← New search

2002 Jeep Liberty

Owner reports · Recalls · Investigations

More warning signs than most Liberty years

Owner complaints for the 2002 Jeep Liberty are substantially higher than the model-year median of 541.

About this comparison →

When problems were reported

Mileage at the reported incident

1,051 reports with mileage · 757 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 546 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Suspension. Review the 494 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

174 crash reports21 fire reports127 injury reports

Service Brakes, Hydraulic complaints

62 reports
Clear category filter
118,000 miles · Apr 9, 2015
Service Brakes, HydraulicVehicle Speed Control

TL* THE CONTACT OWNS A 2002 JEEP LIBERTY. WHEN COMING TO AN IDLE SPEED AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE INDEPENDENTLY ACCELERATED. THE CONTACT MENTIONED THAT EXCESSIVE FORCE WAS REQUIRED ON THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED THAT THE THRO…

Read full complaint

TL* THE CONTACT OWNS A 2002 JEEP LIBERTY. WHEN COMING TO AN IDLE SPEED AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE INDEPENDENTLY ACCELERATED. THE CONTACT MENTIONED THAT EXCESSIVE FORCE WAS REQUIRED ON THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED THAT THE THROTTLE BODY NEEDED TO BE CLEANED AND THE IDLE CONTROL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 118,000. THE VIN WAS NOT AVAILABLE. UPDATED 5/26/15*CN THE CONSUMER WAS INFORMED THE BRAKE AND ACCELERATOR PEDAL WERE TOO CLOSE TOGETHER. UPDATED 06/18/15*JB

NHTSA ODI #10704619

Mileage unknown · Aug 28, 2014
Electrical SystemElectronic Stability Control (esc)Exterior Lighting

TL* THE CONTACT OWNS A 2002 JEEP LIBERTY. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE PARTS WERE NOT AVAILABLE. THE DEALER DID NOT KNOW WHEN THE PARTS WOULD BE A…

Read full complaint

TL* THE CONTACT OWNS A 2002 JEEP LIBERTY. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE PARTS WERE NOT AVAILABLE. THE DEALER DID NOT KNOW WHEN THE PARTS WOULD BE AVAILABLE. THE VIN WAS NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ODI #10629183

107,000 miles · Apr 7, 2010
Electronic Stability Control (esc)Service Brakes, Hydraulic

TL*THE CONTACT OWNS A 2002 JEEP LIBERTY SPORT. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH. THE ANTI-LOCK BRAKE SYSTEM AND BRAKE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AND SUDDENLY THE SPEEDOMETER BECAME NONFUNCTIONAL. THE CONTACT STATED THAT THE ELECTRICAL WIRES TO THE BLOWER MOTOR OVERHEATED AS A RESULT TO THE WIR…

Read full complaint

TL*THE CONTACT OWNS A 2002 JEEP LIBERTY SPORT. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH. THE ANTI-LOCK BRAKE SYSTEM AND BRAKE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AND SUDDENLY THE SPEEDOMETER BECAME NONFUNCTIONAL. THE CONTACT STATED THAT THE ELECTRICAL WIRES TO THE BLOWER MOTOR OVERHEATED AS A RESULT TO THE WIRING HARNESS. THE DEALER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE LABOR FEE WOULD BE $87 AN HOUR. THE FAILURE MILEAGE WAS 107,000.

NHTSA ODI #10324291

135,000 miles · Oct 11, 2009
Electrical SystemPower TrainService Brakes, Hydraulic

2002 JEEP LIBERTY SPEED SENSOR FAILURE CAUSES SPEEDOMETER TO STOP WORKING, ENGINE TO DIE WHILE DRIVING, LOSS OF POWERSTEERING, LOSS OF BRAKES, STEERING WHEEL LOCKS UP. *TR

NHTSA ODI #10287043

98,000 miles · Apr 26, 2009
Service Brakes, Hydraulic

HAD JUST PURCHASED A JEEP LIBERTY USED --FIRST TIME I DROVE IT ON A WET ROAD-I WAS BRAKING AS USUAL AT A RED LIGHT--THE CAR SKIDDED AND SWERVED 40 FEET, FINALLY STOPPING BUT NOT BEFORE I HAD TO VERY OFF THE ROAD TO AVOID HITTING THE CAR IN FRONT OF ME --I WAS ONLY GOING 30-35 MILES AN HOUR WHEN I STARTED BRAKING--I WAS TERRIF…

Read full complaint

HAD JUST PURCHASED A JEEP LIBERTY USED --FIRST TIME I DROVE IT ON A WET ROAD-I WAS BRAKING AS USUAL AT A RED LIGHT--THE CAR SKIDDED AND SWERVED 40 FEET, FINALLY STOPPING BUT NOT BEFORE I HAD TO VERY OFF THE ROAD TO AVOID HITTING THE CAR IN FRONT OF ME --I WAS ONLY GOING 30-35 MILES AN HOUR WHEN I STARTED BRAKING--I WAS TERRIFIED BY THE FACT THAT THE CAR WOULD NOT STOP AND COULD ONLY IMAGINE WHAT WOULD HAVE HAPPENED UNDER DIFFERENT CIRCUMSTANCES!! --TOOK THE CAR INTO THE JEEP DEALERSHIP--THEY SAID THE BRAKES WERE FINE --I HAD NEW TIRES PUT ON THE CAR --EVEN THOUGH THE DEALERSHIP SAID THE TIRES WERE FINE TOO --THE SECOND TIME -(--WET ROAD)--I WAS GOING ABOUT 25 MILES AND HOUR AND LIGHTLY BRAKED ----CAR SLID INSTEAD OF STOPPING---SAME DAY---NOW VERY CAUTIOUS, I CAREFULLY HIT THE BRAKES WHEN A CAR QUITE A DISTANCE AHEAD OF ME PULLED OUT --AGAIN--I WAS ONLY GOING ABOUT 35MPH---FORTUNATELY I STARTED BRAKING THE SECOND I SAW HIM BECAUSE THE CAR SKIDDED 30-40 FEET AT LEAST, TURNING TOWARD THE RIGHT, AND FINALLY STOPPED 3 CAR LENGTHS BEFORE I WOULD HAVE HIT THIS CAR IN THE DRIVER SIDE DOOR ---HAD I NOT HAD THE PREVIOUS INCIDENT JUST MINUTES BEFORE ---I WOULD HAVE BEEN GOING 60 MILES AN HOUR AND NOT BEEN ABLE TO AVOID AN ACCIDENT--I WENT ONLINE TODAY --THERE ARE NUMEROUS SIMILAR COMPLAINTS WITH JEEP LIBERTY'S--ONE PERSON REFERS TO HER LIBERTY AS A DEATH TRAP--ANOTHER MAN SAID HIS WIFE COMPLAINED OF THIS AND HE DIDN'T BELIEVE HER UNTIL HE SKIDDED THROUGH AN INTERSECTION GOING ONLY 20 MPH!!! SOMEONE ELSE, KNOWING THIS PROBLEM , SIMPLY TRADED HIS VEHICLE TO AN UNSUSPECTING BUYER ---THIS DEFECT IS FRIGHTENING!!!! THIS IS A CAR I RARELY DRIVE-- FORTUNATELY BECAUSE NOW I CAN'T TAKE IT ON THE ROAD FOR FEAR OF HAVING A SERIOUS ACCIDENT!! *TR

NHTSA ODI #10266748

70,000 miles · May 14, 2008
Service Brakes, Hydraulic

I WAS ATTEMPTING TO STOP, GOING DOWNHILL ON A DAY IT HAD RAINED BUT WAS NO LONGER RAINING. I HAD MY 4 YEAR OLD DAUGHTER IN THE CAR THE DAY OF THIS INCIDENT. I APPLIED THE BRAKES TO STOP BECAUSE ANOTHER CAR WAS MAKING A LEFT HAND TURN AT THE END OF THE HILL AND THE VEHICLE STARTED TO SLIDE I WAS GOING APPROXIMATELY 25 MILES AN HO…

Read full complaint

I WAS ATTEMPTING TO STOP, GOING DOWNHILL ON A DAY IT HAD RAINED BUT WAS NO LONGER RAINING. I HAD MY 4 YEAR OLD DAUGHTER IN THE CAR THE DAY OF THIS INCIDENT. I APPLIED THE BRAKES TO STOP BECAUSE ANOTHER CAR WAS MAKING A LEFT HAND TURN AT THE END OF THE HILL AND THE VEHICLE STARTED TO SLIDE I WAS GOING APPROXIMATELY 25 MILES AN HOUR, AND LUCKILY STARTED TO STOP IN TIME BECAUSE I SLIDE ALMOST 50 FEET AND TURNED THE WHEEL SHARPLY TO AVOID THE CAR. THE JEEP NEVER CAME TO A STOP THE CAR TURNED AND WAS ABLE TO LET OFF THE BRAKES. THE JEEP HAS DONE THIS ON SEVERAL OCCASION PRIOR AND I THOUGHT I NEED BRAKES AND THAT THEM REPLACED. THIS HAPPENED AFTER I HAD NEW BRAKES PUT ON. *TR

NHTSA ODI #10227720

Mileage unknown · Dec 18, 2007
Service Brakes, HydraulicCrash

WHEN IT IS DAMP OUT OR MOISTURE IN THE AIR, MY BRAKES LOCKED UP AND I HAVE NO CONTROL OVER MY JEEP LIBERTY, I HAVE SLID OFF THE ROAD TWICE. *TR

NHTSA ODI #10212255

61,260 miles · Nov 14, 2007
Service Brakes, HydraulicSuspensionCrash

TL*THE CONTACT OWNS A 2002 JEEP LIBERTY. ON APRIL 21, 2006, WHILE DRIVING UPHILL AT 5 MPH, THE VEHICLE SURGED AND REAR ENDED THE PRECEDING VEHICLE. THE CONTACT WAS CHARGED WITH FAILURE TO YIELD. THE MECHANIC STATED THAT THE BRAKES AND THE BRAKE ROTORS FAILED. PRIOR TO THE CRASH, SHE RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIG…

Read full complaint

TL*THE CONTACT OWNS A 2002 JEEP LIBERTY. ON APRIL 21, 2006, WHILE DRIVING UPHILL AT 5 MPH, THE VEHICLE SURGED AND REAR ENDED THE PRECEDING VEHICLE. THE CONTACT WAS CHARGED WITH FAILURE TO YIELD. THE MECHANIC STATED THAT THE BRAKES AND THE BRAKE ROTORS FAILED. PRIOR TO THE CRASH, SHE RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 06V288000 (SUSPENSION:FRONT:CONTROL ARM: LOWER BALL JOINT) IN OCTOBER OF 2006. SHE MADE FOUR ATTEMPTS TO HAVE THE RECALL REPAIR PERFORMED; HOWEVER, EACH TIME SHE WAS INFORMED THAT THE PART WAS UNAVAILABLE AND THE DEALER WOULD CALL HER WHEN IT ARRIVED. THE CONTACT NEVER RECEIVED A CALL AND GAVE UP. A COUPLE OF MONTHS AFTER THE CRASH, SHE RECEIVED A SECOND RECALL NOTICE. THE CONTACT BELIEVES THAT THE CRASH OCCURRED BECAUSE THE REPAIR WAS NOT MADE EARLIER. THE VEHICLE SUSTAINED DAMAGES TO THE BUMPER, FOG LIGHTS, FRONT BUMPER COVER, GRILL, FRONT LAMP, HEAD LAMP, PASSENGER SIDE HEAD LAMP ASSEMBLY, HOOD PANEL, HOOD ASSEMBLY, FRONT PASSENGER SIDE WIRING HARNESS, PASSENGER SIDE OUTSIDE FENDER, PASSENGER SIDE FENDER BRACKET, FRONT PASSENGER SIDE DOOR GLASS RUNNING CHANNEL, HAZARDOUS WASTE DISPOSAL, PAINT JOB, AND FENDER BRACKETS. THE COST TO REPAIR THE DAMAGES WOULD BE $3,759. THE CURRENT MILEAGE WAS 89,682 AND FAILURE MILEAGE WAS 61,260. UPDATED 01/07/08. *LJ UPDATED 12/31/07 *TR

