← New search

2005 Jeep Liberty

Owner reports · Recalls · Investigations

More warning signs than most Liberty years

Owner complaints for the 2005 Jeep Liberty are substantially higher than the model-year median of 541.

About this comparison →

When problems were reported

Mileage at the reported incident

768 reports with mileage · 350 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Suspension. Review the 262 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 192 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 184 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

73 crash reports27 fire reports42 injury reports

What owners actually said

1,118 reports
81,859 miles · Oct 4, 2011
Vehicle Speed Control

TL* THE CONTACT OWNS A 2005 JEEP LIBERTY, THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE SUDDENLY SURGED FORWARD UNTIL SHE SHIFTED INTO PARK. THE VEHICLE WAS SAFELY DRIVEN HOME AND WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FA…

Read full complaint

TL* THE CONTACT OWNS A 2005 JEEP LIBERTY, THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE SUDDENLY SURGED FORWARD UNTIL SHE SHIFTED INTO PARK. THE VEHICLE WAS SAFELY DRIVEN HOME AND WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 81,859. UPDATED 11/28/11 *CN

NHTSA ODI #10428699

Mileage unknown · Sep 26, 2011
Fuel System, Gasoline

EACH TIME I GO TO HAVE GAS PUT IN MY VEHICLE (NO MATTER WHAT GAS STATION) OR WHETHER THE GAS IS ALMOST FULL OR ALMOST EMPTY. WHEN THE GAS IS BEING FILLED IT WILL SPIT THE GAS BACK OUT UNLESS YOU FILL IT VERY, VERY, VERY SLOW AND WAIT FOR THE GAS TO SETTLE. IT SPITS IT OUT ON THE SIDE OF THE TRUCK AND HAS A VERY BAD FUME SMELL …

Read full complaint

EACH TIME I GO TO HAVE GAS PUT IN MY VEHICLE (NO MATTER WHAT GAS STATION) OR WHETHER THE GAS IS ALMOST FULL OR ALMOST EMPTY. WHEN THE GAS IS BEING FILLED IT WILL SPIT THE GAS BACK OUT UNLESS YOU FILL IT VERY, VERY, VERY SLOW AND WAIT FOR THE GAS TO SETTLE. IT SPITS IT OUT ON THE SIDE OF THE TRUCK AND HAS A VERY BAD FUME SMELL OR ODOR AFTER HAVING GAS PUMPED EACH TIME. THIS SHOULD BE A SAFETY CONCERN AND I DO NOT UNDERSTAND WHY THIS HAS NOT BEEN A RECALL VIA CHRYSLER-JEEP WITH ALL OF THE COMPLAINTS I HAVE READ ONLINE. *TR

NHTSA ODI #10427195

72,905 miles · Sep 25, 2011
Suspension

WHILE DRIVING ON A PRIVATE STREET, HEARD A "POP" NEAR THE BACK OF VEHICLE. I STOPPED AND CHECKED TO SEE IF I HAD A FLAT, AS THE CAR WAS SWERVING AS IF I HAD A FLAT TIRE. HOWEVER, UPON INSPECTION, TIRE WAS FULLY INFLATED BUT IT WAS RUBBING THE BACK OF THE WHEEL WELL. THE WHEEL WAS OFF-CENTER AND THE VEHICLE ITSELF WAS LOWER TO TH…

Read full complaint

WHILE DRIVING ON A PRIVATE STREET, HEARD A "POP" NEAR THE BACK OF VEHICLE. I STOPPED AND CHECKED TO SEE IF I HAD A FLAT, AS THE CAR WAS SWERVING AS IF I HAD A FLAT TIRE. HOWEVER, UPON INSPECTION, TIRE WAS FULLY INFLATED BUT IT WAS RUBBING THE BACK OF THE WHEEL WELL. THE WHEEL WAS OFF-CENTER AND THE VEHICLE ITSELF WAS LOWER TO THE WHEEL. I PROCEEDED TO PULL INTO MY DRIVEWAY. AFTER VIEWING UNDERNEATH THE VEHICLE, NOTICED THE RUSTED BROKEN ARM OF THE SUSPENSION SYSTEM (LEFT REAR). THE OTHER SIDE IS RUSTED AND CRACKED AS WELL (RIGHT REAR). FORTUNATELY I WAS TRAVELING IN A SUBDIVISION AT A SLOW RATE OF SPEED. OTHERWISE I FEEL HAD I BEEN ON A BUSIER HIGHWAY AT HIGHER RATE OF SPEED, MAY HAVE LOST CONTROL AS THE CAR WAS SWERVING WHILE I WAS ONLY DOING 20MPH AND UNDER. *TR

