NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
22 reportsClear category filterMileage unknown · Apr 18, 2022
Structure
driver side door lock does not open using the arm rest switch. wife was in the car could reach the switch but not the unlatch lever . Car was overheating with Ac on with keys in the ignition . Had to have her roll down the passenger door window to manually open the rear passenger side door . From the rear seat I could reach t…
Read full complaint
driver side door lock does not open using the arm rest switch. wife was in the car could reach the switch but not the unlatch lever . Car was overheating with Ac on with keys in the ignition . Had to have her roll down the passenger door window to manually open the rear passenger side door . From the rear seat I could reach the lever and unlock the door. If I could not it would have been a fire hazard.
NHTSA ODI #11461246
Mileage unknown · Nov 16, 2018
Structure
THE DRIVER DOOR BECOME JAMMED AND SOMETIMES WILL NOT OPEN. YOU HAVE TO CONTINUOUSLY/EXCESSIVELY JERK ON IT. DUE TO NOT OPENING, I HAVE TO CRAWL THROUGH THE PASSENGER SIDE DOOR IN ORDER TO GAIN ENTRANCE INTO THE VEHICLE. NOT ONLY THAT, AFTER FINALLY GETTING THE DRIVER DOOR TO OPEN, I HAVE TO LEAVE IT CRACK TO AVOID THIS STRUGGLE.
NHTSA ODI #11151911
Mileage unknown · Sep 16, 2017
Structure
DRIVERS SIDE DOOR LOCKING MECHANISM MALFUNCTION. MECHANISM WILL NOT ALLOW THE DOOR TO UNLOCK, THEREFORE THE DOOR CAN NOT BE OPENED. DRIVER MUST CLIMB OUT OF PASSENGER SIDE.
NHTSA ODI #11023810
155,000 miles · Dec 31, 2015
Electrical SystemStructure
LOCKED CAR AFTER BUYING IT USED DRIVERS DOOR WILL NOT UNLOCK. MULTIPLE COMPLAINTS ONLINE ABOUT THIS PROBLEM. MY DAUGHTER WAS GOING TO DRIVE THIS THING. KIA DEALER DID NOT EVEN MENTION THIS TO ME, BUT DID SAY IT WAS 200 MINIMUM. I HOPE THIS GETS INVESTIGATED. IN AN ACCIDENT THE DOOR WILL NEVER OPEN. I DROVE THE CAR HOME AND AFTE…
Read full complaint
LOCKED CAR AFTER BUYING IT USED DRIVERS DOOR WILL NOT UNLOCK. MULTIPLE COMPLAINTS ONLINE ABOUT THIS PROBLEM. MY DAUGHTER WAS GOING TO DRIVE THIS THING. KIA DEALER DID NOT EVEN MENTION THIS TO ME, BUT DID SAY IT WAS 200 MINIMUM. I HOPE THIS GETS INVESTIGATED. IN AN ACCIDENT THE DOOR WILL NEVER OPEN. I DROVE THE CAR HOME AND AFTER 2 HOURS IT WILL NOT UNLOCK.
NHTSA ODI #10817234
128,000 miles · Oct 5, 2015
Electrical SystemStructure
TL* THE CONTACT OWNS A 2005 KIA OPTIMA. WHILE IN PARK, THE AUTOMATIC DOOR LOCKS FAILED. THE CONTACT ATTEMPTED TO USE THE REMOTE FOR ENTRY AND HEARD A CLICKING NOISE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000.
NHTSA ODI #10779855
75,000 miles · May 12, 2015
Structure
THE FRAME IS EXTENSIVE RUSTED TO THE POINT WHERE THE VEHICLE'S STRUCTURAL INTEGRITY HAS LIKELY BEEN COMPROMISED. NOTHING UNUSUAL HAS HAPPENED THAT WOULD CAUSE SUCH RUST, SUCH AS BACKING INTO SALT WATER, ETC. IT HAS BEEN DRIVEN ON SALTED NY ROADS BUT STILL, THE RUST IS EXTREME ON THIS VEHICLE EVEN WITH THAT TAKEN INTO CONSIDERATI…
Read full complaint
THE FRAME IS EXTENSIVE RUSTED TO THE POINT WHERE THE VEHICLE'S STRUCTURAL INTEGRITY HAS LIKELY BEEN COMPROMISED. NOTHING UNUSUAL HAS HAPPENED THAT WOULD CAUSE SUCH RUST, SUCH AS BACKING INTO SALT WATER, ETC. IT HAS BEEN DRIVEN ON SALTED NY ROADS BUT STILL, THE RUST IS EXTREME ON THIS VEHICLE EVEN WITH THAT TAKEN INTO CONSIDERATION. THE BODY HAS RUSTED EXTENSIVELY AS WELL, TO THE POINT WHERE THE REAR QUARTER PANELS BY THE REAR WHEEL ARCHES HAVE RUSTED COMPLETELY THROUGH.
