IllustrationENGINE LEAK BAD SEAT AND BRAKE LIGHT I NEED SOME HELP PLEASE REPLACE REAR WIPE,
2000 Jeep Cherokee
Owner reports · Recalls · Investigations
More warning signs than most Cherokee years
Owner complaints for the 2000 Jeep Cherokee are substantially higher than the model-year median of 113.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cherokee years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
2825–50K
2450–75K
1975–100K
28100–150K
16150K+
132 reports with mileage · 237 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports40 fire reports13 injury reports
Seats complaints
22 reportsDRIVING DOWN CITY STREET(35MPH),APPLIED BRAKES FOR STOP LIGHT,SEAT FRAME(DRIVERS SIDE) APPARENTLY BROKE IN 2 SPOTS ALMOST CATAPULTING ME INTO THE BACK SEAT,IF NOT FOR THE SEAT BELT.
I NOTICED MY DRIVER'S SEAT WOBBLING AND FOUND THAT TWO OF THE BRACKETS THAT HOLD THIS SEAT TO THE FLOOR WERE BROKEN. THE LEFT FRONT BRACKET BROKE ONCE BEFORE BUT IT WAS WELDED ABOUT 2 YEARS AGO. FROM WHAT I'VE SEEN ON THE INTERNET, THERE ARE HUNDREDS, IF NOT THOUSANDS, OF COMPLAINTS REGARDING THIS SAME ISSUE. A RECALL NEEDS T…
Read full complaint
I NOTICED MY DRIVER'S SEAT WOBBLING AND FOUND THAT TWO OF THE BRACKETS THAT HOLD THIS SEAT TO THE FLOOR WERE BROKEN. THE LEFT FRONT BRACKET BROKE ONCE BEFORE BUT IT WAS WELDED ABOUT 2 YEARS AGO. FROM WHAT I'VE SEEN ON THE INTERNET, THERE ARE HUNDREDS, IF NOT THOUSANDS, OF COMPLAINTS REGARDING THIS SAME ISSUE. A RECALL NEEDS TO BE ISSUED AS THIS IS A HUGE SAFETY CONCERN FOR MYSELF AND MY FAMILY AS WELL AS OTHERS WHO OWN JEEP VEHICLES. PLEASE ISSUE A RECALL BEFORE A FATAL ACCIDENT OCCURS. PLEASE LET ME KNOW IF THERE IS ANYTHING FURTHER THAT I NEED TO DO; AND I LOOK FORWARD TO YOUR PROMPT RESPONSE IN THIS REGARD. THANK YOU. *TR
TL* THE CONTACT OWNS A 2000 JEEP CHEROKEE. WHILE PARKED, THE CONTACT NOTICED THAT THE METAL RAIL FOR THE FRONT DRIVER SIDE SEAT WAS FRACTURED, CAUSING THE SEAT TO SLIDE BACKWARD. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTS. THE CONTACT ADDED A BOLT IN ORDER TO HOLD THE SEAT IN PLACE. THE VEHICLE WAS NOT REPAIRED…
Read full complaint
TL* THE CONTACT OWNS A 2000 JEEP CHEROKEE. WHILE PARKED, THE CONTACT NOTICED THAT THE METAL RAIL FOR THE FRONT DRIVER SIDE SEAT WAS FRACTURED, CAUSING THE SEAT TO SLIDE BACKWARD. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTS. THE CONTACT ADDED A BOLT IN ORDER TO HOLD THE SEAT IN PLACE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
SEAT BRACKET ON DRIVERS SIDE SEAT COMPLETELY BROKE, SEAT WIGGLES AND MOVES. *TR
THE DRIVER SEAT BROKE IN THE REAR RIGHT CORNER AND FRONT LEFT CORNER AND NOW THE SEAT LEANS BACK AND IS NOT DRIVABLE. *TR
I WAS DRIVING MY 2000 JEEP CHEROKEE SPORT ON THE HIGHWAY GOING 55MPH WHEN MY DRIVERS SEAT WENT BACK UNEXPECTEDLY ALMOST CAUSING ME TO GET INTO AN ACCIDENT. (THE PROBLEM WAS THE FRONT FRAME OF THE SEAT JUST SNAPPED, THIS SEEMS TO BE A COMMON ISSUE I HAVE JUST FOUND OUT THAT HAS BEEN GOING ON FOR A WHILE, JEEP SHOULD DO A RECALL O…
Read full complaint
I WAS DRIVING MY 2000 JEEP CHEROKEE SPORT ON THE HIGHWAY GOING 55MPH WHEN MY DRIVERS SEAT WENT BACK UNEXPECTEDLY ALMOST CAUSING ME TO GET INTO AN ACCIDENT. (THE PROBLEM WAS THE FRONT FRAME OF THE SEAT JUST SNAPPED, THIS SEEMS TO BE A COMMON ISSUE I HAVE JUST FOUND OUT THAT HAS BEEN GOING ON FOR A WHILE, JEEP SHOULD DO A RECALL ON THESE AS THIS IS VERY DANGEROUS AND I COULD HAVE GOTTEN KILLED). *TR
