2023 Kia Niro

My 2023 Kia Niro Hybrid has a recurring intermittent electrical defect. Warnings appear together: Check Hybrid System, Check Engine, Forward Collision, Rear Cross-Traffic, Lane Keeping, Driver Attention, ESC, Brake, Auto Hold. They appear and persist while driving, during which stability control, automatic emergency braking, lane keeping, and related safety assists are disabled. Once, the vehicle would not start and was temporarily disabled, recovering after several minutes. This creates risk from loss of all electronic safety assists in traffic and from the vehicle failing to start when needed. Stored codes show lost CAN communication among multiple modules: U0101, C1611, C1693, U0111, U0164, U0293, U042B, U1341. Confirmed by two Kia dealerships over five warranty visits. V1–2 (Coughlin Kia, Dublin OH): software updates; warnings returned. V3 (Ricart Kia, Columbus OH): inspected, released OK; warnings returned. V4 (Ricart): Kia Techline case [XXX] opened; CAN signal confirmed out of spec at a passenger kick panel connector; dash harness replaced per Techline under warranty (~$2,800). V5 (current): same warnings returned within days, confirmed by the dealership; vehicle is in the dealer's possession for continued diagnosis and available for inspection. Warnings first appeared June 2026 at ~58,500 miles, recurring since. Current mileage ~59,700. No crash or injury. Kia Consumer Affairs case open. Note: attached RO [XXX] says no issues found after repair — outdated; warnings returned within days, vehicle back at dealer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I bought my Niro hybrid EX Touring new from the dealership in 2023. The first issue arose when the car shut off completely while driving and was towed to the dealership. Later, I started hearing a squeaking/rubber rubbing sound. The car would make squeaking and creaking noises when turning or going over minor bumps. The "rubber rubbing sound" happened when I was at a full stop, right after removing my foot from the brake, as the car began to move forward. These issues were both reported to the dealership, and they did an inspection. The dealership service center has been able to hear the sounds. Since then, the calliper boots have been replaced multiple times and the full calliper kit once. The strut bearing has also been replaced multiple times. Consistent issues with the car's braking system is a significant safety issue. I have no idea what damage the rest of my car could have sustained, and I have not been able to get an answer for why this is happening. I have also been in contact with the manufacturer.

When attempting to activate the parking brake there is no response from the vehicle. No matter how many times in attempting to activate the parking brake it would not activate. The only way to successfully activate the parking brake was if "auto hold" was on and i turned off the vehicle. i have a safety concern regarding this matter as the vehicle could potentially roll away if the car is unattended. The problem has not been reproduced or confirmed by the service center as of yet but it will be inspected on 01/14/2026. There are no warning lamps, messages or other symptoms of the problem prior to the failure.

On Oct 4, 2024, a driver rolled into my car on an incline. While waiting for the police, I looked inside my car and thought the engine was still on. (Flashers). I turned the power button and the car began to roll backwards. I jumped in and tried the break. Pedal went all the way to the floor and car rolled faster. Moved gear shift around and kept rolling faster and faster (incline). I had my left foot out of the car and right on the break. At one point, I was thrown out of the car and my left leg was run over. Car stopped when it hit a tree. Three weeks in hospital and rehab. Still haven’t been able to return to work.