Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Equipment. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reports
18,000 miles · Feb 19, 2015
EquipmentStructure
THE FRESH WATER TANK SUPPORT BRACKETS AND SECURING 3/8 SELF-DRILLING ? TO 1? TAP SCREWS FAILED. ALL (5) BRACKETS FAILED. ONLY (2) TAP SCREWS ON ONE END OF THE (2) OUTBOARD BRACKETS REMAINED INSTALLED. THOSE SCREWS WERE BACKED OFF A TIGHTENED POSITION BY APPROXIMATELY 1/8? TO 1/4? POSITION. THREE (3) SUPPORT CHANNEL BRACKETS AR…
Read full complaint
THE FRESH WATER TANK SUPPORT BRACKETS AND SECURING 3/8 SELF-DRILLING ? TO 1? TAP SCREWS FAILED. ALL (5) BRACKETS FAILED. ONLY (2) TAP SCREWS ON ONE END OF THE (2) OUTBOARD BRACKETS REMAINED INSTALLED. THOSE SCREWS WERE BACKED OFF A TIGHTENED POSITION BY APPROXIMATELY 1/8? TO 1/4? POSITION. THREE (3) SUPPORT CHANNEL BRACKETS ARE BENT IN THE MIDDLE TO A PERMANENT POSITION BY A 2 1/2" TO 3? DROP IN THE CENTER. THE (2) SUPPORT BRACKETS AT BOTH ENDS OF THE TANK SUPPORT SYSTEM DIPPED MARGINALLY.THE BOTTOM OF THE FRESH WATER TANK IS PERMANENTLY DISTORTED ON THE BOTTOM BY APPROXIMATELY A 3? DIP. THE BRACKETS ARE MADE OF 1/16 THICK STEEL CHANNEL SPANNING A DISTANCE OF 60 5/8.? THE BRACKETS & MOUNTING SCREWS ARE NOT SUBSTANTIAL ENOUGH TO SUPPORT A LOAD MAX OF 830 LBS. OR LESS IN EITHER A STATIONARY OR ON THE ROAD CONDITION AS ILLUSTRATED BY THE FAILURE. THERE ARE NO WARNINGS IN THE KEYSTONE OWNER?S MANUAL THAT ADVISE THE OWNER THAT THE RV SHOULD NOT BE PLACED IN MOTION WITH A PARTIALLY FULL OR FULL TANK OF FRESH WATER. ON OCCASION, WHEN TRAVELING, THE FRESH WATER TANK HAS BEEN PARTIALLY FILLED TO BETWEEN THE 1/3 AND 2/3 WATER LEVEL AS NOTED ON THE WATER TANK MONITOR PANEL. HOWEVER, THE MOST CONCERNING SITUATION WOULD BE A CATASTROPHIC FRESH WATER TANK SUPPORT SYSTEM FAILURE WITH THE RV IN MOTION, A TANK OF WATER BREACHING THE UNDERCARRIAGE COVER, (SEE OTHER COMPLAINT FILED 7/29/13), THAT COULD RESULT IN COLLATERAL DAMAGE TO ANOTHER VEHICLE OR PERSON. KEYSTONE CLAIMS THAT THE SUPPORT SYSTEM FAILED DUE TO OVER FILLING THE WATER TANK. IF KEYSTONE BELIEVES IT IS POSSIBLE TO OVER FILL THE FRESH WATER TANK, KEYSTONE SHOULD HAVE DESIGNED A TANK THAT WOULD PREVENT THE POSSIBILITY OF OVER FILLING THE FRESH WATER TANK, I.E. PRESSURE RELIEF PLUG ON THE TANK OR AN OVERFLOW DRAIN LINE, ETC. I AM THE FIRST AND CURRENT OWNER/OPERATOR OF THIS RECREATIONAL VEHICLE (RV). PICTURES AVAILABLE. *TR
NHTSA ODI #10689436
Mileage unknown · Feb 13, 2012
Structure
(2) 2,500 LB FLUSH MOUNT D-RINGS IN CARGO AREA PULLED OUT OF FLOOR WHILE TRAVELING NORTH IN INTERSTATE 5 IN CALIFORNIA. 600LB MOTORCYCLE FULL OF FUEL CAME LOOSE AND CRASHED INTO WALL OF TRAILER. DISCOVERED THAT ALL OF THE D-RINGS WERE IMPROPERLY SECURED TO FRAME AND FLOOR OF TRAILER BY MANUFACTURER BY (1) DRILL TIP SCREW INTO F…
Read full complaint
(2) 2,500 LB FLUSH MOUNT D-RINGS IN CARGO AREA PULLED OUT OF FLOOR WHILE TRAVELING NORTH IN INTERSTATE 5 IN CALIFORNIA. 600LB MOTORCYCLE FULL OF FUEL CAME LOOSE AND CRASHED INTO WALL OF TRAILER. DISCOVERED THAT ALL OF THE D-RINGS WERE IMPROPERLY SECURED TO FRAME AND FLOOR OF TRAILER BY MANUFACTURER BY (1) DRILL TIP SCREW INTO FRAME AND (2) WOOD SCREWS INTO PLYWOOD. ONE OF THE D-RINGS THAT CAME LOOSE HAD ALLEGEDLY BEEN FIXED UNDER WARRENTY AT THE RV DEALERSHIP UNDER KEYSTONES DIRECTION. A LOOSE MOTOR VEHICLE IN A TOY HAULER COULD POSSIBLY CAUSE FIRE, EXPLOSION INJURY OR DEATH FROM LEAKING FUEL, PROPANE AND ELECTRICAL SHORTS. *TR
Keystone RV Company (Keystone) is recalling various 2003-2018 Crossroads, Dutchmen, and Keystone recreational trailers equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V755-5127.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: Keystone will notify owners and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Keystone customer service at 1-574-535-2100, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Keystone's number for this recall is 17-307.
