2019 Kia Forte

2019 Kia with approximately 64,000 miles. Engine failed without warning. Prior to failure, vehicle had been experiencing intermittent stalling on multiple prior occasions and had been brought to a mechanic for inspection before the final failure occurred. Vehicle stalled while being driven on a highway at night on [XXX] between mile markers 67-71 in Maryland, creating a dangerous situation for the driver and other motorists. The oil warning light appeared immediately prior to engine failure. Vehicle was towed to an independent mechanic who inspected it and confirmed the engine had failed. The mechanic noted that the engine was well maintained, ruling out neglect as a contributing factor. Mechanic stated this is a known issue with Kia engines from this era. Vehicle is available for inspection. Problem has been confirmed by an independent service center. Engine replacement cost is approximately $6,000. Kia's powertrain warranty does not fully transfer to subsequent owners, leaving this vehicle owner without coverage despite low mileage and what appears to be a manufacturing defect. Owner was advised by mechanic that Kia has covered similar failures as goodwill replacements due to the known nature of this defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Transmission was getting stuck in gear and slipping intermittently would cause the car to not accelerate over 20mph especially in the cold unless you switched it to the manual mode and manually shifted up two gears ans then back down two gears. If you looked at the tach while it did this is would bounce between 500 and 1500rpm and then would stutter and bounce between 1500 and 2500rpm until you did the manual gear trick. Eventually it started making a strange noise. I have serviced it on time and complained to Kia before about the issue which they stated they could not repeat so there was nothing they could do at that time and now when I took it back to Kia they stated its an internal trans issue and it now needs to be replaced but there was nothing they could do as it was now out of warranty. The car has less the 95k on it. I've had cars that had well over 400k on them in the past and still ran like new. The trans should not be failing already.

Engine stalled while driving causing the car to turn off in traffic. The vehicle is available for inspection upon request. This caused loss of power and steering at 45 miles per hour and could have caused a collision. A licensed and accredited auto mechanic has confirmed that the engine is a total loss. The same day and shortly before the engine stalled, a check engine light appeared. The driver was on his way home and had planned to park the car and have it towed to the mechanic the next day.

The contact owns a 2019 Kia Forte. The contact was notified by her son that the third brake light was burned and was melting. There were no warning lights illuminated. The local dealer was contacted and suggested that a diagnostic test be performed. The vehicle was not diagnosed or repaired. The manufacturer was contacted and informed the owner that there was no warranty coverage on the vehicle for the failure and referred the owner to the local dealer for assistance. The failure mileage was approximately 65,000.

The contact owns a 2019 Kia Forte. The contact stated that during start-up, the vehicle was rattling and vibrating abnormally with a clanking sound while shifting into gear. The vehicle was taken to the local dealer, who diagnosed that the crankcase sensor was faulty, and that there were metal shavings inside the engine oil. The contact was advised that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was not contacted. The failure mileage was 108,000.

the safety of others are put at risk due to system on and off due to shortage and wire triggering. The vehicle listed above collision system wire harness have a shortage and causes the vehicle not to be safe and unable to operate on roadways, highways and streets. there were warning light indicators on the dashboard and need a full-inspection and harness replacement before resale or auction sale.

October 2, 2025 @ approximately 7:30a. I was heading east on I-10 on my way to work when I seen white smoke coming from under my car. I pulled over, noticed it was on fire. There was a man passing by who seen me & was nice enough to stop & put the fire out. The firefighter then stated my oil pan came a loose and caught fire when it hit the ground. Which caused a lot of damage including me need a new engine. The firefighter stated the pan is useless & is a safety hazard.

I am writing to report a recurring and potentially dangerous issue with my Kia Forte. My vehicle has randomly failed to start on multiple occasions, requiring a jump start. More concerning, it has also shut off while I was driving, which is extremely alarming and could have resulted in a serious accident. These incidents have happened several times, and I no longer feel safe driving the vehicle. I suspect this may be related to an electrical issue, as I am also experiencing:     •    Intermittent failure of the backup camera     •    Headlights, brake lights, fog lights, and daytime running lights failing to operate correctly     •    General electrical irregularities throughout the vehicle I have checked for recalls related to Kia Fortes and found that other vehicles of the same make and model have had similar issues. However, there are no active recalls for my VIN, despite experiencing the same or more severe symptoms described in those recalls. This situation is extremely concerning and I believe it warrants further investigation. I am requesting that NHTSA review this issue and consider whether additional recalls or safety investigations may be necessary for other Kia Forte owners experiencing similar electrical and engine issues. Thank you for your attention to this matter. I would appreciate any guidance on next steps or how to ensure my vehicle is properly inspected for these safety concerns.