IllustrationFRONT PASSENGER SIDE DOOR WILL MOT OPEN FROM THE INSIDE OR OUTSIDE CAUSING YOU TO BE LOCKED IN THE VEHICLE. ALSO WHEN YOU TRY TO OPEN THE DOOR FROM INSIDE THE VEHICLE AUTOMATICALLY LOCKS THE CAR. THIS IS A SAFETY HAZARD THAT NEEDS TO BE ADDRESS.
2006 Kia Optima
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Kia Optima do not stand out strongly from the model-year median of 186.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Optima years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
410–25K
1225–50K
2950–75K
1575–100K
23100–150K
8150K+
128 reports with mileage · 27 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Latches/locks/linkages. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports1 fire reports2 injury reports
Structure complaints
12 reportsDRIVER'S SIDE DOOR WILL NOT OPEN FROM EITHER THE INSIDE OR THE OUTSIDE. THIS IS THE SECOND TIME THAT THIS HAS OCCURRED BUT I WAS ABLE TO FINALLY GET THE DOOR OPEN BEFORE AND DISENGAGED THE ACTUATOR. AS LONG AS NO ONE LOCKED THE DOOR, IT WORKED FINE, HOWEVER; MOTHER RECENTLY HAD WORK DONE ON HER CAR AND WHEN THEY RETURNED IT, THE…
Read full complaint
DRIVER'S SIDE DOOR WILL NOT OPEN FROM EITHER THE INSIDE OR THE OUTSIDE. THIS IS THE SECOND TIME THAT THIS HAS OCCURRED BUT I WAS ABLE TO FINALLY GET THE DOOR OPEN BEFORE AND DISENGAGED THE ACTUATOR. AS LONG AS NO ONE LOCKED THE DOOR, IT WORKED FINE, HOWEVER; MOTHER RECENTLY HAD WORK DONE ON HER CAR AND WHEN THEY RETURNED IT, THEY LOCKED THE DOOR. I'VE SPENT NUMEROUS HOURS TRYING TO GET THE DOOR OPEN SO THAT I CAN REPLACE THE MECHANISM AND ACTUATOR BUT HAVE BEEN UNSUCCESSFUL. AFTER LOOKING ONLINE, THIS SEEM TO BE AN ONGOING ISSUE WITH KIA, THIS IS A DANGEROUS CONDITION AND NEEDS TO BE LOOKED INTO. NOT SURE HOW LITTLE ELDERLY PEOPLE ARE EXPECTED TO SAFELY GET OUT OF THEIR VEHICLES IN CASE OF AN EMERGENCY. (THIS HAPPENED WHILE STATIONARY ON A FLAT, PAVED ROAD).
ONCE THE DOORS ARE LOCKED, THEY CAN NOT BE UNLOCKED FROM THE INSIDE. THE KEY MUST BE INSERTED INTO THE DRIVERS SIDE LOCK CYLINDER (OUTSIDE) AND MANIPULATED FOR SEVERAL MINUTES BACK AND FORTH WHILE AT THE SAME TIME PULLING ON THE HANDLE UNTIL THE RIGHT COMBINATION OF FORCE AND TIMING ALLOW THE DOOR TO BE OPENED. *TR
TL* THE CONTACT OWNS A 2006 KIA OPTIMA. WHILE ATTEMPTING TO EXIT THE VEHICLE, THE FRONT DRIVER SIDE DOOR FAILED TO UNLOCK FROM THE INSIDE. THE CONTACT HAD TO ROLL DOWN THE WINDOW AND USE THE EXTERIOR DOOR HANDLE IN ORDER TO UNLOCK THE DOOR. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTI…
Read full complaint
TL* THE CONTACT OWNS A 2006 KIA OPTIMA. WHILE ATTEMPTING TO EXIT THE VEHICLE, THE FRONT DRIVER SIDE DOOR FAILED TO UNLOCK FROM THE INSIDE. THE CONTACT HAD TO ROLL DOWN THE WINDOW AND USE THE EXTERIOR DOOR HANDLE IN ORDER TO UNLOCK THE DOOR. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 40,000.
