TRANSMISSION GRINDS WHEN SHIFTING INTO SECOND GEAR MOST OF THE TIME... GRINDING IS MOST NOTICABLE AFTER THE TRANSMISSION HAS BEEN DRIVEN FOR AT LEAST 15 MINUTES. THE WARMER THE TRANSMISION GETS THE WORSE THE SHIFTING GETS. I HAVE HAD IT POP OUT OF GEAR TWICE WHEN STARTING FROM A STOP. THE SHIFTING IS NOTCHY IN ALL OF THE GEAR…
Read full complaint
TRANSMISSION GRINDS WHEN SHIFTING INTO SECOND GEAR MOST OF THE TIME... GRINDING IS MOST NOTICABLE AFTER THE TRANSMISSION HAS BEEN DRIVEN FOR AT LEAST 15 MINUTES. THE WARMER THE TRANSMISION GETS THE WORSE THE SHIFTING GETS. I HAVE HAD IT POP OUT OF GEAR TWICE WHEN STARTING FROM A STOP. THE SHIFTING IS NOTCHY IN ALL OF THE GEARS ESPECIALLY 2ND GEAR. THERE IS ALSO A RATTLE WHILE IN NEUTRAL AND IT WILL NOT GO INTO 1ST AT TIMES, YOU MUST PUT IT BACK IN NEUTRAL AND RE ENGAGE THE CLUTCH FOR IT TO GO INTO GEAR. *AK
NHTSA ODI #736684
Mileage unknown · Nov 15, 2000
Power TrainService Brakes, HydraulicVisibility
CONSUMER PUT VEHICLE IN DRIVE & IT WENT INTO REVERSE. DEALER REPLACED THE MASTER CYLINGER BECAUSE WHILE BRAKING PEDAL WENT TO FLOOR, CONSUMER LATER HEARD A NOISE WHILE BRAKING, DEALER LUBRICATED AND ADJUSTED REAR DRUMS. REAR GLASS WAS CHIPPED AND WAS REPLACED. *SLC
NHTSA ODI #875032
Mileage unknown · Nov 15, 2000
Power Train
5 SPEED MANUAL TRANSMISSION STARTED (NV3500) IS NOT SHIFTING SMOOTHLY INTO ANY GEAR. THERE IS RESISTANCE AND A GRINDING SOUND DURING SHIFTING INTO ANY AND ALL GEARS. TRANSMISSION EMITS A "CLUNKING" NOISE WHEN CLUTCH IS DISENGAGED BETWEEN GEAR SHIFTS. ON 11/06/2000, VEHICLE WAS TAKEN TO DEALERSHIP RESPONSIBLE FOR WARRANTY SERV…
Read full complaint
5 SPEED MANUAL TRANSMISSION STARTED (NV3500) IS NOT SHIFTING SMOOTHLY INTO ANY GEAR. THERE IS RESISTANCE AND A GRINDING SOUND DURING SHIFTING INTO ANY AND ALL GEARS. TRANSMISSION EMITS A "CLUNKING" NOISE WHEN CLUTCH IS DISENGAGED BETWEEN GEAR SHIFTS. ON 11/06/2000, VEHICLE WAS TAKEN TO DEALERSHIP RESPONSIBLE FOR WARRANTY SERVICE REPAIRS. DEALER CLAIMED THAT THEY ROAD-TESTED THE VEHICLE AND THAT ALL SHIFTING FUNCTIONS WERE "WORKING TO FACTORY SPECS". DEALERSHIP REFUSED TO PERFORM ANY FURTHER INVESTIGATION INTO THIS COMPLAINT AND DID NOT OFFER A REMEDY OR OFFER TO REPAIR. AFTER 2 MORE WEEKS OF OPERATION, THE GEAR GRINDING IS GETTING WORSE AND MORE RESISTIVE TO SHIFTING FROM GEAR TO GEAR. *AK
NHTSA ODI #736380
Mileage unknown · Nov 7, 2000
Power Train
VEHICLE WILL VIOLENTLY JUMP OUT OF 1ST GEAR UPON ACCELERATION. DEALER HAS REPLACED TRANSMISSION ONCE AT 404 MILES. MANUFACTURER DID CHANGE SUPPLIER.*AK THE REPLACED TRANSMISSION HAS EXCESSIVE NOISE, AND IT IS DIFFICULT TO CHANGE GEARS WHEN THE VEHICLE IS WARMED UP. THE VEHICLE IS DEFECTIVE. *YH
NHTSA ODI #874531
Mileage unknown · Oct 29, 2000
Power Train
TRANSMISSION POPS OUT OF 1ST AND 2ND GEAR. TRANSMISSION VERY NOISY WHILE IDLING IN NEURTRAL. NOISE STOPS WHEN CLUTCH IS DEPRESSED. NOISE IS WORSE WHEN TRANSMISSION IS HOT. DEALER REPLACED TRANSMISSION WHICH CORRECTED POPPING OUT OF GEAR PROBLEM BUT NEW TRANNY IS STILL NOISY WHEN IDLING IN NEURTRAL.
