BEFORE THE INCIDENT THERE WERE ISSUES WITH THE REAR CAPTAIN CHAIRS SEAT BELT LATCH WHEN TRYING TO BUCKLE THEM. I HAVE THREE SMALL CHILDREN UNDER THE AGE OF 3 YEARS OF AGE AND IT IS VERY IMPORTANT AND CRUCIAL THAT SEAT BELTS ARE IN WORKING ORDER WITHOUT ISSUES FOR THE SAFETY OF THEIR WELL BEING. BEFORE THE INCIDENT THE SEATS THEM…
Read full complaint
BEFORE THE INCIDENT THERE WERE ISSUES WITH THE REAR CAPTAIN CHAIRS SEAT BELT LATCH WHEN TRYING TO BUCKLE THEM. I HAVE THREE SMALL CHILDREN UNDER THE AGE OF 3 YEARS OF AGE AND IT IS VERY IMPORTANT AND CRUCIAL THAT SEAT BELTS ARE IN WORKING ORDER WITHOUT ISSUES FOR THE SAFETY OF THEIR WELL BEING. BEFORE THE INCIDENT THE SEATS THEMSELVES IN THE REAR ROWS HAD ISSUES LATCHING AS WELL WHEN BEING INSTALLED. ON AUGUST 18, 2015 MYSELF AND THREE SMALL CHILDREN WERE IN A SEVERE HIGH IMPACT ACCIDENT AND NONE OF THE AIRBAGS HAD GONE OFF LIKE THEY NEVER EXISTED. MY KIDS AND I SUFFER FROM SEAT BELT ABRASIONS AND I SUFFER FROM BRUISING IN MULTIPLE PLACES FROM MY HEAD DOWN, SHOULDER PAIN AND BACK ISSUES. POLICE, PARAMEDIC'S, COLLISION CENTER, WITNESSES, AND MY INSURANCE COMPANY WERE ALL NOTIFIED OR HAD NOTIFIED ABOUT THE AIRBAGS. APPARENTLY, MY SEAT WHICH WAS THE DRIVER SEAT WAS ALSO COMPLETELY SNAPPED OFF AS WELL. UPDATED 08/26/15*BF
NHTSA ODI #10750433
92,000 miles · Mar 18, 2014
Air BagsCrashInjury
TL* THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH AND CRASHED INTO THE REAR ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUFFERED HEAD, NECK AND BACK INJURIES. THE VEHICLE WAS DESTROYED AND A POLICE REPORT WAS FILED AT THE SCENE. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE…
Read full complaint
TL* THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH AND CRASHED INTO THE REAR ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUFFERED HEAD, NECK AND BACK INJURIES. THE VEHICLE WAS DESTROYED AND A POLICE REPORT WAS FILED AT THE SCENE. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS 92,000.
NHTSA ODI #10573181
187,376 miles · Nov 23, 2013
Air BagsCrash
DRIVING HOME AND A DEER JUMPED OUT IN FRONT OF MY VAN AND I HIT THE DEER AND TOTALED MY VAN BAD WHERE THE AIR BAGS SHOULD OF WENT OFF BUT IT DIDN'T NOW THERE'S A LIGHT ON THE DASH THAT LOOKS LIKE A GUY SITTING IN A SEAT WITH A BELT ON AND AN AIR BAG IN FRONT OF IT.
NHTSA ODI #10553509
90,000 miles · Nov 9, 2012
Air BagsSeat Belts
AIRBAG LIGHT WAS ILLUMINATING INTERMITTENTLY - TOOK TO DEALERSHIP FOR DIAGNOSTIC IN 2010. KIA DEALERSHIP IN TURNERSVILLE SAID THAT LIGHT ILLUMINATING WAS NORMAL AND NO ISSUE. I RECENTLY HAD TIMING CHAIN REPLACED BY SAME DEALERSHIP - DIFFERENT TECH. THIS TIME THEY SAID THAT THE LIGHT MEANT THE AIRBAGS WOULD NOT DEPLOY IN AN ACCID…
Read full complaint
AIRBAG LIGHT WAS ILLUMINATING INTERMITTENTLY - TOOK TO DEALERSHIP FOR DIAGNOSTIC IN 2010. KIA DEALERSHIP IN TURNERSVILLE SAID THAT LIGHT ILLUMINATING WAS NORMAL AND NO ISSUE. I RECENTLY HAD TIMING CHAIN REPLACED BY SAME DEALERSHIP - DIFFERENT TECH. THIS TIME THEY SAID THAT THE LIGHT MEANT THE AIRBAGS WOULD NOT DEPLOY IN AN ACCIDENT! THEY SAID REPAIRS WOULD NOT BE COVERED! I AM FURIOUS. *TR
NHTSA ODI #10483838
100,000 miles · Oct 11, 2011
Air Bags
TL* THE CONTACT OWNS A 2002 KIA SEDONA. THE CONTACT WAS DRIVING 45 MPH WHEN THE DRIVER AND PASSENGER SIDE AIR BAGS DEPLOYED INDEPENDENTLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER, BUT THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 100,000.