I CAN NOT OPEN THE PASSENGER DOOR. *JS
IT IS A WELL-KNOWN ISSUE WITH KIA OPTIMA CARS THAT THE DOOR LATCH IS FAULTY, AND AFTER VARIOUS LENGTHS OF TIME, IT WILL STOP UNLOCKING. BY NO LONGER UNLOCKING, I MEAN UNDER ANY CONDITION. USING A REMOTE, USING THE KEY, EVEN SITTING IN THE VEHICLE PRESSING THE BUTTON ON THE DOOR OR MANUALLY MOVING THE INDICATOR BY THE HANDLE. …
Read full complaint
IT IS A WELL-KNOWN ISSUE WITH KIA OPTIMA CARS THAT THE DOOR LATCH IS FAULTY, AND AFTER VARIOUS LENGTHS OF TIME, IT WILL STOP UNLOCKING. BY NO LONGER UNLOCKING, I MEAN UNDER ANY CONDITION. USING A REMOTE, USING THE KEY, EVEN SITTING IN THE VEHICLE PRESSING THE BUTTON ON THE DOOR OR MANUALLY MOVING THE INDICATOR BY THE HANDLE. THIS IS A SEVERE SAFETY ISSUE. IN THE EVENT OF A WRECK OR OTHER EMERGENCY SITUATION, IT IS IMPOSSIBLE TO EXIT THE DRIVER'S SIDE DOOR ON MY KIA OPTIMA. NO MATTER WHAT YOU ATTEMPT, THE DOOR WILL NOT OPEN. WHEN YOU UNLOCK IT USING ANY OF THE AFOREMENTIONED METHODS, THE CAR WILL AUTOMATICALLY RE-LOCK THE DOOR AS SOON AS YOU TOUCH THE HANDLE, EITHER INTERIOR OR EXTERIOR. WHILE I CAN UNDERSTAND NORMAL WEAR AND TEAR EATING AWAY AT THE COMPONENT, THERE IS ABSOLUTELY NO REASON FOR THE CAR TO DEFAULT TO THE LOCK POSITION IN THE CASE OF SUCH WEAR AND TEAR. A SIMPLE SOLUTION WOULD BE TO HAVE THE LATCH DEFAULT TO THE OPEN POSITION, WHICH WILL ALLOW PERSONS TO EXIT THE VEHICLE IN CASE OF EMERGENCY. IF THIS HAS NOT ALREADY COST INDIVIDUALS THEIR LIFE, I AM SURE IT IS ONLY A MATTER OF TIME. THIS NEEDS TO BE CORRECTED IMMEDIATELY, BEFORE IT COSTS ME MY FAMILY. *TR
THE DRIVERS SIDE DOOR LOCK WILL NOT UNLOCK WITH THE ELECTRICAL BUTTON OR MANUALLY. THE LOCK ONLY OPENS HALF WAY - PULL HANDLE TO OPEN - DOOR AUTOMATICALLY LOCKS. CAN'T OPEN DOOR WITH KEY FROM OUTSIDE. MUST ENTER IN PASSENGER SIDE DOOR AND CLIMB OVER. BIG DANGER AS DRIVING WITH CHILDREN IN THE CAR. *TR
I WAS TRAPPED INSIDE THE CAR WHEN THE DRIVERS DOOR WOULD NOT OPEN BY ACTIVATING THE INSIDE DOOR HANDLE, THE INSIDE DOOR UNLOCK LEVER OR THE REMOTE KEY FOB. WHEN I USED THE DOOR HANDLE NOTHING HAPPENED. WHEN I PRESSED THE INSIDE DOOR UNLOCK LEVER I COULD HEAR THE POWER UNLOCK MECHANISM ACTIVATE BUT THE DOOR WOULD NOT OPEN. NOR WO…
