← New search

2002 Jeep Grand Cherokee

Owner reports · Recalls · Investigations

More warning signs than most Grand Cherokee years

Owner complaints for the 2002 Jeep Grand Cherokee are substantially higher than the model-year median of 726.

About this comparison →

When problems were reported

Mileage at the reported incident

908 reports with mileage · 568 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 486 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Visibility. Review the 323 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 153 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

75 crash reports20 fire reports61 injury reports

Tires complaints

9 reports
Clear category filter
81,695 miles · Jun 1, 2014
Tires

MY DAUGHTERS JEEP JUST FAILED STATE INSPECTION DUE TO SEVERE CRACKING OF THE TIRE NEXT TO THE RIM. ALL 4 TIRES ARE GOODYEAR WRANGLER ST 225/75/16 104S. THE TREAD DEPTH IS STILL VERY GOOD HOWEVER THEY WILL NOT PASS STATE INSPECTION DUE TO THE LARGE CRACKS TOTALLY AROUND THE RIMS. A TECH AT THE LOCAL JEEP STORE TOLD ME THAT THIS…

Read full complaint

MY DAUGHTERS JEEP JUST FAILED STATE INSPECTION DUE TO SEVERE CRACKING OF THE TIRE NEXT TO THE RIM. ALL 4 TIRES ARE GOODYEAR WRANGLER ST 225/75/16 104S. THE TREAD DEPTH IS STILL VERY GOOD HOWEVER THEY WILL NOT PASS STATE INSPECTION DUE TO THE LARGE CRACKS TOTALLY AROUND THE RIMS. A TECH AT THE LOCAL JEEP STORE TOLD ME THAT THIS IS A HUGE PROBLEM WITH THESE TIRES. HE STATED THAT THIS PROBLEM GOES WAY BACK.THE LOCAL GOODYEAR DEALER (SULLIVAN TIRE) WILL NOT DO ANYTHING TO HELP. GOODYEAR USED TO BE ONE OF THE BEST TIRES, WHAT HAPPENED? IT SEEMS THAT ALL OF THE OTHER TIRE COMPANIES OFFER A MUCH BETTER PRODUCT. NO MORE GOODYEAR TIRES FOR MY FAMILY!!! *TR

NHTSA ODI #10595420

85,450 miles · Jan 21, 2009
Tires

MY DAUGHTER WAS RETURNING HOME TO MADISON, AL FROM AUBURN UNIVERSITY, ALABAMA USING INTERSTATE I-65 NORTH. JUST OUTSIDE OF BIRMINGHAM, AL AT MILE MARKER 170 SHE HAD A BLOWOUT OF THE RIGHT REAR TIRE. THE TIRE TREAD SEEMED TO COMPLETELY SEPARATE FROM THE SIDEWALL ALL AROUND THE TIRE. THE TIRE WAS COMPLETELY USELESS. THE TIRE WAS O…

Read full complaint

MY DAUGHTER WAS RETURNING HOME TO MADISON, AL FROM AUBURN UNIVERSITY, ALABAMA USING INTERSTATE I-65 NORTH. JUST OUTSIDE OF BIRMINGHAM, AL AT MILE MARKER 170 SHE HAD A BLOWOUT OF THE RIGHT REAR TIRE. THE TIRE TREAD SEEMED TO COMPLETELY SEPARATE FROM THE SIDEWALL ALL AROUND THE TIRE. THE TIRE WAS COMPLETELY USELESS. THE TIRE WAS ON A JEEP GRAND CHEROKEE OVERLAND WITH FULL TIME FOUR WHEEL DRIVE, WHICH WE BELIEVE HELPED MY DAUGHTER COME TO A SAFE STOP ON THE HIGHWAY MEDIAN. THE TIRE WAS A GOODYEAR WRANGLER SR A P235/65 R17 DOT MK87 DYWR 0506. WE ARE NOW VERY CONCERNED ABOUT THE QUALITY OF THE REMAINING WRANGLER TIRES ON THIS VEHICLE AND IF IT IS SAFE TO CONTINUE TO USE THEM. PICTURES OF THE DAMAGED TIRE AND THE TIRE ITSELF ARE AVAILABLE. *TR

