IllustrationRIGHT FRONT FUEL LINE BROKE, CAUSING FUEL LEAKAGES, AND LEADING TO AN ENGINE COMPARTMENT FIRE. MANUFACTURER WAS NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
2000 Jeep Cherokee
Owner reports · Recalls · Investigations
More warning signs than most Cherokee years
Owner complaints for the 2000 Jeep Cherokee are substantially higher than the model-year median of 113.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cherokee years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
2825–50K
2450–75K
1975–100K
28100–150K
16150K+
132 reports with mileage · 237 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports40 fire reports13 injury reports
What owners actually said
369 reportsI DROVE MY JEEP TO WORK AND PARKED IN THE PARKING GARAGE. APPROXIMATELY 40 MIN. TO 1 HOUR LATER, I WAS NOTIFIED THAT MY VEHICLE WAS ON FIRE. THE FIRE DEPARTMENT HAD ALREADY BEEN NOTIFIED AND EXTINGUISHED THE FIRE. THE HOOD LOCK MELTED AND FROZE THE HOOD SHUT. THE FIRE DEPT. HAD TO PRY THE HOOD OPEN WITH A CROWBAR. ALL PLAST…
Read full complaint
I DROVE MY JEEP TO WORK AND PARKED IN THE PARKING GARAGE. APPROXIMATELY 40 MIN. TO 1 HOUR LATER, I WAS NOTIFIED THAT MY VEHICLE WAS ON FIRE. THE FIRE DEPARTMENT HAD ALREADY BEEN NOTIFIED AND EXTINGUISHED THE FIRE. THE HOOD LOCK MELTED AND FROZE THE HOOD SHUT. THE FIRE DEPT. HAD TO PRY THE HOOD OPEN WITH A CROWBAR. ALL PLASTIC AND ELECTICAL COMPONENTS ON THE TOP OF THE MOTOR HAD BURNED. CHRYSLER IS INVESTIGATING THE CAUSE BUT DOES NOT YET HAVE A DETERMINATION.*AK
TRANSMISSION GRINDS WHEN SHIFTING, GROWLS WHEN CLUTCH NOT DEPRESSED, POPS OUT OF GEAR, AT HIGHWAY SPEEDS WHEN RAINING PASS. SIDE LEAKS ONTO FEET AND SOAKING CARPET, ALL COMPLAINTS MADE TO DEALER AND CAN EITHER FIND NO PROBLEM OR SAYS THAT THE NOISES ARE NORMAL, AND REFUSES TO DO ANYMORE WITH VEHICLE. *AK
JEEP WAS PARKED OUTSIDE TIRE CENTER WAITING FOR TECHNICIAN TO PUT THE NEW TIRES ON. TECHNICIAN CAME OUT, AND SAW SMOKE FROM UNDER THE HOOD. FIRE WAS PUT OUT, CHRYSLER INVESTIGATOR COULDN'T FIND THE CAUSE.*AKCHRYSLER LATER FOUND A FUEL LEAK. *NLM
VEHICLE EXPERIENCED ENGINE COMPARTMENT FIRE, SUSPECT FAILURE OF THE WIRING HARNESS TO BE CAUSE, CLAIM 29-6065-511. *SLC
I HAD BEEN INVOLVED IN AN ACCIDENT ON 7-4-01 DUE TO BRAKES FAILING TO EVEN SLOW JEEP. ON 8-6-01 I MET W/ DISTRICT SERVICE MANAGER, FRANK TELIOFARIO AT MARTIN JEEP SO HE COULD LOOK AT THE JEEP. HE TEST DROVE IT FOR 2 MILES, "PULLED THE WHEELS" AND SAID THERE WAS NOTHING WRONG WITH THE JEEP. HE STATED THAT HE THOUGHT MY PROBLEM W…
Read full complaint
I HAD BEEN INVOLVED IN AN ACCIDENT ON 7-4-01 DUE TO BRAKES FAILING TO EVEN SLOW JEEP. ON 8-6-01 I MET W/ DISTRICT SERVICE MANAGER, FRANK TELIOFARIO AT MARTIN JEEP SO HE COULD LOOK AT THE JEEP. HE TEST DROVE IT FOR 2 MILES, "PULLED THE WHEELS" AND SAID THERE WAS NOTHING WRONG WITH THE JEEP. HE STATED THAT HE THOUGHT MY PROBLEM WAS THAT IT DIDN'T HAVE ABS BRAKES AS I'D BEEN TOLD. I TOLD HIM NO, MY PROBLEM WAS THE BRAKES DIDN'T WORK SOMETIMES! AN HOUR AND A HALF LATER, I STEPPED ON THE