NHTSA ODI #10427087

102,000 miles · Sep 21, 2011
Fuel System, Gasoline

GAS SPURTS OUT THE FILLER TUBE WHEN THE VEHICLE IS BEING FILLED AND IT IS NEAR FULL. THE AUTOMATIC PUMPS DO NOT SHUT OFF AS THEY WOULD WHEN THE VEHICLE'S TANK IS FULL. THIS HAPPENS REGARDLESS OF WHETHER I AM FILLING WITH THE CONVENIENCE LOCK ON THE HANDLE OF THE PUMP OR WHEN FILLING THE VEHICLE SQUEEZING THE PUMP HANDLE MYSELF. …

Read full complaint

GAS SPURTS OUT THE FILLER TUBE WHEN THE VEHICLE IS BEING FILLED AND IT IS NEAR FULL. THE AUTOMATIC PUMPS DO NOT SHUT OFF AS THEY WOULD WHEN THE VEHICLE'S TANK IS FULL. THIS HAPPENS REGARDLESS OF WHETHER I AM FILLING WITH THE CONVENIENCE LOCK ON THE HANDLE OF THE PUMP OR WHEN FILLING THE VEHICLE SQUEEZING THE PUMP HANDLE MYSELF. *TR

NHTSA ODI #10426628

24,000 miles · Sep 14, 2011
Visibility

SINCE WE BOUGHT THE LIBERTY WE HAVE HAD A TOTAL OF 12 INCIDENTS WHERE THE WINDOWS HAVE FALLEN DOWN AND LEFT THE VEHICLE VULNERABLE TO THE ELEMENTS AND ON TWO OCCASIONS PERSONAL PROPERTY HAS BEEN TAKEN FROM INSIDE THE VEHICLE IN SHOPPING CENTER PARKING LOTS. CHRYSLER SOLD US AN EXTENDED WARRANTY WHICH WILL COVER THE REPAIRS BUT T…

Read full complaint

SINCE WE BOUGHT THE LIBERTY WE HAVE HAD A TOTAL OF 12 INCIDENTS WHERE THE WINDOWS HAVE FALLEN DOWN AND LEFT THE VEHICLE VULNERABLE TO THE ELEMENTS AND ON TWO OCCASIONS PERSONAL PROPERTY HAS BEEN TAKEN FROM INSIDE THE VEHICLE IN SHOPPING CENTER PARKING LOTS. CHRYSLER SOLD US AN EXTENDED WARRANTY WHICH WILL COVER THE REPAIRS BUT THERE IS A $100 DEDUCTIBLE EVERY TIME THE VEHICLE GOES IN. JEEP MAKES A JOKE OUT OF IT WHEN THEY SEE ME COME IN BY SAYING "WHAT, ANOTHER WINDOW ?" AND THEN LAUGHING AND SAYING THIS IS GETTING TO BE A ROUTINE, THIS IS TRUE AND I KNOW ALL OF THE PEOPLE THERE BECAUSE I SOLD CHRYSLER/ JEEP / DODGE FOR 5 YEARS SO I JUST LAUGH WITH THEM BUT IT REALLY MAKES ME MAD THAT JEEP WON'T FIX AN ISSUE THAT IS SO OBVIOUS AND SO MANY PEOPLE HAVE PROBLEMS WITH. THIS IS A SAFETY ISSUE SINCE MY WIFE DRIVES THIS CAR TO WORK AND WHEN SHE GOES TO THE CAR AFTER WORK SHE HAS TO CHECK AND SEE IF ANYONE IS INSIDE THE VEHICLE BEFORE SHE GETS IN AND WHEN SHE IS DRIVING THE CAR ON THE FREEWAY IF THE WINDOW FALLS DOWN IT STARTLES HER AND SHE HAS ALMOST HAD AN ACCIDENT TWICE OVER THE FRONT WINDOWS FALLING. I NOW HAVE TWO WINDOWS BEING HELD UP BY COAT HANGERS STUFFED IN THE WINDOW TRACK SO THE INSIDE DOESN'T GET WET OR THE CAR SIT OUTSIDE WITH WINDOWS WIDE OPEN. SOMEONE NEEDS TO NIP THIS IN THE BUD AND GET THE CHRYSLER CORPORATION TO STEP UP AND FIX THESE VEHICLES BEFORE THEY HURT SOMEONE. *KB

NHTSA ODI #10425442

Mileage unknown · Sep 13, 2011
Steering

I CANNOT CONTROL MY VEHICLE WHILE DRIVING ON THE HIGHWAY. THE STEERING COLUMN SEEMS TO BE VERY LOOSE AND THE JEEP SHIMMIES. IT SEEMS THAT WHEN YOU REACH MAYBE 50 MPH THE BACK END SEEMS TO PULL TO THE RIGHT WHILE YOU ARE TRYING TO DRIVE STRAIGHT. CAUSING ALOT OF SHAKING AND PULLING GOING ON. A VERY UNSTEADY RIDE. AND NOTICED WHE…

