The contact owns a 2023 Kia Carnival. The contact stated that during freezing weather, the button was depressed to open the driver's side rear sliding door, and the door automatically opened; however, the motor reached a point of resistance and attempted to close the sliding door. Due to the failure of the cable in the door snap…
Read full complaint
The contact owns a 2023 Kia Carnival. The contact stated that during freezing weather, the button was depressed to open the driver's side rear sliding door, and the door automatically opened; however, the motor reached a point of resistance and attempted to close the sliding door. Due to the failure of the cable in the door snapped behind the glass window. The contact manually opened the sliding door and used excessive force to close the door. The vehicle was taken to the dealer, who confirmed that the door cable had snapped. The contact was informed that the vehicle was out of warranty; however, the dealer reached out to the manufacturer for assistance. The manufacturer later agreed to partial assistance with the repair. The contact paid for the remaining cost of the repair. The manufacturer was contacted about the repair and provided a case number. The vehicle was repaired. The failure mileage was 63,476.
NHTSA ODI #11717587
Mileage unknown · Jan 15, 2023
Electrical SystemLatches/locks/linkages
Rear automatic door shut on adult even after bumping into the individual. The sensor did not stop the door from closing. This could have caused serious injury, especially if this were to happen to a kid.
Kia America, Inc. (Kia) is recalling certain 2022-2026 Carnival vehicles. Fuel may leak at the pipe connection between the fuel pipe and fuel rail.
Consequence & remedy
Consequence: A fuel leak increases the risk of a fire.
Remedy: Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed June 2, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC368. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on April 24, 2026.
Kia America, Inc. (Kia) is recalling certain 2023-2024 Sportage and 2022-2024 Carnival vehicles. The roof molding may loosen and detach.
Consequence & remedy
Consequence: A detached roof molding can create a road hazard for other vehicles, increasing the risk of a crash.
Remedy: Dealers will inspect the roof molding and replace or secure it as necessary, free of charge. Owner notification letters were mailed March 15, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC292.
Kia America, Inc. (Kia) is recalling all 2022 and certain 2023 Carnival vehicles. The auto-reverse feature for the power sliding doors (PSD) may not activate in all situations.
Consequence & remedy
Consequence: A power sliding door that does not auto-reverse can close on an occupant, increasing the risk of injury.
Remedy: Dealers will update the power sliding door control module software, free of charge. Owner notification letters were mailed April 28, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC266.
Kia America, Inc. (Kia) is recalling certain 2022-2023 Carnival vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will inspect and verify whether the vehicle is equipped with a Genuine Kia accessory trailer tow hitch assembly. If equipped, dealers will install a new fuse and wire extension kit. Repairs will be performed free of charge. Owner notification letters were mailed May 16, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC265.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2023 Kia Carnival Problems, Complaints & Recalls | Skip That Year
Illustration