IllustrationELECTRICAL SYSTEM HAS FAILED TWO TIMES IN THE LAST WEEK. DEALER NOTIFIED. *AK
2001 Kia Optima
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Kia Optima do not stand out strongly from the model-year median of 186.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Optima years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
425–50K
1550–75K
1775–100K
22100–150K
10150K+
84 reports with mileage · 59 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports0 fire reports5 injury reports
What owners actually said
143 reportsTHIS VEHICLES ELECTRICAL SYSTEM CONTINUES TO FAIL ALONG WITH NONWORKING LIGHTS, AIR CONDITIONER, LOCK FAILURE, BATTERY AND ALTRENATOR FAILURE. CAR HAS BEEN WORKED ON FOR SAME PROBLEMS MORE THAN 5 TIMES. CAR HAS HAD (THAT I KNOW OF) 3 BATTERIES AND 2 ALTERNATORS. ONCE THE LOCKS ON THE CAR FAILED AND I WAS TRAPPED INSIDE VEHICL…
Read full complaint
THIS VEHICLES ELECTRICAL SYSTEM CONTINUES TO FAIL ALONG WITH NONWORKING LIGHTS, AIR CONDITIONER, LOCK FAILURE, BATTERY AND ALTRENATOR FAILURE. CAR HAS BEEN WORKED ON FOR SAME PROBLEMS MORE THAN 5 TIMES. CAR HAS HAD (THAT I KNOW OF) 3 BATTERIES AND 2 ALTERNATORS. ONCE THE LOCKS ON THE CAR FAILED AND I WAS TRAPPED INSIDE VEHICLE FOR MORE THAN AN HOUR. LOCKS WOULD AUTOMATICALLY RELOCK FASTER THAN YOU COULD OPEN THE DOOR.*AK
VEHICLE TRANSMISSION SLIPS WHILE DRIVING.*MR THE AIR CONDITION, AUTO CHECK LIGHT AND AUTOMATIC DOOR LOCKS DO NOT REMAIN UNLOCKED TRAPPING THE DRIVER.*TS *JB
I'VE TAKEN MY 2001 KIA OPTIMA INTO THE SHOP GOING AT LEAST 6 TIMES. MY BRAKES ARE A PROBLEM. THEY SQUEAK AND MY FRONT END VIBRATES. THE DEALER, GALEANA KIA, SAYS THERE'S NOTHING WRONG WITH THE CAR, JUST BRAKE DUST. THEY'VE TRIED TO FIX IT, BUT THE PROBLEM COMES BACK. KIA GAVE ME 500 DOLLARS (CUSTOMER SATISFACTION MONEY) AND …
Read full complaint
I'VE TAKEN MY 2001 KIA OPTIMA INTO THE SHOP GOING AT LEAST 6 TIMES. MY BRAKES ARE A PROBLEM. THEY SQUEAK AND MY FRONT END VIBRATES. THE DEALER, GALEANA KIA, SAYS THERE'S NOTHING WRONG WITH THE CAR, JUST BRAKE DUST. THEY'VE TRIED TO FIX IT, BUT THE PROBLEM COMES BACK. KIA GAVE ME 500 DOLLARS (CUSTOMER SATISFACTION MONEY) AND THEY SAID THEY'D FIX THE PROBLEM. I TOOK THE MONEY, BUT THE PROBLEM CONTINUES. DON'T KNOW WHAT TO DO. BOUGHT CAR WITH 18 MILES ON IT... AND STARTED HAVING PROBLEMS RIGHT AWAY. CAR NOW HAS 20 THOUSAND MILES. *NLM
MY 2001 KIA OPTIMA HAS BECOME THE MODERN AGE , THIS VEHICLE HAS A MIND OF IT'S OWN. THE POWER LOCKS SHUTS OPEN AND LOCKS ON IT'S OWN, THE VEHICLE IS NOT RELIABLE WHEN CROSSING A HIGHWAY ON OUR STREET. VEHICLE STALLS AT THE POINT OF ACCELERATION AND DOES NOT RESPOND TO PRESSING OF GAS PEDAL. WHEN CAR ELECTRICAL SYSTEM FAILS AND …
Read full complaint
MY 2001 KIA OPTIMA HAS BECOME THE MODERN AGE , THIS VEHICLE HAS A MIND OF IT'S OWN. THE POWER LOCKS SHUTS OPEN AND LOCKS ON IT'S OWN, THE VEHICLE IS NOT RELIABLE WHEN CROSSING A HIGHWAY ON OUR STREET. VEHICLE STALLS AT THE POINT OF ACCELERATION AND DOES NOT RESPOND TO PRESSING OF GAS PEDAL. WHEN CAR ELECTRICAL SYSTEM FAILS AND YOU ARE IN THE VEHICLE THE POWER LOCKS DO NOT OPERATE CAUSING DRIVER AND PASSENGERS TO BE LOCKED IN VEHICLE. I WAS RECENTLY LOCKED IN MY VEHICLE WITH MY DAUGHTER FOR EXACTLY 4 HOURS WHEN THE POWER FINALLY RETURNED AND I WAS ABLE TO GET OUT. I CONTACTED KIA MOTORS CORP. AND WAS SIMPLY NOT TAKEN SERIOUS WITH THIS COMPLAINT. I HOPE THAT YOU FOLLOW UP WITH MANUFACTURES POSSIBLE DEATH TRAP AND THAT NO LOSES THEIR LIFE. *JB
WHEN THE BRAKES ARE APPLIED, THE REAR BRAKES HAVE BEEN SQUEALING LIKE NOTHING I HAVE EVER HEARD. BRAKES WERE CHECKED OUT AT A LOCAL BRAKE SHOP AND RECOMMENDED REPLACEMENT OF THE REAR BRAKES. AT THAT TIME THE CAR ONLY HAD 15,000 MILES ON IT. IT NOW HAS 29,000 MILES ON IT AND THE NOISE IS EVEN LOUDER. I CONTACTED THE DEALER AN…