Read full complaint

I CANNOT CONTROL MY VEHICLE WHILE DRIVING ON THE HIGHWAY. THE STEERING COLUMN SEEMS TO BE VERY LOOSE AND THE JEEP SHIMMIES. IT SEEMS THAT WHEN YOU REACH MAYBE 50 MPH THE BACK END SEEMS TO PULL TO THE RIGHT WHILE YOU ARE TRYING TO DRIVE STRAIGHT. CAUSING ALOT OF SHAKING AND PULLING GOING ON. A VERY UNSTEADY RIDE. AND NOTICED WHEN TRYING TO STOP AT THE FAST PACE THE FRONT END WANTS TO GO TO THE LEFT WHILE THE BACK END WANTS TO GO TO THE RIGHT. VERY SCARY DRIVING CONDITIONS. TOOK IT TO THE JEEP DEALER LAST YEAR AND THEY TOLD ME THAT THERE WAS NOTHING WRONG WITH THE VEHICLE, THAT JEEPS HAVE ALOT OF PLAY IN THE STEERING. BUT WHEN I NOTICED THAT WHEN I GO OVER A BUMP A LOUD CLANKING NOISE HAPPENS I DECIDED TO LOOK ON LINE TO SEE WHAT THE PROBLEM COULD BE AND I SAW THAT THERE WAS A RECALL ON BALL JOINTS, SO I THOUGHT IT COULD BE THAT. I TOOK IT INTO THE DEALERSHIP YESTERDAY AND THEY TOLD ME THAT THERE WAS SOMETHING WRONG, DESCRIBED EXACTLY WHAT I WAS DEALING WITH AND TOLD ME THAT THEY WOULD FIND OUT. TO MY DISMAY, THEY SAID IT WAS MY REAR LOWE CONTROL ARMS THAT NEEDED TO BE REPLACED AND WOULD CHARGE ME OVER 600 TO FIX. NOW FINDING OUT THAT OTHERS ARE HAVING THE SAME ISSUE AND SOME HAVE RESULTED IN A WRECK. SOMETHING NEEDS TO BE DONE REGARDING THIS ISSUE BEFORE SOMEONE LOSES THEIR LIVES. *TR

NHTSA ODI #10425211

34,300 miles · Aug 27, 2011
Equipment

I HAVE A 2005 JEEP LIBERTY RENEGADE AND ONCE AGAIN...FOR THE 3RD TIME, THE REGULATOR HAS FAILED ON MY DRIVER'S SIDE PASSENGER WINDOW. THIS HAS ALSO HAPPENED ON THE PASSENGER SIDE REAR WINDOW TWICE. I'M SURE AFTER I HAVE THE DRIVER'S SIDE REPAIRED, THIS ONE WILL ALSO FAIL. SEEING THE NEVERENDING COMPLAINTS FILED FROM OTHER JEEP O…

Read full complaint

I HAVE A 2005 JEEP LIBERTY RENEGADE AND ONCE AGAIN...FOR THE 3RD TIME, THE REGULATOR HAS FAILED ON MY DRIVER'S SIDE PASSENGER WINDOW. THIS HAS ALSO HAPPENED ON THE PASSENGER SIDE REAR WINDOW TWICE. I'M SURE AFTER I HAVE THE DRIVER'S SIDE REPAIRED, THIS ONE WILL ALSO FAIL. SEEING THE NEVERENDING COMPLAINTS FILED FROM OTHER JEEP OWNERS HAVING THE SAME PROBLEM, HOW MANY COMPLAINTS HAVE TO BE FILED BEFORE CHRYSLER FIXES THE PROBLEM? *TT

NHTSA ODI #10421700

58,000 miles · Aug 22, 2011
Visibility

TL* THE CONTACT OWNS A 2004 JEEP LIBERTY. THE CONTACT STATED THAT BOTH THE DRIVER AND PASSENGER SIDE REAR WINDOWS FELL INTO THE DOORPANEL. THE CONTACT TOOK THE VEHICLE TO A DEALER AND THE DEALER REPLACE THE REGULATOR ASSEMBLY FOR EACH WINDOW. THE CONTACT STATED THE REAR WINDOW HAD TO BE REPLACED OVER THREE TIMES. THE CONTAC…

Read full complaint

TL* THE CONTACT OWNS A 2004 JEEP LIBERTY. THE CONTACT STATED THAT BOTH THE DRIVER AND PASSENGER SIDE REAR WINDOWS FELL INTO THE DOORPANEL. THE CONTACT TOOK THE VEHICLE TO A DEALER AND THE DEALER REPLACE THE REGULATOR ASSEMBLY FOR EACH WINDOW. THE CONTACT STATED THE REAR WINDOW HAD TO BE REPLACED OVER THREE TIMES. THE CONTACT STATED THAT REGULATOR THAT THE DEALERS WERE USING TO REMEDY THE ISSUE WERE DEFECTIVE. THE FAILURE MILEAGE WAS 58,000.

