IllustrationKIA HAS INFORMED US THAT OUR CAR WILL CONTINUE TO NEED REPAIRS SINCE IT WAS NOT DESIGNED TO BE DRIVEN ON DIRT ROADS. WE LIVE ON A DIRT ROAD AND DRIVE MANY MILES OF DIRT ROADS AND NOW WE ARE SPENDING MONEY REPLACING PARTS NOT PROTECTED FROM DIRT DUE TO FAULTY ENGINEERING DESIGN.*AK
2002 Kia Sedona
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Kia Sedona do not stand out strongly from the model-year median of 120.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sedona years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
310–25K
2225–50K
2750–75K
1475–100K
8100–150K
7150K+
109 reports with mileage · 89 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports13 fire reports11 injury reports
Engine And Engine Cooling complaints
27 reportsCONSUMER STATED THAT VEHICLE STALLED. CONSUME DROVE IN NORMAL CITY TRAFFIC WHEN SUDDENLY THE VEHICLE STALLED WITHOUT A CAUSE. VEHICLE HAD BEEN TO THE DEALER AT LEAST 4 TIMES. YET, PROBLEM RECURRED. *AK
WHILE DRIVING ON HIGHWAY WITH HEAT ON, THE AIR STOPPED BLOWING INTO THE CAR FROM THE VENTS EVEN THOUGH WE COULD HEAR THE BLOWER MOTOR RUNNING. THIS STARTED OCTOBER 4, 2003 AND STILL HAS NOT BEEN FIXED AS OF JUNE 2004.EVEN THOUGH WE HAVE HAD THE CAR IN THE REPAIR SHOP 11 TIMES. WE HAVE BEEN PLACED IN VERY DANGEROUS SITUATIONS …
Read full complaint
WHILE DRIVING ON HIGHWAY WITH HEAT ON, THE AIR STOPPED BLOWING INTO THE CAR FROM THE VENTS EVEN THOUGH WE COULD HEAR THE BLOWER MOTOR RUNNING. THIS STARTED OCTOBER 4, 2003 AND STILL HAS NOT BEEN FIXED AS OF JUNE 2004.EVEN THOUGH WE HAVE HAD THE CAR IN THE REPAIR SHOP 11 TIMES. WE HAVE BEEN PLACED IN VERY DANGEROUS SITUATIONS BECAUSE OF THIS. DURING THE WINTER, WHEN THE BLOWER WOULD QUIT, THE WINDOWS WOULD FOG UP OR FREEZE UP IMMEDIATELY. WE COULDN'T EVEN SEE TO GET THE CAR OFF THE ROAD. THERE WAS NO WAY TO CLEAR THE WINDOWS, NOT TO MENTION THE DISCOMFORT OF FREEZING TO DEATH WHEN IT WAS 30 DEGREES BELOW ZERO. THE ENTIRE HEATING SYSTEM, ACTUATORS, BLOWER MOTOR WERE REPLACED AND THE BLENDER DOORS WERE REPROGRAMMED. WE ONLY HAVE HEAT SPORADICALLY. NOW THAT SUMMER IS HERE, THE AIR CONDITIONER DOESN'T WORK,. IT IS IN THE SHOP NOW HAVING THE COMPRESSOR REPLACED. THE TRANSMISSION ALSO WAS REPLACED IN OCT. 2003. WE FEEL THE COMPANY HAS HAD AMPLE TIME TO REPAIR THE CAR. THEY EVEN ADMIT THEY CAN'T FIX IT. WE ARE SEEKING A REPLACEMENT (COMPARABLE) VEHICLE OR A REFUND SO THAT WE CAN GET A VEHICLE THAT WORKS. I REFUSE TO GO THROUGH ANOTHER WINTER LIKE THAT. *AK
VEHICLE STALLED DUE TO AN ELECTRICAL COMPONENT SHORTING OUT THE BATTERY. THE BATTERY WAS REPLACED 4 TIMES AND ALTERNATOR WAS REPLACED ONCE. ALSO, THE ENGINE LIGHT CAME ON WHILE DRIVING. DEALERSHIP REPLACED THE ENTIRE MOTOR. VEHICLE BURNED EXCESSIVE FUEL UNDER NORMAL DRIVING CONDITION. THE ABOVE REPAIRS ONLY PROVIDED A TEM…
Read full complaint
VEHICLE STALLED DUE TO AN ELECTRICAL COMPONENT SHORTING OUT THE BATTERY. THE BATTERY WAS REPLACED 4 TIMES AND ALTERNATOR WAS REPLACED ONCE. ALSO, THE ENGINE LIGHT CAME ON WHILE DRIVING. DEALERSHIP REPLACED THE ENTIRE MOTOR. VEHICLE BURNED EXCESSIVE FUEL UNDER NORMAL DRIVING CONDITION. THE ABOVE REPAIRS ONLY PROVIDED A TEMPORARY SOLUTION FOR THE PROBLEMS.*AK