Read full complaint
I WAS TRAPPED INSIDE THE CAR WHEN THE DRIVERS DOOR WOULD NOT OPEN BY ACTIVATING THE INSIDE DOOR HANDLE, THE INSIDE DOOR UNLOCK LEVER OR THE REMOTE KEY FOB. WHEN I USED THE DOOR HANDLE NOTHING HAPPENED. WHEN I PRESSED THE INSIDE DOOR UNLOCK LEVER I COULD HEAR THE POWER UNLOCK MECHANISM ACTIVATE BUT THE DOOR WOULD NOT OPEN. NOR WOULD THE DOOR OPEN WHEN THE REMOTE KEY FOB UNLOCK WAS PRESSED EVEN THOUGH I COULD HEAR THE UNLOCK MECHANISM ACTIVATE. THE DOOR LATCH WOULD NOT RELEASE AND ALLOW THE DOOR TO OPEN. I HAD TO CRAWL ACROSS THE FRONT CONSOLE TO EXIT THE CAR THRU THE PASSENGER DOOR. DUE TO THE SMALL SIZE OF THE CAR THIS COULD EASILY HAVE BEEN IMPOSSIBLE WITH AN INJURY OR FOR AN ELDERLY PERSON. IN CASE OF A FIRE WHERE THE ONLY EXIT WAS THRU THE DRIVERS DOOR THIS WOULD BE A FATAL COMPONENT FAILURE. AFTER EXITING THRU THE PASSENGER DOOR I TRIED TO UNLOCK THE DOOR WITH THE KEY BUT THE LATCH WOULD NOT RELEASE THE DOOR. I TRIED PRESSING AND RELEASING THE REMOTE UNLOCK WITH AND WITHOUT THE KEY MULTIPLE TIMES USING MULTIPLE COMBINATIONS OF THE DOOR HANDLE, DOOR UNLOCK LEVER AND REMOTE KEY FOB, NOTHING WORKED. THIS IS A VERY DANGEROUS SITUATION. THE DOOR HANDLE AND DOOR KEY SHOULD ALWAYS FUNCTION TO ALLOW EXIT FROM THE CAR. *TR
TL* THE CONTACT OWNS A 2006 KIA OPTIMA. THE CONTACT STATED THAT HE WAS UNABLE TO UNLOCK AND OPEN THE FRONT DRIVER'S SIDE DOOR FROM THE INTERIOR OR EXTERIOR. AFTER APPROXIMATELY TWENTY ATTEMPTS, THE CONTACT WAS ABLE TO SUCCESSFULLY UNLOCK AND OPEN THE DOOR. THE FAILURE HAD SINCE RECURRED ON AN INTERMITTENT BASIS. THE VEHICLE WAS …
Read full complaint
TL* THE CONTACT OWNS A 2006 KIA OPTIMA. THE CONTACT STATED THAT HE WAS UNABLE TO UNLOCK AND OPEN THE FRONT DRIVER'S SIDE DOOR FROM THE INTERIOR OR EXTERIOR. AFTER APPROXIMATELY TWENTY ATTEMPTS, THE CONTACT WAS ABLE TO SUCCESSFULLY UNLOCK AND OPEN THE DOOR. THE FAILURE HAD SINCE RECURRED ON AN INTERMITTENT BASIS. THE VEHICLE WAS NOT TAKEN TO HAVE THE VEHICLE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000.