NHTSA ODI #10421014

58,000 miles · Aug 22, 2011
Engine And Engine Cooling

TL* THE CONTACT OWNS A 2005 JEEP LIBERTY SPORT DIESEL. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT WOULD ILLUMINATE SPORADICALLY. THE DEALER DIAGNOSED THAT THE TURBO WAS DEFECTIVE AND WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS REPAIRED BUT THE FAILUR…

Read full complaint

TL* THE CONTACT OWNS A 2005 JEEP LIBERTY SPORT DIESEL. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT WOULD ILLUMINATE SPORADICALLY. THE DEALER DIAGNOSED THAT THE TURBO WAS DEFECTIVE AND WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 58,000 AND THE CURRENT MILEAGE WAS 58,200.

NHTSA ODI #10420966

90,000 miles · Aug 18, 2011
Visibility

TL* THE CONTACT OWNS A 2005 JEEP LIBERTY. WHILE PARKED, THE REAR DRIVER SIDE WINDOW GLASS DETACHED AND FELL INTO THE DOOR PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN STATED THE LIFTING BAR ON THE REAR DRIVER SIDE DOOR HAD CAUSED THE FAILURE AND WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. T…

Read full complaint

TL* THE CONTACT OWNS A 2005 JEEP LIBERTY. WHILE PARKED, THE REAR DRIVER SIDE WINDOW GLASS DETACHED AND FELL INTO THE DOOR PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN STATED THE LIFTING BAR ON THE REAR DRIVER SIDE DOOR HAD CAUSED THE FAILURE AND WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

NHTSA ODI #10420043

Official recalls

5

18V278000 · Suspension:rear

May 1, 2018

Chrysler (FCA US LLC) is recalling certain 2004-2007 Jeep Liberty vehicles. The rear suspension lower control arms can fracture due to excessive corrosion, causing a loss of vehicle control.

Consequence & remedy

Consequence: A fractured control arm can cause a loss of vehicle control, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the rear lower control arms, free of charge. The recall began June 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U38. Note: This recall is an expansion of recall 12V-085. Vehicles included in that campaign are not included in this recall.

13V252000 · Fuel System, Gasoline:storage:tank Assembly; Structure

Jun 19, 2013

Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.

Consequence & remedy

Consequence: A fuel leak in the presence of an ignition source may result in a fire.

Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).

Additional source detail variants (2)

Structure

Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.

Consequence: A fuel leak in the presence of an ignition source may result in a fire.

Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).

Fuel System, Gasoline:storage:tank Assembly

Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.

Consequence: A fuel leak in the presence of an ignition source may result in a fire.

Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).

12V085000 · Suspension:rear

Mar 5, 2012

IN JUNE 2012, CHRYSLER EXPANDED THIS RECALL TO INCLUDE MODEL YEAR 2006 AND 2007 JEEP LIBERTY VEHICLES, REPRESENTING AN ADDITIONAL 137,176 VEHICLES. THIS RECALL NOW CONCERNS CERTAIN MY 2004-2007 JEEP LIBERTY VEHICLES. THE TOTAL NUMBER VEHICLES BEING RECALLED IS NOW 346,900. THESE VEHICLES WERE MANUFACTURED FROM JULY 3, 2003 THROUGH JUNE 29, 2007. THE RECALL ADDRESSES THOSE VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. SOME VEHICLES MAY BE EQUIPPED WITH REAR LOWER CONTROL ARMS THAT CAN EXPERIENCE A REAR SUSPENSION LOWER CONTROL ARM FRACTURE DUE TO EXCESSIVE CORROSION DUE TO APPLICATION OF ROAD SALTS DURING WINTER WEATHER CONDITIONS.

Consequence & remedy

Consequence: A FRACTURE OF THE REAR LOWER CONTROL ARM MAY RESULT IN A LOSS OF VEHICLE CONTROL AND MAY LEAD TO A VEHICLE CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE REAR LOWER CONTROL ARMS ON ALL AFFECTED VEHICLES ORIGINALLY SOLD IN, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 26, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

06V288000 · Suspension:front:control Arm:lower Ball Joint

Aug 3, 2006

ON CERTAIN TRUCKS, THE CONSTANT TENSION FRONT LOWER BALL JOINTS MAY EXPERIENCE CONTAMINATION. IF THE VEHICLE IS OPERATED FOR AN EXTENDED PERIOD WITH THIS CONDITION, THE BALL JOINT MAY EVENTUALLY EXPERIENCE WEAR AND LOOSENESS.

