Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Tires. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
4 reports
Mileage unknown · Aug 5, 2026
Structure
On XXX between 11 am to 2pm, I was driving [XXX] to [XXX], via [XXX], and at rest area [XXX], I stopped for fueling truck and getting something to eat with family. After stopping at the parking site for trailer, I noticed that the RV box on the front above the gooseneck, was touching the top of my truck trunk. I use a fifth whe…
Read full complaint
On XXX between 11 am to 2pm, I was driving [XXX] to [XXX], via [XXX], and at rest area [XXX], I stopped for fueling truck and getting something to eat with family. After stopping at the parking site for trailer, I noticed that the RV box on the front above the gooseneck, was touching the top of my truck trunk. I use a fifth wheel gooseneck and tow from the center of my truck/trunk bed, and we usually have about 2 inch gap between rv and truck, but at this time there was no gap, the weight of RV was on top the truck back side panels. The Lippert frame welds were broken. I have to call a 50 ton truck crane to tow RV to closest Camping World dealer at Fort Pierce. I was lucky that my 12,000 lb RV trailer did not disconnected, I could have killed my family in a hard brake, or someone in the highway if the trailer gets disconnected (the safety chains nor the emergency brake would have stop it to fall and rollover). My family (wife and kids) are psychologically affected and will not ride a truck towing and RV again, and I will not do either. I opened a claim with insurance Progressive (Claim#XXX), but they have denied any coverage saying manufacturer's defect are not covered by any policy. However they have failed to provide written report demonstrating it is defect. I opened Work Order #XXX, with the reseller, Camping World, but they have not being helpful, I left the RV at their parking lot and visit them in person to open my request for inspection and coverage, they refused to accept the RV inside their workshop, they told me I have to repair the weld first before they accept the unit. I opened claim with Lippert (trailer manufacturer), Case #XXX, they came back saying unit is not dafe to drive, and it is not a defect. On XXX called Keystone at [XXX], opened a complaint but did not get any case number, send pictures to [XXX], and they told me they are responsible. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11755033
Mileage unknown · May 29, 2022
Tires
New Trailer King RST ST 225/75R15 hanging on the spare tire rack on the back of my 2021 Cougar 22 MLSWE travel trailer that was never useD stored covered at my home BLEW UP. HEARD LOAD EXPLOSION AND TIRE DESTROYED AS WELL AS SPARE TIRE COVER
NHTSA ODI #11466606
Mileage unknown · Apr 3, 2022
Unknown Or Other
Spontaneous increase in propane supply levels causing heating equipment to overheat. No inspection has taken place because manufacturer cites lack of replacement parts for warranty replacement.
NHTSA ODI #11459460
400 miles · Jan 5, 2021
Tires
I BOUGHT THIS KEYSTONE TRAILER NEW IN AUGUST OF 2020. THE TIRES ONLY HAD 400 MILES OF USE BEFORE THIS TRIP. I EQUIPPED MY TRAILER WITH TIRE MINDER SYSTEM TO MONITOR TIRE PRESSURE AND TEMPERATURE. THERE WAS NO WARNING OF TIRE FAILURE. THE TIRE JUST EXPLODED AND CAME APART. DAMAGING MY TRAILER.
Keystone RV Company (Keystone) is recalling certain 2019-2022 Cougar 29FKD travel trailers. Improper clearance may allow the tires to contact the outrigger, causing damage to the tires.
Consequence & remedy
Consequence: Damaged tires can fail, causing a loss of vehicle control and increasing the risk of a crash.
Remedy: Dealers will notch the existing outrigger and install an additional outrigger between the two tires to provide proper clearance, free of charge. Owner notification letters were mailed May 12, 2022. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 22-430.
Additional source detail variants (2)
Tires
Keystone RV Company (Keystone) is recalling certain 2019-2022 Cougar 29FKD travel trailers. Improper clearance may allow the tires to contact the outrigger, causing damage to the tires.
Consequence: Damaged tires can fail, causing a loss of vehicle control and increasing the risk of a crash.
Remedy: Dealers will notch the existing outrigger and install an additional outrigger between the two tires to provide proper clearance, free of charge. Owner notification letters were mailed May 12, 2022. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 22-430.
Structure:frame And Members
Keystone RV Company (Keystone) is recalling certain 2019-2022 Cougar 29FKD travel trailers. Improper clearance may allow the tires to contact the outrigger, causing damage to the tires.
Consequence: Damaged tires can fail, causing a loss of vehicle control and increasing the risk of a crash.
Remedy: Dealers will notch the existing outrigger and install an additional outrigger between the two tires to provide proper clearance, free of charge. Owner notification letters were mailed May 12, 2022. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 22-430.