DOOR JAM ON RIGHT BACK DOOR AND SUN VISORS ON RIGHT PASSENGER OVER VIEW JUST DROPS DOWN IN THE PASSENGER OR CHILD VIEW THATS CAUSES ONE TO BECOME FEARFUL. *TR
Official recalls
212V014000 · Air Bags:frontal
Jan 17, 2012
KIA MOTORS AMERICA, INC. (KIA) IS RECALLING CERTAIN MODEL YEAR 2006-2008 KIA OPTIMA VEHICLES MANUFACTURED FROM SEPTEMBER 29, 2005, THROUGH JANUARY 29, 2008, AND MODEL YEAR 2007 AND 2008 KIA RONDO VEHICLES MANUFACTURED FROM SEPTEMBER 13, 2006, THROUGH MARCH 21, 2008. THE CLOCK SPRING CONTACT ASSEMBLY FOR THE DRIVER'S SIDE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) MAY BECOME DAMAGED THROUGH USAGE OVER TIME. IF THE CLOCK SPRING CONTACT ASSEMBLY BECOMES DAMAGED, THE DRIVER'S AIR BAG ELECTRICAL CIRCUIT WILL EXPERIENCE A HIGH RESISTANCE CONDITION POTENTIALLY CAUSING THE DRIVER'S AIR BAG TO NOT DEPLOY.
Consequence & remedy
Consequence: IF THE CLOCK SPRING DEVELOPS HIGH RESISTANCE, IN THE EVENT OF A CRASH, THE DRIVERS AIR BAG WILL NOT DEPLOY AND WILL NOT BE ABLE TO PROPERLY PROTECT THE DRIVER, INCREASING THE RISK OF INJURIES.
Remedy: KIA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE VEHICLE'S AIR BAG CLOCK SPRING CONTACT ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 11, 2012. OWNERS MAY CONTACT KIA CUSTOMER ASSISTANCE CENTER AT 1-800-333-4542.
11V153000 · Power Train:automatic Transmission:lever And Linkage:column Shift
Mar 9, 2011
KIA IS RECALLING CERTAIN MODEL YEAR 2006-2008 OPTIMA VEHICLES MANUFACTURED FROM SEPTEMBER 29, 2005, THROUGH JUNE 13, 2007. THERE IS A POSSIBILITY THAT THE SHIFT CABLE MAY HAVE BEEN INSTALLED INCORRECTLY, CAUSING TENSION IN THE CABLE. IF PRESENT, THIS CONDITION COULD CAUSE THE CABLE TO DETACH FROM THE SHIFTER ASSEMBLY'S DOWEL PIN PREVENTING THE TRANSMISSION FROM BEING SHIFTED. THE SHIFT LEVER CAN THEN BE MOVED INTO THE PARK (P) POSITION WHILE THE VEHICLE'S TRANSMISSION IS STILL IN THE LAST USED GEAR BEFORE DETACHMENT.
Consequence & remedy
Consequence: IF THE DRIVER LEAVES THE VEHICLE WITHOUT ENGAGING THE PARKING BRAKE, THERE IS A POSSIBILITY THAT THE VEHICLE CAN ROLL INJURE A PERSON IN ITS PATH OR CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE SHIFT CABLE AND REINSTALL IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 23, 2011. OWNER MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
PE10046 · Transmission Shift Cable Detachment
Opened Nov 22, 2010 · Closed Apr 5, 2011
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:floor Shift
During manufacture the automatic transmission shift cables in certain subject vehicles were installed incorrectly causing extra tension on the cable.This condition can cause the shift cable to detach from the gear shifter assembly's dowel pin preventing the transmission from being shifted.The shift lever can be moved into the Park (P) position while the vehicle transmission is still in the last used gear before detachment.If this were to occur, and if the driver leaves the vehicle without engaging the parking brake, the vehicle may inadvertently roll away thus creating the risk of a crash.Kia is conducting a safety recall (11V-153) to correct the subject problem in approximately 70,115 model year (MY) 2006 through 2008 Kia Optima vehicles produced from 9/29/2005 to 6/13/2007.Kia has stated that the early MY 2006 Optima vehicles built before 9/29/2005 had different automatic transmission shift cables and shift levers than the subsequent MY 2006 through early MY 2008 Optima vehicles built up to 6/13/2007.Beginning 6/14/2007, Kia changed the assembly process for the shift cables to ensure correct installation.As for the recall remedy, Kia dealers will inspect the shift cables for correct installation, and re-install them, if necessary.For more details on the recall, see NHTSA recall 11V-153.This investigation is closed.
