← New search

2012 Jeep Patriot

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2012 Jeep Patriot do not stand out strongly from the model-year median of 188.

About this comparison →

When problems were reported

Mileage at the reported incident

257 reports with mileage · 97 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Engine. Review the 114 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports5 fire reports5 injury reports

Power Train complaints

63 reports
Clear category filter
Mileage unknown · Mar 25, 2019
Power Train

CAR IS UNABLE TO TRANSFER TO HIGHER GEARS. ERROR CODE P0730 AND P0777. 84K MILES. TWO SHOPS STATING NEW TRANSMISSION NEEDED.

NHTSA ODI #11191352

140,000 miles · Mar 18, 2019
Power Train

I WAS DRIVING DOWN THE STREET STOPPED AND PROCEEDED TO GO UP THE HILL WHEN I PRESSED ON THE GAS PEDAL IT WOULD NOT ACCELERATE SO I PUT IT IN NEUTRAL IT WOULD REV UP BUT WHEN I PUT IT DRIVE IT WOULD NOT ACCELERATE. SO I HAVE TAKEN IT TO THE MECHANIC TO HAVE IT EVALUATED AND HE SAID THE TRANSMISSION NEEDS TO BE REPLACED IT IS ON…

Read full complaint

I WAS DRIVING DOWN THE STREET STOPPED AND PROCEEDED TO GO UP THE HILL WHEN I PRESSED ON THE GAS PEDAL IT WOULD NOT ACCELERATE SO I PUT IT IN NEUTRAL IT WOULD REV UP BUT WHEN I PUT IT DRIVE IT WOULD NOT ACCELERATE. SO I HAVE TAKEN IT TO THE MECHANIC TO HAVE IT EVALUATED AND HE SAID THE TRANSMISSION NEEDS TO BE REPLACED IT IS ONLY 7 YEARS OLD I THINK THAT IS CRAZY. FROM ONLINE FORUMS THERE HAVE BEEN QUITE A FEW PATRIOTS THAT HAVE NEEDED NEW TRANSMISSIONS WITH NO AVAIL FROM THE MANUFACTURERS. I AM HOPING FOR A RECALL ON THIS TRANSMISSION SINCE I AM STILL PAYING ON THIS VEHICLE AND CANNOT AFFORD TO BUY ANOTHER AND PAY OUT $4200 FOR A NEW TRANSMISSION.

NHTSA ODI #11189742

64,892 miles · Oct 3, 2018
EnginePower Train

WHEN THE VEHICLE SLOWED DOWN AND WAITED AT INTERSECTION OR MIDDLE LANE, THE ENGINE SHUTS OFF BY ITSELF. WHEN IT IS RESTARTED, THE POWER IS BACK EITHER IMMEDIATELY OR AFTER A FEW MINUTES. I READ ONLINE AND MANY MANY CUSTOMERS REPORTED THIS PROBLEM, RANGING FROM VERY NEW JEEP PATRIOT (LESS THAN 10,000 MILES) TO DRIVING AT HIGH SPE…

Read full complaint

WHEN THE VEHICLE SLOWED DOWN AND WAITED AT INTERSECTION OR MIDDLE LANE, THE ENGINE SHUTS OFF BY ITSELF. WHEN IT IS RESTARTED, THE POWER IS BACK EITHER IMMEDIATELY OR AFTER A FEW MINUTES. I READ ONLINE AND MANY MANY CUSTOMERS REPORTED THIS PROBLEM, RANGING FROM VERY NEW JEEP PATRIOT (LESS THAN 10,000 MILES) TO DRIVING AT HIGH SPEED. THE LINKS ARE SHOWN BELOW: HTTP://WWW.CARPROBLEMZOO.COM/JEEP/PATRIOT/AUTOMATIC-TRANSMISSION-CONTROL-MODULE-PROBLEMS.PHP HTTPS://WWW.JEEPPATRIOT.COM/FORUM/5-JEEP-PATRIOT-GENERAL-DISCUSSION/92388-HELP-ENGINE-SHUT-DOWN.HTML WHEN I TOOK IT TO THE DEALER, THEY CAN NOT FIGURE OUT THE CAUSES. THE LAST TIME, THEY SAID IT IS THE TRANSMISSION CONTROL MODULE ISSUE. SINCE SO MANY CUSTOMERS REPORTED THIS ISSUE, THIS VEHICLE NEEDS A RECALL. THE UNEXPECTED SHUTOFF IS VERY DANGEROUS.