NHTSA ODI #10208941

34,000 miles · Oct 10, 2007
Service Brakes, Hydraulic

WHEN BRAKING, LEFT BRAKE STICKS AND JERKS VEHICLE TO THE LEFT. EXTREMELY DANGEROUS AT HIGHWAY SPEEDS. ALMOST CAUSING SEVERAL ACCIDENTS. BRAKES HAVE BEEN SERVICED SEVERAL TIMES. REPLACING ROTORS, AND PADS AT DEALERSHIP. CONDITION LESSENS AFTER BEING SERVICED BUT CONTINUALLY WORSENS OVER TIME. *JB

NHTSA ODI #10205389

Mileage unknown · Sep 26, 2007
EquipmentService Brakes, HydraulicVisibility

LTR IN REGARDS TO THE RECALL SERVICES ON HER 2002 JEEP LIBERTY; SHE IS SEEKING REIMBURSEMENT AND RECOMMENDATIONS ON HOW TO RESOLVE REPAIRS DONE TO HER VEHICLE. *KB THE CONSUMER STATED THE VEHICLE HAS A BAD VIBRATION WHEN COMING TO A STOP. THE CONSUMER WAS TOLD THE TIRES NEEDED TO BE BALANCED AND ROTATED, HOWEVER THE CONSUMER C…

Read full complaint

LTR IN REGARDS TO THE RECALL SERVICES ON HER 2002 JEEP LIBERTY; SHE IS SEEKING REIMBURSEMENT AND RECOMMENDATIONS ON HOW TO RESOLVE REPAIRS DONE TO HER VEHICLE. *KB THE CONSUMER STATED THE VEHICLE HAS A BAD VIBRATION WHEN COMING TO A STOP. THE CONSUMER WAS TOLD THE TIRES NEEDED TO BE BALANCED AND ROTATED, HOWEVER THE CONSUMER CONTINUED TO FEEL THE VIBRATION AFTER THE WORK WAS DONE. THE CONSUMER WAS INFORMED THE BRAKES AND ROTORS HAD RUSTED. THE WIPER BLADES WERE REPLACED. THE DRIVERS SIDE SPEAKER WAS MAKING A RATTLING NOISE. *JB

NHTSA ODI #10204904

Official recalls

8

15V046000 · Air Bags:frontal

Jan 28, 2015

Chrysler (FCA US LLC) is recalling certain model year 2002-2003 Jeep Liberty vehicles manufactured January 9, 2001, to March 28, 2003, 2002-2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, to May 23 2003, and 2003-2004 Dodge Viper vehicles manufactured November 1, 2001, to June 30, 2004. Due to electrical noise beyond the tolerance of the air bag electronic control module (ECM), a component in the ECM may fail, causing the front air bags, side air bags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence & remedy

Consequence: Inadvertent deployment of the air bags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler dealers will replace the air bag control module and side impact sensors as required, free of charge. This recall remedy was applied during earlier recall campaigns of these vehicles under safety recalls 12V527 and 13V040. All owners that have not had the recall repair performed under safety recalls 12V527 or 13V040 are strongly encouraged to have it performed and not wait for the final remedy to be deployed to the field. The recall began on December 29, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R06.

13V252000 · Fuel System, Gasoline:storage:tank Assembly; Structure

Jun 19, 2013

Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.

Consequence & remedy

Consequence: A fuel leak in the presence of an ignition source may result in a fire.

Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).

Additional source detail variants (2)

Structure

Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.

Consequence: A fuel leak in the presence of an ignition source may result in a fire.

Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).

Fuel System, Gasoline:storage:tank Assembly

Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.

Consequence: A fuel leak in the presence of an ignition source may result in a fire.

Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).

12V527000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE

Nov 8, 2012

Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence & remedy

Consequence: Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.

Additional source detail variants (2)

Air Bags:frontal:sensor/control MODULE-INACTIVE

Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence: Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.

Air Bags

Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence: Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.

09V119000 · Suspension:front:control Arm

Apr 9, 2009

CHRYSLER IS RECALLING 42,469 MY 2002-2003 JEEP LIBERTY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN SALT BELT STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA , WISCONSIN AND THE DISTRICT OF COLUMBIA. THE FRONT SUSPENSION UPPER CONTROL ARM BALL JOINT MAY EXPERIENCE A LOSS OF LUBRICATION WHICH COULD LEAD TO CORROSION, ACCELERATED WEAR, AND POSSIBLE SEPARATION WHILE DRIVING.

Consequence & remedy

Consequence: FAILURE OF THE BALL JOINT COULD RESULT IN A LOSS OF STEERING CAPABILITY, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE FRONT UPPER CONTROL ARM ASSEMBLIES FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT APRIL 24, 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

06V288000 · Suspension:front:control Arm:lower Ball Joint

Aug 3, 2006

ON CERTAIN TRUCKS, THE CONSTANT TENSION FRONT LOWER BALL JOINTS MAY EXPERIENCE CONTAMINATION. IF THE VEHICLE IS OPERATED FOR AN EXTENDED PERIOD WITH THIS CONDITION, THE BALL JOINT MAY EVENTUALLY EXPERIENCE WEAR AND LOOSENESS.

Consequence & remedy

Consequence: WHEN THE DRIVER CONTINUES TO OPERATE THE VEHICLE WITH THIS CONDITION, THE CONTAMINATION CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE CAUSING A LOSS OF VEHICLE STEERING CONTROL INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE FRONT LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 11, 2006. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

03V460000 · Suspension:front:control Arm:lower Ball Joint

Nov 10, 2003

ON CERTAIN SPORT UTILITY VEHICLES, THE LOWER CONTROL ARM BALL JOINTS CAN EXPERIENCE A LOSS OF LUBRICATION THAT CAN LEAD TO CORROSION, ACCELERATED WEAR, AND POSSIBLE SEPARATION FROM THE STEERING KNUCKLE.

Consequence & remedy

Consequence: A BALL JOINT THATHAS SEPARATED FROM THE KNUCKLE COULD RESULT IN LOSS OF VEHICLE DIRECTIONAL CONTROL AND COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REPLACE THE FRONT LOWER CONTROL ARM BALL JOINTS WITH MODIFIED ASSEMBLIES AND HEAT SHIELDS ON VEHICLES BUILT BETWEEN JANUARY 2, 2001 AND OCTOBER 4, 2002. ON VEHICLES BUILT BETWEEN OCTOBER 5, 2002 AND MARCH 26, 2003, DEALERS WILL INSPECT THE BALL JOINT ASSEMBLIES (AND REPLACE THEM AS NECESSARY) AND INSTALL HEAT SHIELDS. OWNER NOTIFICATION BEGAN ON DECEMBER 15, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

01V373000 · Air Bags:frontal

Dec 5, 2001

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. IN THE EVENT OF A SEVERE FRONTAL OFFSET COLLISION, SHARP EDGES ON THE POWER STEERING PRESSURE HOSE BRACKET COULD CUT THE FRONT IMPACT SENSOR WIRING INSULATION CAUSING A SHORT CIRCUIT IN THE WIRING.

Consequence & remedy

Consequence: THIS COULD DELAY THE DEPLOYMENT OF THE AIR BAG SYSTEM, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.

Remedy: DEALERS WILL WRAP THE FRONT IMPACT SENSOR WIRE HARNESS WITH PROTECTIVE INSULATION TO PREVENT THE POSSIBILITY OF DAMAGE. OWNER NOTIFICATION BEGAN FEBRUARY 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

01V311000 · Unknown Or Other

Oct 4, 2001

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE DRIVER'S SIDE KNEE BLOCKER TRIM PANEL ASSEMBLY CAN DISENGAGE, FALL, AND STARTLE THE OPERATOR.

Consequence & remedy

Consequence: THIS COULD STARTLE THE OPERATOR, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE KNEE BLOCKER TRIM PANEL. OWNER NOTIFICATION BEGAN NOVEMBER 26, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

10

RQ14001 · Jeep Inadvertent Air Bag Deployment

Opened May 29, 2014 · Closed Nov 13, 2015

Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window; Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Additional source detail variants (24)

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

EA12005 · Crash Related Fuel Tank Fires

Opened Jun 12, 2012 · Closed Nov 14, 2014

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage:tank Assembly

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

EA12001 · Inadvertent Air Bag Deployment

Opened Jan 23, 2012 · Closed Feb 21, 2013

Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:sensor/control MODULE-INACTIVE

The investigation was opened based on reports of frontal air bag inadvertent deployments (ABIDs) on model year (MY) 2002-2003 Jeep Liberty vehicles.Data provided by Chrysler indicate that the air bag squib filter circuitry inside the Occupant Restraint Control (ORC) module can degrade and result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated on the roadway.As of Oct. 04, 2012, ODI is aware of 131 frontal ABIDs on the Jeep Liberty vehicles resulting in 62 injuries consisting of burns, cuts and bruises to the upper body region.There were no reports of loss of vehicle control or vehicle crashes.Some owners noted that the air bag warning light (ABL) and/or chime had activated just seconds prior to the air bag deployment, while others stated that they did not observe any prior ABL illumination.Chrysler's analysis found there were no reports of ABID on Liberty vehicles build after March 28, 2003, a date which coincides with a filter circuit design change in the ORC module.The Jeep Grand Cherokee and Dodge Viper were identified as having the same basic circuit.ODI is aware of 61 frontal ABIDs with 31 injuries on the Grand Cherokee and none on the Dodge Viper.In its Nov. 07, 2012 letter (12V-527), Chrysler announced plans to recall 744,822 Jeep Vehicles (MY02-03 Liberty through 03/28/03 and MY02-04 Grand Cherokee through 5/23/03).The remedy consists of installing an in-line jumper harness with an integrated squib circuit electrical filter.In addition, in Feb 05, 2013 letter (13V-040), Chrysler added the MY03-04 Dodge Viper (through 6/30/04) with a similar remedy, bringing the total number of recalled vehicles to 748,482.During the investigation ODI contacted the ORC module supplier (TRW) to determine the usage of this circuitry in other manufacturers? vehicles.As a result, ODI sent peer Information Request (IR) letters to five other manufactures.Toyota's response identified 72 frontal ABIDs resulting in 31 injuries.The rate and failure mode/trend were consistent with the subject defective issue as reported by Chrysler.In a Jan. 30, 2013 letter (13V-029), Toyota announced plans to recall 897,709 MY2003-2004 Corolla/Matrix and Pontiac Vibe vehicles and will utilize a similar remedy to that of Chrysler consisting of adding an in-line noise filter to its air bag wire harness.Honda's IR response reported 126 unique ABIDs for both frontal, side impact and/or side curtain air bag deployments across 4 models and 800k vehicles.However upon further review, no more than 25 of the reports appeared to be frontal ABIDs.The remaining involved less aggressive non-frontal ABIDs mainly stemming from side sensors that trigger side and/or side curtain air bags upon undercarriage debris strike or heavy door slams.The Honda rates are lower than those from the recalled Liberty and Toyota models, and with the exception of the MY 2002-2003 Odyssey, the other Honda models' failure mode/trend was also less severe.ODI will continueto monitor the affected Honda models.There were no reports of ABIDs from the other three peer manufacturers.It should be noted that since the October 2012 data collection date, ODI has received 4 additional Jeep Liberty and 2 Jeep Grand Cherokee reports for frontal ABIDs with two reports alleging loss of vehicle control and crashes. To date, the ORC modules from the two crash vehicles have not been available for detailed analysis by Chrysler or ODI, so the cause of the ABIDs cannot be confirmed at this time.Accordingly the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAI

Additional source detail variants (12)

Air Bags

The investigation was opened based on reports of frontal air bag inadvertent deployments (ABIDs) on model year (MY) 2002-2003 Jeep Liberty vehicles.Data provided by Chrysler indicate that the air bag squib filter circuitry inside the Occupant Restraint Control (ORC) module can degrade and result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated on the roadway.As of Oct. 04, 2012, ODI is aware of 131 frontal ABIDs on the Jeep Liberty vehicles resulting in 62 injuries consisting of burns, cuts and bruises to the upper body region.There were no reports of loss of vehicle control or vehicle crashes.Some owners noted that the air bag warning light (ABL) and/or chime had activated just seconds prior to the air bag deployment, while others stated that they did not observe any prior ABL illumination.Chrysler's analysis found there were no reports of ABID on Liberty vehicles build after March 28, 2003, a date which coincides with a filter circuit design change in the ORC module.The Jeep Grand Cherokee and Dodge Viper were identified as having the same basic circuit.ODI is aware of 61 frontal ABIDs with 31 injuries on the Grand Cherokee and none on the Dodge Viper.In its Nov. 07, 2012 letter (12V-527), Chrysler announced plans to recall 744,822 Jeep Vehicles (MY02-03 Liberty through 03/28/03 and MY02-04 Grand Cherokee through 5/23/03).The remedy consists of installing an in-line jumper harness with an integrated squib circuit electrical filter.In addition, in Feb 05, 2013 letter (13V-040), Chrysler added the MY03-04 Dodge Viper (through 6/30/04) with a similar remedy, bringing the total number of recalled vehicles to 748,482.During the investigation ODI contacted the ORC module supplier (TRW) to determine the usage of this circuitry in other manufacturers? vehicles.As a result, ODI sent peer Information Request (IR) letters to five other manufactures.Toyota's response identified 72 frontal ABIDs resulting in 31 injuries.The rate and failure mode/trend were consistent with the subject defective issue as reported by Chrysler.In a Jan. 30, 2013 letter (13V-029), Toyota announced plans to recall 897,709 MY2003-2004 Corolla/Matrix and Pontiac Vibe vehicles and will utilize a similar remedy to that of Chrysler consisting of adding an in-line noise filter to its air bag wire harness.Honda's IR response reported 126 unique ABIDs for both frontal, side impact and/or side curtain air bag deployments across 4 models and 800k vehicles.However upon further review, no more than 25 of the reports appeared to be frontal ABIDs.The remaining involved less aggressive non-frontal ABIDs mainly stemming from side sensors that trigger side and/or side curtain air bags upon undercarriage debris strike or heavy door slams.The Honda rates are lower than those from the recalled Liberty and Toyota models, and with the exception of the MY 2002-2003 Odyssey, the other Honda models' failure mode/trend was also less severe.ODI will continueto monitor the affected Honda models.There were no reports of ABIDs from the other three peer manufacturers.It should be noted that since the October 2012 data collection date, ODI has received 4 additional Jeep Liberty and 2 Jeep Grand Cherokee reports for frontal ABIDs with two reports alleging loss of vehicle control and crashes. To date, the ORC modules from the two crash vehicles have not been available for detailed analysis by Chrysler or ODI, so the cause of the ABIDs cannot be confirmed at this time.Accordingly the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAI

Air Bags

The investigation was opened based on reports of frontal air bag inadvertent deployments (ABIDs) on model year (MY) 2002-2003 Jeep Liberty vehicles.Data provided by Chrysler indicate that the air bag squib filter circuitry inside the Occupant Restraint Control (ORC) module can degrade and result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated on the roadway.As of Oct. 04, 2012, ODI is aware of 131 frontal ABIDs on the Jeep Liberty vehicles resulting in 62 injuries consisting of burns, cuts and bruises to the upper body region.There were no reports of loss of vehicle control or vehicle crashes.Some owners noted that the air bag warning light (ABL) and/or chime had activated just seconds prior to the air bag deployment, while others stated that they did not observe any prior ABL illumination.Chrysler's analysis found there were no reports of ABID on Liberty vehicles build after March 28, 2003, a date which coincides with a filter circuit design change in the ORC module.The Jeep Grand Cherokee and Dodge Viper were identified as having the same basic circuit.ODI is aware of 61 frontal ABIDs with 31 injuries on the Grand Cherokee and none on the Dodge Viper.In its Nov. 07, 2012 letter (12V-527), Chrysler announced plans to recall 744,822 Jeep Vehicles (MY02-03 Liberty through 03/28/03 and MY02-04 Grand Cherokee through 5/23/03).The remedy consists of installing an in-line jumper harness with an integrated squib circuit electrical filter.In addition, in Feb 05, 2013 letter (13V-040), Chrysler added the MY03-04 Dodge Viper (through 6/30/04) with a similar remedy, bringing the total number of recalled vehicles to 748,482.During the investigation ODI contacted the ORC module supplier (TRW) to determine the usage of this circuitry in other manufacturers? vehicles.As a result, ODI sent peer Information Request (IR) letters to five other manufactures.Toyota's response identified 72 frontal ABIDs resulting in 31 injuries.The rate and failure mode/trend were consistent with the subject defective issue as reported by Chrysler.In a Jan. 30, 2013 letter (13V-029), Toyota announced plans to recall 897,709 MY2003-2004 Corolla/Matrix and Pontiac Vibe vehicles and will utilize a similar remedy to that of Chrysler consisting of adding an in-line noise filter to its air bag wire harness.Honda's IR response reported 126 unique ABIDs for both frontal, side impact and/or side curtain air bag deployments across 4 models and 800k vehicles.However upon further review, no more than 25 of the reports appeared to be frontal ABIDs.The remaining involved less aggressive non-frontal ABIDs mainly stemming from side sensors that trigger side and/or side curtain air bags upon undercarriage debris strike or heavy door slams.The Honda rates are lower than those from the recalled Liberty and Toyota models, and with the exception of the MY 2002-2003 Odyssey, the other Honda models' failure mode/trend was also less severe.ODI will continueto monitor the affected Honda models.There were no reports of ABIDs from the other three peer manufacturers.It should be noted that since the October 2012 data collection date, ODI has received 4 additional Jeep Liberty and 2 Jeep Grand Cherokee reports for frontal ABIDs with two reports alleging loss of vehicle control and crashes. To date, the ORC modules from the two crash vehicles have not been available for detailed analysis by Chrysler or ODI, so the cause of the ABIDs cannot be confirmed at this time.Accordingly the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAI

Air Bags

The investigation was opened based on reports of frontal air bag inadvertent deployments (ABIDs) on model year (MY) 2002-2003 Jeep Liberty vehicles.Data provided by Chrysler indicate that the air bag squib filter circuitry inside the Occupant Restraint Control (ORC) module can degrade and result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated on the roadway.As of Oct. 04, 2012, ODI is aware of 131 frontal ABIDs on the Jeep Liberty vehicles resulting in 62 injuries consisting of burns, cuts and bruises to the upper body region.There were no reports of loss of vehicle control or vehicle crashes.Some owners noted that the air bag warning light (ABL) and/or chime had activated just seconds prior to the air bag deployment, while others stated that they did not observe any prior ABL illumination.Chrysler's analysis found there were no reports of ABID on Liberty vehicles build after March 28, 2003, a date which coincides with a filter circuit design change in the ORC module.The Jeep Grand Cherokee and Dodge Viper were identified as having the same basic circuit.ODI is aware of 61 frontal ABIDs with 31 injuries on the Grand Cherokee and none on the Dodge Viper.In its Nov. 07, 2012 letter (12V-527), Chrysler announced plans to recall 744,822 Jeep Vehicles (MY02-03 Liberty through 03/28/03 and MY02-04 Grand Cherokee through 5/23/03).The remedy consists of installing an in-line jumper harness with an integrated squib circuit electrical filter.In addition, in Feb 05, 2013 letter (13V-040), Chrysler added the MY03-04 Dodge Viper (through 6/30/04) with a similar remedy, bringing the total number of recalled vehicles to 748,482.During the investigation ODI contacted the ORC module supplier (TRW) to determine the usage of this circuitry in other manufacturers? vehicles.As a result, ODI sent peer Information Request (IR) letters to five other manufactures.Toyota's response identified 72 frontal ABIDs resulting in 31 injuries.The rate and failure mode/trend were consistent with the subject defective issue as reported by Chrysler.In a Jan. 30, 2013 letter (13V-029), Toyota announced plans to recall 897,709 MY2003-2004 Corolla/Matrix and Pontiac Vibe vehicles and will utilize a similar remedy to that of Chrysler consisting of adding an in-line noise filter to its air bag wire harness.Honda's IR response reported 126 unique ABIDs for both frontal, side impact and/or side curtain air bag deployments across 4 models and 800k vehicles.However upon further review, no more than 25 of the reports appeared to be frontal ABIDs.The remaining involved less aggressive non-frontal ABIDs mainly stemming from side sensors that trigger side and/or side curtain air bags upon undercarriage debris strike or heavy door slams.The Honda rates are lower than those from the recalled Liberty and Toyota models, and with the exception of the MY 2002-2003 Odyssey, the other Honda models' failure mode/trend was also less severe.ODI will continueto monitor the affected Honda models.There were no reports of ABIDs from the other three peer manufacturers.It should be noted that since the October 2012 data collection date, ODI has received 4 additional Jeep Liberty and 2 Jeep Grand Cherokee reports for frontal ABIDs with two reports alleging loss of vehicle control and crashes. To date, the ORC modules from the two crash vehicles have not been available for detailed analysis by Chrysler or ODI, so the cause of the ABIDs cannot be confirmed at this time.Accordingly the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAI

Air Bags:frontal

The investigation was opened based on reports of frontal air bag inadvertent deployments (ABIDs) on model year (MY) 2002-2003 Jeep Liberty vehicles.Data provided by Chrysler indicate that the air bag squib filter circuitry inside the Occupant Restraint Control (ORC) module can degrade and result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated on the roadway.As of Oct. 04, 2012, ODI is aware of 131 frontal ABIDs on the Jeep Liberty vehicles resulting in 62 injuries consisting of burns, cuts and bruises to the upper body region.There were no reports of loss of vehicle control or vehicle crashes.Some owners noted that the air bag warning light (ABL) and/or chime had activated just seconds prior to the air bag deployment, while others stated that they did not observe any prior ABL illumination.Chrysler's analysis found there were no reports of ABID on Liberty vehicles build after March 28, 2003, a date which coincides with a filter circuit design change in the ORC module.The Jeep Grand Cherokee and Dodge Viper were identified as having the same basic circuit.ODI is aware of 61 frontal ABIDs with 31 injuries on the Grand Cherokee and none on the Dodge Viper.In its Nov. 07, 2012 letter (12V-527), Chrysler announced plans to recall 744,822 Jeep Vehicles (MY02-03 Liberty through 03/28/03 and MY02-04 Grand Cherokee through 5/23/03).The remedy consists of installing an in-line jumper harness with an integrated squib circuit electrical filter.In addition, in Feb 05, 2013 letter (13V-040), Chrysler added the MY03-04 Dodge Viper (through 6/30/04) with a similar remedy, bringing the total number of recalled vehicles to 748,482.During the investigation ODI contacted the ORC module supplier (TRW) to determine the usage of this circuitry in other manufacturers? vehicles.As a result, ODI sent peer Information Request (IR) letters to five other manufactures.Toyota's response identified 72 frontal ABIDs resulting in 31 injuries.The rate and failure mode/trend were consistent with the subject defective issue as reported by Chrysler.In a Jan. 30, 2013 letter (13V-029), Toyota announced plans to recall 897,709 MY2003-2004 Corolla/Matrix and Pontiac Vibe vehicles and will utilize a similar remedy to that of Chrysler consisting of adding an in-line noise filter to its air bag wire harness.Honda's IR response reported 126 unique ABIDs for both frontal, side impact and/or side curtain air bag deployments across 4 models and 800k vehicles.However upon further review, no more than 25 of the reports appeared to be frontal ABIDs.The remaining involved less aggressive non-frontal ABIDs mainly stemming from side sensors that trigger side and/or side curtain air bags upon undercarriage debris strike or heavy door slams.The Honda rates are lower than those from the recalled Liberty and Toyota models, and with the exception of the MY 2002-2003 Odyssey, the other Honda models' failure mode/trend was also less severe.ODI will continueto monitor the affected Honda models.There were no reports of ABIDs from the other three peer manufacturers.It should be noted that since the October 2012 data collection date, ODI has received 4 additional Jeep Liberty and 2 Jeep Grand Cherokee reports for frontal ABIDs with two reports alleging loss of vehicle control and crashes. To date, the ORC modules from the two crash vehicles have not been available for detailed analysis by Chrysler or ODI, so the cause of the ABIDs cannot be confirmed at this time.Accordingly the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAI

Air Bags:frontal

The investigation was opened based on reports of frontal air bag inadvertent deployments (ABIDs) on model year (MY) 2002-2003 Jeep Liberty vehicles.Data provided by Chrysler indicate that the air bag squib filter circuitry inside the Occupant Restraint Control (ORC) module can degrade and result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated on the roadway.As of Oct. 04, 2012, ODI is aware of 131 frontal ABIDs on the Jeep Liberty vehicles resulting in 62 injuries consisting of burns, cuts and bruises to the upper body region.There were no reports of loss of vehicle control or vehicle crashes.Some owners noted that the air bag warning light (ABL) and/or chime had activated just seconds prior to the air bag deployment, while others stated that they did not observe any prior ABL illumination.Chrysler's analysis found there were no reports of ABID on Liberty vehicles build after March 28, 2003, a date which coincides with a filter circuit design change in the ORC module.The Jeep Grand Cherokee and Dodge Viper were identified as having the same basic circuit.ODI is aware of 61 frontal ABIDs with 31 injuries on the Grand Cherokee and none on the Dodge Viper.In its Nov. 07, 2012 letter (12V-527), Chrysler announced plans to recall 744,822 Jeep Vehicles (MY02-03 Liberty through 03/28/03 and MY02-04 Grand Cherokee through 5/23/03).The remedy consists of installing an in-line jumper harness with an integrated squib circuit electrical filter.In addition, in Feb 05, 2013 letter (13V-040), Chrysler added the MY03-04 Dodge Viper (through 6/30/04) with a similar remedy, bringing the total number of recalled vehicles to 748,482.During the investigation ODI contacted the ORC module supplier (TRW) to determine the usage of this circuitry in other manufacturers? vehicles.As a result, ODI sent peer Information Request (IR) letters to five other manufactures.Toyota's response identified 72 frontal ABIDs resulting in 31 injuries.The rate and failure mode/trend were consistent with the subject defective issue as reported by Chrysler.In a Jan. 30, 2013 letter (13V-029), Toyota announced plans to recall 897,709 MY2003-2004 Corolla/Matrix and Pontiac Vibe vehicles and will utilize a similar remedy to that of Chrysler consisting of adding an in-line noise filter to its air bag wire harness.Honda's IR response reported 126 unique ABIDs for both frontal, side impact and/or side curtain air bag deployments across 4 models and 800k vehicles.However upon further review, no more than 25 of the reports appeared to be frontal ABIDs.The remaining involved less aggressive non-frontal ABIDs mainly stemming from side sensors that trigger side and/or side curtain air bags upon undercarriage debris strike or heavy door slams.The Honda rates are lower than those from the recalled Liberty and Toyota models, and with the exception of the MY 2002-2003 Odyssey, the other Honda models' failure mode/trend was also less severe.ODI will continueto monitor the affected Honda models.There were no reports of ABIDs from the other three peer manufacturers.It should be noted that since the October 2012 data collection date, ODI has received 4 additional Jeep Liberty and 2 Jeep Grand Cherokee reports for frontal ABIDs with two reports alleging loss of vehicle control and crashes. To date, the ORC modules from the two crash vehicles have not been available for detailed analysis by Chrysler or ODI, so the cause of the ABIDs cannot be confirmed at this time.Accordingly the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAI

Air Bags:frontal

The investigation was opened based on reports of frontal air bag inadvertent deployments (ABIDs) on model year (MY) 2002-2003 Jeep Liberty vehicles.Data provided by Chrysler indicate that the air bag squib filter circuitry inside the Occupant Restraint Control (ORC) module can degrade and result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated on the roadway.As of Oct. 04, 2012, ODI is aware of 131 frontal ABIDs on the Jeep Liberty vehicles resulting in 62 injuries consisting of burns, cuts and bruises to the upper body region.There were no reports of loss of vehicle control or vehicle crashes.Some owners noted that the air bag warning light (ABL) and/or chime had activated just seconds prior to the air bag deployment, while others stated that they did not observe any prior ABL illumination.Chrysler's analysis found there were no reports of ABID on Liberty vehicles build after March 28, 2003, a date which coincides with a filter circuit design change in the ORC module.The Jeep Grand Cherokee and Dodge Viper were identified as having the same basic circuit.ODI is aware of 61 frontal ABIDs with 31 injuries on the Grand Cherokee and none on the Dodge Viper.In its Nov. 07, 2012 letter (12V-527), Chrysler announced plans to recall 744,822 Jeep Vehicles (MY02-03 Liberty through 03/28/03 and MY02-04 Grand Cherokee through 5/23/03).The remedy consists of installing an in-line jumper harness with an integrated squib circuit electrical filter.In addition, in Feb 05, 2013 letter (13V-040), Chrysler added the MY03-04 Dodge Viper (through 6/30/04) with a similar remedy, bringing the total number of recalled vehicles to 748,482.During the investigation ODI contacted the ORC module supplier (TRW) to determine the usage of this circuitry in other manufacturers? vehicles.As a result, ODI sent peer Information Request (IR) letters to five other manufactures.Toyota's response identified 72 frontal ABIDs resulting in 31 injuries.The rate and failure mode/trend were consistent with the subject defective issue as reported by Chrysler.In a Jan. 30, 2013 letter (13V-029), Toyota announced plans to recall 897,709 MY2003-2004 Corolla/Matrix and Pontiac Vibe vehicles and will utilize a similar remedy to that of Chrysler consisting of adding an in-line noise filter to its air bag wire harness.Honda's IR response reported 126 unique ABIDs for both frontal, side impact and/or side curtain air bag deployments across 4 models and 800k vehicles.However upon further review, no more than 25 of the reports appeared to be frontal ABIDs.The remaining involved less aggressive non-frontal ABIDs mainly stemming from side sensors that trigger side and/or side curtain air bags upon undercarriage debris strike or heavy door slams.The Honda rates are lower than those from the recalled Liberty and Toyota models, and with the exception of the MY 2002-2003 Odyssey, the other Honda models' failure mode/trend was also less severe.ODI will continueto monitor the affected Honda models.There were no reports of ABIDs from the other three peer manufacturers.It should be noted that since the October 2012 data collection date, ODI has received 4 additional Jeep Liberty and 2 Jeep Grand Cherokee reports for frontal ABIDs with two reports alleging loss of vehicle control and crashes. To date, the ORC modules from the two crash vehicles have not been available for detailed analysis by Chrysler or ODI, so the cause of the ABIDs cannot be confirmed at this time.Accordingly the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAI

Air Bags:frontal:driver Side:inflator Module

The investigation was opened based on reports of frontal air bag inadvertent deployments (ABIDs) on model year (MY) 2002-2003 Jeep Liberty vehicles.Data provided by Chrysler indicate that the air bag squib filter circuitry inside the Occupant Restraint Control (ORC) module can degrade and result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated on the roadway.As of Oct. 04, 2012, ODI is aware of 131 frontal ABIDs on the Jeep Liberty vehicles resulting in 62 injuries consisting of burns, cuts and bruises to the upper body region.There were no reports of loss of vehicle control or vehicle crashes.Some owners noted that the air bag warning light (ABL) and/or chime had activated just seconds prior to the air bag deployment, while others stated that they did not observe any prior ABL illumination.Chrysler's analysis found there were no reports of ABID on Liberty vehicles build after March 28, 2003, a date which coincides with a filter circuit design change in the ORC module.The Jeep Grand Cherokee and Dodge Viper were identified as having the same basic circuit.ODI is aware of 61 frontal ABIDs with 31 injuries on the Grand Cherokee and none on the Dodge Viper.In its Nov. 07, 2012 letter (12V-527), Chrysler announced plans to recall 744,822 Jeep Vehicles (MY02-03 Liberty through 03/28/03 and MY02-04 Grand Cherokee through 5/23/03).The remedy consists of installing an in-line jumper harness with an integrated squib circuit electrical filter.In addition, in Feb 05, 2013 letter (13V-040), Chrysler added the MY03-04 Dodge Viper (through 6/30/04) with a similar remedy, bringing the total number of recalled vehicles to 748,482.During the investigation ODI contacted the ORC module supplier (TRW) to determine the usage of this circuitry in other manufacturers? vehicles.As a result, ODI sent peer Information Request (IR) letters to five other manufactures.Toyota's response identified 72 frontal ABIDs resulting in 31 injuries.The rate and failure mode/trend were consistent with the subject defective issue as reported by Chrysler.In a Jan. 30, 2013 letter (13V-029), Toyota announced plans to recall 897,709 MY2003-2004 Corolla/Matrix and Pontiac Vibe vehicles and will utilize a similar remedy to that of Chrysler consisting of adding an in-line noise filter to its air bag wire harness.Honda's IR response reported 126 unique ABIDs for both frontal, side impact and/or side curtain air bag deployments across 4 models and 800k vehicles.However upon further review, no more than 25 of the reports appeared to be frontal ABIDs.The remaining involved less aggressive non-frontal ABIDs mainly stemming from side sensors that trigger side and/or side curtain air bags upon undercarriage debris strike or heavy door slams.The Honda rates are lower than those from the recalled Liberty and Toyota models, and with the exception of the MY 2002-2003 Odyssey, the other Honda models' failure mode/trend was also less severe.ODI will continueto monitor the affected Honda models.There were no reports of ABIDs from the other three peer manufacturers.It should be noted that since the October 2012 data collection date, ODI has received 4 additional Jeep Liberty and 2 Jeep Grand Cherokee reports for frontal ABIDs with two reports alleging loss of vehicle control and crashes. To date, the ORC modules from the two crash vehicles have not been available for detailed analysis by Chrysler or ODI, so the cause of the ABIDs cannot be confirmed at this time.Accordingly the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAI

