NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
14 reportsClear category filterMileage unknown · Aug 21, 2017
Structure
THE DOOR HANDLES ARE PLASTIC AND EVENTUALLY BROKE OFF ON THE OUTSIDE SO THAT OPENING THE DOORS -ALL 4- IS TRICKY SINCE ONLY ONE SIDE OF THE HANDLE REMAINS IN PLACE. THE INSIDE DOOR HANDLES HAVE A PLASTIC CHROME-LOOKING COATING THAT PEELS OFF AND HAS CUT OUR HANDS SEVERAL TIMES CAUSING US TO NEED BANDAGES AS SOON AS WE RUN IN TH…
Read full complaint
THE DOOR HANDLES ARE PLASTIC AND EVENTUALLY BROKE OFF ON THE OUTSIDE SO THAT OPENING THE DOORS -ALL 4- IS TRICKY SINCE ONLY ONE SIDE OF THE HANDLE REMAINS IN PLACE. THE INSIDE DOOR HANDLES HAVE A PLASTIC CHROME-LOOKING COATING THAT PEELS OFF AND HAS CUT OUR HANDS SEVERAL TIMES CAUSING US TO NEED BANDAGES AS SOON AS WE RUN IN THE FRONT DOOR.
NHTSA ODI #11016451
Mileage unknown · Mar 17, 2017
Structure
DRIVER DOOR WILL NOT OPEN FROM THE INSIDE OR OUTSIDE.
NHTSA ODI #10966519
Mileage unknown · May 15, 2014
Structure
BOTH OF MY FRONT DOOR HANDLES ON INSIDE BROKE COMPLETELY OFF EXACTLY THE SAME WAY ONLY WAY TO GET OUT IF MY CAR IS TO ROLL WINDOW DOWN AND OPEN FROM OUTSIDE. ALSO SLIDING DOOR HANDLE SAME MATERIAL BROKE OFF I FEEL IT IS A SAFETY HAZARD IF THE WINDOWS WERE TO QUIT WORKING I WOULD HAVE NO WAY OUT. INFORMATION REDACTED PURS…
Read full complaint
BOTH OF MY FRONT DOOR HANDLES ON INSIDE BROKE COMPLETELY OFF EXACTLY THE SAME WAY ONLY WAY TO GET OUT IF MY CAR IS TO ROLL WINDOW DOWN AND OPEN FROM OUTSIDE. ALSO SLIDING DOOR HANDLE SAME MATERIAL BROKE OFF I FEEL IT IS A SAFETY HAZARD IF THE WINDOWS WERE TO QUIT WORKING I WOULD HAVE NO WAY OUT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10588646
62,000 miles · Aug 16, 2012
Electrical SystemStructure
TL* THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT STATED THAT THE AIR CONDITIONING UNIT FAILED AND WAS BLOWING WARM AIR. THE VEHICLE WAS TAKEN TO THE DEALER AND AN INSPECTION WAS PERFORMED, WHICH DETERMINED THAT THE CONDENSER WAS LEAKING. THE DEALER ALSO FOUND THAT THE VEHICLE PASSENGER SIDE OF THE SUB FRAME WAS CORRODED WITH …
Read full complaint
TL* THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT STATED THAT THE AIR CONDITIONING UNIT FAILED AND WAS BLOWING WARM AIR. THE VEHICLE WAS TAKEN TO THE DEALER AND AN INSPECTION WAS PERFORMED, WHICH DETERMINED THAT THE CONDENSER WAS LEAKING. THE DEALER ALSO FOUND THAT THE VEHICLE PASSENGER SIDE OF THE SUB FRAME WAS CORRODED WITH ONLY TWO INCHES OF METAL LEFT SUPPORTING THE ENGINE. THE CORROSION ALSO SPREAD TO THE DRIVER'S SIDE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DENIED ASSISTANCE WITH THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 62,000.