NHTSA ODI #11133024

119,000 miles · Oct 2, 2018
Power Train

TRANSMISSION OVERHEATED GOING 60 MILES PER HOUR ON THE INTERSTATE. I PULLED OVER AND LET THE LIGHT GO OFF PER THE USER MANUAL AND DIDN'T DRIVE IT ANYMORE. PUT IT IN THE SHOP ON MONDAY AND IT NEEDS A BRAND NEW TRANSMISSION WITH ONLY 119K MILES ON IT!

NHTSA ODI #11132915

75,000 miles · Sep 10, 2018
Power Train

THE TRANSMISSION TEMPERATURE GAUGE HAS COME ON WHEN TRAVELING AT NORMAL HIGHWAY SPEEDS, CAUSING AN IMMEDIATE LOSS OF POWER AND REQUIRING ME TO PULL OVER AND LET THE ENGINE COOL DOWN. 2 JEEP DEALERSHIPS HAVE ASSESSED THE VEHICLE IN THE DAYS AFTER THE INCIDENTS, NEITHER OF WHICH COULD OFFER ANY REMEDY. BOTH DEALERSHIPS' SERVICE …

Read full complaint

THE TRANSMISSION TEMPERATURE GAUGE HAS COME ON WHEN TRAVELING AT NORMAL HIGHWAY SPEEDS, CAUSING AN IMMEDIATE LOSS OF POWER AND REQUIRING ME TO PULL OVER AND LET THE ENGINE COOL DOWN. 2 JEEP DEALERSHIPS HAVE ASSESSED THE VEHICLE IN THE DAYS AFTER THE INCIDENTS, NEITHER OF WHICH COULD OFFER ANY REMEDY. BOTH DEALERSHIPS' SERVICE MANAGERS MENTIONED THAT THESE VEHICLES' TRANSMISSIONS ARE OFTEN PROBLEMATIC AND DO NOT HANDLE HIGH TEMPERATURES WELL, BUT WITH NO ACTIVE RECALL, NEITHER COULD OFFER ANY RECOURSE OR EVEN A REMEDY. THIS IS CLEARLY A CASE OF A POORLY ENGINEERED PRODUCT (THE JATCO CVT) THAT THE MANUFACTURER IS AVOIDING DEALING WITH, AT THE EXPENSE AND SAFETY OF ITS CONSUMERS. IN FACT, JEEP NO LONGER USES THIS TRANSMISSION - THEY REPLACED IT IN 2014 - CLEARLY THEY KNEW THERE WAS A PROBLEM. THIS ISSUE IS A BLATANT SAFETY HAZARD AND NEEDS TO BE INVESTIGATED MORE THOROUGHLY AND THE MANUFACTURER HELD TO ACCOUNT FOR THE UNSAFE CONDITIONS THEY KNOW THEIR CONSUMERS ARE IN. UNACCEPTABLE!!!

NHTSA ODI #11128461

80,000 miles · Aug 15, 2018
Power Train

MY JEEP IS BY FAR ONE OF THE BIGGEST SAFETY HAZARDS IF NOT FOR ME BUT FOR EVERYONE ELSE ON THE ROAD. THE TRANSMISSION OVERHEAT LIGHT COMES ON CONSTANTLY. IF I GO OVER 60 ON A DAY THAT IS OVER 70 DEGREES FOR LONGER THAN 10 MINUTES THE TRANSMISSION WILL OVER HEAT. IT ISN'T JUST AN ANNOYANCE IT IS A SAFETY ISSUE THAT JEEP HAS KNOWN…

Read full complaint

MY JEEP IS BY FAR ONE OF THE BIGGEST SAFETY HAZARDS IF NOT FOR ME BUT FOR EVERYONE ELSE ON THE ROAD. THE TRANSMISSION OVERHEAT LIGHT COMES ON CONSTANTLY. IF I GO OVER 60 ON A DAY THAT IS OVER 70 DEGREES FOR LONGER THAN 10 MINUTES THE TRANSMISSION WILL OVER HEAT. IT ISN'T JUST AN ANNOYANCE IT IS A SAFETY ISSUE THAT JEEP HAS KNOWN ABOUT. A RECALL NEEDS TO BE INICIATED. THE

NHTSA ODI #11120200

60,000 miles · Aug 8, 2018
Power TrainUnknown Or OtherVehicle Speed Control

INTERSTATE 44 ST. ROBERTS MISSOURI SPEED LIMIT 70 MILES AN HOUR AMBER TRANSMISSION WARNING LIGHT INDICATES OVERHEATING KARZAN REDUCE THE SPEED TO 40 MILES AN HOUR ON THE INTERSTATE. JEEP IS AWARE OF THIS DUE TO A DEFECT AND THE DESIGN OF THE CVT TRANSMISSION. WILL NOT BE REPAIR TELL RECALL ORDERED BY GOVERNMENT

