA STATED TO ME THAT MY ODOMETER READING WAS INCORRECT AND THE KIA MANUFACTURER TOOK MY CAR TO ANOTHER DEALER BECAUSE I WAD BEING SEEN AT THEIR AUTO SHOP TOO MUCH AND IS BIZARRE OR WHAT? I SPOKE TO A PAUL STAPLETON AT KIA MOTORS AMERICA BECAUSE THEY HAVE HAD MY VEHICLE FOR 30 DAYS STRAIGHT. ON OCT 8 I PICKED MY CAR UP AND 20 MIN LATER MY ENGINE LIGHT WAS BACK ON. THE DAY BEFORE I WAS OFFERED $1000 FOR A GOOD WILL GESTURE FROM KIA. WHEN THE ENGINE LIGHT CAME BACK ON THE NEXT DAY MR. STAPLETON OFFERED TO BUY MY VEHICLE BACK FOR 11,300 AND THAT WAS WITHOUT THE $1000 GOOD WILL. TODAY IS OCT 12TH AND BY THIS AFTERNOON I WILL BE HEARING FROM THIS COMPANY. THIS IS NOT SATISFYING TO ME BECAUSE I STILL HAD A FULL WARRANTY ON MY CAR AND FOR 11,300 I WILL HAVE TO PURCHASE USED AND NO WARRANTY BECAUSE I HAD A 2002 THAT WAS PAID IN FULL AND A FULL WARRANTY.
NHTSA ODI #10070909
Mileage unknown · Jan 15, 2004
Seat Belts
LEFT MIDDLE REAR SEAT WILL NOT LOCK CHILD SAFETY SEAT IN PLACE. SEAT BELT SHOULD LOCK IN PLACE ONCE SEAT BELT IS IN USE AND FULLY RETRACTED HOWEVER IT DOES NOT. SEAT BELT HAS BEEN REPLACED THREE TIMES WITH SAME RESULT.
NHTSA ODI #10068733
47,857 miles · Dec 29, 2003
Electrical SystemExterior LightingInterior Lighting
WE PURCHASED THE 2002 KIA SEDONA YESTERDAY 12-28-03. WE DROVE THE CAR FOR ABOUT 45 MINUTES TODAY, STOPPED FOR DINNER AT A FAST FOOD RESTAURANT AND THEN DROVE AGAIN FOR ABOUT 10 MINUTES WHEN WHILE DRIVING THE VEHICLE, THE BATTERY AND BRAKE WARNING LIGHTS FLASHED ON AND OFF A FEW TIMES, THEN STAYED ON. WHEN THE BRAKE PEDAL WAS DE…
Read full complaint
WE PURCHASED THE 2002 KIA SEDONA YESTERDAY 12-28-03. WE DROVE THE CAR FOR ABOUT 45 MINUTES TODAY, STOPPED FOR DINNER AT A FAST FOOD RESTAURANT AND THEN DROVE AGAIN FOR ABOUT 10 MINUTES WHEN WHILE DRIVING THE VEHICLE, THE BATTERY AND BRAKE WARNING LIGHTS FLASHED ON AND OFF A FEW TIMES, THEN STAYED ON. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE RADIO SHUT OFF AND WOULD NOT COME BACK ON. THEN THE SEATBELT WARNING LIGHT CAME ON AND THE DASH LIGHTS, EXTERIOR AND INTERIOR LIGHTS DIMMED. WHILE CAR WAS STILL IN MOTION, THE SUNROOF WOULD NOT CLOSE AND THE OTHER WINDOWS WERE VERY SLOW AT CLOSING. THE CAR SHUDDERED A COUPLE OF TIMES AS IF READY TO STALL. WE MADE IT HOME JUST IN TIME, THE CAR STALLED AND WOULD NOT RESTART. WE WERE ABLE TO CLOSE THE SUNROOF, BUT IT WAS VERY SLOW. WE HAVE TRIED TO CHARGE THE BATTERY, BUT IT DOES NOT SEEM TO BE TAKING A CHARGE. SECONDLY THE SEATBELT INDICATOR LIGHT DOES NOT SOUND OR INDICATE THAT SEATBELTS ARE NOT BUCKLED. THIRDLY THERE IS MOISTURE UNDER THE DRIVERS SIDE HEAD LIGHT. ALSO, WHEN THE VEHICLE IS IN MOTION AND THE DVD PLAYER IS OPERATING, THERE IS A WHISTLING SOUND HEARD THROUGH THE DVD HEADPHONES/SOUND DURING ACCELERATION. WE WILL BE NOTIFYING THE DEALER TOMORROW MORNING.
NHTSA ODI #10051291
35,000 miles · Dec 15, 2003
Electrical System
UNKNOWN ELECTRICAL DRAIN IN ELECTRICAL SYSTEM LEAVES BATTERY DEAD. HAS HAPPENED ON SEVERAL OCCASIONS REQUIRING JUMP STARTS.*AK
NHTSA ODI #10049763
35,000 miles · Dec 15, 2003
Service Brakes, Hydraulic
VEHICLE SHUTTERS AND PULLS WHEN BRAKES APPLIED FROM FREEWAY SPEED ON DOWNHILL EXIT.*AK
NHTSA ODI #10049762
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Illustration