NHTSA ODI #735384
Mileage unknown · Oct 27, 2000
Power Train
I BELIEVE A BRAND NEW VEHICLE SHOULD HAVE NOTHING WRONG WITH IT FOR AT LEAST 2 YEARS THATS WHY I BOUGHT A NEW ONE. THIS HAS BEEN THE WORST TIME OF MY LIFE AND I CANNOT GET HELP WITHOUT SPENDING LOADS OF MONEY TO FIGHT THESE PEOPLE AND CHRYSLER. NO ,SAFETY DEFECT LISTED IN SUMMARY. *AK
NHTSA ODI #735286
Mileage unknown · Oct 24, 2000
Power Train
VERY HARD TO DOWN SHIFT FROM 5TH AFTER HIGHWAY DRIVING, LOUD CLUTCH NOISE WHEN IDLING IN NEUTRAL.*AK
NHTSA ODI #735017
Mileage unknown · Oct 22, 2000
Power TrainVisibility
WATER LEAKS UNDER THE DASH ON THE DRIVERS SIDE IF DRIVING AT HIWAY SPEEDS. TRANSMISSION POPS OUT OF GEAR AT TAKE OFF AND IS HARD TO SHIFT AFTER THE VEHICLE IS DRIVEN AND WARMED UP.
NHTSA ODI #734916
Mileage unknown · Oct 17, 2000
Power Train
5SPD TRANSMISSION IS ABNORNALLY LOUD AND OCCASIONALLY POPS OUT OF GEAR.*AK
NHTSA ODI #734524
Mileage unknown · Oct 16, 2000
Power Train
TRANSMISSION IS HARD TO SHIFT OUT OF 2ND GEAR (ALMOST TO THE POINT OF BEING STUCK) AFTER THE TRANSMISSION HAS WARMED UP.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE00018 · Air Bag Module Detachment
Opened Apr 14, 2000 · Closed Oct 13, 2000
Status: closed (inferred from source dates) · Air Bags
ODI HAS RECEIVED A COMMPLAINT STATING THAT THE DRIVER-SIDE FRONTAL AIR BAG MODULE DETACHED FROM THE STEERING WHEEL WHILE ATTEMPTION TO USE THE HORN FOR THE FIRST TIME IN A BRAND NEW MODEL YEAR 2000 JEEP WRANGLE (PURCHASED I LATE MARCH 2000).THE AIR BAG MODULE FELL OFF THE STEERING WHEEL AND WAS HANGING BY ITS WIRES.THE REPAIRING DELERSHIP STATED THAT THE TWO MOUNTING SCREWS, HOLDING THE INTEGTATED HORN/AIR BAG MODULE TO THE STEERING WHEEL, WERE MISSING.THIS INVESTIGATIONN IS OPENED TO DETERMINE THE SCOPE OF THE POTENTIAL PROBLEM OF MIS-ASSEMBLED AIR BAG MODULES IN TH EJEEP WRANGLE VEHICLES.
Illustration