NHTSA ODI #11118627

79,888 miles · Jul 1, 2018
Power TrainVehicle Speed Control

I WAS STOPPED AT A STOPLIGHT TURNING RIGHT THE LIGHT TURNED GREEN I WENT TO GO AND MY JEEP PATRIOT STARTED HESITATING IN THE MIDDLE OF THE INTERSECTION AND IT TOOK A FEW MINUTES TO GET UP TO SPEED I HAVE HAD THE PROBLEM MULTIPLE TIMES BUT THE DEALERSHIP COULDN'T RECREATE THE PROBLEM SO THEY COULDN'T TELL ME A SALUTATION BROU…

Read full complaint

I WAS STOPPED AT A STOPLIGHT TURNING RIGHT THE LIGHT TURNED GREEN I WENT TO GO AND MY JEEP PATRIOT STARTED HESITATING IN THE MIDDLE OF THE INTERSECTION AND IT TOOK A FEW MINUTES TO GET UP TO SPEED I HAVE HAD THE PROBLEM MULTIPLE TIMES BUT THE DEALERSHIP COULDN'T RECREATE THE PROBLEM SO THEY COULDN'T TELL ME A SALUTATION BROUGHT IT IN 3 TIMES NOW WHEN I GO TO SPEED UP TO FLOW OF TRAFFIC COMING OFF THE ON RAMP MY TRANSMISSION MAKES A HOWLING NOISE AND IT IS SLOW TO GET UP TO SPEED

NHTSA ODI #11105016

96,986 miles · Jun 9, 2018
Power Train

THE VEHICLE WAS IN MOTION, REAR DRIVER SIDE TIRE WOULD NOT ROLL CORRECTLY AND WAS MAKING A NOISE UNDER THE HOOD. IT WAS TOWED TO A REPAIR SHOP AND AFTER RUNNING DIAGNOSTIC TESTING FOUND THAT THE CVT TRANSMISSION, DRIVE SHAFT JOINT AND TRANSMISSION COOLER HAD TO BE REPLACED. PER THE REPAIR SHOP "THE TRANSMISSION HAD CATASTROPHIC …

Read full complaint

THE VEHICLE WAS IN MOTION, REAR DRIVER SIDE TIRE WOULD NOT ROLL CORRECTLY AND WAS MAKING A NOISE UNDER THE HOOD. IT WAS TOWED TO A REPAIR SHOP AND AFTER RUNNING DIAGNOSTIC TESTING FOUND THAT THE CVT TRANSMISSION, DRIVE SHAFT JOINT AND TRANSMISSION COOLER HAD TO BE REPLACED. PER THE REPAIR SHOP "THE TRANSMISSION HAD CATASTROPHIC FAILURE" AT 96,986K MILES AND WITHOUT ANY ADVANCED WARNING I HAD NO CHOICE BUT TO AGREE TO HAVE A REBUILT TRANSMISSION, DRIVE SHAFT AND COOLER BE INSTALLED BECAUSE MINE COULD NOT BE REPAIRED. THE ONLY THING THEY COULD SALVAGE WAS THE TRANSFER CASE WHICH WAS THOUGHT TO HAVE BEEN THE ISSUE BUT THE DIAGNOSTIC TESTING FOUND THAT WAS OK. THREE WEEKS IT IS FINALLY FIXED AND APPEARS TO BE WORKING FINE.

NHTSA ODI #11100677

57,000 miles · Mar 17, 2018
Power Train

WHEN ACCELERATING ON THE HIGHWAY THE TRANSMISSION SEEMS TO "LOCK" UP, PREVENTING THE GEARS FROM SHIFTING AND CAUSING THE ENGINE TO OVER-REV. SINCE THE GEARS DON'T SHIFT, THE VEHICLE IS UNABLE TO ACCELERATE. THIS IS THE SECOND JEEP PATRIOT I HAVE OWNED AND THE SECOND ONE THAT HAS HAD THIS PROBLEM. THE ISSUE IN THE FIRST WOULD…