Keystone RV Company (Keystone) is recalling certain 2019-2021 Dutchmen Aspen Trail, Coleman, Keystone Cougar, Bullet, Passport, Hideout, Springdale, Sprinter, 2019 Keystone Impact, Fuzion, Residence, Retreat, Summerland, and Dutchmen Kodiak recreational vehicles, equipped with Winntec model 6020 two-stage propane regulators. The regulator may fail, causing an increase in propane pressure.
Consequence & remedy
Consequence: Increased propane pressure can enlarge the flames in gas appliances, increasing the risk of a fire.
Remedy: Dealers will replace the regulator and test the propane system for leaks, free of charge. Owner notification letters mailed February 25, 2021. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 21-414.
Keystone RV Company (Keystone) is recalling certain 2017-2021 Keystone Cougar 368MBI trailers. The frame rails do not have enough cross support, which could cause them to buckle under certain side-load stress conditions.
Consequence & remedy
Consequence: A buckled frame rail can increase the risk of a crash.
Remedy: Dealers will add cross braces between each spring hanger and an outrigger between the tires on the off-door side of the vehicle, free of charge. Owner notification letters were mailed July 15, 2021. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 21-411.
Additional source detail variants (2)
Structure:frame And Members
Keystone RV Company (Keystone) is recalling certain 2017-2021 Keystone Cougar 368MBI trailers. The frame rails do not have enough cross support, which could cause them to buckle under certain side-load stress conditions.
Consequence: A buckled frame rail can increase the risk of a crash.
Remedy: Dealers will add cross braces between each spring hanger and an outrigger between the tires on the off-door side of the vehicle, free of charge. Owner notification letters were mailed July 15, 2021. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 21-411.
Suspension:front:springs:leaf Spring Assembly:hanger,bracket
Keystone RV Company (Keystone) is recalling certain 2017-2021 Keystone Cougar 368MBI trailers. The frame rails do not have enough cross support, which could cause them to buckle under certain side-load stress conditions.
Consequence: A buckled frame rail can increase the risk of a crash.
Remedy: Dealers will add cross braces between each spring hanger and an outrigger between the tires on the off-door side of the vehicle, free of charge. Owner notification letters were mailed July 15, 2021. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 21-411.
Keystone RV Company (Keystone) is recalling certain 2021 Cougar 29MBS, 30RLS, 315RLS, 316RLS, 32BHS, 353SRX, 364BHL, and 368MBI trailers equipped with the Off the Grid (OTG) Solar package. The inverter may have been incorrectly wired, causing power to energize the shore power connection, when in use.
Consequence & remedy
Consequence: An energized shore power connection can cause an electrical shock, increasing the risk of injury.
Remedy: Keystone will notify owners, and dealers will test the inverter function, and rewire it if necessary, free of charge. The recall began March 24, 2021. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 21-403.
Keystone RV Company (Keystone) is recalling certain 2021 Cougar 22MLS, 22RBS, 25RDS, 26RBS, 26RKS, 27RES, 29BHS, 30RKD, 31MBS, 32RLI and 34TSB recreational trailers equipped with a Solar Prep or an off-the-grid "OTG" Solar Camping Package. The Solar Prep wiring to the 12VDC breakers located by the battery may not be connected to the protected side of the breaker.
Consequence & remedy
Consequence: Since it is not connected properly to the breaker, if the Solar Prep wiring experiences an electrical short, it will increase the risk of a fire.
Remedy: Keystone will notify owners, and dealers will inspect the installation of the Solar Prep wiring at the circuit breaker mounted close to the battery and remount the wiring if needed, free of charge. The recall began January 11, 2021. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 21-392.
Keystone RV Company (Keystone) is recalling certain 2020-2021 Cougar trailers equipped with the Off the Grid (OTG) Solar package. The inverter may have been incorrectly wired, causing power to energize the shore power connection, when in use.
Consequence & remedy
Consequence: If the inverter is turned on, and energizes the shore power connection, it can increase the risk of injury.
Remedy: Keystone will notify owners, and dealers will test the function of the inverter and rewire it as needed, free of charge. The recall began November, 18, 2020. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 20-389.
Keystone RV Company (Keystone) is recalling certain 2020-2021 Cougar travel trailers, model 24RDS, equipped with a Furrion range cook top. The interior range cooktop is installed in a cabinet that may not be entirely sealed from the furnace cavity. As a result, during furnace operation, the interior range cooktop burner flame may invert.
Consequence & remedy
Consequence: If the cooktop burner flames invert, there is an increased risk of a fire and injury.
Remedy: Keystone will notify owners, and dealers will inspect the interior range cooktop with the furnace running, installing a plywood panel to seal it as necessary, free of charge. This recall began July 17, 2020. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 20-377.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2021 Keystone Cougar Problems, Complaints & Recalls | Skip That Year
Illustration