Air Bags:frontal:driver Side:inflator Module

The investigation was opened based on reports of frontal air bag inadvertent deployments (ABIDs) on model year (MY) 2002-2003 Jeep Liberty vehicles.Data provided by Chrysler indicate that the air bag squib filter circuitry inside the Occupant Restraint Control (ORC) module can degrade and result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated on the roadway.As of Oct. 04, 2012, ODI is aware of 131 frontal ABIDs on the Jeep Liberty vehicles resulting in 62 injuries consisting of burns, cuts and bruises to the upper body region.There were no reports of loss of vehicle control or vehicle crashes.Some owners noted that the air bag warning light (ABL) and/or chime had activated just seconds prior to the air bag deployment, while others stated that they did not observe any prior ABL illumination.Chrysler's analysis found there were no reports of ABID on Liberty vehicles build after March 28, 2003, a date which coincides with a filter circuit design change in the ORC module.The Jeep Grand Cherokee and Dodge Viper were identified as having the same basic circuit.ODI is aware of 61 frontal ABIDs with 31 injuries on the Grand Cherokee and none on the Dodge Viper.In its Nov. 07, 2012 letter (12V-527), Chrysler announced plans to recall 744,822 Jeep Vehicles (MY02-03 Liberty through 03/28/03 and MY02-04 Grand Cherokee through 5/23/03).The remedy consists of installing an in-line jumper harness with an integrated squib circuit electrical filter.In addition, in Feb 05, 2013 letter (13V-040), Chrysler added the MY03-04 Dodge Viper (through 6/30/04) with a similar remedy, bringing the total number of recalled vehicles to 748,482.During the investigation ODI contacted the ORC module supplier (TRW) to determine the usage of this circuitry in other manufacturers? vehicles.As a result, ODI sent peer Information Request (IR) letters to five other manufactures.Toyota's response identified 72 frontal ABIDs resulting in 31 injuries.The rate and failure mode/trend were consistent with the subject defective issue as reported by Chrysler.In a Jan. 30, 2013 letter (13V-029), Toyota announced plans to recall 897,709 MY2003-2004 Corolla/Matrix and Pontiac Vibe vehicles and will utilize a similar remedy to that of Chrysler consisting of adding an in-line noise filter to its air bag wire harness.Honda's IR response reported 126 unique ABIDs for both frontal, side impact and/or side curtain air bag deployments across 4 models and 800k vehicles.However upon further review, no more than 25 of the reports appeared to be frontal ABIDs.The remaining involved less aggressive non-frontal ABIDs mainly stemming from side sensors that trigger side and/or side curtain air bags upon undercarriage debris strike or heavy door slams.The Honda rates are lower than those from the recalled Liberty and Toyota models, and with the exception of the MY 2002-2003 Odyssey, the other Honda models' failure mode/trend was also less severe.ODI will continueto monitor the affected Honda models.There were no reports of ABIDs from the other three peer manufacturers.It should be noted that since the October 2012 data collection date, ODI has received 4 additional Jeep Liberty and 2 Jeep Grand Cherokee reports for frontal ABIDs with two reports alleging loss of vehicle control and crashes. To date, the ORC modules from the two crash vehicles have not been available for detailed analysis by Chrysler or ODI, so the cause of the ABIDs cannot be confirmed at this time.Accordingly the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAI

Air Bags:frontal:driver Side:inflator Module

The investigation was opened based on reports of frontal air bag inadvertent deployments (ABIDs) on model year (MY) 2002-2003 Jeep Liberty vehicles.Data provided by Chrysler indicate that the air bag squib filter circuitry inside the Occupant Restraint Control (ORC) module can degrade and result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated on the roadway.As of Oct. 04, 2012, ODI is aware of 131 frontal ABIDs on the Jeep Liberty vehicles resulting in 62 injuries consisting of burns, cuts and bruises to the upper body region.There were no reports of loss of vehicle control or vehicle crashes.Some owners noted that the air bag warning light (ABL) and/or chime had activated just seconds prior to the air bag deployment, while others stated that they did not observe any prior ABL illumination.Chrysler's analysis found there were no reports of ABID on Liberty vehicles build after March 28, 2003, a date which coincides with a filter circuit design change in the ORC module.The Jeep Grand Cherokee and Dodge Viper were identified as having the same basic circuit.ODI is aware of 61 frontal ABIDs with 31 injuries on the Grand Cherokee and none on the Dodge Viper.In its Nov. 07, 2012 letter (12V-527), Chrysler announced plans to recall 744,822 Jeep Vehicles (MY02-03 Liberty through 03/28/03 and MY02-04 Grand Cherokee through 5/23/03).The remedy consists of installing an in-line jumper harness with an integrated squib circuit electrical filter.In addition, in Feb 05, 2013 letter (13V-040), Chrysler added the MY03-04 Dodge Viper (through 6/30/04) with a similar remedy, bringing the total number of recalled vehicles to 748,482.During the investigation ODI contacted the ORC module supplier (TRW) to determine the usage of this circuitry in other manufacturers? vehicles.As a result, ODI sent peer Information Request (IR) letters to five other manufactures.Toyota's response identified 72 frontal ABIDs resulting in 31 injuries.The rate and failure mode/trend were consistent with the subject defective issue as reported by Chrysler.In a Jan. 30, 2013 letter (13V-029), Toyota announced plans to recall 897,709 MY2003-2004 Corolla/Matrix and Pontiac Vibe vehicles and will utilize a similar remedy to that of Chrysler consisting of adding an in-line noise filter to its air bag wire harness.Honda's IR response reported 126 unique ABIDs for both frontal, side impact and/or side curtain air bag deployments across 4 models and 800k vehicles.However upon further review, no more than 25 of the reports appeared to be frontal ABIDs.The remaining involved less aggressive non-frontal ABIDs mainly stemming from side sensors that trigger side and/or side curtain air bags upon undercarriage debris strike or heavy door slams.The Honda rates are lower than those from the recalled Liberty and Toyota models, and with the exception of the MY 2002-2003 Odyssey, the other Honda models' failure mode/trend was also less severe.ODI will continueto monitor the affected Honda models.There were no reports of ABIDs from the other three peer manufacturers.It should be noted that since the October 2012 data collection date, ODI has received 4 additional Jeep Liberty and 2 Jeep Grand Cherokee reports for frontal ABIDs with two reports alleging loss of vehicle control and crashes. To date, the ORC modules from the two crash vehicles have not been available for detailed analysis by Chrysler or ODI, so the cause of the ABIDs cannot be confirmed at this time.Accordingly the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAI

Air Bags:frontal:sensor/control MODULE-INACTIVE

The investigation was opened based on reports of frontal air bag inadvertent deployments (ABIDs) on model year (MY) 2002-2003 Jeep Liberty vehicles.Data provided by Chrysler indicate that the air bag squib filter circuitry inside the Occupant Restraint Control (ORC) module can degrade and result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated on the roadway.As of Oct. 04, 2012, ODI is aware of 131 frontal ABIDs on the Jeep Liberty vehicles resulting in 62 injuries consisting of burns, cuts and bruises to the upper body region.There were no reports of loss of vehicle control or vehicle crashes.Some owners noted that the air bag warning light (ABL) and/or chime had activated just seconds prior to the air bag deployment, while others stated that they did not observe any prior ABL illumination.Chrysler's analysis found there were no reports of ABID on Liberty vehicles build after March 28, 2003, a date which coincides with a filter circuit design change in the ORC module.The Jeep Grand Cherokee and Dodge Viper were identified as having the same basic circuit.ODI is aware of 61 frontal ABIDs with 31 injuries on the Grand Cherokee and none on the Dodge Viper.In its Nov. 07, 2012 letter (12V-527), Chrysler announced plans to recall 744,822 Jeep Vehicles (MY02-03 Liberty through 03/28/03 and MY02-04 Grand Cherokee through 5/23/03).The remedy consists of installing an in-line jumper harness with an integrated squib circuit electrical filter.In addition, in Feb 05, 2013 letter (13V-040), Chrysler added the MY03-04 Dodge Viper (through 6/30/04) with a similar remedy, bringing the total number of recalled vehicles to 748,482.During the investigation ODI contacted the ORC module supplier (TRW) to determine the usage of this circuitry in other manufacturers? vehicles.As a result, ODI sent peer Information Request (IR) letters to five other manufactures.Toyota's response identified 72 frontal ABIDs resulting in 31 injuries.The rate and failure mode/trend were consistent with the subject defective issue as reported by Chrysler.In a Jan. 30, 2013 letter (13V-029), Toyota announced plans to recall 897,709 MY2003-2004 Corolla/Matrix and Pontiac Vibe vehicles and will utilize a similar remedy to that of Chrysler consisting of adding an in-line noise filter to its air bag wire harness.Honda's IR response reported 126 unique ABIDs for both frontal, side impact and/or side curtain air bag deployments across 4 models and 800k vehicles.However upon further review, no more than 25 of the reports appeared to be frontal ABIDs.The remaining involved less aggressive non-frontal ABIDs mainly stemming from side sensors that trigger side and/or side curtain air bags upon undercarriage debris strike or heavy door slams.The Honda rates are lower than those from the recalled Liberty and Toyota models, and with the exception of the MY 2002-2003 Odyssey, the other Honda models' failure mode/trend was also less severe.ODI will continueto monitor the affected Honda models.There were no reports of ABIDs from the other three peer manufacturers.It should be noted that since the October 2012 data collection date, ODI has received 4 additional Jeep Liberty and 2 Jeep Grand Cherokee reports for frontal ABIDs with two reports alleging loss of vehicle control and crashes. To date, the ORC modules from the two crash vehicles have not been available for detailed analysis by Chrysler or ODI, so the cause of the ABIDs cannot be confirmed at this time.Accordingly the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAI

Air Bags:frontal:sensor/control MODULE-INACTIVE

The investigation was opened based on reports of frontal air bag inadvertent deployments (ABIDs) on model year (MY) 2002-2003 Jeep Liberty vehicles.Data provided by Chrysler indicate that the air bag squib filter circuitry inside the Occupant Restraint Control (ORC) module can degrade and result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated on the roadway.As of Oct. 04, 2012, ODI is aware of 131 frontal ABIDs on the Jeep Liberty vehicles resulting in 62 injuries consisting of burns, cuts and bruises to the upper body region.There were no reports of loss of vehicle control or vehicle crashes.Some owners noted that the air bag warning light (ABL) and/or chime had activated just seconds prior to the air bag deployment, while others stated that they did not observe any prior ABL illumination.Chrysler's analysis found there were no reports of ABID on Liberty vehicles build after March 28, 2003, a date which coincides with a filter circuit design change in the ORC module.The Jeep Grand Cherokee and Dodge Viper were identified as having the same basic circuit.ODI is aware of 61 frontal ABIDs with 31 injuries on the Grand Cherokee and none on the Dodge Viper.In its Nov. 07, 2012 letter (12V-527), Chrysler announced plans to recall 744,822 Jeep Vehicles (MY02-03 Liberty through 03/28/03 and MY02-04 Grand Cherokee through 5/23/03).The remedy consists of installing an in-line jumper harness with an integrated squib circuit electrical filter.In addition, in Feb 05, 2013 letter (13V-040), Chrysler added the MY03-04 Dodge Viper (through 6/30/04) with a similar remedy, bringing the total number of recalled vehicles to 748,482.During the investigation ODI contacted the ORC module supplier (TRW) to determine the usage of this circuitry in other manufacturers? vehicles.As a result, ODI sent peer Information Request (IR) letters to five other manufactures.Toyota's response identified 72 frontal ABIDs resulting in 31 injuries.The rate and failure mode/trend were consistent with the subject defective issue as reported by Chrysler.In a Jan. 30, 2013 letter (13V-029), Toyota announced plans to recall 897,709 MY2003-2004 Corolla/Matrix and Pontiac Vibe vehicles and will utilize a similar remedy to that of Chrysler consisting of adding an in-line noise filter to its air bag wire harness.Honda's IR response reported 126 unique ABIDs for both frontal, side impact and/or side curtain air bag deployments across 4 models and 800k vehicles.However upon further review, no more than 25 of the reports appeared to be frontal ABIDs.The remaining involved less aggressive non-frontal ABIDs mainly stemming from side sensors that trigger side and/or side curtain air bags upon undercarriage debris strike or heavy door slams.The Honda rates are lower than those from the recalled Liberty and Toyota models, and with the exception of the MY 2002-2003 Odyssey, the other Honda models' failure mode/trend was also less severe.ODI will continueto monitor the affected Honda models.There were no reports of ABIDs from the other three peer manufacturers.It should be noted that since the October 2012 data collection date, ODI has received 4 additional Jeep Liberty and 2 Jeep Grand Cherokee reports for frontal ABIDs with two reports alleging loss of vehicle control and crashes. To date, the ORC modules from the two crash vehicles have not been available for detailed analysis by Chrysler or ODI, so the cause of the ABIDs cannot be confirmed at this time.Accordingly the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAI

Air Bags:frontal:sensor/control MODULE-INACTIVE

The investigation was opened based on reports of frontal air bag inadvertent deployments (ABIDs) on model year (MY) 2002-2003 Jeep Liberty vehicles.Data provided by Chrysler indicate that the air bag squib filter circuitry inside the Occupant Restraint Control (ORC) module can degrade and result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated on the roadway.As of Oct. 04, 2012, ODI is aware of 131 frontal ABIDs on the Jeep Liberty vehicles resulting in 62 injuries consisting of burns, cuts and bruises to the upper body region.There were no reports of loss of vehicle control or vehicle crashes.Some owners noted that the air bag warning light (ABL) and/or chime had activated just seconds prior to the air bag deployment, while others stated that they did not observe any prior ABL illumination.Chrysler's analysis found there were no reports of ABID on Liberty vehicles build after March 28, 2003, a date which coincides with a filter circuit design change in the ORC module.The Jeep Grand Cherokee and Dodge Viper were identified as having the same basic circuit.ODI is aware of 61 frontal ABIDs with 31 injuries on the Grand Cherokee and none on the Dodge Viper.In its Nov. 07, 2012 letter (12V-527), Chrysler announced plans to recall 744,822 Jeep Vehicles (MY02-03 Liberty through 03/28/03 and MY02-04 Grand Cherokee through 5/23/03).The remedy consists of installing an in-line jumper harness with an integrated squib circuit electrical filter.In addition, in Feb 05, 2013 letter (13V-040), Chrysler added the MY03-04 Dodge Viper (through 6/30/04) with a similar remedy, bringing the total number of recalled vehicles to 748,482.During the investigation ODI contacted the ORC module supplier (TRW) to determine the usage of this circuitry in other manufacturers? vehicles.As a result, ODI sent peer Information Request (IR) letters to five other manufactures.Toyota's response identified 72 frontal ABIDs resulting in 31 injuries.The rate and failure mode/trend were consistent with the subject defective issue as reported by Chrysler.In a Jan. 30, 2013 letter (13V-029), Toyota announced plans to recall 897,709 MY2003-2004 Corolla/Matrix and Pontiac Vibe vehicles and will utilize a similar remedy to that of Chrysler consisting of adding an in-line noise filter to its air bag wire harness.Honda's IR response reported 126 unique ABIDs for both frontal, side impact and/or side curtain air bag deployments across 4 models and 800k vehicles.However upon further review, no more than 25 of the reports appeared to be frontal ABIDs.The remaining involved less aggressive non-frontal ABIDs mainly stemming from side sensors that trigger side and/or side curtain air bags upon undercarriage debris strike or heavy door slams.The Honda rates are lower than those from the recalled Liberty and Toyota models, and with the exception of the MY 2002-2003 Odyssey, the other Honda models' failure mode/trend was also less severe.ODI will continueto monitor the affected Honda models.There were no reports of ABIDs from the other three peer manufacturers.It should be noted that since the October 2012 data collection date, ODI has received 4 additional Jeep Liberty and 2 Jeep Grand Cherokee reports for frontal ABIDs with two reports alleging loss of vehicle control and crashes. To date, the ORC modules from the two crash vehicles have not been available for detailed analysis by Chrysler or ODI, so the cause of the ABIDs cannot be confirmed at this time.Accordingly the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAI

PE11035 · Inadvertent Air Bag Deployment

Opened Sep 23, 2011 · Closed Jan 30, 2012

Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:sensor/control MODULE-INACTIVE

Based on analysis of Chrysler's response, and including ODI's consumer complaints, ODI has identified 87 reports of air bag inadvertent deployment incidents resulting in 50 alleged injuries.The injuries consists of burn/cuts and bruises to the upper body region.Forty-two (42) of the 87 incidents involved the driver frontal air bag, and the remaining 45 incidents involved both the driver and passenger frontal air bags inadvertently deploying without a crash.These incidents occurred both at vehicle startup or while the vehicle is being operated on the roadway.Some owners noted that the air bag warning light had illuminated, or had intermittently illuminated, and that this occurred just prior to the air bag deployment, while others stated they did not observe any illumination of the air bag light. Inspection of the Occupant Restraint Control (ORC) module conducted by Chrysler indicates that an internal electronic circuit (an ASIC chip) which controls air bag deployment fails due to an electrical over stress (EOS) condition possibly caused by a transient voltage spike.Chrysler is in the process of identifying potential root causes of the component failure and/or a source for the electrical over stress.In addition, Chrysler noted that there have been no reports of inadvertent air bag deployment in vehicles manufactured after a March 19, 2003 production date.However, Chrysler had not identified a component or other change that would explain why the inadvertent deployments ceased. Accordingly, this investigation has been upgraded to an Engineering Analysis (EA12-001) to further study the alleged defect and its consequences.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10435710 10429579 10429306 10428411 10407276 10399551 10335637 10283484 10249231 10166706 10055405

Additional source detail variants (4)

Air Bags

Based on analysis of Chrysler's response, and including ODI's consumer complaints, ODI has identified 87 reports of air bag inadvertent deployment incidents resulting in 50 alleged injuries.The injuries consists of burn/cuts and bruises to the upper body region.Forty-two (42) of the 87 incidents involved the driver frontal air bag, and the remaining 45 incidents involved both the driver and passenger frontal air bags inadvertently deploying without a crash.These incidents occurred both at vehicle startup or while the vehicle is being operated on the roadway.Some owners noted that the air bag warning light had illuminated, or had intermittently illuminated, and that this occurred just prior to the air bag deployment, while others stated they did not observe any illumination of the air bag light. Inspection of the Occupant Restraint Control (ORC) module conducted by Chrysler indicates that an internal electronic circuit (an ASIC chip) which controls air bag deployment fails due to an electrical over stress (EOS) condition possibly caused by a transient voltage spike.Chrysler is in the process of identifying potential root causes of the component failure and/or a source for the electrical over stress.In addition, Chrysler noted that there have been no reports of inadvertent air bag deployment in vehicles manufactured after a March 19, 2003 production date.However, Chrysler had not identified a component or other change that would explain why the inadvertent deployments ceased. Accordingly, this investigation has been upgraded to an Engineering Analysis (EA12-001) to further study the alleged defect and its consequences.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10435710 10429579 10429306 10428411 10407276 10399551 10335637 10283484 10249231 10166706 10055405

Air Bags:frontal

Based on analysis of Chrysler's response, and including ODI's consumer complaints, ODI has identified 87 reports of air bag inadvertent deployment incidents resulting in 50 alleged injuries.The injuries consists of burn/cuts and bruises to the upper body region.Forty-two (42) of the 87 incidents involved the driver frontal air bag, and the remaining 45 incidents involved both the driver and passenger frontal air bags inadvertently deploying without a crash.These incidents occurred both at vehicle startup or while the vehicle is being operated on the roadway.Some owners noted that the air bag warning light had illuminated, or had intermittently illuminated, and that this occurred just prior to the air bag deployment, while others stated they did not observe any illumination of the air bag light. Inspection of the Occupant Restraint Control (ORC) module conducted by Chrysler indicates that an internal electronic circuit (an ASIC chip) which controls air bag deployment fails due to an electrical over stress (EOS) condition possibly caused by a transient voltage spike.Chrysler is in the process of identifying potential root causes of the component failure and/or a source for the electrical over stress.In addition, Chrysler noted that there have been no reports of inadvertent air bag deployment in vehicles manufactured after a March 19, 2003 production date.However, Chrysler had not identified a component or other change that would explain why the inadvertent deployments ceased. Accordingly, this investigation has been upgraded to an Engineering Analysis (EA12-001) to further study the alleged defect and its consequences.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10435710 10429579 10429306 10428411 10407276 10399551 10335637 10283484 10249231 10166706 10055405

Air Bags:frontal:driver Side:inflator Module

Based on analysis of Chrysler's response, and including ODI's consumer complaints, ODI has identified 87 reports of air bag inadvertent deployment incidents resulting in 50 alleged injuries.The injuries consists of burn/cuts and bruises to the upper body region.Forty-two (42) of the 87 incidents involved the driver frontal air bag, and the remaining 45 incidents involved both the driver and passenger frontal air bags inadvertently deploying without a crash.These incidents occurred both at vehicle startup or while the vehicle is being operated on the roadway.Some owners noted that the air bag warning light had illuminated, or had intermittently illuminated, and that this occurred just prior to the air bag deployment, while others stated they did not observe any illumination of the air bag light. Inspection of the Occupant Restraint Control (ORC) module conducted by Chrysler indicates that an internal electronic circuit (an ASIC chip) which controls air bag deployment fails due to an electrical over stress (EOS) condition possibly caused by a transient voltage spike.Chrysler is in the process of identifying potential root causes of the component failure and/or a source for the electrical over stress.In addition, Chrysler noted that there have been no reports of inadvertent air bag deployment in vehicles manufactured after a March 19, 2003 production date.However, Chrysler had not identified a component or other change that would explain why the inadvertent deployments ceased. Accordingly, this investigation has been upgraded to an Engineering Analysis (EA12-001) to further study the alleged defect and its consequences.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10435710 10429579 10429306 10428411 10407276 10399551 10335637 10283484 10249231 10166706 10055405

Air Bags:frontal:sensor/control MODULE-INACTIVE

Based on analysis of Chrysler's response, and including ODI's consumer complaints, ODI has identified 87 reports of air bag inadvertent deployment incidents resulting in 50 alleged injuries.The injuries consists of burn/cuts and bruises to the upper body region.Forty-two (42) of the 87 incidents involved the driver frontal air bag, and the remaining 45 incidents involved both the driver and passenger frontal air bags inadvertently deploying without a crash.These incidents occurred both at vehicle startup or while the vehicle is being operated on the roadway.Some owners noted that the air bag warning light had illuminated, or had intermittently illuminated, and that this occurred just prior to the air bag deployment, while others stated they did not observe any illumination of the air bag light. Inspection of the Occupant Restraint Control (ORC) module conducted by Chrysler indicates that an internal electronic circuit (an ASIC chip) which controls air bag deployment fails due to an electrical over stress (EOS) condition possibly caused by a transient voltage spike.Chrysler is in the process of identifying potential root causes of the component failure and/or a source for the electrical over stress.In addition, Chrysler noted that there have been no reports of inadvertent air bag deployment in vehicles manufactured after a March 19, 2003 production date.However, Chrysler had not identified a component or other change that would explain why the inadvertent deployments ceased. Accordingly, this investigation has been upgraded to an Engineering Analysis (EA12-001) to further study the alleged defect and its consequences.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10435710 10429579 10429306 10428411 10407276 10399551 10335637 10283484 10249231 10166706 10055405