I REALLY NEED HELP AND DON?T KNOW WHAT TO DO. ALSO WITH MY CAR MY ENGINE LIGHT WAS CONSTANTLY ON AND TO THIS DAY THE LIGHT IS PROBABLY STILL ON AND KIA HAVE NOT CONTACTED ME YET AND EVEN THOUGH I HAVE A RENTAL FROM ENTERPRISE THROUGH KIA PAYING THAT IS NOT THE ISSUE I WANT MY CAR SO THAT CAN SELL IT SO THAT I DON?T LOSE MY HOME…
Read full complaint
I REALLY NEED HELP AND DON?T KNOW WHAT TO DO. ALSO WITH MY CAR MY ENGINE LIGHT WAS CONSTANTLY ON AND TO THIS DAY THE LIGHT IS PROBABLY STILL ON AND KIA HAVE NOT CONTACTED ME YET AND EVEN THOUGH I HAVE A RENTAL FROM ENTERPRISE THROUGH KIA PAYING THAT IS NOT THE ISSUE I WANT MY CAR SO THAT CAN SELL IT SO THAT I DON?T LOSE MY HOME BECAUSE I AM UNEMPLOYED DUE TO THIS BUCKET OF BOLTS. AND ALSO THE KIA REPAIR MAN STEVE JOHNSON AT KIRKLAND KIA STATED TO ME THAT MY ODOMETER READING WAS INCORRECT AND THE KIA MANUFACTURER TOOK MY CAR TO ANOTHER DEALER BECAUSE I WAD BEING SEEN AT THEIR AUTO SHOP TOO MUCH AND IS BIZARRE OR WHAT? I SPOKE TO A PAUL STAPLETON AT KIA MOTORS AMERICA BECAUSE THEY HAVE HAD MY VEHICLE FOR 30 DAYS STRAIGHT. ON OCT 8 I PICKED MY CAR UP AND 20 MIN LATER MY ENGINE LIGHT WAS BACK ON. THE DAY BEFORE I WAS OFFERED $1000 FOR A GOOD WILL GESTURE FROM KIA. WHEN THE ENGINE LIGHT CAME BACK ON THE NEXT DAY MR. STAPLETON OFFERED TO BUY MY VEHICLE BACK FOR 11,300 AND THAT WAS WITHOUT THE $1000 GOOD WILL. TODAY IS OCT 12TH AND BY THIS AFTERNOON I WILL BE HEARING FROM THIS COMPANY. THIS IS NOT SATISFYING TO ME BECAUSE I STILL HAD A FULL WARRANTY ON MY CAR AND FOR 11,300 I WILL HAVE TO PURCHASE USED AND NO WARRANTY BECAUSE I HAD A 2002 THAT WAS PAID IN FULL AND A FULL WARRANTY.
CHECK ENGINE LIGHT KEEPS COMING ON, EVERY 2000 MILES. IT IS ALWAYS THE SAME THING, A RICH FUEL MIXTURE. THIS PROBLEM AFFECTS THE ACCELERATION OF THE VEHICLE. WHEN THE DRIVER STEPS ON THE GAS, THE CAR EITHER BUCKS AND WON'T GO, OR JUST BOGS DOWN AND WON'T ACCELERATE. THIS IS DANGEROUS WHEN TRYING TO MERGE IN TRAFFIC ON BUSY, CON…
Read full complaint
CHECK ENGINE LIGHT KEEPS COMING ON, EVERY 2000 MILES. IT IS ALWAYS THE SAME THING, A RICH FUEL MIXTURE. THIS PROBLEM AFFECTS THE ACCELERATION OF THE VEHICLE. WHEN THE DRIVER STEPS ON THE GAS, THE CAR EITHER BUCKS AND WON'T GO, OR JUST BOGS DOWN AND WON'T ACCELERATE. THIS IS DANGEROUS WHEN TRYING TO MERGE IN TRAFFIC ON BUSY, CONGESTED HIGHWAYS. EVERYTIME THIS HAPPENS, WE TAKE IT TO THE DEALER AND THEY KEEP IT SEVERAL DAYS TO A WEEK BEFORE THEY CAN FIGURE OUT WHAT IS WRONG. THIS IS THE 3RD TIME SINCE APRIL 2003 FOR THE SAME ISSUE. *LA
MY 2002 KIA SEDONA HAS EXPERIENCED MULTIPLE PROBLEMS SINCE I BOUGHT IT IN MARCH, 2002. MAJOR ELECTRICAL PROBLEMS, BATTERY REPLACEMENT, SLIDING DOOR FAILING TO CLOSE, ENGINE NOISE, AIR CONDITIONER PROBLEMS. HAVE CONTACTED MANUFACTURER AND DEALER. SOME ISSUES RESOLVED - - OTHERS UNABLE TO BE DIAGNOSED OR REPLICATED. FEAR THAT …
Read full complaint