Additional source detail variants (3)
Power Train:automatic Transmission:gear Position Indication (prndl)
During manufacture the automatic transmission shift cables in certain subject vehicles were installed incorrectly causing extra tension on the cable.This condition can cause the shift cable to detach from the gear shifter assembly's dowel pin preventing the transmission from being shifted.The shift lever can be moved into the Park (P) position while the vehicle transmission is still in the last used gear before detachment.If this were to occur, and if the driver leaves the vehicle without engaging the parking brake, the vehicle may inadvertently roll away thus creating the risk of a crash.Kia is conducting a safety recall (11V-153) to correct the subject problem in approximately 70,115 model year (MY) 2006 through 2008 Kia Optima vehicles produced from 9/29/2005 to 6/13/2007.Kia has stated that the early MY 2006 Optima vehicles built before 9/29/2005 had different automatic transmission shift cables and shift levers than the subsequent MY 2006 through early MY 2008 Optima vehicles built up to 6/13/2007.Beginning 6/14/2007, Kia changed the assembly process for the shift cables to ensure correct installation.As for the recall remedy, Kia dealers will inspect the shift cables for correct installation, and re-install them, if necessary.For more details on the recall, see NHTSA recall 11V-153.This investigation is closed.
Power Train:automatic Transmission
During manufacture the automatic transmission shift cables in certain subject vehicles were installed incorrectly causing extra tension on the cable.This condition can cause the shift cable to detach from the gear shifter assembly's dowel pin preventing the transmission from being shifted.The shift lever can be moved into the Park (P) position while the vehicle transmission is still in the last used gear before detachment.If this were to occur, and if the driver leaves the vehicle without engaging the parking brake, the vehicle may inadvertently roll away thus creating the risk of a crash.Kia is conducting a safety recall (11V-153) to correct the subject problem in approximately 70,115 model year (MY) 2006 through 2008 Kia Optima vehicles produced from 9/29/2005 to 6/13/2007.Kia has stated that the early MY 2006 Optima vehicles built before 9/29/2005 had different automatic transmission shift cables and shift levers than the subsequent MY 2006 through early MY 2008 Optima vehicles built up to 6/13/2007.Beginning 6/14/2007, Kia changed the assembly process for the shift cables to ensure correct installation.As for the recall remedy, Kia dealers will inspect the shift cables for correct installation, and re-install them, if necessary.For more details on the recall, see NHTSA recall 11V-153.This investigation is closed.
Power Train:automatic Transmission:lever And Linkage:floor Shift
During manufacture the automatic transmission shift cables in certain subject vehicles were installed incorrectly causing extra tension on the cable.This condition can cause the shift cable to detach from the gear shifter assembly's dowel pin preventing the transmission from being shifted.The shift lever can be moved into the Park (P) position while the vehicle transmission is still in the last used gear before detachment.If this were to occur, and if the driver leaves the vehicle without engaging the parking brake, the vehicle may inadvertently roll away thus creating the risk of a crash.Kia is conducting a safety recall (11V-153) to correct the subject problem in approximately 70,115 model year (MY) 2006 through 2008 Kia Optima vehicles produced from 9/29/2005 to 6/13/2007.Kia has stated that the early MY 2006 Optima vehicles built before 9/29/2005 had different automatic transmission shift cables and shift levers than the subsequent MY 2006 through early MY 2008 Optima vehicles built up to 6/13/2007.Beginning 6/14/2007, Kia changed the assembly process for the shift cables to ensure correct installation.As for the recall remedy, Kia dealers will inspect the shift cables for correct installation, and re-install them, if necessary.For more details on the recall, see NHTSA recall 11V-153.This investigation is closed.