KEYSTONE HAS REVISED THEIR REMEDY PROCESS AND IS AGAIN RECALLING CERTAIN 2009-2011 VEHICLES WITH THE GENERATOR READY OPTION, OR WITH STANDARD GENERATOR. SEE THE LIST ABOVE FOR THE AFFECTED MODELS. SOME IOTA ITS-50R TRANSFER SWITCHES ARE EXPERIENCING FAILURES WHEN EXPOSED TO HIGH ELECTRICAL LOADS. THE FAILURE IS CAUSING CONNECTIONS AND WIRING IN THE TRANSFER SWITCH TO DEGRADE AND OVER HEAT.
Consequence & remedy
Consequence: CONTINUED USE OF THE VEHICLE WITHOUT REPLACING THE TRANSFER SWITCH MAY DAMAGE OTHER APPLIANCES, INCREASE THE RISK OF A FIRE, PERSONAL INJURY, AND PROPERTY DAMAGE.
Remedy: KEYSTONE WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE TRANSFER SWITCH, FREE OF CHARGE. THE REMEDY FOR THE PREVIOUS RECALL (10V-594) WAS TO INSPECT AND TIGHTEN THE SWITCH CONNECTIONS. THE SAFETY RECALL BEGAN ON FEBRUARY 24, 2012. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2011 SPRINTER, COUGAR AND FUZION TRAVEL TRAILERS EQUIPPED WITH SIEMENS AND MURRAY ONE INCH PLUG-IN CIRCUIT BREAKERS. THE "SPRING CLIP" PLUG-IN ASSEMBLY MAY BREAK OR FAIL TO PROVIDE SUFFICIENT FORCE TO MAINTAIN A PROPER ELECTRICAL CONNECTION IN THE PANEL BOARD.
Consequence & remedy
Consequence: THIS COULD LEAD TO EXCESSIVE TEMPERATURE, ARCING OR THERMAL DAMAGE AT THE CONNECTION POINT AND POTENTIAL DAMAGE TO THE PANEL BOARD'S ELECTRICAL INSULATION WHICH COULD LEAD TO FIRE, PROPERTY DAMAGE, OR PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE BREAKERS AND REPLACE AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 15, 2010. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
KEYSTONE IS RECALLING CERTAIN FIFTH WHEEL TRAILERS WITH A GENERATOR READY OPTION. IF THE TRANSFER SWITCH IS NOT INSTALLED TO THE PROPER SPECIFICATIONS, THE ELEVATED ELECTRICAL LOADS ASSOCIATED WITH THE RECREATIONAL VEHICLE USE IN HIGHER AMBIENT TEMPERATURES MAY CAUSE OVERHEATING OF THE LUGS AND DEGRADING OF THE ELECTRICAL CONNECTIONS.
Consequence & remedy
Consequence: OVERHEATING OF THE CONNECTIONS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND REPLACE THE TRANSFER SWITCH IF NECESSARY FREE OF CHARGE. THE SAFETY WAS SUPERCEDED BY CAMPAIGN 11V-577. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
KEYSTONE IS RECALLING CERTAIN RECREATIONAL VEHICLES AND FIFTH WHEEL TRAILERS EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
Consequence & remedy
Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Remedy: KEYSTONE IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN ON DECEMBER 10, 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR KEYSTONE AT 866-425-4369.
KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2011 RECREATIONAL VEHICLES EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.
Consequence & remedy
Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.
Remedy: DEALERS WILL ISOLATE AND PERFORM A DROP PRESSURE TEST ON THE OVEN SUPPLY TUBE AND IF THE TUBE LEAKS IT WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2010. OWNER MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
KEYSTONE IS RECALLING CERTAIN 2011 ALPINE, AVALANCHE, FUZION, LAREDO, MONTANA, AND MOUNTAINEER FIFTH WHEEL TRAILERS MANUFACTURED FROM AUGUST 19, 2010 THROUGH SEPTEMBER 1, 2010, EQUIPPED WITH DEXTER AXLES. ON SOME AXLES, CRACKS COULD APPEAR IN THE SPINDLE WELD.
Consequence & remedy
Consequence: THESE CRACKS CAN PROPAGATE AND CAUSE THE SPINDLE TO DETACH FROM THE AXLE TUBE, RESULTING IN THE SEPARATION OF THE WHEEL END FROM THE VEHICLE, CREATING A ROAD HAZARD THAT INCREASES THE RISK OF A CRASH TO OTHER VEHICLES, AND COMPROMISES THE DRIVER'S CONTROL OF THE VEHICLE INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: KEYSTONE WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE AXLE SERIAL NUMBER AND REPLACE IT IF IT FALLS WITHIN THE SERIAL NUMBER RANGE. REPLACEMENT OF THE AXLE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 24, 2010. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2011 Keystone Fuzion Problems, Complaints & Recalls | Skip That Year
Illustration