NHTSA ODI #10715943
105,000 miles · May 12, 2015
Structure
FOR THE LAST FEW YEARS THE DRIVER'S SIDE DOOR LOCK HAS NOT WORKED PROPERLY. IT WILL LOCK WITHOUT PROBLEM BUT THEN WILL NOT UNLOCK. IT CANNOT BE UNLOCKED FROM WITHIN THE VEHICLE AT ALL. TO UNLOCK IT FROM OUTSIDE REQUIRES THAT THE DOOR BE UNLOCKED AT THE SAME TIME THE DOOR HANDLES IS PULLED OPEN. IT REQUIRES MULTIPLE TRIES TO GET …
Read full complaint
FOR THE LAST FEW YEARS THE DRIVER'S SIDE DOOR LOCK HAS NOT WORKED PROPERLY. IT WILL LOCK WITHOUT PROBLEM BUT THEN WILL NOT UNLOCK. IT CANNOT BE UNLOCKED FROM WITHIN THE VEHICLE AT ALL. TO UNLOCK IT FROM OUTSIDE REQUIRES THAT THE DOOR BE UNLOCKED AT THE SAME TIME THE DOOR HANDLES IS PULLED OPEN. IT REQUIRES MULTIPLE TRIES TO GET IT RIGHT - USUALLY IT TAKES A FEW MINUTES OF PLAYING WITH THE DOOR HANDLE AND KEY TO GET IT TO WORK PROPERLY.
NHTSA ODI #10715940
100,000 miles · Apr 30, 2015
Structure
TL* THE CONTACT OWNS A 2005 KIA OPTIMA. WHILE THE VEHICLE WAS PARKED, THE FRONT DRIVER SIDE DOOR WAS LOCKED AND FAILED TO OPEN FROM THE INSIDE OR OUTSIDE. THE CONTACT HAD TO GO THROUGH THE FRONT PASSENGER SIDE DOOR AND CLIMB OVER THE SEAT TO THE DRIVER'S SIDE. THE FAILURE RECURRED CONTINUOUSLY. THE VEHICLE WAS NOT TAKEN TO A DEA…
Read full complaint
TL* THE CONTACT OWNS A 2005 KIA OPTIMA. WHILE THE VEHICLE WAS PARKED, THE FRONT DRIVER SIDE DOOR WAS LOCKED AND FAILED TO OPEN FROM THE INSIDE OR OUTSIDE. THE CONTACT HAD TO GO THROUGH THE FRONT PASSENGER SIDE DOOR AND CLIMB OVER THE SEAT TO THE DRIVER'S SIDE. THE FAILURE RECURRED CONTINUOUSLY. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10713880
56,650 miles · Mar 17, 2015
Structure
KEY WILL NOT UNLOCK DRIVER'S DOOR AND DRIVER CANNOT UNLOCK DOOR FROM INSIDE VEHICLE. KIA MOTORS WILL NOT ISSUE A RECALL EVEN THOUGH THIS IS A MAJOR SAFETY ISSUE. CLIMBING OVER THE CENTER CONSOLE IS REQUIRED TO ENTER OR EXIT THE VEHICLE. THIS IS A FREQUENT ISSUE WITH KIA OPTIMA CARS, WELL KNOWN AND OFTEN WRITTEN UP ONLINE, THE PA…
Read full complaint
KEY WILL NOT UNLOCK DRIVER'S DOOR AND DRIVER CANNOT UNLOCK DOOR FROM INSIDE VEHICLE. KIA MOTORS WILL NOT ISSUE A RECALL EVEN THOUGH THIS IS A MAJOR SAFETY ISSUE. CLIMBING OVER THE CENTER CONSOLE IS REQUIRED TO ENTER OR EXIT THE VEHICLE. THIS IS A FREQUENT ISSUE WITH KIA OPTIMA CARS, WELL KNOWN AND OFTEN WRITTEN UP ONLINE, THE PART REQUIRED TO REPAIR THE VEHICLE IS SOLD ON EBAY BY MULTIPLE SELLERS ALWAYS. *TR
NHTSA ODI #10694950
80,000 miles · Nov 11, 2014
Electrical SystemStructure
DRIVER'S SIDE DOOR WOULD NOT OPEN. YOU COULD CLICK IT AND IT WOULD SOUND LIKE IT WAS GOING TO OPEN, BUT IT DIDN'T. HAD TO DRIVE TO A KIA STORE AND HAVE THE WHOLE ASSEMBLY REPLACED AT THE TUNE OF $450. INTERESTINGLY ENOUGH, THEY DID NOT SEEM TO THINK THIS WAS A COMMON PROBLEM, BUT I CAN SEE THERE ARE HUNDREDS OF COMPLAINTS ABO…
Read full complaint
DRIVER'S SIDE DOOR WOULD NOT OPEN. YOU COULD CLICK IT AND IT WOULD SOUND LIKE IT WAS GOING TO OPEN, BUT IT DIDN'T. HAD TO DRIVE TO A KIA STORE AND HAVE THE WHOLE ASSEMBLY REPLACED AT THE TUNE OF $450. INTERESTINGLY ENOUGH, THEY DID NOT SEEM TO THINK THIS WAS A COMMON PROBLEM, BUT I CAN SEE THERE ARE HUNDREDS OF COMPLAINTS ABOUT THIS PROBLEM. I HAD MY TWO YEAR OLD GRANDSON IN THE BACK SEAT AND WAS VERY WORRIED ABOUT GETTING STUCK IN THE CAR. IF THIS HAPPENS AGAIN, I WILL SELL THE CAR. THERE SEEM TO BE A LOT OF ELECTRICAL PROBLEMS ON THIS CAR. I REPLACE THE HEADLIGHTS AND TAILLIGHTS REGULARLY (ABOUT ONCE A MONTH) AND I AM ALWAYS HAVING THE ENGINE LIGHT COME ON, WHEN THERE IS NOTHING WRONG. HOW MANY OF THESE COMPLAINTS DO YOU NEED BEFORE SOMETHING IS DONE? OR DOES SOMEONE HAVE TO GET KILLED FIRST? *TR
NHTSA ODI #10654169
NHTSA investigations
2DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
Illustration