Consequence & remedy

Consequence: WHEN THE DRIVER CONTINUES TO OPERATE THE VEHICLE WITH THIS CONDITION, THE CONTAMINATION CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE CAUSING A LOSS OF VEHICLE STEERING CONTROL INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE FRONT LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 11, 2006. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

05V460000 · Power Train:automatic Transmission

Oct 6, 2005

ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.

Consequence & remedy

Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

5

EA12005 · Crash Related Fuel Tank Fires

Opened Jun 12, 2012 · Closed Nov 14, 2014

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage:tank Assembly

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

EA11013 · Rear Suspension Control Arm Failure

Opened Sep 15, 2011 · Closed Mar 14, 2012

Status: closed (inferred from source dates) · Suspension; Suspension:rear

In a letter dated March 2, 2012 Chrysler Group LLC (Chrysler) submitted a Defect Information Report (NHTSA recall No. 12V-085) to the NHTSA identifying a safety defect regarding rear suspension lower control arm corrosion in approximately 210,000 model year (MY) 2004 and 2005 Jeep Liberty vehicles, originally sold or currently registered in a Salt-belt state (Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).According to Chrysler, excessive corrosion could result in fracture of a rear suspension lower control arm which may result in a loss vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Chrysler, ODI identified 54 non-duplicative reports alleging failure of one or both rear lower control arms due to excessive corrosion.Thirteen of these complaints allege that the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional 11 complaints reported difficulty maintaining control of the vehicle when the rear lower control arm failed.All of the complainant vehicles were either originally sold or registered at the time of the incident in a Salt-belt state.ODI did not identify any reports (complaints or warranty claims) related to rear lower control failure due to excessive corrosion in the approximately 138,000 MY 2004 and 2005 Liberty vehicles that are not included in this recall (i.e., not sold or currently registered in a Salt-belt state).In Chrysler?s Defect Information Report, Chrysler stated that during the investigation a field survey of MY 2004 and 2005 Jeep Liberty vehicles was conducted.In total, Chrysler is aware of 83 incidents alleging rear control arm fracture (including complaints and field study results).Based on Chrysler?s decision to conduct a safety recall this investigation is closed. The associated VOQs are: 10449912, 10448981, 10448406, 10448119, 10447069,10446737, 10445029, 10443863, 10443222, 10441248, 10438681, 10437308, 10436416, 10436231, 10436024, 10434927, 10434157, 10433963, 10430852, 10429346, 10428006, 10427087, 10426644, 10426393, 10419094, 10417697, 10416623, 10410148, 10409668, 10402048, 10397413, 10392160, 10388448, 10365118, 10360057, 10360049, 10345985

Additional source detail variants (2)

Suspension

In a letter dated March 2, 2012 Chrysler Group LLC (Chrysler) submitted a Defect Information Report (NHTSA recall No. 12V-085) to the NHTSA identifying a safety defect regarding rear suspension lower control arm corrosion in approximately 210,000 model year (MY) 2004 and 2005 Jeep Liberty vehicles, originally sold or currently registered in a Salt-belt state (Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).According to Chrysler, excessive corrosion could result in fracture of a rear suspension lower control arm which may result in a loss vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Chrysler, ODI identified 54 non-duplicative reports alleging failure of one or both rear lower control arms due to excessive corrosion.Thirteen of these complaints allege that the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional 11 complaints reported difficulty maintaining control of the vehicle when the rear lower control arm failed.All of the complainant vehicles were either originally sold or registered at the time of the incident in a Salt-belt state.ODI did not identify any reports (complaints or warranty claims) related to rear lower control failure due to excessive corrosion in the approximately 138,000 MY 2004 and 2005 Liberty vehicles that are not included in this recall (i.e., not sold or currently registered in a Salt-belt state).In Chrysler?s Defect Information Report, Chrysler stated that during the investigation a field survey of MY 2004 and 2005 Jeep Liberty vehicles was conducted.In total, Chrysler is aware of 83 incidents alleging rear control arm fracture (including complaints and field study results).Based on Chrysler?s decision to conduct a safety recall this investigation is closed. The associated VOQs are: 10449912, 10448981, 10448406, 10448119, 10447069,10446737, 10445029, 10443863, 10443222, 10441248, 10438681, 10437308, 10436416, 10436231, 10436024, 10434927, 10434157, 10433963, 10430852, 10429346, 10428006, 10427087, 10426644, 10426393, 10419094, 10417697, 10416623, 10410148, 10409668, 10402048, 10397413, 10392160, 10388448, 10365118, 10360057, 10360049, 10345985