NHTSA ODI #10471149
50,764 miles · Jan 26, 2006
Structure
THE SLIDING DOOR ON THE DRIVER'S SIDE WON'T GO FARTHER BACK THAN 1/2 WAY & THEN STOPS. WHEN THIS HAPPENED ON THE PASSENGER SIDE ON MAY 16, 2005, AND WE PULLED IT BACK ALL THE WAY, THE SLIDING DOOR ASSEMBLY FELL OUT OF THE WINDOW IN THE REAR & THE REAR PART OF THE SLIDING DOOR FELL DOWN TO THE GROUND & LEFT LARGE GOUGES IN THE S…
Read full complaint
THE SLIDING DOOR ON THE DRIVER'S SIDE WON'T GO FARTHER BACK THAN 1/2 WAY & THEN STOPS. WHEN THIS HAPPENED ON THE PASSENGER SIDE ON MAY 16, 2005, AND WE PULLED IT BACK ALL THE WAY, THE SLIDING DOOR ASSEMBLY FELL OUT OF THE WINDOW IN THE REAR & THE REAR PART OF THE SLIDING DOOR FELL DOWN TO THE GROUND & LEFT LARGE GOUGES IN THE SIDE OF THE VEHICLE. THIS WAS MARKED AS RECALL WHEN FIXED ON THE PASSENGER SIDE - 2002, KIA SEDONA.*AKI
NHTSA ODI #10148739
68,000 miles · Dec 20, 2005
Structure
DT: THE CONTACT STATED BOTH T SLIDING DOORS MALFUNCTIONED. HE HAD A PROBLEM WITH THE PASSENGER'S SIDE DOOR PREVIOUSLY. IT FELL OFF THE TRACK, AND WAS REPAIRED BY SERVICE DEALER. NOW, BOTH DOORS WERE STUCK SHUT AND WILL NOT OPEN, EVEN OPEN FROM THE INSIDE. NO APPOINTMENT HAS BEEN MADE WITH THE SERVICE DEALER FOR REPAIRS.*AK
NHTSA ODI #10145734
46,876 miles · Nov 10, 2005
Electrical SystemEngine And Engine CoolingEquipment
CONSUMER BELTS SQUEAL, SLIDDING DOOR DRAGS, PULLEY WAS REPLACED AT 7744 MILES. *TS ***NO ANSWER REQUIRED*** THE PULLEY AND BELT HAVE BEEN REPLACED 10 TIMES. THE ALTERNATOR SEIZED WHILE THE VEHICLE WAS BEING DRIVEN. THE A/C FAN MADE LOUD NOISES. THE SLIDING DOOR DRAGGED. THE EMERGENCY BRAKE WOULD NOT HOLD, THE DEALER ADJUST…
Read full complaint
CONSUMER BELTS SQUEAL, SLIDDING DOOR DRAGS, PULLEY WAS REPLACED AT 7744 MILES. *TS ***NO ANSWER REQUIRED*** THE PULLEY AND BELT HAVE BEEN REPLACED 10 TIMES. THE ALTERNATOR SEIZED WHILE THE VEHICLE WAS BEING DRIVEN. THE A/C FAN MADE LOUD NOISES. THE SLIDING DOOR DRAGGED. THE EMERGENCY BRAKE WOULD NOT HOLD, THE DEALER ADJUSTED IT THREE TIMES THEN FINALLY REPLACED. AN INTERNAL SHORT IN THE FUSE CLOCK CAUSED THE VEHICLE NOT TO START. THE VEHICLE STALLED INTERMITTENLTY BUT THE DEALER WAS UNABLE TO DUPLICATE THE STALLING. THE POWER WINDOWS WOULD STICK AND MAKE NOISE, THE DEALER LUBED IT AND REPLACED THE REGULATOR. THE REAR HATCH RUSTED AROUND HANDLE AND HAD TO BE REPAIRED/REFINISHED TWICE. THE EXHAUST MANIFOLD RACKED. OIL LEAKED FROM OIL FILTER. THE FRONT AND REAR WIPERS FAILED. THE SLIDING DOOR HANDLE BROKE. THE DASH LIGHTS ILLUMINATED DUE TO BROKEN BAD SWITCH CONTACTS. THE ROTORS WARPED. THE A/C WAS BLOWING WHEN IT WASN'T ON AND SOMETIMES IT BLEW OUT WARM AIR. THE REAR SEAT ARM REST WILL NOT STAY DOWN. THE THRESHOLD ON THE LEFT SIDE IS CRACKED. *NM
NHTSA ODI #10143219
Mileage unknown · Dec 27, 2004
Electrical SystemEngine And Engine CoolingLatches/locks/linkages
WE HAVE A 2002 KIA SEDONA; WE BOUGHT IN DEC OF 2001. WITHIN THE FIRST 6 MONTHS, THE ALTERNATOR,BATTERY,IGNITION SWITCH, HAD TO BE REPLACED, ALONG WITH SLIDING DOORS FALLING OFF THE HINGE. I COMPLAINED OF A WIND NOISE FOR THE FIRST YEAR NO ONE KNEW WHAT IT WAS. IT WENT UNFIXED. WITHIN A YEAR THE SHOCKS, THE STRUTS AND SLIDING DO…
