2002 Kia Rio

2002 KIA RIO. CONSUMER STATES TIMING BELT FAILED *TGW THE CONSUMER STATED THE TIMING BELT FAILED FOR A SECOND TIME AT 59,059 AND DESTROYED THE SECOND ENGINE. THE CONSUMER WAS INFORMED THE VEHICLE WOULD NOT BE COVERED UNDER WARRANTY, BECAUSE THE ORIGINAL TIMING BELT WAS NOT REPLACED AT THE PROPER MILEAGE. THE CONSUMER STATED THE ORIGINAL TIMING BELT WAS REPLACED AT 53,668 AND THE REPLACEMENT BELT FAILED AT 59,059 BEFORE THE RECOMMENDED 60,000. A KIA REPRESENTATIVE INFORMED THE CONSUMER THE WARRANTY ONLY EXTENDED TO THE ORIGINAL ENGINE, NOT THE REPLACEMENT ENGINE. *JB

WE WERE JUST 10 MINUTES DRIVING FROM HOME, WHEN WE SAW THE SMOKE COMING FROM FRONT OF THE CAR. WE WERE APPROACHING THE LIGHT SO THE SPEED WAS ABOUT 10 MILES . WITHIN 5/6 METERS WE STOPPED IN TURN LINE AND TURNED OFF THE ENGINE. THE SMOKE GOT MORE AND MORE. SO WE GET OUT OF THE CAR AND WE WERE JUST SHOCKED. SOMEBODY TOLD US CALL 911 AND WE DID AND WE CALLED FIRE FIGHTERS AS WELL. DURING THAT PERIOD FIRE WAS COMING OUT OF THE BONNET AND OTHER CARS WERE AROUND US. I WAS JUST AFRAID OF EXPLOSION . IN COUPLE OF MINUTES POLICE CAME AND BLOCK THE ROAD. THEN FIRE FIGHTERS CAME AND PUT THE FIRE OUT. BUT OUR CAR WAS TOTALLY DAMAGED AND OUT OF ORDER. WE TOWED IT TO THE AUTO BODY AND SOME DAYS LATER THEY TOLD CAN'T DO ANYTHING WITH IT.

I GOT THE SECOND HAND 2002 KIA RIO 4 MONTHS AGO . ME AND MY WIFE WERE DRIVING FOR 1 MILE WHEN THE SMELL OF SMOKE CAME AND IN THE COUPLE OF SECONDS THERE WAS SMOKE CAME FROM THE BONNET. I SWITCHED OFF AND TRIED TO OPEN THE BONNET BUT THE SMOKE GOT MORE AND MORE ,SO WE LEFT THE CAR IMMEDIATELY AND WE SAW FLAMES CAME FROM RIGHT PART OF THE BONNET. WE WERE JUST SHOCKED AND SCARED OF FIRE. WE CALLED 911 AND FIREFIGHTERS AND IN LESS THAN TEN MINUTES FRONT PART OF THE CAR WAS TOTALLY RUINED. LOOKING OPTIMISTICALLY THERE WAS NO INJURY AT ALL . BUT HOW ABOUT THE NEXT ONE! CAN EVERYBODY BE LUCKY AS WE WERE?! WE WERE JUST IN THE MIDDLE OF THE TURN LINE IN MIDDLE OF THE STREET , SO OTHER CARS WERE AROUND US I CAN NOT IMAGINE WHAT COULD HAPPENED IF I WAS IN FREEWAY OR IF MY WIFE WAS ALONE!? *TR

TL*THE CONTACT OWNS A 2002 KIA RIO. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 2-5 MPH IN THE RESIDENCE DRIVEWAY, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THEY INFORMED THAT THE FAILURE WAS RELATED TO THE TIMING BELT. THE TECHNICIAN ADVISED THAT THE ENGINE WOULD NEED TO BE REPLACED. ALSO, PREVIOUSLY THE SPARK PLUGS, AND CRANK SHAFT POSITION SENSOR WERE REPLACED BY THE DEALER. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLIANT. THE FAILURE MILEAGE WAS 103,000. UPDATED 01/14/11 *BF UPDATED 03/01/11 UPDATED 04/1511

WHILE MY DAUGHTER WAS DRIVING HER 2002 KIA RIO, ALL OF A SUDDEN THE CAR JUST STOPPED RUNNING AND WOULD NOT START UP. THERE WAS NO PRIOR INDICATION THAT ANYTHING WAS WRONG - NO LIGHT OR INDICATORS ON. HAD IT TOWED TO OUR MECHANIC - ENGINE WAS LOCKED UP. HE DIDN'T KNOW FOR SURE WHY - OIL AND COOLANT WERE FINE. WE DIDN'T WANT TO PAY TO HAVE THE REASON DIAGNOSED, AS IT DOESN'T REALLY MATTER WHAT CAUSED IT - THE MOTOR IS SHOT. THIS CAR HAS BEEN REGULARLY MAINTAINED - OIL CHANGE EVERY 3000 MILES, REGULAR SERVICE AS RECOMMENDED IN THE BOOK. WE HAD TO HAVE THE TRANSMISSION REPLACED TWO YEARS AGO, AS IT JUST DECIDED TO DIE ALSO. *TR

