Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 5 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
5 reports
7,000 miles · Dec 14, 2019
SuspensionWheels
ONLY EVENT SO FAR, A PROPERLY INFLATED TIRE HAD THE TREAD COME OFF THE CASING AT ABOUT 7000 MILES AT 60 MPH. I REPLACED THE OEM LOAD RANGE 'D' TIRES WITH LOAD RANGE 'E' TIRES.THESE OEM TIRES AT 2540# GIVE A SCANT 160# SAFETY MARGIN. IN JULY WHILE DOING MAINTENANCE FOR A 1500 MILE TRIP I READ THE AXLE TAGS SO I COULD OBTAIN THE…
Read full complaint
ONLY EVENT SO FAR, A PROPERLY INFLATED TIRE HAD THE TREAD COME OFF THE CASING AT ABOUT 7000 MILES AT 60 MPH. I REPLACED THE OEM LOAD RANGE 'D' TIRES WITH LOAD RANGE 'E' TIRES.THESE OEM TIRES AT 2540# GIVE A SCANT 160# SAFETY MARGIN. IN JULY WHILE DOING MAINTENANCE FOR A 1500 MILE TRIP I READ THE AXLE TAGS SO I COULD OBTAIN THE CORRECT SEALS FOR THE HUB BEARINGS. THE AXLES ARE RATED 4400# EACH TIMES 2 IS 8800#. THE GVW RATING FOR THE TRAILER IS 10,000#. SO IF THIS 5TH WHEEL IS TRAVELING FULLY LOADED IT IS 1200# OVER THE CAPACITY OF THE INSTALLED AXLES. I AM A CERTIFIED AUTO TECHNICIAN, I FIND THIS UNSAFE, ESPECIALLY WITH THE LARGE HILLS HERE IN NORTH CAROLINA.
NHTSA ODI #11289033
5,000 miles · Jan 19, 2018
Unknown Or Other
I HAVE A 2015 KEYSTONE COUGAR FIFTH WHEEL TRAILER AND HAD A FAILURE OF THE SPARE TIRE CARRIER THAT IS MOUNTED TO THE BUMPER OF A PULL OUT BIKE/STORAGE TRAY. THE SPARE TIRE CARRIER BROKE OFF AND THE TIRE COULD HAVE CAUSED TERRIBLE DANGER TO ANOTHER VEHICLE, BUT FORTUNATELY THAT DID NOT OCCUR. I GOT NO RESPONSE FROM KEYSTONE OR …
Read full complaint
I HAVE A 2015 KEYSTONE COUGAR FIFTH WHEEL TRAILER AND HAD A FAILURE OF THE SPARE TIRE CARRIER THAT IS MOUNTED TO THE BUMPER OF A PULL OUT BIKE/STORAGE TRAY. THE SPARE TIRE CARRIER BROKE OFF AND THE TIRE COULD HAVE CAUSED TERRIBLE DANGER TO ANOTHER VEHICLE, BUT FORTUNATELY THAT DID NOT OCCUR. I GOT NO RESPONSE FROM KEYSTONE OR GUIDANCE ON HOW TO RESOLVE THE ISSUE. I SEE THAT THERE WAS A RECALL IN 2/25/10 FOR THE SAME ISSUE ON KEYSTONE FIFTH WHEELS. HOW DOES THIS KEEP HAPPENING. I AM UNSURE HOW TO MOUNT THE SPARE TIRE SAFELY NOW AND KEYSTONE WILL NOT HELP. I AM CONCERNED IF I BUY ANOTHER CARRIER AND PLACE IT BACK ON THE BUMPER THE SAME THING WILL EVENTUALLY HAPPEN AGAIN AND IT COULD KILL SOMEONE ON THE ROAD IF IT CAME OFF. THANKS FOR YOUR ATTENTION.