Suspension:rear

In a letter dated March 2, 2012 Chrysler Group LLC (Chrysler) submitted a Defect Information Report (NHTSA recall No. 12V-085) to the NHTSA identifying a safety defect regarding rear suspension lower control arm corrosion in approximately 210,000 model year (MY) 2004 and 2005 Jeep Liberty vehicles, originally sold or currently registered in a Salt-belt state (Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).According to Chrysler, excessive corrosion could result in fracture of a rear suspension lower control arm which may result in a loss vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Chrysler, ODI identified 54 non-duplicative reports alleging failure of one or both rear lower control arms due to excessive corrosion.Thirteen of these complaints allege that the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional 11 complaints reported difficulty maintaining control of the vehicle when the rear lower control arm failed.All of the complainant vehicles were either originally sold or registered at the time of the incident in a Salt-belt state.ODI did not identify any reports (complaints or warranty claims) related to rear lower control failure due to excessive corrosion in the approximately 138,000 MY 2004 and 2005 Liberty vehicles that are not included in this recall (i.e., not sold or currently registered in a Salt-belt state).In Chrysler?s Defect Information Report, Chrysler stated that during the investigation a field survey of MY 2004 and 2005 Jeep Liberty vehicles was conducted.In total, Chrysler is aware of 83 incidents alleging rear control arm fracture (including complaints and field study results).Based on Chrysler?s decision to conduct a safety recall this investigation is closed. The associated VOQs are: 10449912, 10448981, 10448406, 10448119, 10447069,10446737, 10445029, 10443863, 10443222, 10441248, 10438681, 10437308, 10436416, 10436231, 10436024, 10434927, 10434157, 10433963, 10430852, 10429346, 10428006, 10427087, 10426644, 10426393, 10419094, 10417697, 10416623, 10410148, 10409668, 10402048, 10397413, 10392160, 10388448, 10365118, 10360057, 10360049, 10345985

PE11013 · Rear Suspension Control Arm Failure

Opened Apr 18, 2011 · Closed Sep 15, 2011

Status: closed (inferred from source dates) · Suspension:rear

During Preliminary Evaluation (PE11-013), the Office of Defects Investigation (ODI) conducted an analysis of consumer field data from its Vehicle Owner Questionnaire (VOQ) database and from complaint data submitted to ODI by Chrysler. ODI's analysis of VOQ data identified 13 complaints alleging failure of either the right or left rear lower control arm due to excessive corrosion.All of these complaints were associated with vehicles originally sold or registered in a salt belt state (for the purposes of this investigation, 'salt belt' includes Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).All of the complaints were associated with vehicles manufactured in model years (MY) 2004 or 2005. Three of these complaints also allege a loss of vehicle control due to the rear lower control arm failure. No complaints related to the alleged defect were identified on vehicles manufactured during MYs 2002 or 2003. Similarly an analysis of Chrysler complaint data identified 11 complaints (2 of which are duplicative of VOQs) alleging failure of a rear lower control arm due to excessive corrosion.All 11 of these complaints were from consumers operating vehicles in a salt belt state and vehicles manufactured in either MY 2004 or 2005. Three of these complaints (not duplicative of VOQs) also allege a loss of vehicle control due to the rear lower control arm failure.The original scope of PE11-013 included MY 2002 through 2005 Jeep Liberty vehicles as they were in the same generation.In response to an Information Request (IR) letter sent by ODI, Chrysler provided information and sample components identifying a substantial design change of the rear lower control arms after MY 2003 and beginning with MY 2004.Analysis of complaint data from both data sources (ODI and Chrysler) did not identify any applicable complaints (lower control arm failures due to excessive corrosion) from vehicles manufactured during MY 2002 or 2003.Similarly no complaints from either data source were found in states outside of those identified as salt belt states.Chrysler stated in its IR letter response that its investigation and analysis is ongoing to determine the scope, possible root causes of the unusual lower control arm corrosion, and define possible consequences to motor vehicle safety. Based on ODI's data analysis from both sources (ODI and Chrysler data), this investigation has been upgraded to an Engineering Analysis (EA11-013) focused on vehicles originally sold or registered in a salt belt state and produced during MY 2004 and 2005, to further assess the scope and potential safety consequences of the alleged defect.

