IllustrationMY AIR BAG LIGHT COMES ON THERE'S NO WIRES DISCONNECTED UNDER THE SEAT AND MY SEAT BELTS DO NOT RETRACT WELL ALSO MY DOOR LOCKS ARE GETTING STUCK IN LOCK MODE AND MY ENGINE COMES ON AND THEN GOES OFF.AFTER AWHILE.WHEN IN PARK
2004 Kia Optima
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Kia Optima do not stand out strongly from the model-year median of 186.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Optima years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
2225–50K
3550–75K
4375–100K
56100–150K
9150K+
187 reports with mileage · 38 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Latches/locks/linkages. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports3 fire reports7 injury reports
Electronic Stability Control (esc) complaints
2 reportsMY CAR COMPLETELY TURNS OFF WHILE IM DRIVING IT, MOST OF THE TIME WHEN I USED IT THE FIRST TIME OF THE DAY AND TRY TO USED IT AGAIN IT TURNS OF AND LOOSE POWER, I CAN'T TURN IT ON AGAIN IN THAT MOMENT I NEED TO WAIT AND THEN IT WORKS AGAIN BUT IF HAPPENS REALLY FREQUENTLY AND ITS REALLY DANGEROUS BECAUSE IM ON THE FREEWAY AND CA…
Read full complaint
MY CAR COMPLETELY TURNS OFF WHILE IM DRIVING IT, MOST OF THE TIME WHEN I USED IT THE FIRST TIME OF THE DAY AND TRY TO USED IT AGAIN IT TURNS OF AND LOOSE POWER, I CAN'T TURN IT ON AGAIN IN THAT MOMENT I NEED TO WAIT AND THEN IT WORKS AGAIN BUT IF HAPPENS REALLY FREQUENTLY AND ITS REALLY DANGEROUS BECAUSE IM ON THE FREEWAY AND CARS ARE BEHIND ME AND I CAN CAUSE AN ACCIDENT OR ANYTHING WORSE. I WENT TO THE DEALERSHIP SO THEY COULD INSPECT MY CAR BUT THEY COULDN'T FIND ANYTHING AT THAT MOMENT. *TR
Official recalls
109V183000 · Suspension:front
May 27, 2009
KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE STATES DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING, OR ACCELERATED ABNORMAL TIRE WEAR.
Consequence & remedy
Consequence: CORROSION OF THE FRONT SUBFRAME COULD LEAD TO SEPARATION, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: KMC WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.