Read full complaint

WHEN ACCELERATING ON THE HIGHWAY THE TRANSMISSION SEEMS TO "LOCK" UP, PREVENTING THE GEARS FROM SHIFTING AND CAUSING THE ENGINE TO OVER-REV. SINCE THE GEARS DON'T SHIFT, THE VEHICLE IS UNABLE TO ACCELERATE. THIS IS THE SECOND JEEP PATRIOT I HAVE OWNED AND THE SECOND ONE THAT HAS HAD THIS PROBLEM. THE ISSUE IN THE FIRST WOULD CAUSE THE TRANSMISSION TO OVER HEAT AND EVENTUALLY THE VEHICLE WOULD SLOW TO A CRAWL. THIS HAPPENED SEVERAL TIMES WHILE HIGHWAY DRIVING, WITH AN INFANT. WE WERE FORCED TO PULL OVER ON THE SIDE OF A BUSY HIGHWAY TO WAIT FOR IT TO COOL DOWN. THIS HAPPENED ONLY 2 MONTHS AFTER PURCHASING THE 2013 JEEP PATRIOT AND THE DEALER AGREED TO TRADE THE VEHICLE BACK AND I WAS STUCK WITH THE SAME MAKE AND MODEL WHICH NOW IS EXHIBITING SIMILAR PROBLEMS. I AM CONCERNED THAT THEY MAY REACH A SIMILAR POINT AND I NOW NEED MY VEHICLE FOR HIGHWAY TRAVEL ON A REGULAR BASIS. I OBTAINED THE 2012 JEEP PATRIOT IN AUGUST OF 2016 AND DID NOT NOTICE ANY ISSUES UNTIL FEBRUARY 2018 AND NOW IT HAPPENS ON A DAILY BASIS ON MY COMMUTE TO AND FROM WORK.

NHTSA ODI #11079908

Official recalls

4

16V668000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner

Sep 15, 2016

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.

Consequence & remedy

Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.

Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.

Additional source detail variants (3)

Seat Belts:pretensioner

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.

Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.

Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.

Air Bags:frontal:sensor/control MODULE-INACTIVE

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.

Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.

Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.

Air Bags

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.

Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.

Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.

13V233000 · Air Bags:side/window; Electrical System:software; Seat Belts

Jun 4, 2013

Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2012 Jeep Compass and Patriot vehicles manufactured May 6, 2008, through July 20, 2012. The affected vehicles have a software error which may result in a delayed deployment or non-deployment of the seatbelt pre-tensioners and/or side airbags.

Consequence & remedy

Consequence: In the event of a rollover necessitating airbag deployment, the software error can lead to a delayed deployment or non-deployment of the side curtain airbag and/or seatbelt pre-tensioners. As a result, vehicle occupants have an increased risk of injury in a crash.

Remedy: Chrysler will notify owners, and dealers will correct the software free of charge. The recall began June 21, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall number is N01.

Additional source detail variants (3)

Electrical System:software

Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2012 Jeep Compass and Patriot vehicles manufactured May 6, 2008, through July 20, 2012. The affected vehicles have a software error which may result in a delayed deployment or non-deployment of the seatbelt pre-tensioners and/or side airbags.

Consequence: In the event of a rollover necessitating airbag deployment, the software error can lead to a delayed deployment or non-deployment of the side curtain airbag and/or seatbelt pre-tensioners. As a result, vehicle occupants have an increased risk of injury in a crash.

Remedy: Chrysler will notify owners, and dealers will correct the software free of charge. The recall began June 21, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall number is N01.

Seat Belts

Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2012 Jeep Compass and Patriot vehicles manufactured May 6, 2008, through July 20, 2012. The affected vehicles have a software error which may result in a delayed deployment or non-deployment of the seatbelt pre-tensioners and/or side airbags.

Consequence: In the event of a rollover necessitating airbag deployment, the software error can lead to a delayed deployment or non-deployment of the side curtain airbag and/or seatbelt pre-tensioners. As a result, vehicle occupants have an increased risk of injury in a crash.

Remedy: Chrysler will notify owners, and dealers will correct the software free of charge. The recall began June 21, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall number is N01.

Air Bags:side/window

Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2012 Jeep Compass and Patriot vehicles manufactured May 6, 2008, through July 20, 2012. The affected vehicles have a software error which may result in a delayed deployment or non-deployment of the seatbelt pre-tensioners and/or side airbags.

Consequence: In the event of a rollover necessitating airbag deployment, the software error can lead to a delayed deployment or non-deployment of the side curtain airbag and/or seatbelt pre-tensioners. As a result, vehicle occupants have an increased risk of injury in a crash.

Remedy: Chrysler will notify owners, and dealers will correct the software free of charge. The recall began June 21, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall number is N01.