NHTSA ODI #10255929

38,000 miles · Aug 15, 2008
Tires

TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE 4WD. THE VEHICLE HAS GOODYEAR WRANGLER TIRES, SIZE P235/70R16. THE CONTACT STATED THAT THE INDEPENDENT OWNER WHO SOLD THE VEHICLE TO THE CONTACT HAD BRAND NEW TIRES PLACED ON THE VEHICLE. AT APPROXIMATELY 38,000 MILES, THE GOODYEAR TIRES BEGAN TO EXPERIENCE TREAD SEPARATION. SHE…

Read full complaint

TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE 4WD. THE VEHICLE HAS GOODYEAR WRANGLER TIRES, SIZE P235/70R16. THE CONTACT STATED THAT THE INDEPENDENT OWNER WHO SOLD THE VEHICLE TO THE CONTACT HAD BRAND NEW TIRES PLACED ON THE VEHICLE. AT APPROXIMATELY 38,000 MILES, THE GOODYEAR TIRES BEGAN TO EXPERIENCE TREAD SEPARATION. SHE NOTICED THAT THE VEHICLE WAS NOT DRIVING PROPERLY AT SPEEDS 50 MPH AND LESS. THE TIRES WERE ALSO SEPARATING FROM THE HUBCAPS OR RIMS AND THEN FLATTENED. THE TIRE WAS REPAIRED. LATER, THE SECOND TIRE FLATTENED. THE TIRE WAS REPLACED WITH THE SPARE TIRE THAT CAME WITH THE VEHICLE. THREE MONTHS LATER, SHE AWAKENED TO FIND THAT THE TIRE WAS ENTIRELY FLAT. SHE PLACED AIR IN THE TIRE, BUT IT REMAINED SOFT. THE FAILURE MILEAGE WAS 38,000 AND CURRENT MILEAGE WAS 45,000. UPDATED 09/10/08 *BF UPDATED 09/17/08. *JB

NHTSA ODI #10238378

25,000 miles · Oct 24, 2005
Electrical SystemEngine And Engine CoolingLatches/locks/linkages

THIS IS MY 4TH JEEP. HERE IS A LITTLE BACKGROUND ON THIS ISSUE. I PURCHASED A 2002 JEEP GRAND CHEROKEE, THE OVERLAND EDITION. THE DEALERSHIP PUSHED BUYING A USED CERTIFIED JEEP VEHICLE! THEY MENTIONED THE EXTENDED WARRANTY THAT WOULD TAKE CARE OF ANY ISSUES THAT THE JEEP HAD DURING THE LAST YEARS OF MY OWNERSHIP. I WENT IN …