MY 2002 KIA SEDONA HAS EXPERIENCED MULTIPLE PROBLEMS SINCE I BOUGHT IT IN MARCH, 2002. MAJOR ELECTRICAL PROBLEMS, BATTERY REPLACEMENT, SLIDING DOOR FAILING TO CLOSE, ENGINE NOISE, AIR CONDITIONER PROBLEMS. HAVE CONTACTED MANUFACTURER AND DEALER. SOME ISSUES RESOLVED - - OTHERS UNABLE TO BE DIAGNOSED OR REPLICATED. FEAR THAT ENGINE, ELECTRICAL SYSTEM IS STILL NOT WORKING PROPERLY AND WILL FAIL AND CAUSE AN ACCIDENT.*AK
FROM 2ND WEEK WE COMPLAINED OF ENGINE NOISE. EACH TIME NO PROBLEM WAS FOUND. FEW MONTHS LATER CK ENGINE CAME ON. A SPARK PLUG WAS REPLACED. 1 MONTH LATER CK ENGINE LIGHT ON AGAIN. NEW FUEL INJECTOR. 2 DAYS LATER CK ENGINE LIGHT AGAIN. NEEDED NEW MOTOR AT 3800 MILES. 1 WEEK LATER CAUGHT ON FIRE IN OUR GARAGE. KIA REGIONAL MAN…
Read full complaint
FROM 2ND WEEK WE COMPLAINED OF ENGINE NOISE. EACH TIME NO PROBLEM WAS FOUND. FEW MONTHS LATER CK ENGINE CAME ON. A SPARK PLUG WAS REPLACED. 1 MONTH LATER CK ENGINE LIGHT ON AGAIN. NEW FUEL INJECTOR. 2 DAYS LATER CK ENGINE LIGHT AGAIN. NEEDED NEW MOTOR AT 3800 MILES. 1 WEEK LATER CAUGHT ON FIRE IN OUR GARAGE. KIA REGIONAL MANAGEMENT CHRIS BUTLER SAID THEY WOULD REPAIR DAMAGES FROM FIRE BUT HAD NO CONCERN THAT OUR 6 MONTH OLD VAN WITH ONLY 3800 MILES ALREADY HAD THE MOTOR REPLACE AND CAUGHT ON FIRE. HIS ADVISE DON'T PARK IN THE GARAGE ANYMORE SO WE WON'T HAVE TO WORRY ABOUT IT BURNING DOWN OUR HOUSE. IRONIC THAT WE CHOOSE THIS VAN BECAUSE WE THOUGHT IT WOULD BE EASIER AND SAFER FOR OUR KIDS. NOW I FEAR OUR FAMILIES SAFETY EVERYDAY BECAUSE WE HAVE IT. *AK
STRONG ANTIFREEZE SMELL WHEN USING THE AC ON HOT DAYS. TRANSMISSION SHIFTS VIOLENTLY FROM 1-2 AND OCCASIONALLY INTO REVERSE. DEALER HAS ATTEMPTED TO CORRECT SEVERAL TIMES. *NLM SLIDING DOORS HAVE HAD ALIGNMENT PROBLEMS AND BEARING FAILURE SEVERAL TIMES ALSO. (CURRENTLY FIXED).
DEFECTIVE AUTO EQUIPMENT.
Official recalls
305V013000 · Vehicle Speed Control:cables
Jan 19, 2005
ON CERTAIN MINI VANS, DURING ASSEMBLY, THE THROTTLE CABLE WOULD TWIST ITSELF OUT OF POSITION.
Consequence & remedy
Consequence: THIS CAN PERMIT THE CABLE TO BE HUNG UP, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE FREE OF CHARGE. VEHICLES PRODUCED FROM MARCH 20, 2001 THROUGH NOVEMBER 7, 2001 WILL HAVE A GUIDE CLIP INSTALLED ON THE THROTTLE BODY ASSEMBLY IN ORDER TO ENSURE THAT THE TENSION FORCE CABLE DOES NOT MOVE OUT OF POSITION. VEHICLES MANUFACTURED BEGINNING ON NOVEMBER 8, 2001, ALREADY HAVE THE EXTENDED GUIDE, WHICH ACCOMPLISHES THE SAME OBJECTIVE. THE RECALL BEGAN MARCH 21, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
03V135000 · Seats:mid/rear Assembly
Apr 3, 2003
ON CERTAIN PASSENGER VEHICLES, SOME OF THE SECOND AND THIRD ROW SEAT STRIKERS INSTALLED ON THE VEHICLE FLOOR PAN HAVE BEEN IMPROPERLY HEAT TREATED AND COULD BREAK IN A CRASH.
Consequence & remedy
Consequence: THIS COULD RESULT IN INJURIES TO OCCUPANTS OF THESE SEATS.
Remedy: DEALERS WILL REPLACE THE SEAT STRIKERS. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542
03V017000 · Seat Belts:rear/other
Jan 22, 2003
CERTAIN MINI VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE SECOND AND THIRD SEAT BELT BUCKLE ANCHOR BOLTS DO NOT COMPLY WITH THE STANDARDS.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE ANCHOR BOLTS. OWNER NOTIFICATION BEGAN FEBRUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.