IllustrationWHILE PUTTING MY T.J. ON A LIFT FOR INSPECTION THE PASSENGER SIDE FRAME CRACKED IN HALF. THIS IS THE SECOND TIME THE FRAME WILL HAVE TO BE REPAIRED DUE TO DETERIERATION.
2000 Jeep Wrangler
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2000 Jeep Wrangler do not stand out strongly from the model-year median of 265.
About this comparison →How this year compares
Owner complaints by model year
Compare all Wrangler years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
1825–50K
1950–75K
1575–100K
26100–150K
29150K+
116 reports with mileage · 135 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports20 fire reports9 injury reports
Structure complaints
56 reportsTL* THE CONTACT OWNS A 2000 JEEP WRANGLER. WHILE AN INDEPENDENT MECHANIC WAS SERVICING THE VEHICLE, HE OBSERVED THE CHASSIS WAS RUSTED. AS A RESULT, THE ENTIRE CHASSIS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000. UPDATED 11/18/1…
Read full complaint
TL* THE CONTACT OWNS A 2000 JEEP WRANGLER. WHILE AN INDEPENDENT MECHANIC WAS SERVICING THE VEHICLE, HE OBSERVED THE CHASSIS WAS RUSTED. AS A RESULT, THE ENTIRE CHASSIS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000. UPDATED 11/18/15*LJ
TL* THE CONTACT OWNS A 2000 JEEP WRANGLER. THE CONTACT STATED THAT THE VEHICLE'S SKID PLATE WAS WITNESSED UNDER THE VEHICLE, WHICH IS WHAT PROMPTED A CLOSER LOOK AT THE VEHICLE. UPON LOOKING MORE CLOSELY, THE CONTACT NOTICED THAT THE VEHICLE'S FRAME WAS COMPLETELY RUSTED AT THE BOTTOM. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. …
Read full complaint
TL* THE CONTACT OWNS A 2000 JEEP WRANGLER. THE CONTACT STATED THAT THE VEHICLE'S SKID PLATE WAS WITNESSED UNDER THE VEHICLE, WHICH IS WHAT PROMPTED A CLOSER LOOK AT THE VEHICLE. UPON LOOKING MORE CLOSELY, THE CONTACT NOTICED THAT THE VEHICLE'S FRAME WAS COMPLETELY RUSTED AT THE BOTTOM. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000. UPDATED 09/10/15*LJ
TL* THE CONTACT OWNS A 2000 JEEP WRANGLER. WHILE DRIVING 10 MPH, THE CONTACT HEARD A LOUD SOUND AND THE CROSS MEMBER FRACTURED. THE CONTACT STATED THAT THE ENGINE STALLED. THE CONTACT STATED THAT THE VEHICLE RESTARTED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE…
Read full complaint
TL* THE CONTACT OWNS A 2000 JEEP WRANGLER. WHILE DRIVING 10 MPH, THE CONTACT HEARD A LOUD SOUND AND THE CROSS MEMBER FRACTURED. THE CONTACT STATED THAT THE ENGINE STALLED. THE CONTACT STATED THAT THE VEHICLE RESTARTED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 191,106.
TL* THE CONTACT OWNS A 2000 JEEP WRANGLER. THE CONTACT STATED THAT UPON INSPECTION, IT WAS DISCOVERED THAT THE SUBFRAME OF THE VEHICLE EXPERIENCED SEVERE RUSTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 41,000.
TL* THE CONTACT OWNS A 2000 JEEP WRANGLER. WHILE TRAVELING APPROXIMATELY 45 MPH, THE GEARS BECAME EXTREMELY DIFFICULT TO CHANGE OVER WITHOUT WARNING. THE CONTACT ALSO HEARD A GRINDING NOISE UPON CHANGING GEARS AND THE VEHICLE WOBBLED. THE CONTACT WAS ABLE TO CAUTIOUSLY DRIVE THE VEHICLE TO A REPAIR SHOP. THE TECHNICIAN DIAGNOSED…
Read full complaint
TL* THE CONTACT OWNS A 2000 JEEP WRANGLER. WHILE TRAVELING APPROXIMATELY 45 MPH, THE GEARS BECAME EXTREMELY DIFFICULT TO CHANGE OVER WITHOUT WARNING. THE CONTACT ALSO HEARD A GRINDING NOISE UPON CHANGING GEARS AND THE VEHICLE WOBBLED. THE CONTACT WAS ABLE TO CAUTIOUSLY DRIVE THE VEHICLE TO A REPAIR SHOP. THE TECHNICIAN DIAGNOSED THAT THE UNDERBODY FRAMING FRACTURED DUE TO CORROSION AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 210,000.
