Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Exterior Lighting. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
1 reports
5,300 miles · Jul 11, 2009
Exterior Lighting
HEADLIGHT LAMP FAILURE HEADLIGHT LAMP WAS REPLACED AT 4800 MILES THE SECOND (NEW) HEADLAMP HAS NOW FAILED AFTER LESS THAN 500 MILES IGNITION STARTER SWITCH CONTACTS CORROSION, FAILED TO TURN OVER ENGINE. THIS WAS REPAIRED BY THE DEALER UNDER WARRANTY. THIS MOTORCYCLE MODEL HAS A SAFETY RECALL CONCERNING THE WIRING HARNES…
Read full complaint
HEADLIGHT LAMP FAILURE HEADLIGHT LAMP WAS REPLACED AT 4800 MILES THE SECOND (NEW) HEADLAMP HAS NOW FAILED AFTER LESS THAN 500 MILES IGNITION STARTER SWITCH CONTACTS CORROSION, FAILED TO TURN OVER ENGINE. THIS WAS REPAIRED BY THE DEALER UNDER WARRANTY. THIS MOTORCYCLE MODEL HAS A SAFETY RECALL CONCERNING THE WIRING HARNESS. THIS PARTICULAR MOTORCYCLE WAS RETURNED TO THE DEALER FOR INSPECTION OF THE WIRING HARNESS, THE DEALER INSTALLED MANUFACTURER SUPPLIED KIT WHICH ADDED PROTECTION FOR POTENTIAL ABRASION POINTS. THE ABOVE FAILURES OF THE IGNITION STARTER AND THE HEADLAMPS ALL HAPPENED AFTER THE DEALER INSPECTION OF THE WIRING HARNESS. *TR
KAWASAKI IS RECALLING 5,804 MY 2008 KL650E8F AND KL650E8FL (CALIFORNIA) MOTORCYCLES. THE TURN SIGNAL STALK(S) CAN BREAK, RESULTING IN THE SIGNAL ASSEMBLY HANGING BY THE WIRE HARNESS.
Consequence & remedy
Consequence: THIS COULD CREATE A POSSIBILITY OF A CRASH RESULTING IN INJURY OR DEATH.
Remedy: DEALERS WILL REPLACE ALL FOUR TURN SIGNAL ASSEMBLIES. THE RECALL BEGAN ON OCTOBER 13, 2008. OWNERS MAY CONTACT KAWASAKI AT 1-866-802-9381.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2008 Kawasaki KL650E8FL Problems, Complaints & Recalls | Skip That Year
Illustration