NHTSA ODI #10429415
84,000 miles · Sep 4, 2007
Air BagsSeat Belts
TL*THE CONTACT OWNS A 2002 KIA SEDONA. WHILE DRIVING LESS THAN 25 MPH, THE CONTACT NOTICED THAT THE AIR BAG LIGHT WAS ILLUMINATED. THE DEALER STATED THAT THE SEAT BELT SENSOR FAILED AND CAUSED THE AIR BAG LIGHT TO ILLUMINATE. NO REPAIRS HAVE BEEN MADE AS OF YET. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE …
Read full complaint
TL*THE CONTACT OWNS A 2002 KIA SEDONA. WHILE DRIVING LESS THAN 25 MPH, THE CONTACT NOTICED THAT THE AIR BAG LIGHT WAS ILLUMINATED. THE DEALER STATED THAT THE SEAT BELT SENSOR FAILED AND CAUSED THE AIR BAG LIGHT TO ILLUMINATE. NO REPAIRS HAVE BEEN MADE AS OF YET. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 84,000. UPDATED 09/19/TR *TR
NHTSA ODI #10201789
84,000 miles · Sep 4, 2007
Air BagsElectrical System
4 MONTHS AGO MY ALTERNATOR WENT, TAKING WITH IT MY ENTIRE ELECTRICAL SYSTEM. AFTER EVERYTHING WAS FIXED BY THE REPAIR SHOP OF MY CHOICE, THE AIRBAG LIGHT WAS STILL ON AND COULD NOT BE RESET BECAUSE KIA WILL NOT RELEASE THE CODES TO DO SO. I TOOK IT TO THE DEALER WHO INSPECTED THE VEHICLE AND $90 LATER SIMPLY RESET THE CODES TO…
Read full complaint
4 MONTHS AGO MY ALTERNATOR WENT, TAKING WITH IT MY ENTIRE ELECTRICAL SYSTEM. AFTER EVERYTHING WAS FIXED BY THE REPAIR SHOP OF MY CHOICE, THE AIRBAG LIGHT WAS STILL ON AND COULD NOT BE RESET BECAUSE KIA WILL NOT RELEASE THE CODES TO DO SO. I TOOK IT TO THE DEALER WHO INSPECTED THE VEHICLE AND $90 LATER SIMPLY RESET THE CODES TO CLEAR THE LIGHT. NOW I FIND MYSELF WITH THE LIGHT ON AGAIN, AND MY 2002 KIA SEDONA AT THE DEALERSHIP TO FIND OUT WHY. OF COURSE, IT CANNOT BE AS SIMPLE AS THE CODE NEEDING TO BE RESET, AND I HAVE BEEN INFORMED THAT THERE IS A FAULTY SENSOR IN THE SEATBELT MECHANISM THAT WILL NEED TO BE REPLACED. THIS WILL COST $200 + TO HAVE DONE. IT IS MY UNDERSTANDING THAT THIS IS A RECURRENT PROBLEM WITH KIA SEDONAS AND I CANNOT UNDERSTAND WHY IT IS NOT A RECALL ITEM. MY SISTER-IN-LAW HAS HAD TO REPLACE THEIRS TWO TIMES NOW, MY FATHER-IN-LAW HAS HAD TO REPLACE HIS AT LEAST ONE TIME, AND MY SISTER-IN-LAWS MOTHER-IN-LAW HAS HAD TO REPLACE HERS AT LEAST TWICE. THESE ARE JUST FAMILY MEMBERS, AND I CAN ONLY IMAGINE HOW MANY OTHER PEOPLE ARE HAVING THIS PROBLEM. ON THIS SITE ALONE I HAVE FOUND SEVERAL, NOT TO MENTION OTHER MESSAGE BOARDS SHOWING THE SAME COMPLAINTS. AT WHAT POINT DOES A COMPLAINT LIKE THIS GET INVESTIGATED TO BE RECALLED? THIS IS A SERIOUS SAFETY ISSUE THAT NEEDS TO BE TAKEN CARE OF AND I IMPLORE YOU TO INVESTIGATE INTO THIS MALFUNCTION. THANK YOU. *TR UPDATED 09/19/07 *TR
NHTSA ODI #10201779
50,000 miles · May 2, 2007
Air BagsCrashInjury
THE AIR BAG DID NOT DEPLOY IN OUR 2002 KIA SEDONA. *TR
NHTSA ODI #10189594
88,302 miles · Jul 10, 2006
Air BagsSeat Belts
BACK IN 2003, THE AIRBAG LIGHT ON MY VAN CAME ON AND WOULD NOT GO AWAY. IT WAS UNDER WARRANTY. THE PROBLEM WAS A DEFECTIVE PASSENGER SIDE SEAT BELT BUCKLE. THAT WAS REPLACED. NOW IN 2005 THE AIRBAG LIGHT CAME ON AND WOULD NOT GO AWAY AGAIN. MY WARRANTY HAS EXPIRED, SO I TRIED FINDING OUT WHAT THE PROBLEM WAS MYSELF. IT WAS THE …
Read full complaint