FRAME IS ROTTING AWAY. VEHICLE IS GARAGE KEPT. NO SPECIFIC AREA BECAUSE ITS THE ENTIRE FRAME. THESE VEHICLES COST ENTIRELY TOO MUCH MONEY FOR THIS TO BE HAPPENING. THERE ARE MANY COMPLAINTS ON HERE WITH THE SAME ISSUE. CHRYSLER APPARENTLY DIDN'T FEEL IT NECESSARY TO STEP UP TO THE PLATE AND FIX THE ISSUE. IF I WAS NOT A KN…
Read full complaint
FRAME IS ROTTING AWAY. VEHICLE IS GARAGE KEPT. NO SPECIFIC AREA BECAUSE ITS THE ENTIRE FRAME. THESE VEHICLES COST ENTIRELY TOO MUCH MONEY FOR THIS TO BE HAPPENING. THERE ARE MANY COMPLAINTS ON HERE WITH THE SAME ISSUE. CHRYSLER APPARENTLY DIDN'T FEEL IT NECESSARY TO STEP UP TO THE PLATE AND FIX THE ISSUE. IF I WAS NOT A KNOWLEDGEABLE INDIVIDUAL, THIS IS A HUGE SAFETY ISSUE FOR SOMEONE DRIVING DOWN THE HIGHWAY AND FRAME OF JEEP BREAKING. I'M SURE IT'S ALREADY HAPPENED AND IS JUST NOT BEING ACKNOWLEDGED. *TR
PREMATURE RUSTING OF THE CHASSIS FRAME. MAY HAVE TO REPAIR OR REPLACE FRAME SECTIONS OR POSSIBLY THE ENTIRE FRAME DUE TO PREMATURE CORRODING OF THE FRAME. APPARENTLY A VERY COMMON PROBLEM WITH WRANGLER OWNERS. *TR
PURCHASED THIS VEHICLE IN 21013 FROM A PRIVATE SELLER. UPON CHANGING THE ENGINE OIL ONE DAY SHORTLY THEREAFTER, NOTICED THE PASSENGER SIDE FRAME AREA, WHERE THE REAR, LOWER CONTROL ARM IS MOUNTED, WAS COMPLETELY RUSTED THROUGH! I HAVE SINCE HAD THIS REPAIRED, AT AN ADDITIONAL COST OF $800.00. ALSO, NOTICED THE PASSENGER SIDE …
Read full complaint
PURCHASED THIS VEHICLE IN 21013 FROM A PRIVATE SELLER. UPON CHANGING THE ENGINE OIL ONE DAY SHORTLY THEREAFTER, NOTICED THE PASSENGER SIDE FRAME AREA, WHERE THE REAR, LOWER CONTROL ARM IS MOUNTED, WAS COMPLETELY RUSTED THROUGH! I HAVE SINCE HAD THIS REPAIRED, AT AN ADDITIONAL COST OF $800.00. ALSO, NOTICED THE PASSENGER SIDE FRAME ALL ALONG WHERE THE TRANSMISSION SKID PLATE IS MOUNTED - IS COMPLETELY RUSTED THROUGH ALONG APPROXIMATELY 8" ALONG THE BOTTOM! I CAN RUN 4 FINGERS IN THE BOTTOM OF THIS FRAME! AND, THE FRONT SKID PLATE NUTSERTS ON BOTH SIDES OF THE SKID PLATE, ARE GONE! RUSTED AWAY - COMPLETELY! PREVIOUS OWNER HAD THE SKID PLATE ACTUALLY WELDED TO THE FRAME! THIS SHOULD NEVER, EVER HAPPEN! I HAVE A 2003 TOYOTA 4RUNNER WITH ZERO FRAME RUST - ZERO! LOOKS BRAND NEW TO THIS DAY! COME TAKE A LOOK. MANY, MANY, MANY AND WAY TOO NUMEROUS TO MENTION PEOPLE HAVE THIS SAME FRAME RUST PROBLEM ON THEIR JEEPS. WHY IS THIS? THIS IS NOT SAFE, YET THESE VEHICLES ARE RE-SOLD OVER AND OVER AGAIN. THIS IS 2015. NO OTHER VEHICLE - AMERICAN OR IMPORT - HAS THIS PROBLEM. WHY IS THIS ALLOWED TO HAPPEN? MUST PEOPLE GET KILLED DURING THEIR ENJOYMENT OF THEIR SUPPOSEDLY "SAFE", IN THIS CASE, AMERICAN MADE VEHICLE BEFORE DEALERS AND THE NHTSA WILL APPLY A REPAIR BULLETIN? TOYOTA, IS STILL BUYING BACK TRUCKS WITH FRAME RUST - WHY ISN'T THE AMERICAN COMPANY CHRYSLER? HMMMM. *TR
THE CONSTRUCTION OF THIS FRAME HAS EXTREME RUST ISSUES. THE INTERNAL FRAME WAS NOT CORRECTLY PROTECTED FORM WEATHER RESULTING IN EXCESSIVE RUST THAT HAS A HIGH RISK OF FRAME FAILURE. *TR
Official recalls
102V104000 · Fuel System, Gasoline:fuel Injection System:injectors
Apr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE00018 · Air Bag Module Detachment
Opened Apr 14, 2000 · Closed Oct 13, 2000
Status: closed (inferred from source dates) · Air Bags
ODI HAS RECEIVED A COMMPLAINT STATING THAT THE DRIVER-SIDE FRONTAL AIR BAG MODULE DETACHED FROM THE STEERING WHEEL WHILE ATTEMPTION TO USE THE HORN FOR THE FIRST TIME IN A BRAND NEW MODEL YEAR 2000 JEEP WRANGLE (PURCHASED I LATE MARCH 2000).THE AIR BAG MODULE FELL OFF THE STEERING WHEEL AND WAS HANGING BY ITS WIRES.THE REPAIRING DELERSHIP STATED THAT THE TWO MOUNTING SCREWS, HOLDING THE INTEGTATED HORN/AIR BAG MODULE TO THE STEERING WHEEL, WERE MISSING.THIS INVESTIGATIONN IS OPENED TO DETERMINE THE SCOPE OF THE POTENTIAL PROBLEM OF MIS-ASSEMBLED AIR BAG MODULES IN TH EJEEP WRANGLE VEHICLES.