PE07041 · Diesel Fuel Leak

Opened Aug 8, 2007 · Closed Dec 7, 2007

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Diesel: PRE-HEATER

OVERHEATING OF THE ELECTRICAL CONNECTOR AT THE FUEL HEATER ON THE FUEL FILTER / WATER SEPARATOR ASSEMBLY CAN CAUSE A FUEL LEAK THROUGH THE ELECTRICAL CONNECTION.OPERATORS REPORT THE SMELL OF DIESEL FUEL, SMOKE, DIFFICULTY STARTING AND/OR POOR ENGINE OPERATION.THE FUEL LEAKAGE IS REPORTED BY SOME OPERATORS AS SEEPAGE, WETNESS, SEVERAL DROPS, AND AN OZ PER MINUTE.EVIDENCE OF OVERHEATING OF THE CONNECTION WAS OBSERVED BY SOME OPERATORS AND REPORTED AS BURNED OR DISCOLORED ELECTRICAL CONNECTION AT THE FUEL HEATER.SEVEN OPERATORS REPORT SMELLING OR SEEING SMOKE.ONE REPORTED A VEHICLE ENGINE COMPARTMENT FIRE HOWEVER THE CAUSE OF THE FIRE WAS NOT IDENTIFIED, AND LINKAGE OF THE FIRE CAUSE TO THIS ISSUE IS NOT LIKELY TO BE ESTABLISHED.THE LOCATION OF THE FUEL FILTER / WATER SEPARATOR ASSEMBLY IS NOT NEAR THE LOCATION OF THE TURBO CHARGER WHICH IS LOCATED ON THE OPPOSITE SIDE OF THE ENGINE.THE TURBO CHARGER WOULD PRESENT A POTENTIALLY HOT SURFACE HOWEVER DUE TO THE LAYOUT OF THE ENGINE COMPARTMENT AND ITS COMPONENTS, DIESEL FUEL LEAKAGE FROM THE ELECTRICAL CONNECTION WOULD NOT LIKELY MIGRATE TO THE TURBO CHARGER.AT THIS TIME, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

Additional source detail variants (2)

Fuel System, Diesel

OVERHEATING OF THE ELECTRICAL CONNECTOR AT THE FUEL HEATER ON THE FUEL FILTER / WATER SEPARATOR ASSEMBLY CAN CAUSE A FUEL LEAK THROUGH THE ELECTRICAL CONNECTION.OPERATORS REPORT THE SMELL OF DIESEL FUEL, SMOKE, DIFFICULTY STARTING AND/OR POOR ENGINE OPERATION.THE FUEL LEAKAGE IS REPORTED BY SOME OPERATORS AS SEEPAGE, WETNESS, SEVERAL DROPS, AND AN OZ PER MINUTE.EVIDENCE OF OVERHEATING OF THE CONNECTION WAS OBSERVED BY SOME OPERATORS AND REPORTED AS BURNED OR DISCOLORED ELECTRICAL CONNECTION AT THE FUEL HEATER.SEVEN OPERATORS REPORT SMELLING OR SEEING SMOKE.ONE REPORTED A VEHICLE ENGINE COMPARTMENT FIRE HOWEVER THE CAUSE OF THE FIRE WAS NOT IDENTIFIED, AND LINKAGE OF THE FIRE CAUSE TO THIS ISSUE IS NOT LIKELY TO BE ESTABLISHED.THE LOCATION OF THE FUEL FILTER / WATER SEPARATOR ASSEMBLY IS NOT NEAR THE LOCATION OF THE TURBO CHARGER WHICH IS LOCATED ON THE OPPOSITE SIDE OF THE ENGINE.THE TURBO CHARGER WOULD PRESENT A POTENTIALLY HOT SURFACE HOWEVER DUE TO THE LAYOUT OF THE ENGINE COMPARTMENT AND ITS COMPONENTS, DIESEL FUEL LEAKAGE FROM THE ELECTRICAL CONNECTION WOULD NOT LIKELY MIGRATE TO THE TURBO CHARGER.AT THIS TIME, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

Fuel System, Diesel: PRE-HEATER

OVERHEATING OF THE ELECTRICAL CONNECTOR AT THE FUEL HEATER ON THE FUEL FILTER / WATER SEPARATOR ASSEMBLY CAN CAUSE A FUEL LEAK THROUGH THE ELECTRICAL CONNECTION.OPERATORS REPORT THE SMELL OF DIESEL FUEL, SMOKE, DIFFICULTY STARTING AND/OR POOR ENGINE OPERATION.THE FUEL LEAKAGE IS REPORTED BY SOME OPERATORS AS SEEPAGE, WETNESS, SEVERAL DROPS, AND AN OZ PER MINUTE.EVIDENCE OF OVERHEATING OF THE CONNECTION WAS OBSERVED BY SOME OPERATORS AND REPORTED AS BURNED OR DISCOLORED ELECTRICAL CONNECTION AT THE FUEL HEATER.SEVEN OPERATORS REPORT SMELLING OR SEEING SMOKE.ONE REPORTED A VEHICLE ENGINE COMPARTMENT FIRE HOWEVER THE CAUSE OF THE FIRE WAS NOT IDENTIFIED, AND LINKAGE OF THE FIRE CAUSE TO THIS ISSUE IS NOT LIKELY TO BE ESTABLISHED.THE LOCATION OF THE FUEL FILTER / WATER SEPARATOR ASSEMBLY IS NOT NEAR THE LOCATION OF THE TURBO CHARGER WHICH IS LOCATED ON THE OPPOSITE SIDE OF THE ENGINE.THE TURBO CHARGER WOULD PRESENT A POTENTIALLY HOT SURFACE HOWEVER DUE TO THE LAYOUT OF THE ENGINE COMPARTMENT AND ITS COMPONENTS, DIESEL FUEL LEAKAGE FROM THE ELECTRICAL CONNECTION WOULD NOT LIKELY MIGRATE TO THE TURBO CHARGER.AT THIS TIME, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

