NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
29 reportsClear category filter146,156 miles · Aug 14, 2017
Electrical SystemUnknown Or Other
AFTER REPAIRING THE MASS AIR FLOW HOSE,PURGE VALVE,AND THE VALVE COVER GASKET. IT DIDN'T PASS THE STATE INSPECTION. I WAS TOLD TO DRIVE IT A LITTLE LONGER TO PUT MILES ON THE CAR. SO I DID.. AFTER SEVEN WEEK GOING BACK TO HAVE IT CHECK IT WAS STILL SHOWING NOT READY. THE MERCHANIC THERE COULDN'T TELL ME WHAT THE PROBLEM AND THE…
Read full complaint
AFTER REPAIRING THE MASS AIR FLOW HOSE,PURGE VALVE,AND THE VALVE COVER GASKET. IT DIDN'T PASS THE STATE INSPECTION. I WAS TOLD TO DRIVE IT A LITTLE LONGER TO PUT MILES ON THE CAR. SO I DID.. AFTER SEVEN WEEK GOING BACK TO HAVE IT CHECK IT WAS STILL SHOWING NOT READY. THE MERCHANIC THERE COULDN'T TELL ME WHAT THE PROBLEM AND THEIR SUBJESTED TO TAKE IT TO THE DEALER AFTER PUTTING 1175 MILES ON MY CAR
NHTSA ODI #11015035
99,000 miles · Jun 6, 2017
Electrical SystemInjury
I AM A DISABLED WOMAN WHO BECAME TRAPPED IN HER OWN CAR BECAUSE THE LOCK MECHANISM ON THE DOOR WOULD NOT OPEN NOR COULD I ROLL DOWN THE WINDOW. THIS IS UNACCEPTABLE. I TRIED TO CLIMB OVER THE GEARSHIFT TO TRY THE PASSENGER DOOR AND HURT MY BACK IN THE PROCESS. I CALLED 911 FOR HELP
NHTSA ODI #10993523
178,000 miles · Jul 26, 2016
Electrical System
CLOSED DRIVER'S DOOR AND DOOR WOULD NOT REOPEN. I TOOK CAR TO AUTO SHOP AND MECHANIC FINALLY GOT DOOR TO OPEN AFTER ABOUT AN HOUR AND A HALF. HE THOUGHT HE HAD REPAIRED THE DOOR AND CLOSED IT, BUT WHEN HE TRIED TO OPEN THE DOOR FOR FINAL INSPECTION, AGAIN IT WOULD NOT OPEN NORMALLY AND UPON FURTHER INSPECTION HE FOUND THE DOOR …
Read full complaint
CLOSED DRIVER'S DOOR AND DOOR WOULD NOT REOPEN. I TOOK CAR TO AUTO SHOP AND MECHANIC FINALLY GOT DOOR TO OPEN AFTER ABOUT AN HOUR AND A HALF. HE THOUGHT HE HAD REPAIRED THE DOOR AND CLOSED IT, BUT WHEN HE TRIED TO OPEN THE DOOR FOR FINAL INSPECTION, AGAIN IT WOULD NOT OPEN NORMALLY AND UPON FURTHER INSPECTION HE FOUND THE DOOR LOCK MECHANISMS WERE NOT FUNCTIONING CORRECTLY FROM THE WAY THEY HAD BEEN MANUFACTURED. AND THERE WAS A RECALL ON THE KIA DOOR LOCK MECHANISMS INCLUDING MY CAR'S YEAR, MAKE AND MODEL. I AM CONCERNED THIS IS A SERIOUS HAZARD, ESPECIALLY SINCE I TRANSPORT SMALL CHILDREN, SOME IN CAR SEATS. MY CAR IS AN OLDER CAR AND I WOULD LIKE ALL FOUR LOCKS REPLACED WITH 'UP TO STANDARD' LOCKS.
NHTSA ODI #10888798
157,000 miles · Jan 29, 2016
Air BagsElectrical System
AIRBAG LIGHT CAME ON FOR NO REASON AND WILL NOT GO OFF. THE DRIVER SEAT AND SUNROOF HAVE AN ELECTRICAL ISSUE WHERE THEY WORK THEN DON'T, FOUND THAT THE SWITCHES ARE BAD AND WORK SOMETIMES.
NHTSA ODI #10822983
155,000 miles · Dec 31, 2015
Electrical SystemStructure
LOCKED CAR AFTER BUYING IT USED DRIVERS DOOR WILL NOT UNLOCK. MULTIPLE COMPLAINTS ONLINE ABOUT THIS PROBLEM. MY DAUGHTER WAS GOING TO DRIVE THIS THING. KIA DEALER DID NOT EVEN MENTION THIS TO ME, BUT DID SAY IT WAS 200 MINIMUM. I HOPE THIS GETS INVESTIGATED. IN AN ACCIDENT THE DOOR WILL NEVER OPEN. I DROVE THE CAR HOME AND AFTE…
Read full complaint
LOCKED CAR AFTER BUYING IT USED DRIVERS DOOR WILL NOT UNLOCK. MULTIPLE COMPLAINTS ONLINE ABOUT THIS PROBLEM. MY DAUGHTER WAS GOING TO DRIVE THIS THING. KIA DEALER DID NOT EVEN MENTION THIS TO ME, BUT DID SAY IT WAS 200 MINIMUM. I HOPE THIS GETS INVESTIGATED. IN AN ACCIDENT THE DOOR WILL NEVER OPEN. I DROVE THE CAR HOME AND AFTER 2 HOURS IT WILL NOT UNLOCK.
NHTSA ODI #10817234
128,000 miles · Oct 5, 2015
Electrical SystemStructure
TL* THE CONTACT OWNS A 2005 KIA OPTIMA. WHILE IN PARK, THE AUTOMATIC DOOR LOCKS FAILED. THE CONTACT ATTEMPTED TO USE THE REMOTE FOR ENTRY AND HEARD A CLICKING NOISE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000.