Read full complaint
WHEN THE BRAKES ARE APPLIED, THE REAR BRAKES HAVE BEEN SQUEALING LIKE NOTHING I HAVE EVER HEARD. BRAKES WERE CHECKED OUT AT A LOCAL BRAKE SHOP AND RECOMMENDED REPLACEMENT OF THE REAR BRAKES. AT THAT TIME THE CAR ONLY HAD 15,000 MILES ON IT. IT NOW HAS 29,000 MILES ON IT AND THE NOISE IS EVEN LOUDER. I CONTACTED THE DEALER AND THEY SAID IF THERE ISN'T ANYTHING WRONG WITH THE BRAKES I WOULD HAVE TO PAY FOR THE BRAKE CHECK AND THE REPLACEMENT OF THE REAR BRAKES. BRAKES DON'T NORMALLY GO BAD THAT FAST UNLESS SOMETHING IS WRONG!! *JB
THE VEHICLE WAS INVOLVED IN A COLLISION. AND THE AIR BAGS FAILED TO DEPLOY. *JB
THE VEHICLE WAS REAR ENDED, AND THE AIR BAGS FAILED TO DEPLOY. *JB
THE SEAT BELT WAS NOT LONG ENOUGH TO ACCOMMODATE WEIGHT, CONSUMER WAS INFORMED A SEAT BELT EXTENDER WAS NOT MADE FOR VEHICLE.*JB
THE VEHICLE FAILED TO START, THE DEALER REPLACED THE BATTERY, HOWEVER THE PROBLEM RECURRED.*JB
Official recalls
309V183000 · Suspension:front
May 27, 2009
KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE STATES DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING, OR ACCELERATED ABNORMAL TIRE WEAR.
Consequence & remedy
Consequence: CORROSION OF THE FRONT SUBFRAME COULD LEAD TO SEPARATION, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: KMC WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
03V067000 · Electrical System:starter Assembly
Mar 4, 2003
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.5 AND 2.7 LITER V6 ENGINES, THE CRANKSHAFT POSITION SENSOR (CKP) CASES DID NOT MEET DIMENSIONAL SPECIFICATIONS.
Consequence & remedy
Consequence: INTERNAL GAPS WITHIN THE CASES ALLOWED EPOXY TO CONTACT THE PRINTED CIRCUIT BOARD, WHICH RESULTED IN CRACKING OF THE CIRCUIT BOARD CAPACITOR. A DAMAGED CKP CAPACITOR COULD RESULT IN ENGINE STALLING.
Remedy: DEALERS WILL REPLACE THE CKP. OWNER NOTIFICATION BEGAN MARCH 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
01V156000 · Air Bags:side/window
May 1, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SIDE AIR BAG WIRE HARNESS FOR THE DRIVER POSITION COULD BE MIS-ROUTED, WHICH COULD RESULT IN IT BEING PINCHED OR CUT BY THE SEAT CUSHION TILT MECHANISM.
Consequence & remedy
Consequence: DAMAGE TO THE WIRE HARNESS COULD RESULT IN THE SIDE AIR BAG NOT DEPLOYING IN AN ACCIDENT.
Remedy: DEALERS WILL CHECK FOR PROPER ROUTING OF THE SIDE AIR BAG WIRE HARNESS AND SECURE IT IN PLACE WITH A PLASTIC TIE-WRAP. IF THE WIRE HARNESS IS DAMAGED, IT WILL BE REPLACED. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA04030 · Power Door Lock Failure
Opened Nov 4, 2004 · Closed Nov 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
INVESTIGATION FAILED TO DISCLOSE A MALFUNCTION WITH A CLEAR AND CONSISTENT PATTERN OF COMPROMISE TO MOTOR VEHICLE SAFETY.FAILURE OF THE SUBJECT DOOR LOCKS MAY IMPEDE NORMAL EGRESS OF A VEHICLE OCCUPANT BUT DOES NOT ENTRAP THE OCCUPANT.COMPLAINTS AND WARRANTY DATA DOCUMENT THE DEFICIENCIES OF THE DOOR LOCK SYSTEM, BUT THESE MALFUNCTIONS HAVE NOT BEEN ACCOMPANIED BY A HISTORY OF DEMONSTRATED SAFETY RELATED IMPLICATIONS.DETAILS REGARDING THIS INVESTIGATION ARE CONTAINED IN THE ENGINEERING ANALYSIS CLOSING REPORT.FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04050 · Power Door Lock Failure
Opened Jul 7, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
THIS PE DISCLOSED THAT THE SUBJECT VEHICLES HAVE EXPERIENCED INCIDENTS OF THE ALLEGED DEFECT IN SIGNIFICANT NUMBERS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-030) TO FACILITATE A THOROUGH REVIEW OF THE MATTER, INCLUDING EVALUATION OF THE POTENTIAL SAFETY-RELATED CONSEQUENCES.