Read full complaint
WE HAVE A 2002 KIA SEDONA; WE BOUGHT IN DEC OF 2001. WITHIN THE FIRST 6 MONTHS, THE ALTERNATOR,BATTERY,IGNITION SWITCH, HAD TO BE REPLACED, ALONG WITH SLIDING DOORS FALLING OFF THE HINGE. I COMPLAINED OF A WIND NOISE FOR THE FIRST YEAR NO ONE KNEW WHAT IT WAS. IT WENT UNFIXED. WITHIN A YEAR THE SHOCKS, THE STRUTS AND SLIDING DOORS HAD TO BE REPLACED. MY AIR-CONDITION WENT OUT COMPLETELY GUESS WHAT NO MORE WIND NOISE. AND NO LONGER UNDER WARRANTY. MY REAR WIPER CONTROL WENT OUT. RECENTLY, WHILE ON THANKSGIVING VACATION TO OHIO WE HAD TO HAVE ROADSIDE PICK UP OUR VAN AS THE TRANSMISSION TOTALLY WENT OUT WITHOUT WARNING. WHILE IN THE SHOP WE WERE ADVISED OUR BRAKES WERE NOT SAFE TO DRIVE. WE HAD NEVER HAD A PROBLEM WITH THE BRAKES. AND THE MOTOR MOUNTS WERE ALSO IN NEED OF REPLACEMENT. WAS IN THE SHOP 14 DAYS, WE HAD TO DRIVE BACK TO OHIO TO WHEN READY. THE BRAKES WENT TO THE FLOOR HAD NEVER EVER DONE THAT BEFORE. WHEN WE WERE ON OUR WAY OUT OF TOWN, THE TRANSMISSION WAS ACTING UP. WE MADE IT HOME ON DEC 7TH AND NO ONE AT KIA COULD TAKE THE VEHICLE IN UNTIL THE SERVICE MANAGER RETURNED MY CALL HE WAS OFF FOR DOCTOR VISIT. ON DEC 13, I TOOK MY VAN IN TO BE REPAIRED, THEY CALLED ME AND TOLD ME IT WOULD NEED A NEW TRANSMISSION, AND GUESS WHAT THEY ARE ALSO REPAIRING THE SLIDING DOORS 5TH TIME I THINK. THEY HAVE TO ALSO FIX THE DENT IN THE HOOD THAT WAS NOT THERE, BEFORE THE OHIO KIA TOOK IT IN TO BE FIXED. TODAY IT HAS BEEN 15 DAYS. I STILL DO NOT HAVE MY VAN. I WOULD NOT RECOMMEND KIA TO MY WORST ENEMY. PLEASE ALLOW OTHERS TO KNOW THAT KIA IS A LEMON IF EVER THERE WERE ONE.*AK
NHTSA ODI #10104569
38,893 miles · Jun 28, 2004
Engine And Engine CoolingStructureWheels
KIA HAS INFORMED US THAT OUR CAR WILL CONTINUE TO NEED REPAIRS SINCE IT WAS NOT DESIGNED TO BE DRIVEN ON DIRT ROADS. WE LIVE ON A DIRT ROAD AND DRIVE MANY MILES OF DIRT ROADS AND NOW WE ARE SPENDING MONEY REPLACING PARTS NOT PROTECTED FROM DIRT DUE TO FAULTY ENGINEERING DESIGN.*AK
NHTSA ODI #10078936
Mileage unknown · Sep 6, 2002
Structure
WHILE STARTING VEHICLE THE SLIDING DOOR WINDOW HAD BLOWNOUT AND SHATTERED INTO PIECES. NO ONE WAS HURT, BUT THE THE ONLY OCCUPANCY WAS THE DRIVER AT TIME OF INCIDENT. *AK THE CONSUMER STATES THAT THE DOOR WAS SHUT AT THE TIME AND THE VEHICLE WAS NOT MOVING. THE CONSUMER FEELS THAT SOMETHING SHOULD BE DONE TO INSURE HIS FAMI…
Read full complaint
WHILE STARTING VEHICLE THE SLIDING DOOR WINDOW HAD BLOWNOUT AND SHATTERED INTO PIECES. NO ONE WAS HURT, BUT THE THE ONLY OCCUPANCY WAS THE DRIVER AT TIME OF INCIDENT. *AK THE CONSUMER STATES THAT THE DOOR WAS SHUT AT THE TIME AND THE VEHICLE WAS NOT MOVING. THE CONSUMER FEELS THAT SOMETHING SHOULD BE DONE TO INSURE HIS FAMILY'S SAFETY, AND TO KEEP THEM DRIVING KIA VEHICLES. *SCC
NHTSA ODI #8018062
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Illustration