NHTSA ODI #10779855
Mileage unknown · Jul 13, 2015
Electrical SystemLatches/locks/linkages
TL* THE CONTACT OWNS A 2005 KIA OPTIMA. WHILE THE VEHICLE WAS PARKED, THE LOCKS ON THE DOOR FAILED TO WORK. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT REPAIRED OR DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10733620
120,000 miles · Jun 3, 2015
Electrical System
DRIVERS SIDE DOOR WILL NOT OPEN, THIS HAS HAPPENED SEVERAL TIMES. WHEN YOU PULL ON THE OUTSIDE HANDLE IT WILL MAKE ALL THE DOORS LOCK SOMETIMES. I THOUGHT THIS WAS AN ISOLATED CASE, BUT THERE ARE SEVERAL OTHER COMPLIANTS WITH THIS SAME ISSUE. THIS IS A SEVERE SAFETY ISSUE IF THE CAR WAS IN A CRASH.
NHTSA ODI #10723113
Mileage unknown · Nov 26, 2014
Electrical System
I BELIEVE THIS PROBLEM SHOULD BE A RECALL. THIS IS A SAFETY ISSUE AND NEEDS TO BE CORRECTED BY THE MANUFACTURER. WE HAD THE SAME PROBLEM WHERE THE DRIVER DOOR WOULD NOT OPEN NO MATTER WHAT YOU DID,. IT WOULDN'T OPEN FROM THE INSIDE OR THE OUTSIDE. ALL THE OTHER DOORS WOULD OPEN, BUT THE DRIVER DOOR. IF YOU OPENED IT WITH THE KEY…
Read full complaint
I BELIEVE THIS PROBLEM SHOULD BE A RECALL. THIS IS A SAFETY ISSUE AND NEEDS TO BE CORRECTED BY THE MANUFACTURER. WE HAD THE SAME PROBLEM WHERE THE DRIVER DOOR WOULD NOT OPEN NO MATTER WHAT YOU DID,. IT WOULDN'T OPEN FROM THE INSIDE OR THE OUTSIDE. ALL THE OTHER DOORS WOULD OPEN, BUT THE DRIVER DOOR. IF YOU OPENED IT WITH THE KEY IT CLICKED, BUT WHEN YOU PULLED THE HANDLE TO OPEN THE DOOR IT WOULD LOCK.. IN ORDER TO GET OUT OF THE CAR MY HUSBAND, WHO HAS A BAD BACK HAD TO CLIMB OVER THE CENTER CONSOLE. YOU WOULDN'T BE ABLE TO GET OUT IN AN EMERGENCY AND THIS ISSUE NEEDS TO BE ADDRESSED. ANOTHER ISSUE THAT WE ARE HAVING IS WE ARE ALWAYS REPLACING BULBS IN THE HEADLIGHTS AND TAILLIGHTS; ABOUT ONCE A MONTH. WE ARE FOREVER GETTING PULLED OVER BY THE POLICE TO TELL US OUR HEADLIGHT OR TAILLIGHT IS OUT. THERE SEEMS TO BE A LOT OF ELECTRICAL PROBLEMS WITH THIS CAR AND THEY NEED TO BE ADDRESSED. THE REPAIR COST FOR THE DOOR WAS $400.00 AND WE SHOULD BE REFUNDED AS WELL AS EVERYONE ELSE WHO HAS PAID TO REPAIR THIS DEFECTIVE ISSUE. *TR
NHTSA ODI #10661055
80,000 miles · Nov 11, 2014
Electrical SystemStructure
DRIVER'S SIDE DOOR WOULD NOT OPEN. YOU COULD CLICK IT AND IT WOULD SOUND LIKE IT WAS GOING TO OPEN, BUT IT DIDN'T. HAD TO DRIVE TO A KIA STORE AND HAVE THE WHOLE ASSEMBLY REPLACED AT THE TUNE OF $450. INTERESTINGLY ENOUGH, THEY DID NOT SEEM TO THINK THIS WAS A COMMON PROBLEM, BUT I CAN SEE THERE ARE HUNDREDS OF COMPLAINTS ABO…
Read full complaint
DRIVER'S SIDE DOOR WOULD NOT OPEN. YOU COULD CLICK IT AND IT WOULD SOUND LIKE IT WAS GOING TO OPEN, BUT IT DIDN'T. HAD TO DRIVE TO A KIA STORE AND HAVE THE WHOLE ASSEMBLY REPLACED AT THE TUNE OF $450. INTERESTINGLY ENOUGH, THEY DID NOT SEEM TO THINK THIS WAS A COMMON PROBLEM, BUT I CAN SEE THERE ARE HUNDREDS OF COMPLAINTS ABOUT THIS PROBLEM. I HAD MY TWO YEAR OLD GRANDSON IN THE BACK SEAT AND WAS VERY WORRIED ABOUT GETTING STUCK IN THE CAR. IF THIS HAPPENS AGAIN, I WILL SELL THE CAR. THERE SEEM TO BE A LOT OF ELECTRICAL PROBLEMS ON THIS CAR. I REPLACE THE HEADLIGHTS AND TAILLIGHTS REGULARLY (ABOUT ONCE A MONTH) AND I AM ALWAYS HAVING THE ENGINE LIGHT COME ON, WHEN THERE IS NOTHING WRONG. HOW MANY OF THESE COMPLAINTS DO YOU NEED BEFORE SOMETHING IS DONE? OR DOES SOMEONE HAVE TO GET KILLED FIRST? *TR
NHTSA ODI #10654169
NHTSA investigations
2DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
Illustration