PE11013 · Rear Suspension Control Arm Failure

Opened Apr 18, 2011 · Closed Sep 15, 2011

Status: closed (inferred from source dates) · Suspension:rear

During Preliminary Evaluation (PE11-013), the Office of Defects Investigation (ODI) conducted an analysis of consumer field data from its Vehicle Owner Questionnaire (VOQ) database and from complaint data submitted to ODI by Chrysler. ODI's analysis of VOQ data identified 13 complaints alleging failure of either the right or left rear lower control arm due to excessive corrosion.All of these complaints were associated with vehicles originally sold or registered in a salt belt state (for the purposes of this investigation, 'salt belt' includes Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).All of the complaints were associated with vehicles manufactured in model years (MY) 2004 or 2005. Three of these complaints also allege a loss of vehicle control due to the rear lower control arm failure. No complaints related to the alleged defect were identified on vehicles manufactured during MYs 2002 or 2003. Similarly an analysis of Chrysler complaint data identified 11 complaints (2 of which are duplicative of VOQs) alleging failure of a rear lower control arm due to excessive corrosion.All 11 of these complaints were from consumers operating vehicles in a salt belt state and vehicles manufactured in either MY 2004 or 2005. Three of these complaints (not duplicative of VOQs) also allege a loss of vehicle control due to the rear lower control arm failure.The original scope of PE11-013 included MY 2002 through 2005 Jeep Liberty vehicles as they were in the same generation.In response to an Information Request (IR) letter sent by ODI, Chrysler provided information and sample components identifying a substantial design change of the rear lower control arms after MY 2003 and beginning with MY 2004.Analysis of complaint data from both data sources (ODI and Chrysler) did not identify any applicable complaints (lower control arm failures due to excessive corrosion) from vehicles manufactured during MY 2002 or 2003.Similarly no complaints from either data source were found in states outside of those identified as salt belt states.Chrysler stated in its IR letter response that its investigation and analysis is ongoing to determine the scope, possible root causes of the unusual lower control arm corrosion, and define possible consequences to motor vehicle safety. Based on ODI's data analysis from both sources (ODI and Chrysler data), this investigation has been upgraded to an Engineering Analysis (EA11-013) focused on vehicles originally sold or registered in a salt belt state and produced during MY 2004 and 2005, to further assess the scope and potential safety consequences of the alleged defect.

EA08008 · Upper Ball Joint Separation

Opened Apr 15, 2008 · Closed Apr 16, 2009

Status: closed (inferred from source dates) · Suspension; Suspension:front:control Arm:upper Ball Joint

ON APRIL 7, 2009, CHRYSLER LLC SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL APPROXIMATELY 42,469 MODEL YEAR 2002 THROUGH 2003 JEEP LIBERTY VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN UPPER BALL JOINT SEPARATION WHILE DRIVING (09V-119).THE AFFECTED VEHICLES WERE BUILT FROM MAY 2002 THROUGH SEPTEMBER 2002 AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, KENTUCKY, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA AND WISCONSIN.ACCORDING TO CHRYSLER, THE FRONT SUSPENSION UPPER CONTROL ARM BALL JOINT MAY EXPERIENCE A LOSS OF LUBRICATION WHICH CAN LEAD TO CORROSION, ACCELERATED WEAR, AND POSSIBLE SEPARATION WHILE DRIVING. CHRYSLER'S RECALL PROCEDURE INSTRUCTS DEALERS TO REPLACE THE FRONT UPPER CONTROL ARM ASSEMBLIES ON ALL AFFECTED VEHICLES. ALTHOUGH THE SPECIFIC CAUSE FOR THE DEFECT IN THE RECALLED PRODUCTION RANGE HAS NOT BEEN DETERMINED, ODI'S ANALYSIS OF UPPER BALL JOINT SEPARATIONS BY VEHICLE BUILD DATE SHOWS A CLEARLY DEFINED AND SIGNIFICANT SPIKE IN THE RATE OF SEPARATION DURING THE FIVE MONTH PRODUCTION RANGE COVERED BY 09V-119, WHICH ACCOUNTS FOR ONLY 11 PERCENT OF SUBJECT VEHICLE PRODUCTION BUT APPROXIMATELY 70 PERCENT OF SEPARATION INCIDENTS.SEVENTY-FOUR (74) OF THE UPPER BALL JOINT SEPARATION INCIDENTS IDENTIFIED BY ODI OCCURRED IN VEHICLES PRODUCED IN THE RECALL MONTHS, RESULTING IN A SEPARATION RATE OF 174 PER 100,000 VEHICLES.THE SEPARATION RATE IN THE REMAINING SUBJECT VEHICLE POPULATION IS SIGNIFICANTLY LOWER, AT 9 INCIDENTS PER 100,000 VEHICLES.AT THIS TIME, THE DATA DO NOT SHOW A DEFECT TREND IN THE SUBJECT VEHICLES BUILT OUTSIDE THE RECALL RANGE AFTER APPROXIMATELY 6-8 YEARS IN SERVICE. THIS ENGINEERING ANALYSIS IS CLOSED.

Additional source detail variants (2)

Suspension

ON APRIL 7, 2009, CHRYSLER LLC SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL APPROXIMATELY 42,469 MODEL YEAR 2002 THROUGH 2003 JEEP LIBERTY VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN UPPER BALL JOINT SEPARATION WHILE DRIVING (09V-119).THE AFFECTED VEHICLES WERE BUILT FROM MAY 2002 THROUGH SEPTEMBER 2002 AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, KENTUCKY, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA AND WISCONSIN.ACCORDING TO CHRYSLER, THE FRONT SUSPENSION UPPER CONTROL ARM BALL JOINT MAY EXPERIENCE A LOSS OF LUBRICATION WHICH CAN LEAD TO CORROSION, ACCELERATED WEAR, AND POSSIBLE SEPARATION WHILE DRIVING. CHRYSLER'S RECALL PROCEDURE INSTRUCTS DEALERS TO REPLACE THE FRONT UPPER CONTROL ARM ASSEMBLIES ON ALL AFFECTED VEHICLES. ALTHOUGH THE SPECIFIC CAUSE FOR THE DEFECT IN THE RECALLED PRODUCTION RANGE HAS NOT BEEN DETERMINED, ODI'S ANALYSIS OF UPPER BALL JOINT SEPARATIONS BY VEHICLE BUILD DATE SHOWS A CLEARLY DEFINED AND SIGNIFICANT SPIKE IN THE RATE OF SEPARATION DURING THE FIVE MONTH PRODUCTION RANGE COVERED BY 09V-119, WHICH ACCOUNTS FOR ONLY 11 PERCENT OF SUBJECT VEHICLE PRODUCTION BUT APPROXIMATELY 70 PERCENT OF SEPARATION INCIDENTS.SEVENTY-FOUR (74) OF THE UPPER BALL JOINT SEPARATION INCIDENTS IDENTIFIED BY ODI OCCURRED IN VEHICLES PRODUCED IN THE RECALL MONTHS, RESULTING IN A SEPARATION RATE OF 174 PER 100,000 VEHICLES.THE SEPARATION RATE IN THE REMAINING SUBJECT VEHICLE POPULATION IS SIGNIFICANTLY LOWER, AT 9 INCIDENTS PER 100,000 VEHICLES.AT THIS TIME, THE DATA DO NOT SHOW A DEFECT TREND IN THE SUBJECT VEHICLES BUILT OUTSIDE THE RECALL RANGE AFTER APPROXIMATELY 6-8 YEARS IN SERVICE. THIS ENGINEERING ANALYSIS IS CLOSED.

Suspension:front:control Arm:upper Ball Joint

ON APRIL 7, 2009, CHRYSLER LLC SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL APPROXIMATELY 42,469 MODEL YEAR 2002 THROUGH 2003 JEEP LIBERTY VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN UPPER BALL JOINT SEPARATION WHILE DRIVING (09V-119).THE AFFECTED VEHICLES WERE BUILT FROM MAY 2002 THROUGH SEPTEMBER 2002 AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, KENTUCKY, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA AND WISCONSIN.ACCORDING TO CHRYSLER, THE FRONT SUSPENSION UPPER CONTROL ARM BALL JOINT MAY EXPERIENCE A LOSS OF LUBRICATION WHICH CAN LEAD TO CORROSION, ACCELERATED WEAR, AND POSSIBLE SEPARATION WHILE DRIVING. CHRYSLER'S RECALL PROCEDURE INSTRUCTS DEALERS TO REPLACE THE FRONT UPPER CONTROL ARM ASSEMBLIES ON ALL AFFECTED VEHICLES. ALTHOUGH THE SPECIFIC CAUSE FOR THE DEFECT IN THE RECALLED PRODUCTION RANGE HAS NOT BEEN DETERMINED, ODI'S ANALYSIS OF UPPER BALL JOINT SEPARATIONS BY VEHICLE BUILD DATE SHOWS A CLEARLY DEFINED AND SIGNIFICANT SPIKE IN THE RATE OF SEPARATION DURING THE FIVE MONTH PRODUCTION RANGE COVERED BY 09V-119, WHICH ACCOUNTS FOR ONLY 11 PERCENT OF SUBJECT VEHICLE PRODUCTION BUT APPROXIMATELY 70 PERCENT OF SEPARATION INCIDENTS.SEVENTY-FOUR (74) OF THE UPPER BALL JOINT SEPARATION INCIDENTS IDENTIFIED BY ODI OCCURRED IN VEHICLES PRODUCED IN THE RECALL MONTHS, RESULTING IN A SEPARATION RATE OF 174 PER 100,000 VEHICLES.THE SEPARATION RATE IN THE REMAINING SUBJECT VEHICLE POPULATION IS SIGNIFICANTLY LOWER, AT 9 INCIDENTS PER 100,000 VEHICLES.AT THIS TIME, THE DATA DO NOT SHOW A DEFECT TREND IN THE SUBJECT VEHICLES BUILT OUTSIDE THE RECALL RANGE AFTER APPROXIMATELY 6-8 YEARS IN SERVICE. THIS ENGINEERING ANALYSIS IS CLOSED.

PE07062 · Upper Ball Joint Separation

Opened Dec 17, 2007 · Closed Apr 18, 2008

Status: closed (inferred from source dates) · Suspension; Suspension:front:control Arm:upper Ball Joint

ODI HAS RECEIVED 22 COMPLAINTS OF UPPER BALL JOINT SEPARATION ON MODEL YEAR 2002 AND 2003 JEEP LIBERTY 4X4 VEHICLES.THE SEPARATION OF AN UPPER BALL JOINT ON EITHER OF THE FRONT WHEELS CAN RESULT IN THE AFFECTED FRONT WHEEL COLLAPSING, POSSIBLY RESULTING IN VEHICLE DISABLEMENT AND CAUSING A LOSS OF VEHICLE CONTROL.THERE IS ONE COMPLAINT OF A FAILURE AT 75 MPH, 1 FAILURE AT 60 MPH, 3 FAILURES AT 40 MPH, 2 FAILURES AT 25 MPH, 7 FAILURES OCCURRING WHILE THE DRIVER WAS PULLING INTO THE FLOW OF TRAFFIC AND 2 FAILURES THAT OCCURRED WHEN THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN ACROSS THE FLOW OF ONCOMING TRAFFIC.ONE COMPLAINANT ALLEGED ALMOST BEING HIT BY AN ONCOMING TRUCK AS A RESULT OF THE VEHICLE SUDDENLY BEING DISABLED IN THE FLOW OF CROSSING TRAFFIC.ANOTHER REPORTED THE COLLAPSE OF THE FRONT RIGHT WHEEL WHEN MAKING A LEFT TURN CAUSED THE VEHICLE TO SWERVE TO THE RIGHT, AS A RESULT OF WHICH THE VEHICLE ENDED UP IN A DITCH JUST MISSING A COLLISION WITH A TELEPHONE POLE.CHRYSLER LLC., IS CONTINUING TO INVESTIGATE THE CAUSE OF UPPER BALL JOINT SEPARATIONS IN THE SUBJECT VEHICLES.ODI HAS UPGRADED THE INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-008) TO CONTINUE TO ASSES THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.

