THE CONSUMER NOTICED PINK FLUID ON THE GARAGE FLOOR. THE VEHICLE WAS TAKEN TO DEALERSHIP. THE GASKET AND SEALS WERE REPLACED ON THE TRANSFER CASE. HOWEVER THE LEAK CONTINUED. AFTER PARTS WERE REPLACED AND TRANSMISSION WAS PUT ON DEALERSHIP FOUND A POROUS LEAK IN WHICH A SMALL PIN HOLE WAS IN THE SIDE TOP OF TRANSFER CASE NE…
Read full complaint
THE CONSUMER NOTICED PINK FLUID ON THE GARAGE FLOOR. THE VEHICLE WAS TAKEN TO DEALERSHIP. THE GASKET AND SEALS WERE REPLACED ON THE TRANSFER CASE. HOWEVER THE LEAK CONTINUED. AFTER PARTS WERE REPLACED AND TRANSMISSION WAS PUT ON DEALERSHIP FOUND A POROUS LEAK IN WHICH A SMALL PIN HOLE WAS IN THE SIDE TOP OF TRANSFER CASE NEAR AIR VENT. THE TRANSFER CASE HAS TO BE REPLACED. *AK *SC
NHTSA ODI #10091719
Mileage unknown · Mar 21, 2001
Power Train
THE VEHICLE SLIPPED INTO A DIFFERENT GEAR. NLM
NHTSA ODI #560443
Mileage unknown · Dec 4, 1996
Power Train
REINFORCEMENT RUBBER HOSE PORTION OF HYDRAULIC CLUTCH LINE RUNS TOO CLOSE TO EXHAUST MANIFOLD, HEAT DESTROYED RUBBER HOSE, CAUSING IT TO BURST WHEN CLUTCH WAS DEPRESSED, PREVENTING SHIFTING OF TRANSMISSION.
NHTSA ODI #512195
Mileage unknown · Apr 17, 1995
Power Train
PLASTIC ON SHIFT LEVER AT CENTER CONSOLE BROKE OFF TWICE, CAUSING DIFFICULTY SEEING WHICH GEAR VEHICLE IS IN/INABILITY TO MOVE LEVER. *SKD
BRAKE BOOSTER VACUUM RESERVOIR CANISTERS MAY DEVELOP LEAKS DUE TO BUMPER IMPACT.
Consequence & remedy
Consequence: THIS WOULD RESULT IN LOSS OF POWER BRAKE ASSIST AND ANINCREASE IN STOPPING DISTANCE.
Remedy: REPLACE BRAKE BOOSTER VACUUM CANNISTERS WITH NEW TYPE CANNISTERS; ALSO, INSTALL A RESTRICTION ORIFICE TO ENSURE SUFFICIENT VACUUM IN EVENT CANNISTER LEAKAGE OCCURS.
A STUD MAY HAVE BEEN INSTALLED ON TOP OF THE INTAKE MANIFOLD OF ENGINE THAT COULD CONTACT THE FUEL SUPPLY HOSE. CONSEQUENCE OF DEFECT: CHAFING OF THE FUEL HOSE COULD OCCUR WHICH COULD RESULT IN A FUEL LEAK.
Consequence & remedy
Consequence: Not supplied
Remedy: REMOVE STUD AND REPLACE FUEL SUPPLY HOSE AND LINE ASSEMBLY ON VEHICLES WITH ACCUMULATED MILEAGE.
STEERING LINKAGE COUPLERS REMAINED IN ACID ETCHING BATH TOO LONG. CONSEQUENCE OF DEFECT: COUPLERS COULD BE OUT OF TOLERANCE RESULTING IN STEERING WHEEL MISALIGNMENT WITH EVENTUAL LOSS OF VEHICLE CONTROL.
