The contact owns a 2022 Kia EV6 equipped with Kumho Tires, Tire Line: Crugen, Tire Size: 235/55/R19, DOT Number [XXX] . The contact stated while driving approximately 60 MPH, the vehicle started vibrating abnormally. The vehicle was driven to the dealer and the technician at the dealer stated that the inner lining of the tires h…
Read full complaint
The contact owns a 2022 Kia EV6 equipped with Kumho Tires, Tire Line: Crugen, Tire Size: 235/55/R19, DOT Number [XXX] . The contact stated while driving approximately 60 MPH, the vehicle started vibrating abnormally. The vehicle was driven to the dealer and the technician at the dealer stated that the inner lining of the tires had separated on the driver’s side front and rear passenger’s side tires. The tires were the original equipment. The contact stated that the tires were replaced. The contact was unable to reach the manufacturer for assistance. The failure mileage was 12,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 and 2024 EV9 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge. Owner notification letters are expected to be mailed August 7, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC375. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning July 17, 2026.
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 13, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC327. This recall expands and replaces previous recall number 24V-200. Vehicles previously repaired under recall 24V-200 will need to have the new remedy completed.
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 13, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC327. This recall expands and replaces previous recall number 24V-200. Vehicles previously repaired under recall 24V-200 will need to have the new remedy completed.
Electrical SYSTEM:12V/24V/48V Battery
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 13, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC327. This recall expands and replaces previous recall number 24V-200. Vehicles previously repaired under recall 24V-200 will need to have the new remedy completed.
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters are expected to be mailed April 29, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC302.
Kia Motor America (Kia) is recalling certain 2022 EV6 vehicles. A software error in the Shifter Control Unit (SCU) may disengage the parking mechanism, which can allow the vehicle to rollaway.
Consequence & remedy
Consequence: Vehicle rollaway can increase the risk of a crash or injury.
Remedy: Drivers are recommended to park their vehicles on level ground and avoid parking on a slope/inclined surface whenever possible until the remedy has been performed. Dealers will update the Shifter Control Unit software, free of charge. Owner notification letters were mailed May 25, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC236.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
On July 3, 2023, the Office of Defect Investigation (ODI) opened PE23012 to investigate allegations of loss of motor power on model year (MY) 2022 Kia EV6 vehicles. Some consumers reported loss of motor power immediately after warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charing Unit (ICCU) may become damaged over time from transient high voltage and thermal cycling. A damaged ICCU may not be able to charge the 12-volt battery which can discharge gradually while driving with a reduction of motive power. The vehicle could eventually experience a complete loss of motive power thereby increasing the risk of a crash. On July 13, 2023, Kia conducted a service campaign to inspect the ICCU and install an improved over-current detection software logic in certain 2022-2023 EV6 vehicles. On March 15, 2024, Kia filed recall 24V-200 for 48,232 MY 2022-2024 Kia EV6 vehicles. The recall remedy provides an inspection of the ICCU, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Kia, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On July 3, 2023, the Office of Defect Investigation (ODI) opened PE23012 to investigate allegations of loss of motor power on model year (MY) 2022 Kia EV6 vehicles. Some consumers reported loss of motor power immediately after warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charing Unit (ICCU) may become damaged over time from transient high voltage and thermal cycling. A damaged ICCU may not be able to charge the 12-volt battery which can discharge gradually while driving with a reduction of motive power. The vehicle could eventually experience a complete loss of motive power thereby increasing the risk of a crash. On July 13, 2023, Kia conducted a service campaign to inspect the ICCU and install an improved over-current detection software logic in certain 2022-2023 EV6 vehicles. On March 15, 2024, Kia filed recall 24V-200 for 48,232 MY 2022-2024 Kia EV6 vehicles. The recall remedy provides an inspection of the ICCU, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Kia, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
On July 3, 2023, the Office of Defect Investigation (ODI) opened PE23012 to investigate allegations of loss of motor power on model year (MY) 2022 Kia EV6 vehicles. Some consumers reported loss of motor power immediately after warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charing Unit (ICCU) may become damaged over time from transient high voltage and thermal cycling. A damaged ICCU may not be able to charge the 12-volt battery which can discharge gradually while driving with a reduction of motive power. The vehicle could eventually experience a complete loss of motive power thereby increasing the risk of a crash. On July 13, 2023, Kia conducted a service campaign to inspect the ICCU and install an improved over-current detection software logic in certain 2022-2023 EV6 vehicles. On March 15, 2024, Kia filed recall 24V-200 for 48,232 MY 2022-2024 Kia EV6 vehicles. The recall remedy provides an inspection of the ICCU, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Kia, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2022 Kia EV6 Problems, Complaints & Recalls | Skip That Year
Illustration