BRAKES FOR A YELLOW LIGHT AND HEARD A SCREECHING AS IF WORKING ON A METAL LATHE AND BRINGING THE CUTTING TOOL TOO DEEP, AND THE WHOLE JEEP SHOOK, FELT LIKE IT WAS GOING TO FALL APART. I WAS HOPING I WOULD SLOW DOWN BEFORE I WENT THROUGH THE NOW-RED LIGHT. I DID STOP BUT DIDN'T KNOW WHAT HAD HAPPENED. I CHECKED REAR-VIEW MIRROR AND ALSO TURNED AROUND AT NEXT OPPORTUNITY. NO SKID MARKS. IT WAS NOT THE TIRES AS THE DIST MGR HAD SUGGESTED. I CALLED HIM *STILL AT THE DEALERSHIP* AND HE SAID HE WOULD CHECK INTO SOME THINGS AND CALL ME BACK "TODAY OR TOMORROW". I HAVE NEVER HEARD FROM HIM AGAIN. HIRED A LAWYER, NOW MY INSURANCE COMPANY NOTIFIED ME TO NOT DRIVE THE JEEP AS IT'S NOT SAFE, AND I"M AWAITING THEIR SPECIALIST TO COME LOOK AT THE JEEP. IT IS PARKED AND I AM DRIVING ANOTHER VEHICLE. I WILL NOT TRADE IT IN BECAUSE I DON'T WANT SOMEONE TO BE KILLED DUE TO WHATEVER THIS PROBLEM IS THAT CHRYSLER IS REFUSING TO ACKNOWLEDGE. IF WHAT THEY STATED WAS TRUE AND THERE WAS NO PROBLEM, THEN I WOULD HAVE NO PROBLEMS WITH STOPPING OF THIS JEEP. EACH TIME THEY TELL ME THERE IS NO PROBLEM, THE PROBLEM OCCURS AGAIN. THEY HAVE A SERIOUS PROBLEM W/ THESE JEEPS. WHEN I TOOK JEEP IN TO GET REPAIRED FROM ACCIDENT ON 7-4-01 AUTO BODY SHOP OWNER SAID HE'S HAD AT LEAST 4 OTHER CHEROKEES IDENTICAL TO MINE IN HIS SHOP FOR REPAIRS OF THE SAME PROBLEM. WHAT IS WRONG WITH THESE JEEPS? WHY IS CHRYSLER REFUSING TO FIX THIS PROBLEM?*AK
BRAKING AT HIGHWAY SPEED CAUSES VIOLENT SHIMMY AND CAUSES THE VEHICLE TO LURCH TO THE LEFT OR RIGHT. DEALER TOLD ME IT WAS THE BRAKE ROTORS WARPED. THEY ARE NOT COVERED PAST 12MO/12KMILE WARRANTY. THIS IS A SERIOUS SAFETY CONCERN AND SHOULD BE RECALLED AND COVERED UNDER WARRANTY.*AK
MY COMPANY OWNS A FLEET OF 1998-2000 JEEP CHEROKEES USED AS MARKED SECURITY VEHICLES. AT LEAST THREE DRIVER BUCKET SEATS HAVE BROKEN WHILE THE VEHICLE WAS BEING DRIVEN- CERTAINLY A POTENTIAL CAUSE OF ACCIDENTS. THE METAL WHERE THE SEAT IS BOLTED TO THE FLOOR OF THE VEHICLE TEARS, CAUSING THE FRONT RIGHT CORNER OF THE SEAT TO COM…
Read full complaint
MY COMPANY OWNS A FLEET OF 1998-2000 JEEP CHEROKEES USED AS MARKED SECURITY VEHICLES. AT LEAST THREE DRIVER BUCKET SEATS HAVE BROKEN WHILE THE VEHICLE WAS BEING DRIVEN- CERTAINLY A POTENTIAL CAUSE OF ACCIDENTS. THE METAL WHERE THE SEAT IS BOLTED TO THE FLOOR OF THE VEHICLE TEARS, CAUSING THE FRONT RIGHT CORNER OF THE SEAT TO COME LOOSE AND PITCH UP.
VEHICLE WAS PARKED, ENGINE RUNNING, EMERGENCY BRAKE NOT APPLIED VEHICLE SUDDENLY WENT BACKWARD, ACROSS THE STREET, HIT A HOUSE, AND DAMAGE TO VEHICLE WAS $ 500, HOUSE $ 3000.*AK *SLC
WHILE TRAVELING ON A ROAD AT 40MPH SWITCH FROM ASPHALT TO PAVEMENT WOULD CAUSE STEERING COLUMN TO SHIMMY VIOLENTLY. VEHICLE WOULD THEN SWAY FROM LEFT TO RIGHT. ENTIRE FRONT END WOULD SHAKE. BARELY ABLE TO MAINTAIN CONTROL OF VEHICLE. HAD TAKEN TO DEALERSHIP, AND STEERING LINKAGE WAS REPLACED.*AK
Official recalls
102V104000 · Fuel System, Gasoline:fuel Injection System:injectors
Apr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by