Consequence & remedy
Consequence: Not supplied
Remedy: REPLACE OUT OF TOLERANCE STEERING LINKAGE COUPLERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
PE89151 · Safety Belt Retractor
Opened Aug 11, 1989 · Closed Dec 11, 1989
Status: closed (inferred from source dates) · Seat Belts:front:retractor
===
PE89095 · Cruise Control Erratic
Opened Mar 1, 1989 · Closed Jun 28, 1989
Status: closed (inferred from source dates) · Equipment
===
EA88025 · Stalling
Opened Mar 10, 1988 · Closed Oct 3, 1989
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ANALYSIS OF INFORMATION FROM MANUFACTURER:THE MULTI-POINT INJECTIONSYSTEM (MPI) USED ON THE SUBJECT VEHICLES HAS HAD WIRING HARNESS FAILUREAND FAILURE OF THE CRANK POSITION SENSOR (CPS).BOTH FAILURES HAVE A HIGHFREQUENCY AND ARE THE SUBJECT OF JEEP TASK FORCES.NUMEROUS MODIFICATIONSTO BOTH ITEMS HAVE BEEN MADE.ANALYSIS:THE STALLING PROBLEM IS SEMI-INTERMITTENT, THAT IS WIRINGHARNESS FAILURE IS MOST LIKELY TO OCCUR UNDER THOSE CONDITIONS WHERE THEHARNESS IS DISTURBED (CORNERING AND ROUGH ROAD).CPS FAILURE CAN OCCUR ANYTIME, BUT FAILURE APPEARS TO BE ACCENTUATED BY HIGH UNDERHOOD TEMPERATURES(EXHAUST MANIFOLD LEAKS, ETC.) AND DISTORTION OF THE CPS HOUSING FROMEXHAUST HEAT DAMAGE OR THERMAL FLEXING.BOTH CONDITIONS RESULT IN NOSIGNAL.STATUS:RECOMMEND OPENING EA AND SENDING A MORE REFINED IR.===
PE88029 · Throttle Control
Opened Feb 23, 1988 · Closed Sep 19, 1988
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
SUMMARY:THE PE WAS OPENED TO INVESTIGATE WHETHER JEEP'S RECALL OF CERTAIN1987 MODEL VEHICLES EQUIPPED WITH THE 4.0 LITER FUEL INJECTED 6 CYLINDERENGINE (87V-035) HAD INVOLVED ALL THE POTENTIALLY AFFECTED VEHICLES.AREVIEW OF THE ODI FILES HAD INDICATED THAT 1987-1988 JEEP VEHICLESEQUIPPED WITH THE 4.O LITER ENGINE ALSO WERE EXPERIENCING SOME THROTTLECONTROL PROBLEM.A REVIEW OF THE WARRANTY CLAIMS AND THE AVAILABLEINCIDENT REPORTS DOES NOT INDICATE THAT A POTENTIAL DEFECT TREND EXISTSOR IS DEVELOPING.THE WARRANTY CLAIMS ATTENUATE, AND THE ALLEDGEDINCIDENTS APPEAR TO BE CAUSED BY A VARIETY OF FACTORS. #===
EA88005 · Elec. Rear Window
Opened Oct 23, 1987 · Closed Mar 28, 1989
Status: closed (inferred from source dates) · Visibility
ANALYSIS OF THE COMPLAINTS AND ODI EXAMINATION OF VEHICLES SUGGESTS THATIMPINGEMENT OF THE TAILGATE LOCK DUST COVER AGAINST THE KEY MAY EITHERINDUCE OR CONTINUE UNINTENDED UPWARD MOVEMENT OF THE TAILGATE WINDOW.STATUS:CHRYSLER RECALLED BY LETTER DATED NOVEMBER 19, 1987.HOWEVER,WE BELIEVE THAT THE SELF EXAMINATION CALLED FOR IN THE RECALL NOTICE DOESNOT MEET WITH THE INTENT OF THE LAW.CHRYSLER HAS BEEN REQUESTED TOREEXAMINE THE RECALL BY LETTER DATED 11/20/87.
PE88001 · Fires Caused By Cltch Lk
Opened Oct 23, 1987 · Closed Jan 28, 1988
Status: closed (inferred from source dates) · Power Train
NO SAFETY DEFECT TREND HAS BEEN DETECTED.===
PE87048 · High Speed Stalling
Opened Aug 19, 1987 · Closed Mar 10, 1988
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
SUMMARY OF INFORMATION FROM MANUFACTURER:THE FUEL INJECTED 6 CYLINDER(242 CID) IN-LINE ENGINE IS APPARENTLY NEW TO THE INSTALLATION INTO THEJEEP CHEROKEE.ANALYSIS:THE FUEL INJECTED ENGINE ALLEGEDLY STALLS WHILE THE VEHICLE ISCRUISING AT HIGHWAY SPEEDS (35-55MPH).TWO FAILURE MODES HAVE BEENIDENTIFIED, STALLING WHEN CORNERING OR GOING OVER A BUMP AND THE OTHERIS ENGINE STALL WHILE CRUISING--USUALLY IN HIGH AMBIENT TEMPERATURESITUATIONS.JEEP HAS IDENTIFIED A PROBLEM WITH THE EXHAUST MANIFOLDGASKET FIT TO THE CYLINDER HEAD WHICH AFFECTS THE HIGH TEMPERATUREPERFORMANCE OF THE CPS (CRANK POSITION SENSOR/ENGINE SPEED SENSOR)MODULE. CHRYSLER/JEEP HAS A TASK FORCE TO STUDY THE PROBLEM.STATUS:CRECOMMEND CLOSING THIS PE AND CONTINUING THE ANALYSIS IN AN EA.#===
1987 Jeep Cherokee Problems, Complaints & Recalls | Skip That Year
Illustration