EA06008 · Front Suspension Ball Joint Separation

Opened May 31, 2006 · Closed Aug 24, 2006

Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint

ON JANUARY 6, 2006, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED FRONT SUSPENSION LOWER BALL JOINT SEPARATIONIN CERTAIN MODEL YEAR (MY) 2004 JEEP LIBERTY VEHICLES.ODI SENT A LETTER TO THE MANUFACTURER ON FEBRUARY 7, 2006 REQUESTING INFORMATION ABOUT THESE AND OTHER JEEP LIBERTY VEHICLES.CONSEQUENTLY, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON MAY 31, 2006 AND THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WAS EXPANDED TO INCLUDE ALL MY 2002-2006 JEEP LIBERTY VEHICLES.ODI IS AWARE OF 566 NON-DUPLICATIVE COMPLAINTS ALLEGING INVOLUNTARY FRONT SUSPENSION LOWER BALL JOINT SEPARATION IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE OF ONE NON-INJURY CRASH AND THREE ALLEGED INJURY INCIDENTS (TWO CRASH INCIDENTS AND ONE NON-CRASH INCIDENT) RELATED TO THE ALLEGED DEFECT RESULTING IN MINOR INJURIES.THE COMPLAINT COUNTS REPORTED ABOVE ONLY INCLUDE THOSE MY 2002-03 LIBERTY VEHICLES WHERE THE ALLEGED BALL JOINT SEPARATION OCCURRED AFTER PRIOR RECALL REPAIRS WERE PERFORMED (SEE BELOW) OR IF THE VEHICLE WAS NOT INCLUDED IN THE PRIOR RECALL.THE MANUFACTURER CONDUCTED A PRIOR SAFETY RECALL (03V-460) TO ADDRESS THE SUBJECT ISSUE IN CERTAIN MY 2002-03 JEEP LIBERTY VEHICLES.ACCORDING TO DAIMLERCHRYSLER?S NOVEMBER 4, 2003, DEFECT INFORMATION REPORT (SUBMITTED IN ACCORDANCE WITH 49 CFR PART 573), ?THE CONSTANT TENSION LOWER CONTROL ARM BALL JOINTS MAY EXPERIENCE A LOSS OF LUBRICATION WHICH CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE.A CONSTANT TENSION BALL JOINT WHICH HAS SEPARATED FROM THE KNUCKLE MAY RESULT IN LOSS OF VEHICLE DIRECTIONAL CONTROL WITH MINIMAL ADVANCED WARNING.?HOWEVER, EVIDENCE INDICATES THAT SOME VEHICLES SERVICED UNDER RECALL 03V-460 CONTINUED TO EXPERIENCE INVOLUNTARY BALL JOINT SEPARATIONS.THE MANUFACTURER HAS MADE NUMEROUS CHANGES IN THE DESIGN, MATERIAL COMPOSITION, MANUFACTURE, QUALITY CONTROL, SUPPLY, AND INSTALLATION OF THE SUBJECT BALL JOINTS SINCE THE PRIOR SAFETY RECALL WAS INITIATED IN AN EFFORT TO IMPROVE PERFORMANCE WITH RESPECT TO SEALING, LUBRICATION, AND JOINT RETENTION CAPABILITY.BY LETTER DATED AUGUST 1, 2006, DAIMLERCHRYSLER CORPORATION HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL TO ADDRESS POTENTIALLY DEFECTIVE FRONT SUSPENSION LOWER CONTROL ARM BALL JOINTS IN APPROXIMATELY 826,687 MODEL YEAR 2002-2006 JEEP LIBERTY VEHICLES MANUFACTURED BETWEEN JANUARY 2, 2001 AND MARCH 15, 2006, INCLUDINGALL VEHICLES SUBJECT TO THE PRIOR RECALL.THE NHTSA CAMPAIGN NUMBER ASSIGNED TO THIS RECALL IS 06V-288 (DAIMLERCHRYSLER RECALL CAMPAIGN F23).DAIMLERCHRYSLER WILL REPLACE BOTH LEFT AND RIGHT FRONT SUSPENSION LOWER CONTROL ARM BALL JOINTS WITH IMPROVED COMPONENTS FREE OF CHARGE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.