Read full complaint

THIS IS MY 4TH JEEP. HERE IS A LITTLE BACKGROUND ON THIS ISSUE. I PURCHASED A 2002 JEEP GRAND CHEROKEE, THE OVERLAND EDITION. THE DEALERSHIP PUSHED BUYING A USED CERTIFIED JEEP VEHICLE! THEY MENTIONED THE EXTENDED WARRANTY THAT WOULD TAKE CARE OF ANY ISSUES THAT THE JEEP HAD DURING THE LAST YEARS OF MY OWNERSHIP. I WENT IN THE DEALERSHIP LOOKING TO PURCHASE A NEW VEHICLE BUT THEY TOLD ME ALL THE ADDED BENEFITS / VALUE FROM BUYING FROM THE USED JEEP FACILITY! THE WARRANTY: AS MENTIONED I PURCHASED THE WARRANTY SOLD BY JEEP AT THE LOCAL DEALERSHIP. THE SERVICE AGREEMENT THAT WAS SOLD BY THE DEALERSHIP WENT BANKRUPT! GARY MILLER CHRYSLER JEEP ISUZU LOCATED IN ERIE, PA SOLD THIS TO ME. MY 1ST ISSUE WAS WHEN I DECIDED TO TAKE THE VEHICLE IN BECAUSE OF A VIBRATION WHILE DRIVING. I WAS MADE AWARE THAT THE COMPANY WAS BANKRUPT WHEN TYING TO CALL AND FIND OUT WHAT INFORMATION WILL BE NEEDED WHEN I GO TO THE LOCAL JEEP DEALERSHIP IN KANSAS CITY. FURTHERMORE I MENTIONED TO THE JEEP DEALERSHIP THAT PUSHED THE CONTRACT THAT I AM WILING TO PURCHASE THE BEST CONTRACT TO MAKE SURE I DO NOT HAVE AN ISSUE WITH MY NEW VEHICLE IN THE FUTURE. THE CONSTANT ISSUES: I HAVE NOW TAKEN IN MY JEEP FOR 6 VISITS! I HAVE ONLY INCLUDED SOME OF THE PAYMENTS (SEE THE ADDITIONAL PAPERWORK) BUT YOU CAN SEE A TREND HERE. THIS JEEP HAD BEEN NOTHING BUT A PROBLEM SINCE I PURCHASED THE VEHICLE! I AM NOW STUCK REPLACING THE STEERING PUMP FOR THE 2ND TIME! I HAVE TO PAY FOR THE REPLACEMENT AND LIVE WITHOUT A VEHICLE. I AM OUT SEVERAL THOUSAND DOLLARS AND STILL HAVE TO TAKE THIS VEHICLE (THAT JEEP PUSHED ON ME) TO THE SERVICE SHOP ABOUT EVERY 6 MONTHS. I JUST STARTED DRIVING MY VEHICLE FROM THE LAST SERVICE REPAIR (I AM GETTING VERY FAMILIAR TO THE LOCAL JEEP DEALERSHIPS) AND STILL THE ITEM IS NOT FIXED AND MY JEEP IS LEAKING OIL ALL OVER OUR COMPANY DRIVEWAY. THIS VEHICLE IS A LEMON AND THE COMPANY THAT MADE THE VEHICLE SOLD ME A BANKRUPT CONTRACT. *NM

NHTSA ODI #10140626

92,000 miles · Jun 8, 2005
TiresWheels

DT: THE CHROME RIMS THAT WERE AN OPTION ON THE VEHICLE, ON THE INSIDE METAL CORRODED AND PEELED OFF. ALREADY TALKED TO THE DEALER, AND THE MANUFACTURER NOTICED THIS . JUST THIS WEEK. THE TIRES ARE GOODYEAR, WRANGLERS. *AK THE TIRES NOW ARE MICHELIN TIRES WHICH WERE CHANGED AT 50,000 MILES. THE WHEEL OR RIM HUBS HAD TO BE …

Read full complaint

DT: THE CHROME RIMS THAT WERE AN OPTION ON THE VEHICLE, ON THE INSIDE METAL CORRODED AND PEELED OFF. ALREADY TALKED TO THE DEALER, AND THE MANUFACTURER NOTICED THIS . JUST THIS WEEK. THE TIRES ARE GOODYEAR, WRANGLERS. *AK THE TIRES NOW ARE MICHELIN TIRES WHICH WERE CHANGED AT 50,000 MILES. THE WHEEL OR RIM HUBS HAD TO BE BROKEN OFF BECAUSE THEY WERE RUSTED OUT DUE TO CORROSION. *TT *SB

NHTSA ODI #10120539

24,000 miles · Jan 11, 2005
Tires

THE MANUFACTURER PUT THE WRONG SIZE TIRES ON THE VEHICLE. IT WAS TOLD TO THE CONSUMER AT 24,000 MILES THAT TIRES WERE WORN OUT. CONSUMER COULD NOT GET THE RIGHT TIRE FOR THE VEHICLE. GOODYEAR WRANGLER, ST ALL SEASON, P22575R16, 104S, WEIGHT RATING 1984 MAXIMUM. *AK.....GOODYEAR TIRES WORE OUT AT 23000 MILES. CONSUMER CLAIMED T…