Additional source detail variants (2)

Suspension

ODI HAS RECEIVED 22 COMPLAINTS OF UPPER BALL JOINT SEPARATION ON MODEL YEAR 2002 AND 2003 JEEP LIBERTY 4X4 VEHICLES.THE SEPARATION OF AN UPPER BALL JOINT ON EITHER OF THE FRONT WHEELS CAN RESULT IN THE AFFECTED FRONT WHEEL COLLAPSING, POSSIBLY RESULTING IN VEHICLE DISABLEMENT AND CAUSING A LOSS OF VEHICLE CONTROL.THERE IS ONE COMPLAINT OF A FAILURE AT 75 MPH, 1 FAILURE AT 60 MPH, 3 FAILURES AT 40 MPH, 2 FAILURES AT 25 MPH, 7 FAILURES OCCURRING WHILE THE DRIVER WAS PULLING INTO THE FLOW OF TRAFFIC AND 2 FAILURES THAT OCCURRED WHEN THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN ACROSS THE FLOW OF ONCOMING TRAFFIC.ONE COMPLAINANT ALLEGED ALMOST BEING HIT BY AN ONCOMING TRUCK AS A RESULT OF THE VEHICLE SUDDENLY BEING DISABLED IN THE FLOW OF CROSSING TRAFFIC.ANOTHER REPORTED THE COLLAPSE OF THE FRONT RIGHT WHEEL WHEN MAKING A LEFT TURN CAUSED THE VEHICLE TO SWERVE TO THE RIGHT, AS A RESULT OF WHICH THE VEHICLE ENDED UP IN A DITCH JUST MISSING A COLLISION WITH A TELEPHONE POLE.CHRYSLER LLC., IS CONTINUING TO INVESTIGATE THE CAUSE OF UPPER BALL JOINT SEPARATIONS IN THE SUBJECT VEHICLES.ODI HAS UPGRADED THE INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-008) TO CONTINUE TO ASSES THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.

Suspension:front:control Arm:upper Ball Joint

ODI HAS RECEIVED 22 COMPLAINTS OF UPPER BALL JOINT SEPARATION ON MODEL YEAR 2002 AND 2003 JEEP LIBERTY 4X4 VEHICLES.THE SEPARATION OF AN UPPER BALL JOINT ON EITHER OF THE FRONT WHEELS CAN RESULT IN THE AFFECTED FRONT WHEEL COLLAPSING, POSSIBLY RESULTING IN VEHICLE DISABLEMENT AND CAUSING A LOSS OF VEHICLE CONTROL.THERE IS ONE COMPLAINT OF A FAILURE AT 75 MPH, 1 FAILURE AT 60 MPH, 3 FAILURES AT 40 MPH, 2 FAILURES AT 25 MPH, 7 FAILURES OCCURRING WHILE THE DRIVER WAS PULLING INTO THE FLOW OF TRAFFIC AND 2 FAILURES THAT OCCURRED WHEN THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN ACROSS THE FLOW OF ONCOMING TRAFFIC.ONE COMPLAINANT ALLEGED ALMOST BEING HIT BY AN ONCOMING TRUCK AS A RESULT OF THE VEHICLE SUDDENLY BEING DISABLED IN THE FLOW OF CROSSING TRAFFIC.ANOTHER REPORTED THE COLLAPSE OF THE FRONT RIGHT WHEEL WHEN MAKING A LEFT TURN CAUSED THE VEHICLE TO SWERVE TO THE RIGHT, AS A RESULT OF WHICH THE VEHICLE ENDED UP IN A DITCH JUST MISSING A COLLISION WITH A TELEPHONE POLE.CHRYSLER LLC., IS CONTINUING TO INVESTIGATE THE CAUSE OF UPPER BALL JOINT SEPARATIONS IN THE SUBJECT VEHICLES.ODI HAS UPGRADED THE INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-008) TO CONTINUE TO ASSES THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.

EA06008 · Front Suspension Ball Joint Separation

Opened May 31, 2006 · Closed Aug 24, 2006

Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint

ON JANUARY 6, 2006, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED FRONT SUSPENSION LOWER BALL JOINT SEPARATIONIN CERTAIN MODEL YEAR (MY) 2004 JEEP LIBERTY VEHICLES.ODI SENT A LETTER TO THE MANUFACTURER ON FEBRUARY 7, 2006 REQUESTING INFORMATION ABOUT THESE AND OTHER JEEP LIBERTY VEHICLES.CONSEQUENTLY, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON MAY 31, 2006 AND THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WAS EXPANDED TO INCLUDE ALL MY 2002-2006 JEEP LIBERTY VEHICLES.ODI IS AWARE OF 566 NON-DUPLICATIVE COMPLAINTS ALLEGING INVOLUNTARY FRONT SUSPENSION LOWER BALL JOINT SEPARATION IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE OF ONE NON-INJURY CRASH AND THREE ALLEGED INJURY INCIDENTS (TWO CRASH INCIDENTS AND ONE NON-CRASH INCIDENT) RELATED TO THE ALLEGED DEFECT RESULTING IN MINOR INJURIES.THE COMPLAINT COUNTS REPORTED ABOVE ONLY INCLUDE THOSE MY 2002-03 LIBERTY VEHICLES WHERE THE ALLEGED BALL JOINT SEPARATION OCCURRED AFTER PRIOR RECALL REPAIRS WERE PERFORMED (SEE BELOW) OR IF THE VEHICLE WAS NOT INCLUDED IN THE PRIOR RECALL.THE MANUFACTURER CONDUCTED A PRIOR SAFETY RECALL (03V-460) TO ADDRESS THE SUBJECT ISSUE IN CERTAIN MY 2002-03 JEEP LIBERTY VEHICLES.ACCORDING TO DAIMLERCHRYSLER?S NOVEMBER 4, 2003, DEFECT INFORMATION REPORT (SUBMITTED IN ACCORDANCE WITH 49 CFR PART 573), ?THE CONSTANT TENSION LOWER CONTROL ARM BALL JOINTS MAY EXPERIENCE A LOSS OF LUBRICATION WHICH CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE.A CONSTANT TENSION BALL JOINT WHICH HAS SEPARATED FROM THE KNUCKLE MAY RESULT IN LOSS OF VEHICLE DIRECTIONAL CONTROL WITH MINIMAL ADVANCED WARNING.?HOWEVER, EVIDENCE INDICATES THAT SOME VEHICLES SERVICED UNDER RECALL 03V-460 CONTINUED TO EXPERIENCE INVOLUNTARY BALL JOINT SEPARATIONS.THE MANUFACTURER HAS MADE NUMEROUS CHANGES IN THE DESIGN, MATERIAL COMPOSITION, MANUFACTURE, QUALITY CONTROL, SUPPLY, AND INSTALLATION OF THE SUBJECT BALL JOINTS SINCE THE PRIOR SAFETY RECALL WAS INITIATED IN AN EFFORT TO IMPROVE PERFORMANCE WITH RESPECT TO SEALING, LUBRICATION, AND JOINT RETENTION CAPABILITY.BY LETTER DATED AUGUST 1, 2006, DAIMLERCHRYSLER CORPORATION HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL TO ADDRESS POTENTIALLY DEFECTIVE FRONT SUSPENSION LOWER CONTROL ARM BALL JOINTS IN APPROXIMATELY 826,687 MODEL YEAR 2002-2006 JEEP LIBERTY VEHICLES MANUFACTURED BETWEEN JANUARY 2, 2001 AND MARCH 15, 2006, INCLUDINGALL VEHICLES SUBJECT TO THE PRIOR RECALL.THE NHTSA CAMPAIGN NUMBER ASSIGNED TO THIS RECALL IS 06V-288 (DAIMLERCHRYSLER RECALL CAMPAIGN F23).DAIMLERCHRYSLER WILL REPLACE BOTH LEFT AND RIGHT FRONT SUSPENSION LOWER CONTROL ARM BALL JOINTS WITH IMPROVED COMPONENTS FREE OF CHARGE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.

EA05022 · Front Seat Belt Buckle Malfunction

Opened Dec 27, 2005 · Closed Dec 21, 2006

Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly

THE OFFICE OF DEFECTS INVESTIGATION (ODI) HAS CLOSED THE INVESTIGATION OF FRONT SEAT BELT BUCKLES IN MODEL YEAR 2002 JEEP LIBERTY VEHICLES.ON AUGUST 26, 2006, ODI OPENED PRELIMINARY EVALUATION (PE)05-046 TO INVESTIGATE COMPLAINT REPORTS THAT ALLEGED PROBLEMS WITH LATCHING AND UNLATCHING THE FRONT SEAT BELT BUCKLE.SEVERAL OF THE COMPLAINTS REPORTED THAT SOMETHING WAS BROKEN INSIDE OF THE BUCKLE.THE INVESTIGATION FOUND THAT SOME BUCKLES MAY EXPERIENCE FAILURE AND SEPARATION OF ONE, OR BOTH, OF THE INTERNAL LATCH GUIDE LEAF SPRINGS.LACK OF LEAF SPRING FUNCTION DOES NOT APPEAR TO INHIBIT BUCKLE OPERATION BECAUSE THERE IS ANOTHER SPRING THAT RETURNS THE RELEASE BUTTON.HOWEVER, A SEPARATED LEAF SPRING MAY IMPEDE THE MOTION OF THE BUCKLE RELEASE BUTTON IF IT BECOMES ENGAGED WITH MOVING PARTS.ANALYSIS OF THE AVAILABLE DATA SHOW THAT VEHICLES EXPERIENCING PROBLEMS WITH THE BUCKLES WERE EARLY PRODUCTION VEHICLES PRODUCED PRIMARILY IN CALENDAR YEAR (CY) 2001.IN EARLY CY 2002, A CHANGE WAS MADE TO THE TOOLING USED TO PRODUCE THE BUCKLES. THIS CHANGE AFFECTED THE LEAF SPRINGS AND APPEARS TO HAVE HAD A POSITIVE EFFECT IN CORRECTING THE BUCKLE ISSUES THAT WERE EXPERIENCED IN THE EARLY PRODUCTION VEHICLES.THE COMPLAINT REPORT TREND IS DOWN AND THE FREQUENCY OF CONSUMER REPORTS IN CY 2006 HAS DECLINED TO THAT OF CY 2004.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.

PE05046 · Front Seat Belt Buckle Malfunction

Opened Aug 26, 2005 · Closed Dec 27, 2005

Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly

THIS INVESTIGATION OF FRONT SEAT BELT BUCKLES IN THE SUBJECT VEHICLES WAS OPENED ON AUGUST 26, 2005.THE BASIS FOR OPENING WAS SEVEN ODI REPORTS ALLEGING THE DRIVER'S SEAT BELT BUCKLE FAILED TO FUNCTION PROPERLY.THE COMPLAINANTS ALLEGED THE BUCKLES WOULD NOT LATCH OR WERE DIFFICULT TO LATCH OR UNLATCH.SOME OF THE COMPLAINANTS ALLEGED SOMETHING WAS BROKEN INSIDE OF THE BUCKLE AND OTHERS ALLEGED THAT THE BUTTON WAS STUCK DOWN AND HAD TO BE PRIED UP IN ORDER TO LATCH THE BUCKLE.THIS INVESTIGATION HAS BEEN UPGRADED TO EA05-022