KIA RIO 2002 THE CHECK ENGINE LIGHT WILL NOT GO OUT I TOOK IT TO GET CHECK OUT.EVERYTHING IS FINE.THERE IS NOTHING WRONG.THEY RESET THE CHECK ENGINE LIGHT AND IT CAME BACK ON.I WAS TOLD BUY A KIA DEALER SHIP IT IS A MANUFACTURER DEFECT. AND NOTHING CAN BE DONE.THIS IS BEEN GOING ON FOR FOUR YEARS NOW. I HAVE TO GET THE CHECK EVERY TIME THE INSPECTION IS DO AND HAVE THE LIGHT RESET. SO I CAN PASS THE INSPECTION. *TR

THE CAR BEGAN TO RUN HOT WHEN I WOULD BE BRIEFLY STOPPED FOR INSTANCE IN A DRIVE THROUGH RESTAURANT OR A LONGER TRAFFIC LIGHT. ONCE THE CAR BEGAN TO MOVE THE CAR COOLED DOWN. I HAD A MECHANIC FRIEND DO A TUNE UP ON MY CAR. HE SAID THE FAN HAS NO BLADES THEY HAVE DISINTEGRATED. THIS WAS OF CONCERN DUE TO THE FACT THERE HAS BEEN NO INJURY TO MY CAR SUCH AS AN ANIMAL IN THE ENGINE. *TR

ORIGINAL OWNER OF 2002 KIA RIO - TIMING BELT FAILED AT 93,000 MILES CAUSING TOTAL ENGINE FAILURE (INTERFERENCE ENGINE). TIMING BELT IS COVERED UNDER WARRANTY FOR 100,000 MILES FOR ORIGINAL OWNER ACCORDING TO THE MANUAL. KIA WOULD NOT HONOR WARRANTY. SEVERAL THOUSAND DOLLARS LATER, I HAD A REPLACEMENT ENGINE INSTALLED. IT FAILED 2,300 MILES LATER DUE TO THE CAMSHAFT SHEARING AND THE INTERFERENCE PROBLEMS. AGAIN, NOT COVERED UNDER WARRANTY. *TR

I HAVE TAKEN MY 2002 KIA RIO TO A CERTIFIED REPUTABLE MECHANIC. HIS DETERMINATION OF THE FAULTY ENGINE WAS DUE TO THE FACT OF A INFERIOR TIMING BELT. HIS STATEMENT WAS THAT THE TIMING BELT GAVE OUT AND THE ENGINE IS DESIGNED SO THAT BASICALLY WHEN THIS HAPPENS THE CRANKSHAFT AND VALVES RUIN ITSELF DUE TO THE BROKEN TIMING BELT. THIS HAPPENING LEAVES ME WITH BASICALLY A $2,000 DOLLAR LOSS ALL BECAUSE OF MAYBE A $100 PART. *TR

TL* - THE CONTACT OWNS A 2002 KIA RIO. WHILE DRIVING AT 35 MPH THE VEHICLE STALLED AND THE ENGINE LOST POWER. THE STEERING, THE BRAKES AND THE EMERGENCY BRAKE WERE LOCKED, THE CONTACT WAS UNABLE TO STEER THE VEHICLE OR STOP IT WHICH CAUSED A CRASH WITH A VAN. THE FAILURE MILEAGE WAS 77,000. THERE WERE NO INJURIES. THE VEHICLE WAS REPAIRED THREE TIMES DUE TO THE FAILURE. THE MECHANIC STATED THAT THE FAILURE WAS DUE TO THE FUEL INJECTION SYSTEM, AND LATER CLAIMED IT WAS THE TIMING BELT. THE CONTACT EXPERIENCED THE FAILURE AFTER THE VEHICLE WAS REPAIRED. ALL OF THE REPAIRS WERE AT COST TO THE CONTACT. THE DEALER STATED THERE WERE NO RECALLS FOR THIS YEAR, MAKE AND MODEL. ADVISED THE CONTACT OF NHTSA RECALL#04V179000: FUEL SYSTEM, GASOLINE:DELIVERY. THE CURRENT MILEAGE WAS 78,000. *AK CUSTOMER DID RECEIVE A RECALL LETTER IN THE MAIL. UPDATED 4/9 *TR