Read full complaint

THE MANUFACTURER PUT THE WRONG SIZE TIRES ON THE VEHICLE. IT WAS TOLD TO THE CONSUMER AT 24,000 MILES THAT TIRES WERE WORN OUT. CONSUMER COULD NOT GET THE RIGHT TIRE FOR THE VEHICLE. GOODYEAR WRANGLER, ST ALL SEASON, P22575R16, 104S, WEIGHT RATING 1984 MAXIMUM. *AK.....GOODYEAR TIRES WORE OUT AT 23000 MILES. CONSUMER CLAIMED THAT HE WAS TOLD BY GOODYEAR THAT HE SHOULD GET 60000 TO 70000 MILES ON THAT TIRE. IN CHECKING FOR REPLACEMENTS BOTH B.F.GOODRICH AND MICHELIN REFUSED TO PUT THEIR TIRES ON CONSUMER'S VEHICLE. THEY STATED THAT THEIR TIRE MUST HAVE A RATING OF 106S. *AK

NHTSA ODI #10107210

12,000 miles · Oct 1, 2003
Tires

THE REAR DRIVER'S SIDE TIRE BLEW OUT WHILE DRIVING AT 50 MPH AND THE OTHER 3 TIRES FORMED BUBBLES IN THE SIDEWALL. MANUFACTURER REPLACED ALL TIRES, INCLUDING THE SPARE TIRE. *AK THERE WERE BUBBLES ON THE INSIDE AND OUTSIDE. *SCC *JB

NHTSA ODI #10042032

Mileage unknown · Oct 21, 2002
Tires

CONSUMER STATES THAT WHILE DRIVING HEARD A LOUD NOISE, PULLED OVER THE FRONT RIGHT PASSENGER SIDE TIRE TREAD SEPARATED. ORGINIAL EQUIPMENT. TS TIRE SIZE 225/75R16 AND DOT# M671EKWR1601. *YH

NHTSA ODI #8021259

Mileage unknown · Mar 12, 2002
Tires

VEHICLE CERTIFICATION LABEL LISTS 17" X 7.5" WHEEL RIMS & TIRES AS MINIMUM SIZE. VEHICLE FACTORY EQUIPPED WITH 16" X 7" WHEEL RIMS & TIRES. OWNERS MANUAL SAYS "WARNING! NEVER USE A TIRE SMALLER THAN THE MINIMUM TIRE SIZE LISTED...." MANUFACTURER REFUSES TO ADVISE AS TO CORRECT GVWR, TIRE PRESSURE FOR TIRES AS EQUIPED, OR TO SU…

Read full complaint

VEHICLE CERTIFICATION LABEL LISTS 17" X 7.5" WHEEL RIMS & TIRES AS MINIMUM SIZE. VEHICLE FACTORY EQUIPPED WITH 16" X 7" WHEEL RIMS & TIRES. OWNERS MANUAL SAYS "WARNING! NEVER USE A TIRE SMALLER THAN THE MINIMUM TIRE SIZE LISTED...." MANUFACTURER REFUSES TO ADVISE AS TO CORRECT GVWR, TIRE PRESSURE FOR TIRES AS EQUIPED, OR TO SUPPLY CORRECT LABEL OR WHEELS & TIRES.*AK

NHTSA ODI #759269

Official recalls

10

15V046000 · Air Bags:frontal

Jan 28, 2015

Chrysler (FCA US LLC) is recalling certain model year 2002-2003 Jeep Liberty vehicles manufactured January 9, 2001, to March 28, 2003, 2002-2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, to May 23 2003, and 2003-2004 Dodge Viper vehicles manufactured November 1, 2001, to June 30, 2004. Due to electrical noise beyond the tolerance of the air bag electronic control module (ECM), a component in the ECM may fail, causing the front air bags, side air bags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence & remedy