NHTSA ODI #11063838
Mileage unknown · Sep 7, 2017
Electrical SystemService Brakes
FROM THE TIME I LEFT THE DEALER LOT, I NEVER HAD BRAKES THAT WORKED PROPERLY. INCREASING THE OUTPUT FROM THE BRAKE CONTROLLER DIDN'T HELP. THE BRAKES WOULD OVER HEAT AND NEVER FELT THAT I HAD ENOUGH BRAKE TO STOP THE TRAILER/TRUCK. HAD THE BRAKES CHECKED BY SEVERAL RV DEALERS WHICH LED TO AN ADJUST ONLY. RECENT TRIP CAUSED "HOT…
Read full complaint
FROM THE TIME I LEFT THE DEALER LOT, I NEVER HAD BRAKES THAT WORKED PROPERLY. INCREASING THE OUTPUT FROM THE BRAKE CONTROLLER DIDN'T HELP. THE BRAKES WOULD OVER HEAT AND NEVER FELT THAT I HAD ENOUGH BRAKE TO STOP THE TRAILER/TRUCK. HAD THE BRAKES CHECKED BY SEVERAL RV DEALERS WHICH LED TO AN ADJUST ONLY. RECENT TRIP CAUSED "HOT" BRAKES/WHEELS AND BRAKE SMELL. WENT TO A FACILITY THAT SPECIALIZES IN RV REPAIR AND TOLD THEM TO TEAR THE SYSTEM APART AND FIX THE PROBLEM. THEY FOUND NOT ENOUGH VOLTAGE AT BRAKES. FURTHER INVESTIGATION FOUND EXCESSIVE LENGTH AND SMALL GAGE WIRE INSTALLED BY MANUFACTURER. NOT ENOUGH CURRENT GOING TO BRAKES. KEYSTONE INSTALLED 14 GAGE WIRE AND IT SHOULD HAVE BEEN 12 GAGE.
NHTSA ODI #11022172
2,000 miles · Jul 17, 2016
Unknown Or Other
THE SPARE TIRE HOLDER MOUNTED ON THE REAR BUMPER BROKE WHILE TRAVELING ON THE INTERSTATE AT 70 MPH IN HEAVY TRAFFIC. WE WERE SHOCKED TO SEE HOW LIGHT IT WAS MADE AFTER IT BROKE. NO INJURIES HAPPEN BUT THIS COULD HAVE EASILY TURNED OUT DIFFERENTLY. WE DID NOT FIND OUR SPARE TIRE.
NHTSA ODI #10885387
Mileage unknown · May 18, 2016
Suspension
TL* THE CONTACT OWNS A 2015 KEYSTONE COUGAR FIFTH WHEEL. WHILE DRIVING 60 MPH, THE HANGER THAT HELD THE DRIVER SIDE SPRING DETACHED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Keystone RV Company (Keystone) is recalling various 2003-2018 Crossroads, Dutchmen, and Keystone recreational trailers equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V755-5127.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: Keystone will notify owners and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Keystone customer service at 1-574-535-2100, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Keystone's number for this recall is 17-307.
Keystone RV Company (Keystone) is recalling certain model year 2015 Keystone Sprinter, Cougar, Montana, Montana High Country, Outback, Bullet, Avalanche, Alpine, Fuzion, Impact, Laredo, Raptor, Carbon, and Passport, and Dutchmen Kodiak, Aerolite, Denali, and Voltage vehicles. In the affected vehicles, the screws that attach the expanding room to the sliding mechanism cable may fail allowing the room to extend unintentionally while the vehicle is in motion.
Consequence & remedy
Consequence: If the room extends while vehicle is in motion, there is an increased risk of a crash.
Remedy: Keystone has notified owners, and dealers will replace the screws that secure the drive chain, free of charge. The recall began on June 18, 2015. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 15-225.
Keystone RV Company (Keystone) is recalling certain model year 2015-2016 Keystone Sprinter, Springdale, Bullet, Cougar, Hideout, and Passport trailers and 2015-2016 Dutchmen Aspen, Coleman, Denali, Razorback, Rubicon, and Voltage trailers. For a full list of the specific models and floor plans affected, see RCLRPT-15V207-4161.PDF under Associated Documents. In the affected trailers, the studs that are used to attach the wheels to the axle hubs may break.
Consequence & remedy
Consequence: If the wheel studs break, the wheel could detach from the vehicle, increasing the risk of a crash.
Remedy: Keystone will notify owners, and dealers will replace the wheel hubs, free of charge. The recall began on June 29, 2015. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 15-230.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2015 Keystone Cougar Problems, Complaints & Recalls | Skip That Year
Illustration