2026 Kia Carnival Hybrid

While driving on an interstate during a heavy summer thunderstorm, the vehicle suddenly displayed a warning stating, "There may be a problem with the Battery Management System," along with a "Check Hybrid System" message. At the same time, the check engine light illuminated and the hybrid system stopped functioning without any prior warning. Approximately 10–15 minutes before the incident, I had driven through approximately 4 inches of standing water on a surface street at a speed of about 25 mph. After entering the interstate and traveling at approximately 65 mph in heavy rain, the hybrid system suddenly disabled itself. Cruise control was not engaged at any point during the trip. Immediately after the warning appeared, the vehicle experienced a significant loss of power and entered what appeared to be a reduced-power (limp) mode. The gasoline engine continued to run, but acceleration was severely limited, making it difficult to maintain speed or accelerate with surrounding highway traffic. This occurred at night, during heavy rain, on a busy interstate.The unexpected reduction in power created a hazardous situation and increased the risk of being struck by other vehicles while attempting to merge or pull over. After I was able to safely stop and restart the vehicle, the "Check Hybrid System" and Battery Management System warning messages disappeared. The vehicle has approximately 6,000 miles and was purchased new. This vehicle is used to transport my family, including my wife and our three young children. I believe this presents a significant safety concern because the sudden loss of power occurred without warning while traveling at highway speed in adverse weather conditions. Even though the vehicle remained drivable, the reduced acceleration made it difficult to safely maintain traffic flow or move to the shoulder, increasing the risk of a collision. I request that this issue be investigated to determine whether there is a defect affecting the hybrid system.

Hello there - I am a fairly new owner of a KIA carnival hybrid 2026. I leased the vehicle in March'26. I have about 2200 miles put on the vehicle. On XXX at around 11am I was driving the vehicle on the left lane of freeway at ~65 mph and there was a sudden flash of Engine Maintenance service light and the vehicle cut out power to the accelerator pedal and started to bring the vehicle to a stop. This is in the fastest lane of the freeway while there was cars behind me. Luckily there was space to stop on the left side of the lane and I parked my car with the EMS light still on. Mind you that cars were going past me at 65+ mph. This is a major safety concern. I switched off the vehicle and turned it back on and the check engine light was still on but I was able to drive the vehicle to an exit and return home. I had the vehicle switched off for a few hours and when I turned it back on, the check engine light was gone. I scheduled a service at the dealership I purchased and explained the situation, they checked the codes/logs and test drove the vehicle and returned the vehicle back to me saying they cannot duplicate the issue. Whether the issue is resolved or not, I am majorly concerned that the diagnosis is incomplete and this issue can happen anytime on a freeway which is a safety hazard. This should not be happening on a brand new vehicle. I have raised a complaint to KIA corporate as well. There are a lot of other users companing similar issues: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving a brand new Kia Carnival Hybrid (purchased yesterday), I experienced a severe, life-threatening powertrain acceleration lag from a rolling start. My children were in the car and this was very scary. When attempting to accelerate into oncoming traffic on a wet road surface, the vehicle completely hesitated and dropped power for approximately 1.5 to 2 seconds, leaving the vehicle stranded in the path of oncoming traffic. When the power finally engaged, it delivered a violent surge of torque that caused the front tires to break traction and squeal aggressively. This software-driven hesitation and power-distribution lag represents a severe safety hazard.

-A "Check Hybrid system. Stop safely. " warning has come on 7 times now. The vehicle loses power and slows down abruptly before coming to a complete halt. This has happened on railroad tracks, the highway, and an intersection where my wife and children were almost hit by other motorists. The dealer has not been able to reproduce the code, but we have pictures and videos of said incidents. The vehicle has been inspected by Kia technicians and "fixed" multiple times, but this keeps happening and I will not risk my family's lives any longer. There has been zero warning every time this system failure has occurred. We are undergoing a buyback process with Kia corporate and are prepared to take legal action under Georgia state lemon laws. Thank you for your time.

Driving on freeway with the heater on, Cold weather, car had multiple issue messages (transmission control unit and adaptive cruise control) as well as a check engine light come on as the car went limp and would not accelerate. Has to pull off of the freeway after nearly getting in multiple accidents due to losing speed from 65 mph to 30. Had the gas pedal all the way to the ground and the car would barely accelerate.