Consequence: Inadvertent deployment of the air bags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler dealers will replace the air bag control module and side impact sensors as required, free of charge. This recall remedy was applied during earlier recall campaigns of these vehicles under safety recalls 12V527 and 13V040. All owners that have not had the recall repair performed under safety recalls 12V527 or 13V040 are strongly encouraged to have it performed and not wait for the final remedy to be deployed to the field. The recall began on December 29, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R06.

12V527000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE

Nov 8, 2012

Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence & remedy

Consequence: Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.

Additional source detail variants (2)

Air Bags:frontal:sensor/control MODULE-INACTIVE

Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence: Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.

Air Bags

Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence: Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.

09V117000 · Seats:front Assembly:seat Heater/cooler

Apr 9, 2009

CHRYSLER IS RECALLING 103,409 MY 2001-2004 JEEP GRAND CHEROKEE VEHICLES WITH HEATED SEATS AND WITH CHRYSLER RECALL NO. 06V-197 COMPLETED (03-04 MY) OR SEAT HEATER ELEMENTS SERVICE REPLACEMENT (01-02 MY). THE FRONT SEAT ELECTRIC HEATER ELEMENTS COULD OVERHEAT.

Consequence & remedy

Consequence: OVERHEATING COULD POTENTIALLY CAUSE A FIRE OR INJURY.

Remedy: DEALERS WILL REPLACE THE FRONT SEAT HEATER ELEMENTS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 23, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

06V199000 · Engine And Engine Cooling:cooling System:fan

Jun 8, 2006

ON CERTAIN SPORT UTILITY VEHICLES, THE PLASTIC BLADES OF THE ELECTRIC MOTOR DRIVEN COOLING FAN MAY SEPARATE AND PENETRATE THE SHROUD.

Consequence & remedy

Consequence: IF THIS OCCURS WHILE THE HOOD IS OPEN, A PERSON IN THE VICINITY OF THE ENGINE COULD BE STRUCK BY THE BLADE AND INJURED.

Remedy: DEALERS WILL REPLACE THE ELECTRIC COOLING FAN MODULES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 4, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

02V104000 · Fuel System, Gasoline:fuel Injection System:injectors

Apr 8, 2002

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.

Consequence & remedy

Consequence: THIS COULD RESULT IN A VEHICLE FIRE.

Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

02V099000 · Air Bags:frontal

Mar 26, 2002

ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER AIR BAG WIRING HARNESS WAS IMPROPERLY MANUFACTURED.

Consequence & remedy

Consequence: THIS COULD CAUSE IMPROPER AIR BAG DEPLOYMENT IN CERTAIN CRASH CONDITIONS.

Remedy: DEALERS WILL ADD A WIRING JUMPER TO THE EXISTING CIRCUITRY TO CORRECT THIS CONDITION. OWNER NOTIFICATION BEGAN APRIL 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

02V032000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Jan 31, 2002

CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A FUEL TANK BRUSH GUARD FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) CONTROL VALVE CAN BECOME DETACHED DURING A CRASH, ALLOWING FUEL LEAKAGE.

Consequence & remedy

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy: DEALERS WILL EITHER REPLACE THE FUEL TANK BRUSH GUARD WITH A SKID PLATE OR REINFORCE THE EXISTING FUEL TANK BRUSH GUARD WITH A REINFORCEMENT BRACKET. OWNER NOTIFICATION WILL BEGIN MARCH 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

01V374000 · Fuel System, Gasoline:delivery

Dec 5, 2001

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FUEL INLET CHECK VALVE COULD STICK IN THE PARTIALLY OPEN POSITION. THIS CONDITION COULD CAUSE FUEL TO SPILL OUT OF THE FILLER TUBE DURING REFUELING.