BACK IN 2003, THE AIRBAG LIGHT ON MY VAN CAME ON AND WOULD NOT GO AWAY. IT WAS UNDER WARRANTY. THE PROBLEM WAS A DEFECTIVE PASSENGER SIDE SEAT BELT BUCKLE. THAT WAS REPLACED. NOW IN 2005 THE AIRBAG LIGHT CAME ON AND WOULD NOT GO AWAY AGAIN. MY WARRANTY HAS EXPIRED, SO I TRIED FINDING OUT WHAT THE PROBLEM WAS MYSELF. IT WAS THE SAME PASSENGER SIDE SEAT BELT BUCKLE. THE PROBLEM WAS A BROKEN WIRE IN THE HARNESS TO THE SENSOR. THE CAUSE WAS A METAL CLIP THAT PINCHES THE HARNESS, AND WITH THE MOVEMENT OF PUTTING THE SEAT BELT ON AND OFF, EVENTUALLY LEADING TO THE WIRE BREAKAGE. THAT I FIXED MYSELF AND AIRBAG LIGHT WENT OUT. IN 2006, THE AIRBAG LIGHT CAME BACK ON AND WOULD NOT GO OUT. THE PROBLEM NOW IS THE DRIVER SIDE SEAT BELT BUCKLE, ONCE AGAIN A BROKEN WIRE AT THE CLIP. ONCE AGAIN MY WARRANTY HAS EXPIRED SO I AM GOING TO FIX IT MYSELF. THIS KIND OF PROBLEM CAN BE FIXED IF THE CLIPS ARE REMOVED, EXTENDING THE LIFE OF THE SENSING UNIT. I AM SURE THAT THERE ARE MANY OTHERS WITH THAT SAME PROBLEM. I WOULD LIKE TO SEE THIS DEFECT FIXED. *JB
NHTSA ODI #10162003
70,000 miles · Mar 17, 2006
Air BagsSeat Belts
DT*: THE CONTACT STATED THE AIR BAG WARNING LIGHT ILLUMINATED SHORTLY AFTER THE VEHICLE WAS STARTED. PREVIOUSLY, THE VEHICLE WAS REPAIRED UNDER RECALL CAMPAIGN #03V17000 REGARDING THE SEAT BELTS. BEFORE THE RECALL WORK WAS COMPLETED THE AIR BAG WARNING LIGHT WAS ILLUMINATED. ONCE THE REPAIR WAS MADE THE LIGHT WENT OFF. THE C…
Read full complaint
DT*: THE CONTACT STATED THE AIR BAG WARNING LIGHT ILLUMINATED SHORTLY AFTER THE VEHICLE WAS STARTED. PREVIOUSLY, THE VEHICLE WAS REPAIRED UNDER RECALL CAMPAIGN #03V17000 REGARDING THE SEAT BELTS. BEFORE THE RECALL WORK WAS COMPLETED THE AIR BAG WARNING LIGHT WAS ILLUMINATED. ONCE THE REPAIR WAS MADE THE LIGHT WENT OFF. THE CONTACT IS CONCERNED THE SAME SEAT BELT PROBLEM HAS RETURNED, BUT HAS NOT MADE AN APPOINTMENT WITH THE DEALER FOR INSPECTION.
ON CERTAIN MINI VANS, DURING ASSEMBLY, THE THROTTLE CABLE WOULD TWIST ITSELF OUT OF POSITION.
Consequence & remedy
Consequence: THIS CAN PERMIT THE CABLE TO BE HUNG UP, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE FREE OF CHARGE. VEHICLES PRODUCED FROM MARCH 20, 2001 THROUGH NOVEMBER 7, 2001 WILL HAVE A GUIDE CLIP INSTALLED ON THE THROTTLE BODY ASSEMBLY IN ORDER TO ENSURE THAT THE TENSION FORCE CABLE DOES NOT MOVE OUT OF POSITION. VEHICLES MANUFACTURED BEGINNING ON NOVEMBER 8, 2001, ALREADY HAVE THE EXTENDED GUIDE, WHICH ACCOMPLISHES THE SAME OBJECTIVE. THE RECALL BEGAN MARCH 21, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN PASSENGER VEHICLES, SOME OF THE SECOND AND THIRD ROW SEAT STRIKERS INSTALLED ON THE VEHICLE FLOOR PAN HAVE BEEN IMPROPERLY HEAT TREATED AND COULD BREAK IN A CRASH.
Consequence & remedy
Consequence: THIS COULD RESULT IN INJURIES TO OCCUPANTS OF THESE SEATS.
Remedy: DEALERS WILL REPLACE THE SEAT STRIKERS. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542
CERTAIN MINI VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE SECOND AND THIRD SEAT BELT BUCKLE ANCHOR BOLTS DO NOT COMPLY WITH THE STANDARDS.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE ANCHOR BOLTS. OWNER NOTIFICATION BEGAN FEBRUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
2002 Kia Sedona Problems, Complaints & Recalls | Skip That Year
Illustration