2000 JEEP CHEROKEE SPORT AIRBAG WARNING LIGHT ILLUMINATES RANDOMLY AND REPEATEDLY. NOT RELATED TO ACTUAL AIRBAG DEPLOYMENT. IT MAY RENDER AIRBAG UNUSABLE. DANGEROUS CONDITION. COMMON CONSUMER COMPLAINT. ALL PASSENGER WINDOW ACTUATOR SWITCHES ARE UNUSABLE. WINDOWS WILL ONLY WORK AT DRIVER PANEL. SAFETY ISSUE IF PASSENGERS HAVE…
Read full complaint
2000 JEEP CHEROKEE SPORT AIRBAG WARNING LIGHT ILLUMINATES RANDOMLY AND REPEATEDLY. NOT RELATED TO ACTUAL AIRBAG DEPLOYMENT. IT MAY RENDER AIRBAG UNUSABLE. DANGEROUS CONDITION. COMMON CONSUMER COMPLAINT. ALL PASSENGER WINDOW ACTUATOR SWITCHES ARE UNUSABLE. WINDOWS WILL ONLY WORK AT DRIVER PANEL. SAFETY ISSUE IF PASSENGERS HAVE TO OPEN WINDOWS.VERY COMMON CONSUMER COMPLAINT. OBD ERROR CODES ARE INACCURATE (ESPECIALLY WHEN APPLYING TO EMISSION CONTROL SYSTEMS P0441, P0442). DIAGNOSIS OFTEN LEAD TO UNNEEDED REPAIRS AND COSTLY REPLACEMENT OF SENSORS AND COMPUTER WITHOUT CAUSE. COMMON CONSUMER COMPLAINT. DRIVER SEAT SUPPORT STRUCTURE BREAKS. EVEN WHEN DRIVEN ONLY IN ORDINARY DRIVING CONDITIONS AND NOT STRESSED UNUSUALLY. MUST BE REWELDED OR REPLACED. SEAT IS NO LONGER STRUCTURALLY SAFE. COMMON CONSUMER COMPLAINT ALL OF THESE ARE DESIGN ISSUES AND NOT SERVICE/MAINTENANCE RELATED. *TR
DRIVER SIDE FRONT SEAT BROKE OFF THE FRAME! NEVER HAS THIS HAPPENED BEFORE TO ME. NOW I HAVE TO GET IT WELDED OR BUY A NEW SEAT. IT RIPPED RIGHT OFF THE FRAME. *TR
WE OWN A 2000 JEEP CHEROKEE SPORT WITH APPROX. 155,000 MILES. WE BOUGHT IT USED 02/2004. SOMETIME IN JUNE 2010, JUST A COUPLE OF WEEKS PRIOR TO INCIDENT, THE DRIVER SEAT BEGAN TO MAKE A NOISE WHILE SITTING IN IT, DURING ACCELERATION, AND BRAKING. WE COULD NOT FIND THE SOURCE OF ANNOYING NOISE AND JUST HOPED IT WOULD GO AWAY. …
Read full complaint
WE OWN A 2000 JEEP CHEROKEE SPORT WITH APPROX. 155,000 MILES. WE BOUGHT IT USED 02/2004. SOMETIME IN JUNE 2010, JUST A COUPLE OF WEEKS PRIOR TO INCIDENT, THE DRIVER SEAT BEGAN TO MAKE A NOISE WHILE SITTING IN IT, DURING ACCELERATION, AND BRAKING. WE COULD NOT FIND THE SOURCE OF ANNOYING NOISE AND JUST HOPED IT WOULD GO AWAY. ON FRIDAY, JULY 9, 2010 WHEN MY HUSBAND WENT TO DO ERRANDS AND SAT IN THE SEAT HE SAID IT FELT ODD AND THE NOISE WAS GONE. HAPPY THE NOISE WAS GONE HE WENT ABOUT HIS BUSINESS. WHEN I GOT INTO THE JEEP ON SUNDAY, JULY 11, 2010 I NOTICED THE SEAT WAS WOBBLING. I GOT OUT AND LOOKED UNDER THE SEAT. I FOUND THE PROBLEM....WHERE THE SEAT ATTACHES TO THE SEAT ADJUSTER THE METAL HAD RIPPED ALMOST COMPLETELY THROUGH AT THE RIGHT FRONT BOLT. WHILE SITTING IN THE SEAT IT ROCKS FROM FRONT LEFT TO RIGHT REAR. THE SITUATION CALLS FOR IMMEDIATE ACTION ON OUR PART TO GET IT FIXED. WE ARE OBTAINING INFORMATION (TIME AND COST TO FIX AND AMOUNT OF TIME WITHOUT A VEHICLE-IT'S THE DRIVER SEAT NOT PASSENGER) ON WELDING, NEW SEAT, OR REPLACEMENT FROM JUNKYARD. I AM NOT EXCITED ABOUT WANTING TO USE ANOTHER JEEP SEAT AS I FEAR SAME ISSUE WILL OCCUR. THIS IS OUR ONLY VEHICLE. WE DO NOT GO MUDDING, FOUR WHEELING, MOUNTAIN CLIMBING, OFF ROADING WITH IT. WE DON'T LIVE NEAR A BEACH OR TAKE IT TO THE COASTLINE IN ORDER FOR HIGH SALT CONCENTRATION IN AIR TO BE A FACTOR. YES WE LIVE IN THE MIDWEST BUT SALT FROM SHOES CANNOT REACH THIS PART. OF THE SEAT. *TR
Official recalls
102V104000 · Fuel System, Gasoline:fuel Injection System:injectors
Apr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by