Consequence & remedy

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE FUEL INLET CHECK VALVE. VEHICLES FOUND TO HAVE A STICKING FUEL INLET CHECK VALVE WILL HAVE THE FUEL TANK ASSEMBLY REPLACED. OWNER NOTIFICATION BEGAN DECEMBER 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

01V348000 · Engine And Engine Cooling:exhaust System:emission Control

Nov 13, 2001

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE ONBOARD VAPOR RECOVERY SYSTEM VENT HOSE MAY HAVE BEEN MISROUTED. THIS COULD ALLOW WATER TO ENTER THE CANISTER WHICH CAN CAUSE FUEL TO SPILL OUT OF THE FILLER TUBE WHEN REFUELING THE TANK.

Consequence & remedy

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT (AND REPOSITION AS NECESSARY) THE VENT HOSE. IF THE VENT HOSE IS FOUND IN THE BENT DOWN POSITION, AND THE VEHICLE HAS BEEN DRIVEN MORE THAN 20 MILES, THE CANISTER ASSEMBLY WILL BE REPLACED. OWNER NOTIFICATION BEGAN DECEMBER 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

01V288000 · Electrical System:wiring:interior/under Dash

Sep 10, 2001

VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES ARE BEING RECALLED FOR A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER MICROPROCESSOR. UNDER CERTAIN CONDITIONS, THE CLUSTER, WITH THE MAJORITY OF ITS GAUGES, ILLUMINATION, AND WARNING LAMPS, COULD BECOME INOPERATIVE.

Consequence & remedy

Consequence: DRIVING THE VEHICLE WITH AN INOPERATIVE CLUSTER COULD CAUSE A DISTRACTION, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL RE-FLASH THE CLUSTER SOFTWARE TO CORRECT THE CONDITION. OWNER NOTIFICATION BEGAN OCTOBER 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

7

RQ14001 · Jeep Inadvertent Air Bag Deployment

Opened May 29, 2014 · Closed Nov 13, 2015

Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window; Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Additional source detail variants (24)

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

EA12005 · Crash Related Fuel Tank Fires

Opened Jun 12, 2012 · Closed Nov 14, 2014

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage:tank Assembly

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

PE10031 · Crash Related Fuel Tank Fires

Opened Aug 23, 2010 · Closed Jun 14, 2012

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Fuel System, Gasoline:storage

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Fuel System, Gasoline:storage:tank Assembly

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

DP09005 · Fuel Storage System Crash Related Fires

Opened Nov 6, 2009 · Closed Aug 23, 2010

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Fuel System, Gasoline:storage

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Fuel System, Gasoline:storage:tank Assembly

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

EA05020 · Fan Blade Failure (engine Cooling Fan)

Opened Nov 14, 2005 · Closed Sep 12, 2006

Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan

DAIMLERCHRYSLER CORPORATION (DCC) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (06V199) OF CERTAIN JEEP GRAND CHEROKEE VEHICLES TO REPLACE THE ENGINE'S ELECTRIC MOTOR DRIVEN COOLING FAN. THE 182,875 VEHICLES INCLUDED IN THE RECALL ARE MODEL YEAR (MY) 2002 EQUIPPED WITH 4.0 LITER (SIX CYLINDER) ENGINES MANUFACTURED FROM FEBRUARY 4, 2002 THROUGH JUNE 17, 2002; AND MY 2000 EQUIPPED WITH EITHER THE 4.0 LITER (SIX CYLINDER) OR THE 4.7 LITER (EIGHT CYLINDER) ENGINE MANUFACTURED FROM JANUARY 31, 2000 THROUGH JUNE 12, 2000.DCC NOTED THAT THEIR ANALYSIS OF FAILED PARTS SHOWED EVIDENCE OF BRITTLE FRACTURE OF THE FAN BLADE.DCC FURTHER STATED, POOR BONDING BETWEEN THE RESIN MATERIAL AND THE GLASS FIBERS WAS OBSERVED, WHICH MAY BE ATTRIBUTED TO THE INJECTION MOLDING PROCESS. SINCE THE ROOT CAUSE OF FAN FAILURE COULD NOT BE CONCLUSIVELY IDENTIFIED DCC DECIDED THE RECALL SCOPE WOULD BE DETERMINED BY THE BUILD DATE RANGE OF THE COMPLAINT VEHICLES.THERE WERE 48 REPORTS FOR MY 2000, AND 196 FOR MY 2002.ODI WILL CONTINUE TO MONITOR THIS ISSUE FOR REPORTS ON VEHICLES OUTSIDE OF THE RECALL SCOPE.