13V120000 · Fuel System, Gasoline

Apr 3, 2013

Chrysler Group LLC (Chrysler) is recalling certain model year 2012 Jeep Patriot and Compass vehicles manufactured October 18, 2011, through May 7, 2012. Due to an incorrectly manufactured transfer tube, the transfer of fuel from the secondary side to the primary side of the fuel tank may be interrupted, causing the engine to stall.

Consequence & remedy

Consequence: If the engine stalls while driving it may increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the fuel tank transfer tube free of charge. An interim letter was mailed to owners on May 30, 2013. Owners were notified by Chrysler on July 19, 2013, that parts are now available. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is N17.

12V142000 · Fuel System, Gasoline:storage:tank Assembly

Apr 3, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 JEEP PATRIOT AND COMPASS VEHICLES MANUFACTURED FROM DECEMBER 17, 2011, THROUGH JANUARY 2, 2012. SOME VEHICLES MAY HAVE BEEN BUILT WITH A FUEL TANK ASSEMBLY CONTAINING A DAMAGED ROLL-OVER VALVE.

Consequence & remedy

Consequence: IN THE EVENT OF AN IMPACT OR ROLL-OVER, FUEL LEAKAGE COULD OCCUR, INCREASING THE RISK OF A FIRE.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE FUEL TANK, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 25, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

PE12032 · Engine Stall, Fuel Delivery Failure

Opened Oct 15, 2012 · Closed May 3, 2013

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery

In a letter dated April 3, 2013, Chrysler Group LLC submitted a Defect Information Report (DIR) to NHTSA identifying a safety defect in the fuel delivery system in approximately 20,532 model year (MY) 2012 Jeep Patriot (11,624) and Compass (8,908) vehicles manufactured from October 18, 2011 through May 7, 2012 and equipped with certain fuel tanks produced between October 18, 2011 and January 26, 2012 (Recall 13V-120).According to Chrysler, Jeep Patriot and Compass vehicles equipped with saddle type fuel tanks built during the affected period may experience low siphoning rate through the transfer tube from the secondary to the primary side of the fuel tank.Chrysler's investigation determined that a material change by the transfer tube supplier (TI Automotive) led to malformed tubes being shipped to the final tank assembly supplier (Kautex).The malformed transfer tubes may make the siphoning process more difficult to start and maintain under certain operating conditions.Sustained driving during this condition may deplete fuel in the primary side of the fuel tank and lead to engine stall without warning.Kautex established a 100% sort on January 26, 2012 as a countermeasure for the malformed tubes being used in production.Chrysler is able to trace fuel tank build dates by vehicle identification number and Recall 13V-120 only includes vehicles equipped withsaddle tanks made during the affected period.Approximately 97 percent of the recalled Patriot vehicles (11,277 out of 11,624) were from October 18, 2011 through January 26, 2012.Chrysler determined that a few suspect tanks were used on vehicles produced as late as May 7, 2012 and is including any such vehicles in the recall.The Office of Defects Investigation (ODI) analyzed complaint data provided by Chrysler as well as complaints submitted to ODI from consumers to identify stalling incidents related to fuel delivery.ODI's analysis identified a total of 64 engine stall incidents related to fuel delivery, all of which involved Patriot 4x4 vehicles equipped with saddle type fuel tanks.The Patriot 4x4 vehicles account for a little over half of the subject vehicle population (59,783 vehicles).Forty-nine (49) of the incidents involved the approximately 11,277 Patriot 4x4 vehicles that were built from October 18, 2011 and January 26, 2012 and equipped with tanks from the period associated with the transfer tube material change.This equates to a complaint rate of 434.5 incidents per 100,000 vehicles sold.Fifteen (15) fuel delivery related engine stalls were identified in the remaining 48,506 Patriot 4x4 vehicles, resulting in a complaint rate of 30.9 incidents per 100,000 vehicles.The rate in the non-recalled Patriot 4x4 vehicles increases to 68.0 incidents per 100,000 vehicles if stalls with no-restart and unknown cause are added to the analysis.The Patriot front-wheel drive vehicles are equipped with single reservoir fuel tanks and are not affected by the saddle-tank fuel delivery issue.Owners of the recalled vehicles will be notified to take their vehicle to a Jeep dealer, who will replace the fuel tank transfer tube to prevent any incidents related to this issue. Chrysler will begin notifying dealers and owners in May 2013. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10481572, 10481452, 10481279, 10481254, 10481222, 10481141, 10481126, 10481110, 10501057, 10478934, 10472705, 10470121, 10468517, 10467488, 10466357, 10464745, 10464449, 10464135, 10462338, 10459383, 10421019, 10410937, 10481392.