PE05039 · Engine Cooling Fan Blade Failure

Opened Jul 13, 2005 · Closed Nov 14, 2005

Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan

THIS INVESTIGATION WAS OPENED ON JULY 13, 2005, BASED ON FOUR ODI CONSUMER REPORTS.ODI CONTACTED ALL OF THOSE COMPLAINANTS AND EACH OF THEM REPORTED THAT PIECES OF THE BROKEN FAN BLADE HAD DAMAGED THE RADIATOR AND PENETRATED THROUGH THE PROTECTIVE FAN SHROUD.SINCE OPENING THE INVESTIGATION, ODI HAS RECEIVED 12 NEW CONSUMER REPORTS.IN ITS RESPONSE TO ODI'S PRELIMINARY EVALUATION INFORMATION REQUEST DAIMLERCHRYSLER CORPORATION PROVIDED ADDITIONAL OWNER REPORTS AND WARRANTY DATA.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO ENGINEERING ANALYSIS EA05-020 TO FURTHER STUDY THE ISSUES REGARDING THE ALLEGED FAN FAILURES.

EA01017 · ROLL-AWAY In Reverse When Parked

Opened Nov 1, 2001 · Closed Dec 18, 2002

Status: closed (inferred from source dates) · Power Train

DAIMLERCHRYSLER HAS RECALLED THE ZJ MODELS TO INCORPORATE A SECONDARY DETENT SPRING INTO THE SHIFTER.EVEN THOUGH THE WJ 6 CYL. VEHICLES USE THE SAME MANUAL DETENT LEVER THAT AS THE VEHICLES IN THE RECALL POPULATION, ODI BELIEVES THAT THE WJ REDESIGNED SHIFTER, WHICH IMPROVES FLOOR SHIFTER FUNCTIONALITY AND ERGONOMICS, HELPS TO PROVIDE FEEDBACK TO THE DRIVER TO INDICATE WHETHER ?PARK? HAS OR HAS NOT BEEN ACHIEVED.ALTHOUGH THE INVESTIGATOR WAS ABLE TO INDUCE A ?FALSE PARK? IN THE WJ PLATFORM FOR 6 CYL. VEHICLES, THE LEVEL OF DIFFICULTY WAS GREATER THAN THAT REQUIRED FOR ALL ZJ MODELS, AND THE COMPLAINT RATE WAS SIGNIFICANTLY LOWER THAN THE RECALLED ZJ POPULATION.FURTHER, THE ODI INVESTIGATOR WAS ALSO ABLE TO CREATE A ?FALSE PARK? IN PEER VEHICLES WITH THE SAME LEVEL OF DIFFICULTY AND FREQUENCY AS THE SUBJECT VEHICLE WJ PLATFORM.THE WJ COMPLAINT RATE WAS INFLATED DUE TO NATIONAL EXPOSURE THROUGH THE PRESS. THE COMPLAINT RATE PRIER TO THE JULY 5, 2001 MEDIA COVERAGE FOR THE WJ VEHICLES IS SIMILAR TO THE PEER VEHICLE INCIDENT RATE.BASED ON THE ABOVE, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME IN THE WJ POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED WITH A SAFETY RECAL FOR THE ZJ PLATFORM ONLY.

Go deeper into Jeep Grand Cherokee problems